1981 CHEVROLET MONTE CARLO oil temperature

Downloaded from www.Manualslib.com manuals search engine COOL
WARM
Add just enough DEXRO~ II fluid to fill the transmission to the proper level. It
takes only 0.5 liter (one pint) to raise the level from "Add" to "Full" with a hot
transmission.
Automatic Transmission Drain Intervals
Change the transmission fluid and change the filter (or clean the screen) as
outlined
in Section A of the Maintenance Schedule folder.
ENGINE COOLING SYSTEM
Your vehicle has a coolant recovery system. Coolant in the system expands
with heat and overflows into the recovery tank. When the system cools down,
coolant is drawn back into the radiator.
The cooling system was
filled at the factory wrth a quality coolant that meets
GM
Spec~ication 1S99-M . The cooling ·system is designed to use coolant (a
mixture of water and ethylene glycol antifreeze) rather than plain water. The
coolant solution should be used year round.
It has many advantages, such as:
~ provides freezing protection down to -3rC (-34"F) "''''''<~. !'"","."" ' • provides boiling protection up to 12S"C (262"F),
• protects against rust and corrosio~in th~ cooling system,
• maintains the proper engine temperature for efficient operation and
emission control, and
• allows proper operation of the coolant temperature light or gage :
See Section A of the Maintenance Schedule folder to find out when the coolant
must
be ·replaced.
Cooling System Care
Check the c60ling system at regular intervals, such as during fuel stops . You usually do not need to remove the radiator cap to check the coolant level. Lift
the engine hood and look at the "see through" coolant recovery tank. When
the engine is
cold, the coolant level should be at the "Full Cold" mark on the
tank . When the engine has fully warmed . up, the level should be above the
"Full Cold" mark on the tank . If the coolantl6vel is low, remove the cap on the
coolant recovery tank. Add to the recovery tank enough of a 50/50 mixture of
water and a good quality ethylene glycol antifreeze to bring the
level up to the
proper mark. Put the cap back on the recovery tank.
Certain conditions, such
as air trapped in the system, may affect the coolant
level in the radiator. You should check"the coolant level in the radiator at the
time you change the engine
oil and when the engine Is cold. Follow.taps I, S,
9, and 10 under "Coolant Repfacement" for the correct way to remove the
radiator cap and add coolant.
5-6

Downloaded from www.Manualslib.com manuals search engine 4. Close the drain valve. Install the block drain plugs, if removed. Add water
until the system is
filled and run the engine until the upper radiator hose is
hot
again.
5. Repeat steps 3 and 4 several times until the drained liquid is nearly colorless.
6. Drain the system, then close the radiator drain valve tightly. Install block
drain plugs, if removed.
7. Disconnect all hoses from the coolant recovery tank. Remove the recovery
tank
and pour out any fluid. Scrub and clean the inside of the recovery
tank with soap and water. Flush it well with clean water, then drain it.
Reinstall the recovery tank and hoses.
8. Add enough water and ethylene glycol antifreeze (meeting GM
Specification 1899-M) to provide the required cooling, freezing and
c()rrosion protection, Use a solution that is at least 50 percent antifreeze out no mOre than 70 percent antifreeze. Fill the radiator to the base of the
filler neck
and fill the coolant recovery tank to the "Full Hot" mark. Put the
recovery tank cap back on.
9. Run the engine, with the radiator cap removed, until the upper radiator
hose is hot.
10. With the engine idling, add coolant to the radiator until it reaches the
bottom of the filler neck. Install the radiator cap, making sure the arrows on the cap line up with the overflow tube.
iI is the owner's responsibility to,
'. -Main)!!!n cooling system freeze protection at -3rC (-34'F) to ensure protection against corrosion and loss of coolant from boiling. (A 50/50
mixture of water and ethylene glycol antifreeze will provide freeze
protection to -37'C or -34'F.) You should do this even if you don't
expect freezing temperatures.
• Add ethylene glycol base' antifreeze that meets GM Specification 1899-M
when antifreeze haS to be added because of coolant loss or for more
protection against freezing at temperatures lower than -37'C (-34'F).
NOTICE: Do "otute methanol-base antifreeze, Of alcohol,or plain water alone, in your vehicle at any time. They will boil at a lower point than that at which the "TEMP"
light (or temperature gage) will warn of overheating,. and they do not provide proper protection against cOrrosion.
Radiator Pressure Cap
The radiator cap, a 105 kPa (15 psi) pressure type, must be installed tightly,
otherwise coolant may be lost and damage to engine may result from
overheating. Radiator pressure
caps should be checked periodically for proper
operation. If replacement is required, an AC cap is recommended.
Thermostat
The engine coolant temperature is controlled by a thermostat. It stops coolant
flow
through the radiator until a preset temperature is reached. This thermostat
is installed in the engine
coolant outlet on the engine block. The same thermostat is used in both winter and summer. When a replacement is needed, AC"Delco parts are recommended.
5-8

Downloaded from www.Manualslib.com manuals search engine CAUTION': It" the alr 'l;lMner i, ren;oveci during repair or maintenance, bel"'re to put H bl,ck on'eQr~ctly. It the air cleilner Is 'not correctly Inltalled. there could bea fire in the engine compertment (It there ~Id h..,.,en to be a backfire) , or other engitie mallunc1lon .
Front Suspension and Steering Linkage
Lubric;lte fi tngsatlhEj ' intery;>1 showninthe Maintenance Schedule with water
resistant
EP Chassis lUb(icantwhich meets GM SpecifICation 6031M.
NOTICE: ,Ball ' joints, should "not be . lubrieak.d unlesS, their temperature il -12"C (10"f},or higher,During ,coldweather, theyahould" .. ~"al,)c)~ to,warm up al nece ... ry ,before being lubricated or damttge to the baH jOint-Could occur. . , ' '.' "
.. ,. fIRnl 'N. c~~~arings
Clean and repack front wheel bearings with a high melting point wheel bearing
lubricant . at the interval shown in the Maintenance Schecule. Use wheel
' bearing lubricant GM Part No. 10 5~ 344 or equivalent.
NonCE: ," Long fiber " or "vbeou.'-' type"iubricenf ~kI nol be used, Do not mix wheel ~irinQ"lUbricant., Be sure to thoroughly c5aan bearings and hubl of all old lubricant before repacking.
Tapered roller,bearings uaed'h'Hhis 'veh icle have' .. sUghtly looSe teel when properly adjusted, They must never ~ over tightened (preJoaded) or sev .... bearing damage may resuit. Con.utt your,Authorized Deektr or Servi<:e.r.enual tor peper detailed adjustment procedures and specifications. . '~". :...,"" .... ~"";~f>"'~"'-"'''''',','',' ,::, Hood tlltchesand.Hood Hinge
At the interva l shown in the Maintenan ce Schedule lubricate hood latch
assembly
and hood hinge assembly as follows :
1. Wipe off any accumul"ti~!).ofqirt Qfoontaminationon latch Pi1!'ts.
2. Apply Lubriplate . or equivalent to latch pilot bolts and latch locking
plate .
3. Apply light engine oil to all pivot paints in release mechanism, as well
as primary and Secbndary latch mechanisms.
4. Lubricate hood hinges .
5~ Make hood hinge and latch mechanism functional check to assure the assembly is working COfTectiy.
Freedom Battery
Your new vehicle has a Delco FREEOOM battery. It neecs . no periodic
maintenance .
Its top is permanently sealec (except for two small vent holes) and has no filler capS. You will never have to add water.
The hydrometer (test indicator) in the top of the battery provides information for
testing purposes only.
For full power needs at replacement time, a Delco battery wijh the same catalog number as shown on the original battery's labe l is recommended ..
CAUTIQN: ",' FOllOW the precautions listed in the' Jump Starting ' 'Caution (see ' Ihe "In Case of EmergenCy " settlon of this manual) when workmg On or 08. a bMtery. Personal Injury {particularly to eyea} or 'property damage may result from battery e~ battery acid, or electrical (short circuit) burns.
5-10

Downloaded from www.Manualslib.com manuals search engine LAMP BULB DATA
Application Power'Rating ~.12.8V.Watts
Headlamp Assembly
Outer - High Beam ... , .. . . . . • . . . .. . . .. . .....•. , Low,'Beam ., ..... ,., ...... ;., ... ,.,.-.. ,', ..... ~ ..
Inner - High Beam (Standard) . . . . . . . . . . . .. . .... .
High Intensity (Opt.) . , ................... .
40 60 50
50
Candle Power Parking Lamp and Front Directional Signal ........••............... Tail and Stop Lamps
Rear Directional Signal ....... , ..... _ ........... .
License Plate Lamp ...............• . ; ............ . Cornering Lamp ................ .......... . Back Up Lsmp ................................... .
Glove Compartment Lamp ..........•.........• .... Tail Lamp Assembly .............................. . Inct ieator Lamps .•................................ WIS Washer & Light Switch Lamp.; ....... . Temperature Indicator Lamp .......... ; .. ' Oil/ChOke. Indicator Lamp .................•... Generator Indicator Lamp ...•.......... ' ........ ,., Ashtray Lamp, .. , . ' .. , . , ..•. ',' ........ , .. .
Hi-Beam Indicator Lamp, ... , . ~,' .... , . , .... ~ ...... .
. 'Brake System Warning Lamp .................... ..
Seat Belt Warning Lamp .... , , .............. ' , .... '
Directional Signal Indicator Lamp, >, ... , , .. , , , ' , .. . Instrument Panel Cluster Lamps .. ' ..... , , ......... . Side Marker-Front, .... , ........ , • ' ....... .. Side Marker-Rear ,,;,~ .... , ....... " ".,., , .. '. ' .... .
Heater.
AlC Control Panel Lsmp .................. . Oome'Lamp .............................. .
Dome and Reading Lamp ....... ~ _ ...... , . , .
Luggage Compartment Lamp
.................. .
Underhood Lamp , ........................ .
Courtesy Lamp ................ _ ............... .
Radio Dial Lsmp ................................ .
Radio
Indicator
(Stereo & 8 Track) ........................... .
Radio Indicator (Stereo) ............. .
a-Track Tape Player Dial .......................... . Cassette Player (Dial) ............ _ . , .. _ ... _
24-2.2
32-3
2 32 32 2
2
2 2
2
2
2
1 1
3 2
2
3 2
2
2
12
15
15
15
6 2
LED 1 5 5
Rear Taillamp Bulb Serricing: To replace a burned out bulb:
Trade No.
4652
4651
H4651
Type
1157NA
lt57
194
1156
1156
1895
194
194
194 194
194
194
1449
161
168
194
194 168
194
194
194
561
1004
1003
93 906 194
05410 66
37
37
1. Open the trunk and remove the two screws as shown In illustration, and disengage tajllamp assembly.
74
2. Remove the socket by first press· ing down on the socket latch, then rotate the socket clockwise to remove; 3. Reverse the above procedure to reinstall. Note: Mak e sure the catch release and the bulb socKet are held securely.

Downloaded from www.Manualslib.com manuals search engine Freeing Vehicle When Stuck . Hazard Warnong FlaSher Jacking Jump Starti ng
Towing: Cru EtIlIssion Caution EmISSic:m Control
3·9 3·' 3·4, 3'5
C ata lytic Conve rter 5-2 ~te< Command ContrOl System 2·18. ; ·3 CHECK ENGINE ligh t Exha ust Ga s Caution
F uel Requ irements (Gas) E",,~
2·18. 5·3 ,., , .,
... " Break -In Code Coo~ng
(See Ma intenance Schedule) 2·2 , .; ;·6 El ,.,
.. , 2·9 ,.,
(See "Fuel") ' ·5 . .. 3·1 Ideflti hcation Jump Starting . C>r Overheating . Spec~fcations Starling . Cold WeaHJeI Star ting (Gasoline) Temperature Gage Tempera ture 19h1 Thermostat E OOIN E ligh!
{See ··Oir . . EllIjne··) 3·3 ,., ,.,
'·6 2·t9 2· 17 5·6 2·t8 El"9oo Oil. (See ·'Oi l. E'ngine.') E thylene Glycot Antifree ze
E)(hausl Gas Cau tion E~~. System , If'Ispection. Ederior Fnsh Care .
Fabric Care
Fan,
Healer & Air Cond FASTEN SEAT BELTS Light. . Fastener s. RepIacemeflI .. Fifter s
Air Cleal'lEl!' . , Finish Care. Firish Damage . Flammable C\e.aoets .. .. F lashers Hazard w arning . Turn Signal..
Flooded EngIne . Starling . Floor Controls .. F luid Capacities .. FM Radios .. Folding Seats ...
5·' ,.,
, .,
... . 4·4 ,., 2-24. 2·25 '·6 5 ·'
;., ,., ,., . . • -1
3·.1 ..... 2:7 . ....... , 2·9 ......... 2·13 ..... ..... 7·1
F Ofeign CounlrllltS . Operation in ... FOUl' Season Ioit ~ . Four·WayHazard FlasheI' ... Freedom Battery .. Freeirig Car When Stt.JCk.". , .... Cop . Economy Tips .. Gogo Gasohol .. a...... Octane RaIing ..
;., , ., . 2 ·15 . '. ..... 2-3 ....... .. . 2-3
7 ·7
Overse3$ OpefatiOtl _. Tanl( Capacity Fuse
Cha rt
Circuit Breakers ...
""'" Engrne Temperat lJ'e
Fuel.. Oil Prossure Tachometef (Engille $peed) Voltmetet' , .. Gasoline
GEN (Gener ator) Light
Glas s Clea ning
Gto"e 80)( Guard AQaIIlSl Theft Hazar d Warning Flasher Headlight s Circuil &eakel IJimmtIf Switc h
instrument Pa~ SWitch Light s ON Reminder .. Head Restraint s .. tEAT Light. Heated Rear Wmdow .
2·' ,.,
'·3 '·3
2-1 9 2-15 2·19 2·18
2· 19
(See "Fuer') 2-\7 ..,
2-16 ,.,
3'
.7-3 2,14 2--?1
2-21
'·5 2·17 2·25 Heat er/Air Condihoner2·23. 2-24 High ·Beam Head~ghl!i 2-2t _ 1·13 5·10 . (Inside Back Colter) 5·10. !Inside Sack Cover)
Hitches. Traile( . Hood Latches .. Hood Release . Horn .. HOT UghL Ideotihcation Nt.mbers 19r>ilion K9YS Lock . In Case of EIT1efgenc:y .nocator lights ... Infant Seats & Aestra.nt .. II1l1ati04'l Pressure. Tires. Inlets . Air.
2-t3 2·t7 7.·5
,.,
2·' ,., (See "UghIS") 1 ·10. r_ll 5·12 2·23 Inside Rearview Muror , '-3 Instrumetl t Pan&! & Controts .. 2·15 InleilOl Appe«i¥1Ce Care.. 4-1 Interior & inst rumen t Lights (See "Lights" ) Jacl:: Operation & Stowage.. 3- 4. 3 ·5 . 3-6 ~ S\aI1ing .. 3- 1 Keys...... '·1 Lane Ct\ange &. Turn Signals 2-7 Lap- Shoulcler Belts . (See "Seat Bells") L_
,_­Hood ...
,..
(Inside 8acto: Cover) Sealback. From. 1-4 Trunk . 2-22 lighter. Cigarette ... 2·22 ligh<' BRAKE .... ...................... .................. 2·1 7
Bright s On. !lui> c.... O£CI( ENGINE Choke Warning .. Comoring .................. . CouttKY·· ClimrneI-Swoi1ch. HNdigflt .. Electrical S)Stem (GEN) ..
2-21 ,..
2·18.,5·2 2-17 .. ....... 2-7 '·30 2-1. 2-11