1976 CHEVROLET VEGA load capacity

Downloaded from www.Manualslib.com manuals search engine ENGINE COOLING
SYSTEM
The recovery type cooling sys­
tem 'is standard on all Chevrolet
passenger cars. The coolant ex­
pands with rising temperature and
the overflow
is collected in the
recovery tank. When the system
temperature drops, the coolant
is
drawn back into the radiator. The
cooling system has been filled at
the factory with a high -quality, in­
hibited ,
year-around coolant that
meets the standards of General
Motor s Specification 1899-M. This
coolant solution provides freezing
protection to
-20oP (- 28 °C),
and in Canada to -35°P
(-37°C), and it has been formu­
lated to be used without replace­
ment for two years
or 30,000 miles.
After two years or
30,000 miles,
the coolant should be drained to
prevent rust
or corrosion in the
radiator and engine.
Cooling System Care
Do not remove radiator cap to
check coolant level, but check visu­
ally in the
"see thru" coolant re­
covery tank at
least as frequently
as needed. Level should be at the
"full cold" mark on the recovery
tank when the system
is cold and
at the
"full hot" mark at normal
operating temperature.
Add a 50/
50
mixture of high-quality ethylene
glycol antifreeze and water for
coolant additions.
If frequent addi­
tions are required, see
your' dealer
for a cooling system check.
NOTE: If recommended quality
antifreeze
is used, supplemental in­
hibitors or additives claiming to
provide increased capability are not
necessary. They may be detrimen­
tal to the efficient operation of the
system, and represent an unneces­
sary operating expense.
5-7
The cooling system should be
serviced every year as follows:
1. Wash radiator cap and filler neck
with clean water.
2. Check coolant for proper level
and freeze protection.
3 . Test system and radiator cap for
proper pressure holding capacity
(15 psi). If required, use cap
designed by
AC for coolant re­
covery systems, and specified for
your model.
4. Tighten hose clamps and inspect
all hoses. Replace hoses if swol­
len, checked or otherwise deteri­
orated.
5 . Clean frontal area of radiator
core and air conditioning con­
denser.

Downloaded from www.Manualslib.com manuals search engine TIRES
The factory installed tires on
your vehicle, shown in the Tire
Usage Chart, are engineered to pro­
vide a proper balance of these per­
formance characteristics for normal
vehicle operation:
• Endurance
• Handling
• Noise
• Ride
• Road Hazard Resistance
• Rolling Resistance
• Traction
• Tread Mileage
This section contains some tips
on how you can obtain maximum
benefit from these tires and your
investment in them.
Vehicle Loading
When inflated as recommended
on the tire pressure placard, located on
the left door of your vehicle,
the
tires originally installed will operate
satisfactorily at all normal highway
loads and speeds. Do not load your
vehicle beyond the capacity shown
on the tire placard. This represents
the design capacity of the vehicle,
not merely of the tires.
Station Wagon loads should
be
distributed as far forward as pos­
sible. Luggage racks do not in­
crease the maximum vehicle load
capacity specified on the tire pla­
card.
Inflation Pressure
Tire cold inflation pressures
listed on the tire placard provide
for the best combination of tire life,
riding comfort, and vehicle hand­
ling for normal driving conditions.
Use of the highest pressures shown
on the placard will result in
im­
proved fuel economy. For those
owners who prefer the utmost in
5-14
II RECOMMENDED TIRE PRESSURES (PSI COlD) VEHICLE lOAD FRONT REAR ----UP TO VEHICLE CAPACITY
1 OCCUPANT + 500 lBS CARGO (650 lBS)
RECOMMENDED TIRE SIZE(S) (USE ONLY IN SETS) LOAD RANGE
BECAUSE OF POSSIBLE ADVERSE EFFECTS ON VEHICLE HANDLING, DO NOT MIX RADIAL TIRES WITH OTHER TYPE TIRES ON THE SAME VEHICLE.
VEHICLE CAPACITY STANDARD SEAT OPTIONAL SEAT
1 OCCUPANT 2 OCCUPANTS 1 fRONT 2 FRONT 710 lBS CARGO LOAD 560 LBS CARGO LOAD TOTAL 860 lBS TOTAL 860 lBS SEE OWNERS MANUAL FOR ADDITIONAL
INFORMATION
c::J PRINTED IN USA

Downloaded from www.Manualslib.com manuals search engine SPECIFICATIONS
VEHICLE IDENTIFICATION NUMBER
Car-Stamped on· Vehicle Identification Plate attached to left
of Instrument panel.
Engine-Stamped
on boss on right side of block, below No. 3
spark plug.
Body-Stamped
on plate attached to cowl panel.
DIMENSIONS
Overall
Length . .........•••••.••••.•..•.•......••\
175.4"
Height (Hatchback) ............................... 50.0"
(Wagon and Notchback) ...•....•........... 51.8"
Width ..........•......••••...•.•...•..•..•.....\
. 65.4"
Wheelbase 97.0"
BATTERY RATING
ENGINE VOLTS
WATTS * RESERVE** CAPACITY
L4-140
12 Std. 2300 60 min. cu. in. 12 H.b. 3200 80 min.
'Cranking power at O°F.
"Minutes before battery drops to 10V2 volts with a continuous 25 amp. drain.
6-1
U.S. CAPACITIES Measure
Gasoline Tank (approx.) . . . . . . . . . . . .
••. 16 gal.
Crankcase
(Refill)
Oil
change only 3V2 ql.
Oil
and Filter change ..•...•....... 4 qt.
Axle (Refill) ..•.•.................... 2~ pts.
Cooling System:
Thermostat All
U.S. Measure
(qts.)
8
Imperial Measure (qts.)
6~
Imperial Measur.
13V4 gal.
3 qt.
3V4 qt.
2V4 pts.
All engines
...................•....•.........•..... 195°
Radiator Pressure Cap ••••••••••••••••••\
••••.•••.••. 15 lb.

Downloaded from www.Manualslib.com manuals search engine Air Conditioning System Compressor 011 (525 vis.) '" . • • • . . • • • . • • . . • • • . . . . . .. 11 oz.
Refrlgerant-R-12
...•••.•..........•.......... 2 lb. 13 oz.
Turbo Hydra-matlc ., ......•.....••.
3-speed Transmission •..•....•••.••
4-speed Transmission ............ .
5-speed Transmission
............ .
U.S. Measure
10.0 qts.
3.0 pts.
3.0 pts.
3.0 pts.
Imperial Measure
8.25 qts.
2.5 pis.
2.5 pis.
2.5 pts.
ITEM
Engine Oil Filter
Radiator
Cap
Gasoline Cap
Air Cleaner (1 bbl.)
(2 bbl.)
Carburetor
Fuel Filter
Positive Crankcase Valve
6-2
TURN SIGNAL FLASHER:
Type
..•.•.••.•••••••.•••.••.•••••...••••.•.• . Capacity
Turn Signal ..•.•.••.•..•••••••••••.\
•••••.• 2 lamp (LL) Hazard Warning Flasher, All ..••..•.•..•••••.•... 6 lamp
TIRE INFORMATION:
Wheel Nut Torques Standard Wheels .............................. 80 ft. Ibs. Aluminum Wheels ............................. 9011. Ibs. Complete tire information will be found in section 5 of this manual.
RECOMMENDATION
AC Type PF25
AC Type RC33
AC Type GT85
AC Type A541 C
AC Type A595C
AC Type
GF470
AC Type CV789C