1980 SKODA 120LE Workshop Manual

L
i g)
Excitotion of the olternotor by o current
supply outside the cor is not permitted.
Agoin the semiconductors would suffer.
h) A blown chorging worning lomp must be
reploced immediotely with o new
one. Other-
wise correct excitotion of the olternotor is
not ensured. Use o new lomp of
the some
roting (or input), i.
e., 1.5
to 2 W.
i) Be sure thot there is
o perfect
electricol
connection on the connecting terminols ond
thot the olternotor
ond regulotor
ore properly
eorthed.
i) The
olternotor is oeroted, open. Therefore
toke core when woshing the cor thot woter
or cleoning ogents do not get
into it through
the venting holes.
Removing the Alternqtor
1. Disconnect the bottery.
2. Disconnect the olternotor leods. lt will be
helpful to remember the colour of one conductor
ond its connection for reinstollotion.
3. Remove oll ports
holding the olternotor on
the engine, ond lift owoy the olternotor.
Reinstolling the Alternotor
1. Cleon oll mounting surfoces.
For the olter-
notor mounting, see Chopter 2.3, por.42.
2. With the bottery
disconnected, insert the
conductors into the respective
connectors "M,,
ond "R"
(the conductors beor the some sym-
bols), ond fosten the remoining leod with o nut.
3. Reconnect the botterv. Alternotor
Disossembly -
Repoirs
1. Screw off the belt pulley
nut ond remove
the belt pulley
ond fon.
2. Lift the brushes with o hook proceeding
through the holes in the
commutotor end
shield
ond hold them in the lifted position
by wires
inserted into the shield through dio. 3 mm holes
under the terminols uM'
ond "Ru.
3. Mork the mutuol (relotive) position
of the
commutotor ond drive end shields ond seporote
the qlternotor
ofter hoving removed its clomping
bolts. The drive end shield remoins connected
with the stotor.
This disossembly will give
occess to the
brushes ond some
of the diodes. All other
iobs,
with the exception of the renewol of the beor-
ing, should be done by experts in speciolized
repcir shops -
see the note supplementing the
following porogrophs.
Alternotor Reossembly
1. Insert the circlip into the becring bore
in
the commutotor end shield.
2. Fit the drive end shield with beoring on
the rotor shoft.
3. Assemble the stotor with the rotor ond the
commutotor end shield. 4" Tighten the olternoior with clomping bolts
ond check the rotor for free rototion while
tightening the bolts.
5. Slip the spocer on to tlre shoft,
top the
key in position,
fit the fon ond belt pulley,
ond
tighten the entire ossembly using the nut with
spring wosher.
6. Pull out wires from the commutotor end
shield which hove been used to hold
brushes
in their lifted position.
Replocement of Beorings
The used beorings ore fullyclosed ond seoled,
ond they hove been filled in the foctory
with
lubricont to lost through their entire service life.
1. Pull the beoring off the rotor
using o suit-
oble puller.
When ref itting the beoring, press
it
on to beor on the shoft
collor-
2. Before removing the drive end shield
beor-
ing, f irst drill off the heods
of the flonge rivets
ond then drive the beoring out from
the outer
side of the drive end shield using o suitoble
mondrel (drift).
On reossembly,
close the beoring with the
flonge ond rivet the flonge to the shield.
Replocement of Diodes
The use of the removoble
diode block with
the individuol
corriers of the so-colled positive,
negotive, ond ouxiliory diodes, focilitotes con-
siderobly the replccement of ony defective
176
Fig.133la
-
Alternotor -
Sectionol View

LLI
-uoc u! 6u11o:ado Jolorqr^ o Allo11uasse sr
ll
'
OZO' LLV-gLL'Ctt
lopoLu'a1ou uo1au6o141
-lvd aql lo sr
pesn:o1o1n6er
a6o11on aq1
uorvln9lu 39vr10n t'tt
'.reuuDuJ urDlJec o
u! eJnpDl Auo
lsotulo o1 Aler.uou
slcoat duiol
slql 'eco;d
]srll eql
ur duo; 6u1u:onn aq] Iq
pe11ou61s st .rololn6ar e6o1;on Jo rolDulo]lD
eql
lo a.!nllD,
o 'pouollueu
Apoarlo ueaq sDr1 sV
'paads req6;q Aglq6rls
o
1o .ro
peads
6u1pt
1o Apoa.rlo
lno o6
lsnu duo;
6ururorvr 6u16roqc eq1 'paeds
aug6ua unrpeur
puo .raq61q
1o a6uor eql ul sllo^
8'0+tL lnoqo
ulq]lM ,{:on
}snu a6o1;on
paloln6el eqi ',,8+,,
lDu!tural eql ol
palceuuoc
lalau]lo^ aq] ql!nn
'paads 6u1s;.r eql ol
relaurulo .ro
dr.uo1
6u1u.ror* 6u16roqc eql
lo uorlcoar eq]
ro
e6o
-llo^ peloln6er eql
lceqc o1
]uerclllns sr
1r 'pa
-lcedsns ]ou sr
lcalep o
ueqM '1as
A;ddns :anrod
erlua eql
lo lcaqs a3!^Jas eullnor
D
lv
'6u16roqcrano iralloq eql oslD
1nq Aralloq
eql lo 6u16roqc-uou Aluo
lou esnDc uoc ,{o1a.r
rolo;n6el ro rolDurallD
aLl]
lo loelap
V :a
] o
N
'6u rql.roe Atal
-1oq .rood ro 'ernlcnJls
JD3 eql puo 'auoJl
Jolol
-n6ar a6o11ol aql 'euo.r;
JolDu,tello aql uaeM]
-eq lcoluoc rood o lla.raLu eq
uoo
loelep aq]
to asnDc aql 'JolDln6a:
a6o11on aql ul
lqDnos
eq ol sDq
lcelep aql
puD 'rePro
u1 s1 1r 's1sa1
paqlrcsaP eql
Pellsllos sDq
rolDure]lD
aq]
]l
'sllo^
t'0 uoq] .ra6:o; eq
lou lsnui
asueral'!p slql',,u,, puD
,,8+,, slDull.uJal JolDu
-rallD eql uo ecuelo]l;p a6o11on aq]
l33qc 'g
'sllo^ gL o1 dn
e6uor
eql urqllM
lsel eql
l3npuoc ol
pePueuuossj
s; 11 '(anlon
>1oed) sllo^
0Z spaocxe
a6o11on aql
loql os
pesDercur
aq
lou lsnu peads
au16ua aql
'lssl slql 6u1rn6 'uo!l!puoc
poo6 u1 {;qoqoLd
sr
rolDuJallD eql "r.u'd'-r
6ur1p; aql e^oqD 6u1s1-r,
paeds aLll qllM
sesrr relaullo^ aql
1o 6u;poor
aq1 11 'paads
aul6ua eqt AllDnPD:6 asoatcul '9
'lqnop Auo puoAaq
e^!lcalep s!
]! 'Pe]!cxa
eq
louuDc JolouJellD eqi
ll 'u8+,
loutuJel oql
o]
spuoces eaJql o] oMl Jo] ',,
l l,, puD
,,u,, sloulul
-Jal eql 01
Palceuuoc 'tolcnpuoc
A.rot;txno aul
lo spua
aq1 {lddo -
roloula}lD oql e}!cx:l 't
'paeds 6uttpt o^oqo oslr
paeds sll lel lou op
1nq au;6ua aql
uDlS 'c
'(-) auotl
rolDursllD aq]
PUD ,8*,,
loultu€l eql
ueeMlsq
Jeloutllo^ o
lcouuoc puo
Jolcnpuos AJDIIlxnD eql
tll!M ,,u,, puD
,, l^l " slDUltuJel
lseuuosJelul 'z
'I:a11oq eq] ol pel
-oeuuoc sulotleJ,,E*,,
louttural'(dn ueq]
xluJ
lou op -
auo lcolq o
"N,, loull.urel 'JolDlnsu!
poJ o sDtl ,,U, lou!ulJel) ',,t
J,, puD
,,U,, slDu!Lu
-Jel JolouJello et{} utoJ,
sPDel
}cauuocs!o '! JolcnpuoC
AJD!lrxnv
uo 6urs61 -
JDC ut
6urr;41 rolDurallV
6ur1ceq3 -
g/t'tL 'DlJ
?gst x0
'g/t'01 '6tJ
ul ruo16orp
aLil o1 6urptocco
slDu!rural rolourello aq] re^o
aDpr.rq o] sjo]
-oauuoc Lltrlra Jolcnpuoc AtorltxnD uD atoda.r6
lceleq ro1oln6eg
- JolDurellv uo
6u1sou6D!C
Jo, elnpecord
'(pe6roqc lou st i.ra11oq
aq1) druol 6u1u.ror* 6ur6.roqc
sqt Aq peplou6rs
s! .ro1o;n6a.r ro rolDuJellD
aq]
lo ]3elap
V
']leq a^rrp rolourellD
aql
lo (6uruorsual
1ca:.roc) 11nd alonbapD uo
puD 'sloul"utel
l.ral
-]Dq puo 'lo1o1n6ar
ebolJon 'tolouJellD
uo suot]
-ceuuoc clrloela 1ca;.ed '6uurrt
pe6ouuopun ero
uorlo.rado JolDuJellD ]oerroc o
Jo suotltpuoC
'Zlt'tL puD L/e'eL 'sDr3
ur
sanJnc aas -
6urpurq puo
aloJnoco paraprsuoc
eq uoc rlcuoq
tsal D uo
pDol
elqorlD^ qpnn
1nd
-]no aql
,o l3eqo o Agu6 'sasodrnd
uorlDrurolul
.to; i(|uo pesn
eq uDc
lceq3 pequcsep
eqf
roC u! rolDurellv
;o 6u1>1caqC
e^llorurolul
'scluoqoer! pelllls puo luetudlnba perlnb
-er aql e^Dq qc!qM
sdoqs llodat pazt;orcads
ol llal aq
plnoqs're!l!tcel
aql
lo A;lorcadse
's.r1ode; Jo spoqleLu ctlsou6otp alDJoqDl3
:aloN
'uorlour
-Jolu! Jol iluo pesn
eq uoc (le66aru 'raleuuqo)
slueuJnJlsug 6ulrnsoeu pasn
Agluarnc eql
,o
s6u;poeg 'lueulnrlsu!
1o;ceds D
lo esn eql
ro c!lsl
-JalcDJDqc e:aduo-11on Jleql
lo 6ut:nsoau
eql sl
poqleu 6ur.rnsoetu epo!p
a^llcalqo lluo aq1
'urelsls .r1ode.r a6uoqcxe aLll rol
lnlosn lllorcadse
senord
Isolq apolP
eqf 'epolP
',8
S;.>
t't1{'t1

junction
with the olternoto,r occording to
Chop-
ier 13.3 ond mointoining
o constont voltoge of
tlre power
supply set within the
entire ronge
of
service speeds.
Tlre voltoge regulotor
is instolled orr the body
cross beorer, to
the right of the engine ond
beside the ignition coil.
To focilitote hondling
of its leods' especiolly
the occess to their
connections, it
is recom-
rrrended to remove the regulotor fostening
screws. For disconnecting procedures,
see
Chopter 13.3 "Alternotor
lnstollotion ond Gen-
erol lnstructions".
DK 1565
Fig.13.411- Internol
Wiring Diogrom of
Alternotol with
Voltoge Regulotor ond
Outer
Connections
Altenrotor: B, R, M -
olternotor outlets
f -
olternotor phose
windings
m -
olternotor field winding
D1,2,3, 4, 5, 6 -
moin diodes
D7, 8,9 -
olternotor ouxiliory diodes
D10 -
olternotor choking diode
Voltoge regulotor:
R, M, 15/54 -
regulotor outlets
reg -
regulotor tension winding
Rk -
boloncing resistor
Ro -
protective resistor
Rr -
odiustoble resistor
Kr -
regulotor contocts
Outer connections: K -
worning lomp (1.5
W)
S -
switch (switch
box)
B -
bottery
Checking Voltoge Regulotor
on Cor
The regulotor operotion con be offected by
loosened connections ond on imperfect eorth- ing.
lf the wsrning lomp does not go
o.ut when
driving, i. e., if it glows
ot increosed engine
speed brightly or dimly,
or if it does not stort
glowing ofter stopping
the engine ond
o new
iurning of the ignition key in
the switch box,
the voitoge regulotor
is probobly
foulty. Another
symptom of o regulotor
foilure is
o poor
chorg-
irrg of tlre bottery or its
overchorging.. lf there
is nothing wrong with the regulotor, check the
reguloted voltoge over the regulotor which
slrould reod 13.2 volts ot the
minimum ond 14.8
volts ot the moximunr. This check
in the
cor
is only tentotive ond only
o check on
the test
bench'con be considered os definite ond
bind'
i ng.
Electricol Adiustment
The voltoge regulotot- should be tested
ond
odjusted only on o test bench
in o connection
slrown in Fig. 13.412.
At o lood of some
2
onrperes, the checked
voltoge should correspond to
volues specified
in the column "Checking".
lf the checked volt-
oge is within the specified ronge, do
not odiust
the regulotor. Othenwise odiust it to the volues
specified in the column "Adiustment".
lf woter
evoporotes obnormolly from the bottery, odiust
the voltoge regulotor to the bosic volues of
"Adiustment" utilizing the lower section of
the
toleronce zone.
Fig.13.al2 -
Wiring Diogrom of
Regulotor Tested
ond Adiusted on
o
G -
olternotor
REG -
voltoge regulotor
A -
ommeter
V -
voltmeter
S -
switch
R -
lood resistor
B -
bottery DK
1566
Voltoge Test Bench
178

6Ll
'seu!l paqsDP Aq polirlueP!
auoz aql
ulqll,v atroJedo uoc rolnqlrlslP Meu
V
'3ltsrrelcDrDqc lorluoc Peeds oqv'voz -
tLz'wv
rolnqlrlslc lo ssrnoc -zlg'tL'611
'sau!l Peqsop Aq
Pallrluap!
euoz aLll u!L{llM alo.ledo uoc
Jo}nq!r}s!P Meu
v
'3rlslrelsorollc lorluoc peads
J$v'voz -
tLT'wv
iolnqrrlsrcl lo asrnoo -
t/s'tL'6!l
mlo$@@5
eql o^oureu 'osoq
6ullcauuoc JollernqlDc
aql
anouel 'alqoc
pao] aql 6ullcauuocs!p JaUD puD
'lroc uoryu6r ar11
'o atqoc
eql 's6n1d
6u11.rods
er{l u,rorl seoqs elqDc
;1o peddrls 6urnoq .ra1;y
6ur11;1eg puo
6ulnorueu rolnqlrlslc
'g'91. :eldoqC eaS
ecuDApV uo!t!u6l puo
dog
1u;o6
JeIDeJg lcoluoC lo lueulsnlpy 'ecuouelu!DW %S+%Sg
('u'd'r
000't o1 dn)
slu;od ]3oluoc;o a16uo
]cDluoC
:o11codo3
slcoluos
sporDlo.lc
! ur
9z' 0 ol
z' a
(6>t g'O
ol g'0)
N 9 ol
s
1'll
II T r
flij'
Iill
LLiI.,, pesolc
lo ejnsseld
Luru g0'0+t'0
(do6
lurod lcoluoc)
slcoluoc lo rl!1
es!Mlcolc '
uo!lDlor lo uo!lcej!c
-ur-d'.r 6661'g paads
lul'rttt I xDru .rolngl.llsI
cj
:ouJos eql eJo suo!loclrlcads rreLll
'as!MJeqlO'o!lstialcoJotlc lorluoc peads
eql
lo sslnoc
eql
u! sesuelell!p ulolJec eJD eleLll
09?'U0Z -
tL7wv lepolu 'uo1au6o61-tVa
adAt
:srolnqlrlslP s'l 0zt puo
1 0zt vco)$
1q7V1Z -
1L7wV lepoLu 'uo1au6oy1-1y6
edAl
:srouqlrlslp 1 90t PUD s 90! vco)$
'g1- 'rod 'g'7
raldoq3 puo 'slo1cnPuo3
eaJl ,o
uolloeuuoo -
1-'g; raldoqC aes 'sseulDq
uot1tu61
Joj 'l!un
loJluoc 6u!ult
unncD^ o puD
rou.leno6
peads cllDuolnD uD
qllM
s6nld 6ul1lods
ol l!ncr!c uotsuel-q61q
aql
;o :adotd
rolnqlrl
-srp sLll puD 'Jo1!oodoc
o tll!M 1!ncllc A.totutld
aLll lo lalDelq
o sasttdtrroc rolnqrilslp arll
uolnslurslc 9'8t
'sc!uDqcou pelMS
1o losodsgp eql
lo s1
luaudlnba ;olcads ereqM
sdoqs rgodal pez;;olceds o1
1;es.rnoA sselPPD
's.rgoda: :o sgsou6olP
Pellolap D lol
:
alo
N
'slou!ural aql uo
lcoluos lo3tilcala 1ca1lad
o puo 6ugt11.roe .redo.rd
sl! ol uolluauo Aod ol
I.rossaceu lluo s1
11 'uollolado
s11 6u;lnP ocuD
-uelulDrl Auo erlnbar
lou seop .ro1o1n6a.r
eq1
ocuDuelu!D1ry rololn6ag
e6o11on
'a1oA .ro1o1n6e.r eql
uo 6u1.rds 6ur1oln6
-ar eql
1o .re6uoq
eql
6ulpueq iq palsnlPo eq
uoc e-6oi1on pelo;n6er
aqt
lo enlo^
eql '(ptoc)
6ugrnsoau paloedel qcDa
lD lsal utoll
pellolsal
aq lsnu JolDulallo
aql 'rolslser
pDol aql
lceu
-ubc puo ,(re11oq aql
lcauuocs!p '('tu'd't
o69'1-
lnoqD 1o) uorlolrcxe
sll .re4y 'Ila11oq
pe6.ror'1c
A11n; o LllrM
lse; tuoll JolDu:allD
etll
dn
1.to13
xew n 6'E I
u!N n 9't! xet^ln9tI
u!u! n tt ll
dals
I dols
rueursnIpv 6ur1caq3 daiS
uorlelnbag
':o1e;n6ag rolcnpuocruraS IZO'6 lr-9 | L'EVV
urnulrxeuJ n o't I
runurulLuA9tt LunLurxPur
n 8't I
urnuif urul A z'el g1
dalS
I oals
luaulsnlpy 6ur1ceq3dets
6ur1e;nbag
rolelnbeg leclueqcan OZO'LLn -
9LL'enn
T
I
+.
II Llcu€
999r
{
uo
pu
oUt
lo
lsn
131
sor
lsn -ll (
pal
Pel
-PrlsJD
8'1 qi
et
EJ
-6
l€ 'x
M
u
elu
q'€ l-t't t

I
I
t
b
c ll
e
c
tl
d n
tN'
>
\'
J I
(Il
qt3
Fig. 13.5i3 -
Vocuum Control Course -
opplicoble to both
regulotor models
copscrew fostening the distributor brocket to
the support on the engine (do
not loosen the
brocket clomping bolt).
Refit the distributor on the engine by
re-
versing this procedure. The
coupling on
tlre
shoft is osymmetricol ond it hos to engoge into
the heod of the drive shoft in the engine. To
seot properly
o new distributor
or o distributor,
the brocket of which hos
been loosened, refer
to Chopter 2.3, por.25
to 27.
Distributor Disossembly ond Reossembly
This should be done in speciolizedworkshops,
especiolly with regord
to the checking of the
mechonicol condition or o repoir
of the dis-
tributor. lt is recommended
to use o suitoble
holder for doing the moiority of the required
iobs in
o verticol position.
When reossembling
the distributor, lubricote
the sliding points
oc-
cording to Chopter 15.3
but bewore of over-
lubricotion.
Remove olso the copscrew
on the bottom of
the distributor housing ond drip some low-pour
point oil into the hole to increose the oil reserve
of the shoft
sel-lubricoting beoring -
see Chop-
ter 15.2 "Speciol
Oils".
Disossembly 1. Remove the distributor cop ond the breoker
orm.
2. Remove the coupling from the shoft (note
the relotive position
of the eccentric dogs ond
the breoker
orm).
3. Remove
the circlip from
the pivot
ond litt
owoy the breoker orm.
4. Remove
the subossembly
of the terminol
"1" (current supply to distributor).
5. Screw off the copocitor. 6. Screw
off
the retoining springs.
7. Lilt owoy the vocuum chomber (do
19t
open it, o chonge of the curve is on.improboble
d'efect; do not chonge the screw-in depth
of the
pull-rod).
' 8. Lift owoy the contoct breoker
bose plote
with pocking piece from
the housing.
g. Litt owoy the shoft with the
centrifugol
governor. -
10. lf necessory, disossemble further
the sub'
ossembly of the shoft with the centrif
ugol
governor (odvonce mechonism) ond
com.
l?;h.',0, ReossemblY
1. Reossemble the centrifugol governor
(the
weights must be free
to rotote on the pins).
2. lnstoll the reossembled shoft
with the res'
pective woshers into
the distributor housing.
3. Fit the contoct breoker bose plote
with the
f ixed contoct holder ond pocking
piece into the
housing. 4. Fit the pull-rod on
the pin
ond lock it in
position, screw down the vocuum chiomber with
the copocitor. Check the
ignition odvonce po-
sition for the first cYlinder.
5. Screw down
the retoining springs
with
shims (the
spring with
the dog opposite to
the
terminol "1"i;
the bose plote must
rotote freely
in the distributor housing.
6. Reosemble the terminol "1".
7. Fit the breoker orm
on
the pivot
ond lock
it in position. Adiust the contoct breoker point
gop (lift) ond check the
contoct
Pressure'
"
if. 'Stip
woshers on
the shoft in
the originol
sequence, slip on the coupling ond
lock
it in
position^ 9. Fit the lubricoting felt
into the hole of
the
com ond instoll the breoker orm.
10. Fit the distributor cop
in position.
11. Check the distributor operotion.
Checking A def inite indicotion of the condition of
the
distributor (during on operotionol check
os
well
os ofter o
repoir) con be obtoined by testing
the distributor on
o test stond with
o circulor
spork gop.
After o preliminory
odiustment of
the
contoc-t breoker point gop,
the stond is
used for
check i ng:
1. The contoct point
contoct ongle.
2. The spork ongulor distribution (with o
tol-
eronce of -+45
ongle minutes within
the entire
operotionol ronge).
3. The rongJ ond course of the
centrifugol
ond vocuum control. 4. The
operotion ot
moximum speed (length
of spork on spork goP -
4 mm) for o
brief period
(obout 2 minutes).
180
t
5
2tD zsa !l!
F llti
rc

r8t
uoeq Mol lo uo!]D!^ep
pJDMuMop -
tuur 09
punol6 a^oqo sarluec duolpoaq
1o 1q61aq
sdtuolpoaq l:o;1;xno
;o suollcalord
e.rluac
sduo;poeq ulor.ll lo suollcalo.rd erluec
ecuDlslp orlaul g puD
o!#Drl puoq-1q61r
.ro1
- llD7y1 6u;lsnlpy
dtuo;poeg -
Li8'eL '6!J
-das duolpoeq qJoe
lsnlpV 'uollorlsnllr
eql u!
umoqs so ('6ap gL
lnoqD ,tq)
tq6tt eql
Jo erluao
eql ulo4 plor*dn
selDr^ap au!l:aproq slql
]o
1.rod puoq-lqDr:
aq1 '1
qllM saprcu!03'lsou eq]
1D 'Jo
aull uMDrp eq] Moleq A11q6rps
st
]! lDql
os s1q6;1 paddlp
lD sseu)iDp
puD
lq6ll usa^
t
-eq eu!lreproq aql lsnlpV'("8,',V, slurod)
surDoq qOtq
aqr
;o ,{.rleutuAs
aq1
lsnlpD rolpuD
)ceqc ueqt 'puno:6
aqt qltrur
lellDrod '1q61eq
s!ql lD llD/l. sq] uo eurl o MorP
PUD 'uollD.itsnll!
orl] jo pue6al
aql ul palylcads
ernsDotu oql
l!
r.uoJl lcDJlqns '(uC,
arnsoau) puno.rO
eql eloqD
soJluac dr.uolpoaq aql ]o iqDleq eql ernsDslA
'l! tlllM pau611o
sr esou slr
lDr.l] os
llDM lDOrl
-.ren l;1ca1.rad erll uro:l
serlaur g
rDO eql e^!r6
:sMollol so paaco.rd '1;
6ulsn uaq6 'op
lllM
Ll8'tL'6tJ ul
uMoLls
llonn 6u11ceqc
D 'elqDpD^D
snlo.roddo 6u11snlpo logceds ou a^oq nol
11
'eutl eJluec JDc eql q]lM
eull u! puo puno.r6
eql qllM
1e;1o.rod erD
stuDeq
3ql loql os
palsnlpo
e.ro sdtuo;poap A"r,o;;1xny
'tuDaq Mol eLll
+o uolloaJ!p
eql sl sdtuol
-poor.l ot{l
}o }uaulsnlpo aqr rol
ro}cD} a^lsrc
-aP aql 'erolareql
:qlnq eqr
'o uo!lcnrlsuoc
3ql
{q uen;6 s! uDoq q6tq
aqr puD
Mol oq}
}o suor}
-cer!p eql
lo ecusrel,rp eq1 's1q6g1
peddrp qlrnt
6u1,rg.rp ueqM sJe^!rp 6uluocuo aqt 6u1lzzop
'tenelvroq 'lnoql!M
lonnpoo.t aql elDU!uJn11r Aaql
lor.ll os
psllolsur
ero sduolpoaq u!Dru orll
lueulsnlpy -
sdruo;poag Aro;1;xny puo
ulDhl
srH9ll cNv sdhtv-tcvlH (D
'ra1doq3 elomdes
lxeu aql
1o slca!qns erD 'uorlDllDlsu!
puD lD^orri
-er Jlorll 'sqlnq
pesn ,o sadAl aq1 'uollDllDlsu!
puo lueulsnlpo .ro1 suorlcnJlsur
puD
uoltouJrol
-ug gorauab urDluoc sqdor6o.rod 6urr*o11o1 aq1 saqclolos
daap anoel ol
lou
erDc aIDt
rnq
llo pedolcs
]sll aq uoc slrsodep
Anoepl'ladod Aratue
u1or6-1sau;; eql qllM
sepor]
-calo eql uoelC 'ruru
l'O aq
plnoqs
do6
lce:loc
aLlI 'epollcole
relno eql 6ulpueq Iq sapo.rlcala
6n;d 6u11.rods eql uoeMlaq do6 eq1
lsnlpV
'llo puo lsnp lo ae:1 'uoe1c
selqoc uo11;u6;
puo s6nld 6ug1lods eq1 daa;'senlestleql salqDc
eq] lo releu 'sle)tcos
elqoc sql
lD 6urglnd
iq
s6nld 6u11rods tuo.r;
salqDc uogluDr e^outou
'gy'.rod
'g'7 .raldoqC aes 'sseurDrl
uol11uDr eql lol
-C
-c
-B
-V
st ozl1 ozL901 9991
9901
9't)
st ozl
't
0zt 90t sH Id8
SH 9d8
)9N
s.l ozt ozl 901 18tuordueqJ
sr 0z
s'l oz
st oz
st oz I
ozl
ozl
ozl
ozl 901
90r
90r
901 J89M
9e100zM
,A.8N
,r.8t I AlN
AL.T L
8-t I qcsB
ted n 0't t
r.rlnurxelA
n t'e t urnuJruru\
s6n13 lredg
sonld
otnouddv'v'I'N
s:tlsvc
NOIIIN9I CNV S9Nld 9NI)UVdS I'EL
'ploc sl lroc aq] el!qM s8^lasulaql
lsel
-!uoru lou op
saJnllol auros esnocaq emp.radtlel
6u;>;rorrrr sll lD l! ]se] ol
pepueuuoceJ
s!
ll
'lloc uoll!uDt eqt
Jo uolllpuoc
lDnl3D 3ql uo
uorlDr.xJolu!
lceJJoc
en16 uoc qcueq
lsel D
uo
lsel o Aluo'JeAeMoH
'(:eplo u! oslD s! llncrlc rt:oru;.rd
oql
lDrll uolllp
-uoc orll uo lluo
1nq) :ap:o u! s!
lloc uollluBl
sLll 'eJnlcnJls
rDc aql o]
Pue elqoc eqt uoJ, Ja^o
rlsDll sl.rods ;1 'Jolour
iauDls eql 6ugsn eu;6
-ue eql
luDJc puo
uo!}ru6! eql uo qcltMs
uaql
'eJnlcnJls JDc aql uoJl urr!
0L lnoqD pua
sl!
6u1p1oq puD
lollno eJluec
l!oo rolnq!Jlslp
oql
]o
elqoc uo!suol-q6lq eql 6u!lceuuocs!p
Aq A1a,r11o1
-uel uo!lcun] lloc uol1u6! 6ql
)3eqo. uDc no1
' ( lDeJq 'arnl
-cund) palorue.! eq
louuDc poc
aql ap1su1 6u;
-1ou161ro slceleq 'acol:ns
dor aql uo Jncco uDc
sa6mqcslp ou
lDql os
A.rp puD
uDelc s1 doc eql
;1 lluo i;:edord alolado uoc
lloc uo111u6; eq1
6u;4caq3 puo
acuouelulDl
t
's1nu 6ulualsDl eql repun
sraqsD,vr 6u3.rds
1nd o1
l!ruo lou op 'g1oc
uo111u61
eq1 6u;11o1su!ar ueqn^ 's1nu
6uluelsDl aql tto
MeJss puo
spDal elll
lceuuocslP ']!
e^oueJ oI
's6n1d
6u11.rods uo e6:oqcs;p
1.rods €tl1
roi pe.rlnbe.r
uo!sue] q6lq
eqr olu!
luoJJnc A:or-u1.td
peldnl:a1
-u! aql 6u1u.ro;suoJl Jol pasn puo
.rogolnDer e6o
-llo^ JolDursllD eql epls3q
luaul.roduoc aul6ue
eql lo 1.rDd puDq-lq6;.r aq1
ur pollDlsul
s!
ll
8'Sti'€t eNtrHetl 8'tL
lroc
NorilNor g-tr p
rl
)
t
(I

I
I
I
s
I
I
I
t
(
(
t
l
,
t
T c
R
L D
v Ir
1' 2
3
orotely
(
screen the other one) . With lef t
directionol heodlomps,
the borderline deviotes
towords the other
side.
lf the heodlomps ore neorer to the woll thon
the soid
5 metres, decreose the meosure indi-
coting the
deviotion of the light ond
dorkness
bordeiline from the
height of the heodlomps
obove the ground in the
direct proportion to
the
decreose of
tfre distonce, for
exomple when
plocing the cor 2.5 metres
from the woll, de-
creose the deviotion bY holf.
Light proiections "A"
ond "B"
correspond to
the spocing of heodlomPs on
the cor ond they
hove the following dimensions:
Heodlomps, dio. 160
mm 1,030
mm
Duol heodlomps, dio.
130 mm 1,114
mm
Auxiliory heodlomps, dio.
130 mm 790 mm
When odjusting the heodlomps, the cor must
be empty ond the
tyres must be correctly in-
floted. Hologen heodlomps should
not be left
switched on for too long o period os they build
up heot if not cooled by heod-on
oir blost when
driving. For lhe odiustment of
heodlomPs ore intended
screws in their fromes. The screws
ore occess'
ible ofter the removol of the side ports
of the
grille. Remove the copscrews of the corners
ond push
the grille
oside.
Heodlomp Assembly
o) The fundomentol fostening
Port of
circulor
heodlomps is the
so-colled support plote
(rec-
tongulor plote)
ottoched to the bodywork by
copscrews with lock woshers. The
heodlomp
housing is bolted to this suPPort plote by bolts
with nuts ond lock woshers. One of the bolts holds
down olso the
lug of the eorthing coble-
The inner frome,
forming the
odiusting element
of the heodlomp insert, is ottoched
to the
hous'
ing by two speciol odiusting screws
ond two
tension springs. The heodlomp insert
is ot'
toched to
the bezel by
three copscrews.
There is one left-hond ond
one right-hond
support plote.
Both should
be mounted with the
oriow ond the word "TOP"
upwords. With
the
exception of the ouxiliory heodlomps, the
heod'
lomp inserts ore different for
the left-hond ond
the right-hond troffic. The leods
enter the hous-
ing through o
rubber grommet.
When r-eplocing the insert, remove
the bezel
copscrews. After
hoving fitted o new insert, it
is necessory to reodiust the
heodlomps.
Front Direction Indicotors
The right-hond ond
left-hond direction indi-
cotors ore undisossembloble units
(the
lomp
fostening sockets (locks) ore
mounted in the
direction towords the cor longitudinol centre
line). They ore fostened to their brockets in the
bumper with o nut ond o ploin ond
o lock
wosher.
Toil Lomp Cluster
The lomp cluster is on undisossembloble unit
fostened to
the bodywork by
nuts with ploin
woshers ond the
respective bolts.
Scrope off
the enomel ot the
top bolt used for holding
down the eorthing coble.
For the sequence
of the individuol lomps ond
their bulbs see Fig. 13.111 ond the respective
porogroph on bulbs.
Fig. 13.812 -
Adiusting ond
Fastening Screws of Right-hond Heodlomps -
their locotion
on
left-hond he-odlomps is their
mirror ref lection
1 -
Sidewoys odiusting screw
2 -
Height odiusting screw
3 -
Fostening screws
182

e8r
s6 v8
36 VB
9'8 S
SgL V8
SgL V8
SgL V8
SgL VB
SSL V8
36 VB
sg'tl d
8C-rtt d
rgt d enlq
^^ uAzL
MZlAZL
LL C
^^ 9IAZL
9/61 U /A9IAZL
L-92 d MLZIAZL
L.gZ d
MLZ|AZL
9/6t U /ASIAZL
L.gZ d
MLTIAZL
r/8 r /V vl^.zL
LH ^^ qgIAZL
rH /\^ 99109/hZL MOVIgVIAZL
esoq
esoq
esoq
esDq
esDq
asDq esDq
esDq
ssDq
esDq
esoq ssDq sdtuolpDeq
Aror;rxno
St gZL
V6O)S (e
s] OzL '1
\zL 't
901 vc10)s (z
(seas 'luaudrnba
lolcads -
S SgL VAO)S (,
::...:'t't;i #'td'*3lil"#
'
fq6tt a1o1d
acuecll
sdtuo; 6urs:a,ra6
s1q6rl dolg
slqDr; 1ro1
(.roa.r puo
1uorl) srolDc!pu!
uorlcerCl
' stq61 6u11.rod 's1q6r1
aprg
(rluatuo;r;-a;6urs'ua6o;oq -
' (.1uauopl-u!rlrrl 'ua6o;oq
-
(11ueuop;-utMl'ctJleruu.rAso -
:sdruo;poag sqlnS Pasn
aA
pu6u
ll( u!
1!r
I.
eI
SJot
dr
-|l
l!l€
-s pl
.F
el
el
P
-l
o-(
ll
t
'gg.'g1
raldoqC ul pequosep
sr 6ur;puoq
Jloql puo
sqlnq eql ol ssecco -
sduo; 6u11ou
-!urnll! ;euod gueunrlsu!
puo sduro; 6u1u.lo1y1
'(lonouer
1q6;1 eruop 6utu.racuoc uo!lDrurolu;
6u;pece:d
aq1 ees) :anoc duo;
eql pa^otua.r
6u1noq .re1;o
qlnq ot{} MDrpq}lM -
lq6!l (Aselrnoc)
ouroo
'dtuo; 6u;s.renar'JolDc
-lpu! uollcerlp 'fq6ll
dols '1q6r;
;1o1 :acuanbes
6u1rrto1loy aql u! Luolloq
eqt ol
do1 ruo4
Jslsnlc
eql u! pa6uo.r.ro
ero sduo;
lDnpl^lpu! eql
'qlnq eql ql!M
Jeqle6ol iorrrro
l! llll puD
a1o1d >1coq ralsnlc dr-uo1 aql uoJ'
ll
esoeler ol lool eqt elDlor -
rq6lt e1old ecuec;;
're1sn;c druol 1;o1 's.rolocgpug
uollcellp luo4
'dtuolpoaq aql olur 1aD louuoc relDm
loql os
llredo:d
lool eql
lo lDes aqt
l!l
'1 ulDler ol IOol qlnq
u!ou aql
]o d!l eql
asn 'a;qoc
6u1q1.roe ou
sDq qlnq
iq6ll €p!s
aql
ll
'slelcos
Jleql ,o sessoq
6u11co1 aql 6uolo
sqlnq
ulDru lJesul 'JapJo
esjensj u! sqlnq Meu llJ
'lalcos sll
qll/v
eqlaool ]q6l| (epts)
scuoroelc aql
lo qlnq
eql MDrpt{}lM 'qlnq
eq} e^ousr puD 'eslMlcols
-lluD ll peurnl
puo
posseJdap
6urnoq JaUD
lcol
qlnq eql lorvro
1111 'Iuo
11 'lcol
aLll Jo lDes eql
elourer '(u6;sep
druolpoaq aql uo 6urpuadap)
sstqoc ro pr'oq
tou!urra] eql
ilo O,'"
.!inH",
eseql ;o sPoeq
aql JeAo uaql s^ouraJ puo
sdtuogpoeq aq1
Aglq6rls eloloJ'smeJcs 6u1ua1so;
duro;poeq eql uesool'lueru1sn!po du.rogpoaq
uo qdo.rDorod
eqt u! peqlJcsep
sD re^oc rolDrpor
aql to s1.rod relno
eql a^oueX -
sdruolpoag
'loqoclD qllM l! qsor* 'i(;luelJe^poul
ll peqcnol
e^oq nol
;; 's.re6u1;
palDu gltrvr
durol uaboloq eql lo qlnq
eq] qcnol
lou 06l
'ueql ulnl PUD
sse:dep I;dLurs'sqlnq esaql 6u1co1da.r ueq11
's1col lauoloq pallDc-os
eqt Aq uMop plsq
aJD sqlnq llD 'sreploq
lcDluoc olu! sesDq
raql1o
sd11
€ql Aq peuesur
sqlnq
tq6r1 europ
sql puo
'slelcos r!eq1 r's^o s1co1
Aq uMop pleq
erD
qc!qM sq;nq dtuolpoeq
Jo uorldecxe
eLll rlll7171
rNtt^tscvldSu
dtSHr cNV s81n8 JO
SSdAr (q
'uoUnq qsnd qc1;rvts
aq1 Aq paurroj
sr sduo;poeq l(ror;gxno
eql
lo dtuo;
6uru.tDM eqf
'elqocr
lddo st
uotlDr.r.tJolu! e^oqD
eql eJsH
sdruol 6ulur,oyy1
'E1-'91- leldoqC eas
sllDlap Jol -
pellLrt!l oslo st
luaueco;da:
;o 11;1tq
-1ssod eq] puD
sdtuo; aql ol sseccD pol!ru!l
D sl
sJeq1 'u6rsep
lueunJlsu! eql
Jo 1.rod
1o.r6a1u1 uo
s! uollou!ulnll! s!ql 'sosDc
;o lytolour
all] ul
uo!lDu!unll I luetunllsul
.1u1od slql lo
lurod eql
e^oueu 'slloq
aql ]o auo
o] peqcol
-lD s! elqoc DulquDe aql 'loas
reqqnr o reno
sreqsDM IOol puD
slnu qllM
s11oq Iq peuelso,
1!un elqDlqrudssDslpun
uD st duo; s!Lll_
1q6;1 e1o16 ecuec!-l
1e;od enllc6su e^!l D s!
ll 'qollMs
sql ol ellsoddo ellul eql
lceuuoc ]ou oc 'el!u)
siluec eql ol (uaer6) qctr!Ms
roop eql uro4
pool otll puo
6ur.rds epls
lDll eql
lD Jolceuuoo
a,tul eql ot poel
(par) enllqsod aqt
loauuoC
pue reqlo eql u! sse.rd uaql
puo qcl/v\s
eql qll/t,[ pua
eql
lsrll ernuedo eql
olu! lresu! '1;
6ug;;olsuleJ uar1M 'qcllMs
eql ol
alrsoddo pue
eql uo ''e'! 'MoJJD
uo qllM palrDr!
ro^oc eql lo pue
eql pulqeq pallddo
loot rol
-lur!s D Jo JenlrpMeJcs o qllr"r
1no 6u1s;.rd
InleJDO
Aq penouer
oq uDc duol eq1 '1u1od
lo ser, oq
lsnu'6ug.rds 6urqlroe
lDll epls
eql qllrrt
lcDluoc
u! aq
lllrttr rlc!qM'e6pa s1; '1:oruApoq
eql u! ernl
-lado anllcedsar aq1 olut I1ru.t;1 pessa:d
s! 'l!un
olqolquessDs!pun uo 6u1lu.ro; '1q6;q
auop aq1
1q6;1 (Ase1rno3)
euro6