1976 CHEVROLET MONTE CARLO service

Downloaded from www.Manualslib.com manuals search engine • If it feels warm, the level should
. be close to the "AilD" mark
(either slightly above or below) .
• If it feels hot (cannot be held
comfortably) the level . should be
between the "ADD" and
"FULL" marks.
NOTE: DO NOT OVERFILL. It
takes only one pint to raise level
from ADD to
FULL with a hot
transmission.
Automatic Transmlssion­
Drain
Intervals
The transmission operating tem-perature
resulting from the type of
driving
conditions under which
your vehicle
is used is the main
consideration in establi shing the
proper frequency of transmission
fluid changes.
If you do not use your vehicle
under severe conditions, change the
fluid and filter every
60,000 miles.
Refer to section
6, "Specifications",
for required fluid quantities.
If the vehicle is usually driven
under one or more of the follow­
ing conditions
-considered severe
transmission service
-change. the
transmission fluid and filter every
15,000 miles.
5-6
• In heavy city traffic .
• Where the outside temperature
regularly reaches 90
0P (32°C)
for extended periods.
• In very hilly or mountainous
areas.
• Frequent trailer pulling .
• Commercial uses, such as taxi,
police
car or delivery service.
Transmission Shift Linkage
Every 7,500 miles or 6 months
lubric ate shift linkage with water
resistant
EP chassis Illbricant which
mee
ts GM specification 6031 M.

Downloaded from www.Manualslib.com manuals search engine ENGINE COOLING
SYSTEM
The recovery type cooling sys­
tem is standard on all Chevrolet
pasSenger cars. The coolant ex~
pands with rising temperature and
the overflow
is dOllected in the
recovery tank.
When the system
temperature drops, the coolant is
drawn back
intocthe radiator. The
cooling system has been filled at
the factory with a high-quality, in­
hibited , year-around coolant that
meets the standards
of General
Motors Specification I
899"M. This
coolant solution provides freezing
protection
to -20oP (-28°C),
and in Canada to _35°P
( -37°C), and it h~s been formu­
lated to be used without replace­
ment for two years or 30,000 miles.
After two years
or 30,000 miles,
the coolant should be drained to
prevent rust or corrosion in the
radiator and engine.
Cooling System Care
Do not remove radiator cap to
check coolantlevel , but
checkvisu­
ally in the "see 'thru " coolant re­
covery tank at least as frequently
as ,needed. LeveL should be at the
"full cold" mark on the recovery
tank when the system
is cold and
at the
"full hot" roark at Iiormal
operating temperature. Add'~ 501
50 mixture of high-quality ethylene
glycol antifreeze and
waler for
coolant additions.
If frequent addi­
tionsare required, see your dealer
for
a cooling system check.
NOTE: If recommended quality
antifreeze
is used,supplemental in­
hibitors or additives claiming to
provide increased capability are
not
necessary. They may be detrimen­
tal to the efficient operation of the
system, and represent an
unneces­
sary operating expense.
5-7
The cooling system should be
serviced every year as follows:
1. Wash radiator cap and filler neck
with clean water.
2. Check coolant for proper level
and freeze protection.
3. Test system
and radiator cap for
, properpresslire holding capacity
(15 psi).
Ifreqitired, use cap
designed by
AC for coolant re­
co~ery systems, and specified for
your model.
4, Tighten hose clamps and
inspect
all hoses. Replace hoses if swol­
len, checked or otherwise deteri­
orated.
5. Clean frontal area of radiator
, qcire and air conditioning con­
denser.

Downloaded from www.Manualslib.com manuals search engine UNDERBODY
MAINTENANCE
The effects of salt and other cor­
rosive materials used for ice and
snow removal and
dust control can
result
in accelerated rusting and
deterioration of underbody
com~
ponents such as brake and fuel
lines, frame, underbody floor pan,
exhaust system, ·brackets, parking
brake cables, etc. These
corrosive
effects, however, can be reduced
by periodic flushing of the under- .
body with
plait) water;
In geographic areas having 11
heavy concentration of such COr­
rosive materials , it is recommended
that the comple te underbody
be
inspected and flushed at least once
each year, preferably after a
win­
ter's exposure. Particular atten­
tion should be given to cleaning
out underbody members where dirt and
other foreign materials may
have collected.
If desired, your Chevrolet dealer
can perform this service for you.
In addition, he can provide recom­
mendations on under coating mate­
rials which will help protect your
vehicle from corrosion.
BA TIERY CARE.
5-13
O. K. TO JUMP START
DO NOT JUMP START
~ DARKENED .. DICATOA WITH GREtH DOT -_ - • BATTERY CHARGE OK • FLUID LEVEL OK
~ OARK9I!.D .. DICATOR NO GAEENDOT _ • BATTERY CHARGE LOW • flUID LEVEL OK
• BATTERY CHARGE UNKNOWN • FLUID LEVEL LOW
{CH ARG& MAV STILL IE SUFfICiENT TO START

Downloaded from www.Manualslib.com manuals search engine ITEM USAGE RECOMMENDATION ITEM USAGE Carburetor
Fuel Filter All AC Type GF470
Positive Crankcase Ventilator Valve All AC Type CU774C
Engine Oil Filter
Radiator Cap All
Crankcase Ventilator Engine Air Cleaner
Filter All AC Type FB59 Element All
SPARK PLUGS The following spark plugs are recommended for Chevrolet engines.
Normal Service (Original Equip.)
All V·8 Engines AO Type R45TS
ENGINE SPECIFICATIONS
CARBURETOR 350 Cu. In. ENGINE DATA 2 and 4 Barrel Compo Ratio 8.5:1 Bore 4.00 Stroke 3.48 Firing Order
FUSES AND CIRCUIT BREAKER
The wiring circuits in your 1976 Chevrolet
are protected from short circuits by a combi­
nation of fuses, circuit breakers, and fusible
thermal links in the wiring itself. This greatly
reduces the hazard of electrically caused
fires
in the automobile. The fuse junction block is
located under the left side of the instrument
paneL
8 Cylinder Engine 400 Cu. In.
4 Barrel
8.5:1
4.125
3.75
1·8·4·3·6·5·7·2
6-2
454 Cu.ln.
4 Barrel
8.25:1
4.25
4.00
RECOMMENDATION
AC Type PF25
AC Type RC·33
AC Type A3480

Downloaded from www.Manualslib.com manuals search engine OWNER
ASSISTANCE
The satisfaction and goodwill of
the owners of Chevrolet products
are of primary concern to your
dealer and the Chevrolet Motor
Division. Normally, any problems
that arise in connection with the
sales transaction or the operation of
your car will be handled by your
dealer's
Sales or Service Depart­
ments.
It is recognized, however,
that despite the best intentions of
everyone concerned, misunder­
standings will sometimes occur. If
you have a problem that has not
been handled to your satisfaction
through normal channels, we sug­
gest that you take the following
steps:
STEP ONE-Discuss your prob­
lem
with a member of dealer­
ship management. Frequently,
6-4
complaints are the result of a break­
down in communications and can
quickly be resolved by a member of
the dealership management.
If the
problem already has been reviewed
with the
Sales Manager or Service
Manager, contact the Dealer him­
self
or the General Manager.
STEP TWO-Contact the Chev­
rolet Zone
Office closest to you
listed on the following pages
(or
in Canada contact the Gen­
eral
Motors Zone Office). When
it appears that your problem
can­
not be readily resolved by the deal­
ership without additional assist­
ance, the matter should be called
to the attention of the Zone's Cus­
tomer Services Department and
the following information pro­
vided:

Downloaded from www.Manualslib.com manuals search engine • Your name, address, telephone
number
• Vehicle Identification number'
•
Dealer's name and location
• Vehicle's delivery date and
mileage
• Nature of problem
STEP THREE -Contact the
Customer Services Manager,
Chevrolet Central
Office, Chev­
rolet Motor Division, 'Detroit,
Michigan 48202 (313-556-5219)
(or In Canada contac.t the
Owner Relations Manager,
Oshawa, Ontario 416-644-6624).
If after an additional review of all
facts involved he feels that some
further action can be taken, he will
so instruct the Zone. In any case,
your contact
will be acknowledged
providing Chevrolet's position in
the matter.
When contacting the Zone or
Central Office, please bear in mind
that ultimately your problem likely
will. be :resolved in the dealership,
utilizing the dealer's facilities,
equipment and
personnel. It is sug·
gested, therefore, that you follow
the above steps in sequence when
pursuing a problem.
Your purchase of a Chevrolet
product
is greatly appreciated by
both your
dealer ' and Chevrolet
Motor Division.
It is our sincere
desire to assist you in any way
pos·
sible to assure your complete satis·
faction with your vehicle.
,
• Available from vehicle registration, title or plate attached to left top of instrument panel and visible through
the windshield,
'
&-5

Downloaded from www.Manualslib.com manuals search engine CHEVROLET ZONE OFFICE ADDRESSES
When calling for assistance, please ask for Customer Services Manager
Homewood, Ala. (Birmingham) 3490 Montgomery Hwy. 35210 (205) 870·5320
Tempe, Arizona (Phoenix) 1625 W. 23rd St. 8528~ (602) 968·2425
Los Angeles, c:alifornla
1800 Avenue of the Stars 90067 (213) 879·9611
Oakland, California 10910 E. 14th St. 94600 (415) 562·0553
San Diego, California 5353 Mission Center Rd. 92112 (714) 299·9480
Denver, Colorado 4355 Kean'ley St. 90200 (303) 320·5023
Jacksonville, Florida 8206 Phillips HWy. 32207 (904) 733·3682
Atlanta. Georgia 5730Glenridge Drive, N.E. (404) 256·5500
Indlal'lapolis, Indiana 2350 N. Shadeland Ave. 46206 (317) 269·5031
Oakbrook, Illinois (Chicago) 2021 Spring Rd. 60680 (312) 654·6345
Peoria, illinois 2009 N. Knoxville 61601 (309) 688·1021
Des Moines, Iowa 818 Fifth Ave. 50305 (515) 244·3141
Lenexa, Kansas (Kansas City) 8900 Marshall Dr. 66201 (913) 281·6702
Loulsvl~le, Kentucky. 4501 Indian Trail 40200 (502) 968·6203
Metairie, La. (New Orleans) 3545 1·10 Service Rd. (504) 888·9013
Hanover, Maryland (Baltimore) 1800 Parkway Drive 21201 (301) 796·3640
Westwood, Mass. (Boston) 505 Blue Hill Drive 02090 (617) 329·1057
Grand Blanc; Michigan (Flint) 5198 Territorial Road 48439 (313) 694·7007
Southfield, Michigan (Detroit) 15565 Northland Drive 48075 (313) 424·2011
Edina, Minn. (Minneapolis) 7600 Metro Blvd. 55424 (612) 830·4044
6-6
Maryland Heights, Missouri (St. Louis) 83 Progress Parkway 63043 (314) 878"3304
Omaha, Nebraska 11616 "'" Street 68100 (402) 333·4500
Englewood, N. J. (Newark) 385 Nordhoff Place 07631 (201) 894·7100
Bethpage, Long Island, N. Y. 175 Central Ave., South 11714 (516) 420·4340
Cheektowaga, N. Y. (Buffalo) 2615 Walden Ave. 14225 (716) 684·8025
Syracuse, N. Y. 107 Twin Oaks Dr. 13200 (315) 437·2861
Tarrytown, N. Y. 371 S. Broadway 10591 (914) 332·0136
Charlotte, N. Carolina 6000 Monroe Road (704) 568·2520
Fargo, N. D. W. Frontage Rd. Hwy. '·29 58102 (701) 282·4451
Parma, Ohio (Cleveland) 12990 Snow Road (Parma) 44129 (216) 265·5600

Downloaded from www.Manualslib.com manuals search engine ,
Service Publications-Chevrolet
The following publi9ations coveri ng t he operation and servicing o f you r Chevr olet can be pu rchased by filling out the
reverse-sid e of this ord er fo rm an d mailing it with you r check or money order to Helm Incorporated
FORM NO. DESCRIPTION . PRICE
ST 329-76 1976 PASSENGER CAR SERVICE AND OVERHAUL $4.25 . SUPPLEMENT
(Available
January, 1976_) For complete coverage ST
329-74 and ST 333-74 should also be purchased.
.-
ST 329-74 1974 SERVICE MANUAL • 7_50
Include s" on-the-car adjustments,
maintenance, and re-
moval and install ation o f compon ents. Some overhaul
information
is als o included (e.g. B rake Master Cylinder ,
distributor,
etc .) . Will provide service information to
handle most own er's requirement s.
ST333-74 1974 OVERHAUL MANUAL 6_50
I neludes basic off-the -car overhaul of major components
(
e.g . engine, transmi ssion, etc.). .
ST 335-76
1976 BODY SERVICE MANUAL 7.00
Includes:
Complete Body Service Information for all
". body styles.
" . " ST 3.04-76 1976 OWNER'S MANUAL 1.00 .
-J -~-NOTE: Please fill in r eve!'seside of this form completely Pric es subj ect to c hange