2023 FORD E SERIES spare wheel

Front axle jacking point: Place the jackunder the pin on the front surface of thefront axle.
Note:Do not place the jack under or on thesteering linkage.
Rear axle jacking points: All models exceptE-350 and E-450 dual rear wheel.
Rear axle jacking points: E-350 and E-450dual rear wheel.
Turn the jack handle clockwise. Forhydraulic jacks, operate the handleup-and-down until the wheel is completelyoff the ground and high enough to installthe spare tire.
Installing the spare wheel and tire
1.Remove the lug nuts with the lugwrench, replace the flat tire with thespare, making sure the valve stem ofthe spare is facing outward whenreplacing a front wheel. For the rearwheel position on vehicles with singlerear wheel fitments, install the spare
220
2023 E-Series (TE4) Canada/United States of America, enUSA, Edition date: 202111, First-PrintingWheels and Tires E366985 E201346 E201347 E162811 E162819

with the valve stem facing outward.For vehicles with dual rear wheels, thevalve stem of the spare must faceoutward when replacing an innerwheel, but must face inward whenreplacing an outboard wheel.
2.Install the lug nuts and finger tighten.Do not fully tighten the lug nuts untilthe wheel has been lowered.
3.Lower the vehicle completely byturning the jack handlecounterclockwise.
Note:For hydraulic jacks, insert the releasevalve, open release valve slightly by turningthe handle counterclockwise. Stop turningthe release valve when vehicle start tolower. Close the valve when the vehicle iscompletely lowered.
4.Install the lug nuts in the sequenceshown.
5.Remove the jack and fully tighten thelug nuts in the sequence shown. SeeTechnical Specifications (page 222).
6.Install any wheel covers or hubcaps.Make sure they snap into place.
Note:When installing the wheel centerornaments, make sure that the ornamentretention towers on the back side of theornament are aligned with the studs andwheel nuts and retain to the flange on thewheel nuts.
Stowing the Flat tire or Spare tire
1.Place the tire on end with the valvestem facing toward the front of thevehicle. Lay the tire on the ground, nearthe rear of the vehicle, with the valvestem side facing up.
2.Slide the wheel partially under thevehicle and install the retainer throughthe wheel center. If equipped, you mayhave to remove the wheel center capprior to pushing the retainer throughthe center of the wheel. To remove thecenter cap, press it off with the lugwrench tip from the inner side of thewheel. Pull on the cable to align thecomponents at the end of the cable.
221
2023 E-Series (TE4) Canada/United States of America, enUSA, Edition date: 202111, First-PrintingWheels and Tires13427658E161441 12345678910E169375 E162800

3.Turn the lug wrench clockwise until thetire is raised to its stowed positionunderneath the vehicle. The wrenchbecomes harder to turn and the sparetire winch ratchets or slips when thetire is raised to its maximum tightness.A clicking sound is heard from thewinch indicating that the tire is properlystowed. Check that the tire lies flat
against the frame and is properlytightened.
4.Reinstall the tools and tighten the wingnut.
5.Reinstall the jack properly into thebracket and tighten the wing nut.
6.Unblock the wheel.
TECHNICAL SPECIFICATIONS
Wheel Lug Nut Torque Specifications
WARNING: When you install a wheel, always remove any corrosion, dirt or foreignmaterials present on the mounting surfaces of the wheel or the surface of the wheelhub, brake drum or brake disc that contacts the wheel. Make sure to secure any fastenersthat attach the rotor to the hub so they do not interfere with the mounting surfaces ofthe wheel. Installing wheels without correct metal-to-metal contact at the wheelmounting surfaces can cause the wheel nuts to loosen and the wheel to come off whileyour vehicle is in motion, resulting in loss of vehicle control, personal injury or death.
lb.ft (Nm)Bolt size
140 lb.ft (190 Nm)9/16 x 18 two-piece lug nut
On vehicles equipped with single rear wheels, retighten the lug nuts to the specified torqueat 100 miles (160 kilometers) after any wheel disturbance (such as tire rotation, changinga flat tire, wheel removal).
On vehicles equipped with dual rear wheels, retighten the wheel lug nuts to the specifiedtorque at 100 miles (160 kilometers), and again at 500 miles (800 kilometers) of newvehicle operation and after any wheel disturbance (such as tire rotation, changing a flattire, wheel removal).
222
2023 E-Series (TE4) Canada/United States of America, enUSA, Edition date: 202111, First-PrintingWheels and Tires

Power Seats.....................................................79Power Steering Fluid Check......................174Power Windows..............................................57Pre-Collision Assist......................................120Protecting the Environment........................17PunctureSee: Changing a Road Wheel.........................215
R
Radio Frequency CertificationLabels............................................................255Cruise Control Module.....................................255Rear Axle Fluid Capacity andSpecification...............................................232Rear Passenger Climate Controls............76Rear View Camera.......................................106Rear View CameraSee: Rear View Camera...................................106Recommended Towing Weights............130Reduced Engine Performance.................138Refueling...........................................................89Remote Control..............................................42Removing a Headlamp...............................178Repairing Minor Paint Damage...............186Replacement PartsRecommendation........................................10Replacing a Lost Key or RemoteControl............................................................44Reporting Safety Defects (CanadaOnly)................................................................151Reporting Safety Defects (U.S.Only)..............................................................150Resuming the Set Speed..........................108Roadside Assistance....................................141Roadside Emergencies................................141Running-InSee: Breaking-In..................................................139Running Out of Fuel......................................88
S
Safety Precautions........................................86Scheduled Maintenance...........................247Seatbelt Extensions......................................34Seatbelt Height Adjustment......................33Seatbelts...........................................................30Principle of Operation........................................30
Seatbelt Warning Lamp and IndicatorChime...............................................................33Seats....................................................................77Security..............................................................48Service Data......................................................14Settings Data....................................................15Setting the Cruise Control Speed...........107Sitting in the Correct Position....................77Snow ChainsSee: Using Snow Chains.................................208Spare WheelSee: Changing a Road Wheel.........................215Special Notices................................................10Special Operating Conditions ScheduledMaintenance...............................................252Speed ControlSee: Cruise Control.............................................107Stability Control............................................104Principle of Operation......................................104Starter SwitchSee: Ignition Switch.............................................82Starting a Gasoline Engine.........................82Starting and Stopping the Engine...........82General Information............................................82Steering.............................................................119Steering Wheel...............................................49Streaming Bluetooth Audio....................240Sun Visors.........................................................58Supplementary Restraints System.........35Principle of Operation.........................................35Switching Automatic High Beam ControlOn and Off.....................................................55Switching Cruise Control On andOff....................................................................107Symbols Glossary.............................................7
T
Technical SpecificationsSee: Capacities and Specifications............224The Better Business Bureau (BBB) AutoLine Program (U.S. Only).......................148Tire Care..........................................................190Tire Pressure Monitoring System..........209TiresSee: Wheels and Tires......................................189Towing a Trailer.............................................129
288
2023 E-Series (TE4) Canada/United States of America, enUSA, Edition date: 202111, First-PrintingIndex