1981 CHEVROLET MONTE CARLO brakes

Downloaded from www.Manualslib.com manuals search engine DISC BRAKE WEAR INDICATORS
Front disc brakes have bum-in we .ar indicators which are desigled to make a
high-pitched squeating or
cricket·tike warning sound when the brake pads are
worn to where new pads are needed . The sound will come
and go. or be heard
all the time when the wheels are rolling, but will stop when the brake pedal is
pushed down
firmly. Expensive damage can result if pads are not replaced When needed .
See also the brake checks listed in the Maintenance Schedule folder.
INSTRUMENT PANEL AND CONTROLS
INSTRUMENTS
The instruments . gages and indicator lights convenienlly grouped in the
instrument cluster are designed to tell you at a glance many important things
about the perform ance of your
vehicle. The following information will enabl e
you to more quickly understand and properly interpret these instruments.
Speedometer
The speedometer hand indicates vehicle speed in miles per hour and
kilometers per hour.
Odometer
The group of six figures in the, speedometer lower center sectiori indicates the
accumulated mileage.
Trip Odometer (optional)
The trip odometer may be reset to zero by turning stem to. the right This
instrument may be used to 1TI<\':!1 .. aPC~rately record trip mileages 'or kilometers .
Fuel Gage
The fuel gage will register the APPROXIMATE fuel level in the tank. when the
ignition is in the
RUN position .
When the
gage registers EMPTY. some fuel is still available as a reserve .
When the gage registers FULL. some
additional fuel can still be added to the
tank. The following conditions maybe considered normal:
•
Gas station pump may shut off before fuel gage indicates FULL
• Amount of gasoline reqUired ior fill~up may not exaclly correspond to gage.
• Needle
may not move awa y from FULL until some time aiter fill·up .
• Needle
may move during turns. stops and accelerations.
When the ignition switch is turned to the OFF position, the needle will not
necessarily return all the way·to the EMPTY mark.
2·15

Downloaded from www.Manualslib.com manuals search engine "
• The lighl is also designed to come oi, briefly during engine starting so you . can check that the bulb is okay .
• Have the system repaired ifth'e light .d~es· not .come on during engine
. starting or when th.e Parking brake is set.
•
This warning light does not do away with the heed for brake inspection and
maintenance. The brake fluid level must be checked regularly . See your
Maintenance
Schedule folder for other brake checks.
If the light 'comes on andstavson when the ignition key is on, after the brake pedal has been firmly pushed down, it may mean that there is somelhing
'
wrongwith I?"" of the br"kesyjitem.
What to do:
1. Check to see that the parking brake hec been released . If it has been ..
2. Pull off the road and stop carefully, And remember that:
" .• " Stopping ,distances may be longer.
•
You may have to push harder on the pedal.
•
The pedal may go down farther than normal.
3, Try out the brakes by starting and stopping on the road shoulder--then:
• If you judge it to be safe, drive cautiously at a safe speed to the .near,est dealer for ,repair, or
• Have vooicle t6w~ to the nearest dealer for repair.
Continued driving without getting necessary repairs could be dangerous .
"'''''''~''., ENGINE" LIGHT
All gasoline"~~gine VehiCles sold in ttwl,lnited States (aridsorne ' vehidle. sok:!
in Canada) have the Computer Command Control sYstem, (canadian owners
should
also ' read the Nole on the. inside front cover of this manual. )
If your vehicle has thElCoTP\Jter :,eommand:'ContrOI-system, ,a , "CHECK
ENGINE" light
on the instrument panel is designed to come on during engine
starting to let you know the bulb is working ; (The light will stay on a short time .
after
the engine starts,) If the light comes on while driving, service to the
Computer , Command
Control system may be required , Although. the. v.ehicle
may still be drivable, see , your Chevrolet dealer as soon as possible . for an inspection of the system , (Some vehicles sold in Canada, DO NOT HAVE the
Computer Command Controtsystem ,
ILyeur vehicle does not have a "Check
Engine " light, then it does not have the Computer Command Control system,)
Continued, driving without having the Computer Command Control system
serviced
could cause damegeto' the emission control system, It could also affect fuel economy and drivability, .
See also "Computer
Command Control' system" in "Service and Maintenance," Section: 5 of this manual.
Tachometer
The optional tachometer i. ndicates the speed of the engine in revolutions per
minute, The' indicated num,ber, times 100, gives the engine speed, Operating
the engine
with. the tachometer . reading .in the colQr-coded high-speed area could lead to seriOUS engine damage,

Downloaded from www.Manualslib.com manuals search engine Towing
Proper equipment .must be used to prevent damage to vehicles during any
towing. State (Provincial in Canada) and local laws which apply to vehicles in
tow must be
followed. Get detailed towing instructions from your dealer.
Your vehicle
may be towed on all four wheels, at speeds less than 35 mph (60
km/h), for distances up to 50 miles (80 kilometers), provided the driveline and
steering are normally operable. For such towing, the steering must be unlocked, transmission in neutral and the· parking brake released. Connect to
main structural parts of the vehicle. Do NOT attach to bumpers or brackets.
Remember also that power assist for brakes and steering will not be available when the engine is off.
If the vehicle is to be towed by a wrecker, use only equipment designed for this purpose, following the instructions of the wrecker manufacturer. A safety Chain
system must be used for all towing.
FREEING VEHICLE FROM SAND, MUD, SNOW OR
ICE
If your vehicle gets stuck in sand, mud, snow or ice, move the shift lever on automatic transmission models from "0" (Drive) to "R" (Reverse) in a repeat
pattern.
Apply a light pressure to the accelerator pedal while the transmission is in gear. Remove your foot from the accelerator while shifting. Do not race
the engine. For best traction, avoid spinning the wheels. Incorrect rocking of your vehicle while it is stuck may result in damage to vehicle components.
CAUTION: Do not spin the wheels faster than 35 mph (55 km/h). Personal injury and
damage (inCluding tire, transmission and/or rear axle failure) may result from excessive
wheel spinning.
If the vehicle remains stuck after several rocking attempts, seek other
assistance. Also see the Notice under '(Automatic Transmissions" in "Steering
Column-Controls," Section 2 of this manual.
3-9

Downloaded from www.Manualslib.com manuals search engine un mUE SAl: VIScOSITY GRADES
F~O 20 40 60 100 C -30 -20 10 0 10 20 30 40 TEMPERATURE RANGE YOU .EXPECT SHORE NEXT Oil CHANGE
NOTICe: DO NOTUSE SAE 5W-2(I OILS fOR COIfi"INUOUS HIGH SPEED DRIVING.
Engine Oil Additives
There are many extra engine oil additives (or helpers) for sale. Your engine
should not need these extra additives if you Use SF-quality engine oil and
change it as suggested. If you think your engine has an oil-related problem,
talk
to your authorized dealer. If needed, your dealer can provide you with a
tested and approved oil additive called "GM Engine Oil Supplement."
AUTOMATIC TRANSMISSION FLUID RECOMMENDATIONS
Proper Fluid -Use only automatic transmission fluid labeled DEXRON® II. You
can buy this fluid from your dealer or other service outlets.
Checking
Fluid Level-Check the automatic transmission fluid level at each
engine
oil change, Overfilling GaI).c"!,J~e foaming and loss of fluid. A low fluid
level can cause slipping or loss of drive. In either case, transmission damage
can result.
To check the fluid
level, first set the parking brake, then start the engine in "P"(Park). With the regular brakes applied, move the shift lever through all the
gear ranges, ending
in "P". You must check the fluid level with the engine
running
at slow idle and the vehicle level.
You cannot read the correct fluid level if you have just.driven you(vehicle fora
long time at high speed, in city traffic in hot weather, or if your vehicle has
been
pulling a trailer. Wait until the fluid cools down (about 30 minutes).
Remove the dipstick
located at the rear of the engine compartment on the
passenger's side. Carefully touch the wet end of the dipstick to find out if the
fluid
is cool, warm or hot. Wipe it clean and push it back in until the cap seats. Pull out the dipstick and read the fluid level.
• If
it felt cool (about room temperature), the level should be 3 to 10
millimeters (118 to 3/8 inch) below the "Add" mark. The dipstick has two
dimples below the" Add" mark to show this range.
• If it felt warm, the level should be close to \he "Add" mark (either above or below).
• If
it was too hot to hold, the level should be at the "Full" mark.
5-5

Downloaded from www.Manualslib.com manuals search engine AJt Cleaner. Ail CoricIitionor FOlK Season .. Mainten ance .. AM" Pressu-e. Tires. AM" Vents. Alterna tOf tGEN) l.ghl AUniIlUffi Cafe .. AM or AM-FM Radios Antenna Antifreeze . Appearaoc e Care . Ash1rays & Lignler s. Assistance. Owl"lef Automat ic Door Locks. Automatic Transmission CorwElfter ClUlch Maintenanr;e
"""'-OpefaJ .... '1 TiPS.: AKIe. Re ar Standard . lifnited-SHp . Babies. AesCraint 01 .. BaIt Joints .. fun..., E mergency S ta ring F reedom. Gas Caution ..• GEN 191I... .•.• Test Indicator ...
. ........ 5-9
2-24
5-11
5-12
2-23 ....... 2·17 ... 2:27. 2-28 2·29 (Seo "Coolant") ,.,
2·22 6·' ,.,
2·10 5-5 .. 2 -9 2 ·'
5 ·'
5·' 1·10. ,-" . 5·1 0
3 ·' 5-10 3·' 2-17 5·10 Betore Dr iving Your Vehide... \. Bells: Sea!....,.. . (See I'Se at Belts") Blower, Healer & Air Cond.. 2-24. 2-25
Body Da mage . 4-4
.. """ ~,. Pedal Travel Trailer Towing .... Warning Ught .
2·14 2-\4 H2 2-17
Breakers . <;ircui t. • ..... 2-21. 7·3 Bteak ..... Period. New Vehicle ..• 2·2 Srioj'!( Headlights 2·7. 2·21 Brighl Metal Cleaning 4-4
Bulbs & Fuses.. 7·3. 7-4 Bumpers & HiIC:·~s. '·13 ~ 'Jack Operation ...... 3-4 B.w:ers._ . (See "'SOunds'" CoirpJler Con"mand Cont rOl System:~ 2·\8, 5·3 Cop Coolant A ecovery Tant.: .. ................. , .. 5-6 F uel.. 5-2 f>o¥Iier Steefing.. _____ -._ ....... ...... 0<. _____ -5-9 Radiator ... 5·8 Capacity, Cargo Weight. 5-11 Capacities. FlUid:. 7- Car Break-In Period . New.. 2-2 . car -Chemicals ... carbon Monoxide cautJorI .... ___ 4·' 2·' Care & Cleaning. Appearance . . .. 4·' Cargo Capacity . 5-11 Cargo on Root . Carrying,. '·2 Catalytic Converter . . ..................... ....... 5-2 ~ Command Control System .. -2·18. , ·3 Chains. Tire .. 5·15
7-6
Changing Wheets & Tires .. _ Cl-£O< ENGtl'E light .. Chectlbt, DrillSf . Child Seals & Restr ainls Chrome Protection .. ag.yette lighter ... CirCUIt Beakers QtiZOtlS Band Raoio . C!earIing .. Clock.I .. Cloth Trim Care .. ClutCh . Converter
Cold W&ather Starting ....
3 ·4 . 3·5 2 ·18. 5-3 ,., I -tO. 1·11 ... 2·22 2·21 , 7·3 2·29 . ..... 4·' 2-22 '·2 2·10 2·8 ~ip""lt Plocedu.-e . . ... 6 ·1
Condi lioner, Air (See "All" Cooditioner"~ Cons umer Relation s ... Converter ClUtch Con...eJo: Mirror Cooling System Afltilreeze (CooIanI) .. Overheating R ecovery Tank Service,. Thermoslal . COfl"lefing Lights . CorTosion Pmlection. Countries. Oper-ating in Fo.-eign .. Courtesy lights CruISe Control Cus!omer Service . 5·6
3·3
3 ·4 ,
5·6 '·7 '·8 2·7 . . 4-5 2· ' 2·30
2·12
6·' Damage, Sheet Metal . 4·4 Detogger,Re..-WiNJoW.. 2-25 DelrOSlor. Windshield . 2·24. 2·25 Delay Wipers 2·20 Descending a· Grade 2-9 Ditlererlliai (Rear Axle) limited·Slip __ 5·9 ,Malt)l~O 5 ·9
Trailllfing. 1·1 2
Dimensions 7· , Oimn'\e( Switch, Head~L 2·14 O ipshCks A.utomalic Tfansmission .. . 5-4 Engine Oil 5·3 Power Steering. 5-9 Directional Signals.. 2-7 Disc Brakes 2·15 Door loc::ks . __ ................ 1-2 Orivet' Checklist 1-1 Driving Down S teep Grades .... 2-9 in OU'sty Areas . 5 .... on Slippery Surlaces .................... 2·9 Economy ripS. Fuel .............................. 2-4 E lectric· Po_oo QpIion$ .. (See "Power"') Electrical System Banerv .. S-1 0 Bulbs .. . ....... ...... .... ........... 7,4 Circuit Breakers ....... , ........................ , 7-3 Fuses:. 7·3 GEN (Genefalor) lighI ..................... 2· 17 Jump S tarting 3- Spark Plugs 7-2 Voltmeter . 2·19 Emetgency. In Case oj Bralle WCIIllWlg li!1Il .. Eroglne Hot light .. • .. 2·17 . 2·17