2023 CHEVROLET COLORADO overheating

Chevrolet Colorado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
15274222) - 2022 - CRC - 11/2/21
Vehicle Care 249
{Warning
Steam and scalding liquids from a hot
cooling system are under pressure.
Turning the pressure cap, even a little,
can cause them to come out at high
speed and you could be burned. Never
turn the cap when the cooling system,
including the pressure cap, is hot. Wait
for the cooling system and pressure cap
to cool.
Caution
Failure to follow the specific coolant fill
procedure could cause the engine to
overheat and could cause system
damage. If coolant is not visible in the
surge tank, contact your dealer.
The coolant surge tank pressure cap can be
removed when the cooling system, including
the surge tank pressure cap and upper
radiator hose, is no longer hot.
1. Turn the pressure cap slowly counterclockwise. If a hiss is heard, wait
for that to stop. A hiss means there is
still some pressure left.
2. Keep turning the cap and remove it.
3. Fill the coolant surge tank with the proper mixture to the mark pointed to
on the front of the coolant surge tank. 4. With the coolant surge tank cap off,
start the engine and let it run until the
upper radiator hose starts getting hot.
Watch out for the engine cooling fan. By
this time, the coolant level inside the
coolant surge tank may be lower. If the
level is lower, add more of the proper
mixture to the coolant surge tank until
the level reaches the mark pointed to on
the front of the coolant surge tank.
5. Replace the cap tightly.
6. Verify coolant level after the engine is shut off and the coolant is cold.
If necessary, repeat coolant fill procedure
Steps 1–6.
Caution
If the pressure cap is not tightly installed,
coolant loss and engine damage may
occur. Be sure the cap is properly and
tightly secured.
Engine Overheating
The vehicle has an engine coolant
temperature gauge on the instrument
cluster to warn of engine overheating. See
Engine Coolant Temperature Gauge 085.

Chevrolet Colorado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
15274222) - 2022 - CRC - 11/2/21
250 Vehicle Care
Caution
Do not run the engine if there is a leak
in the engine cooling system. This can
cause a loss of all coolant and can
damage the system and vehicle. Have
any leaks fixed right away.
If the decision is made not to lift the hood
when this warning appears, get service help
right away.
If the decision is made to lift the hood,
make sure the vehicle is parked on a level
surface.
Then check to see if the engine cooling fan
is running. If the engine is overheating, the
fan should be running. If it is not, do not
continue to run the engine and have the
vehicle serviced.
If Steam Is Coming from the Engine
Compartment
{Warning
Steam and scalding liquids from a hot
cooling system are under pressure.
Turning the pressure cap, even a little,
can cause them to come out at high (Continued)
Warning (Continued)
speed and you could be burned. Never
turn the cap when the cooling system,
including the pressure cap, is hot. Wait
for the cooling system and pressure cap
to cool.
If No Steam Is Coming from the Engine
Compartment
If an engine overheat warning is displayed
but no steam can be seen or heard, the
problem may not be too serious. Sometimes
the engine can get a little too hot when the
vehicle:
.Climbs a long hill on a hot day.
.Stops after high-speed driving.
.Idles for long periods in traffic.
If the overheat warning is displayed with no
sign of steam: 1. Turn the air conditioning off.
2. Turn the heater on to the highest temperature and to the highest fan
speed. Open the windows as necessary.
3. When it is safe to do so, pull off the road, shift to P (Park) or N (Neutral), and
let the engine idle. If the engine coolant temperature gauge is
no longer in the overheat zone, the vehicle
can be driven. Continue to drive the vehicle
slowly for about 10 minutes. Keep a safe
distance from the vehicle in front. If the
warning does not come back on, continue to
drive normally and have the cooling system
checked for proper fill and function.
If the warning continues, pull over, stop, and
park the vehicle right away.
If there is no sign of steam, idle the engine
for three minutes while parked. If the
warning is still displayed, turn off the
engine until it cools down.
Engine Fan
If the vehicle has a clutched engine cooling
fan, when the clutch is engaged, the fan
spins faster to provide more air to cool the
engine. In most everyday driving conditions,
the fan is spinning slower and the clutch is
not fully engaged. This improves fuel
economy and reduces fan noise. Under
heavy vehicle loading, trailer towing, and/or
high outside temperatures, the fan speed
increases as the clutch more fully engages,
so an increase in fan noise may be heard.
This is normal and should not be mistaken
as the transmission slipping or making extra

Chevrolet Colorado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
15274222) - 2022 - CRC - 11/2/21
270 Vehicle Care
warranty and where to get service. For
additional information refer to the tire
manufacturer.
{Warning
.Poorly maintained and improperly
used tires are dangerous.
.Overloading the tires can cause
overheating as a result of too
much flexing. There could be a
blowout and a serious crash. See
Vehicle Load Limits0178.
.Underinflated tires pose the same
danger as overloaded tires. The
resulting crash could cause serious
injury. Check all tires frequently to
maintain the recommended
pressure. Tire pressure should be
checked when the tires are cold.
.Overinflated tires are more likely
to be cut, punctured, or broken by
a sudden impact —such as when
hitting a pothole. Keep tires at the
recommended pressure.
(Continued)
Warning (Continued)
.Worn or old tires can cause a
crash. If the tread is badly worn,
replace them.
.Replace any tires that have been
damaged by impacts with
potholes, curbs, etc.
.Improperly repaired tires can cause
a crash. Only your dealer or an
authorized tire service center
should repair, replace, dismount,
and mount the tires.
.Do not spin the tires in excess of
56 km/h (35 mph) on slippery
surfaces such as snow, mud, ice,
etc. Excessive spinning may cause
the tires to explode.
All-Season Tires
This vehicle may come with all-season tires.
These tires are designed to provide good
overall performance on most road surfaces
and weather conditions. Original equipment
tires designed to GM's specific tire
performance criteria have a TPC specification
code molded onto the sidewall. Original equipment all-season tires can be identified
by the last two characters of this TPC code,
which will be
“MS.”
Consider installing winter tires on the
vehicle if frequent driving on snow or
ice-covered roads is expected. All-season tires
provide adequate performance for most
winter driving conditions, but they may not
offer the same level of traction or
performance as winter tires on snow or
ice-covered roads. See Winter Tires0270.
Winter Tires
This vehicle was not originally equipped
with winter tires. Winter tires are designed
for increased traction on snow and
ice-covered roads. Consider installing winter
tires on the vehicle if frequent driving on ice
or snow covered roads is expected. See your
dealer for details regarding winter tire
availability and proper tire selection. Also,
see Buying New Tires 0282.
With winter tires, there may be decreased
dry road traction, increased road noise, and
shorter tread life. After changing to winter
tires, be alert for changes in vehicle
handling and braking.

Chevrolet Colorado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
15274222) - 2022 - CRC - 11/2/21
Vehicle Care 275
Recommended Inflation Pressure:
Vehicle manufacturer's recommended
tire inflation pressure as shown on the
tire placard. SeeTire Pressure0275 and
Vehicle Load Limits 0178.
Radial Ply Tire
:A pneumatic tire in
which the ply cords that extend to the
beads are laid at 90 degrees to the
centerline of the tread.
Rim
:A metal support for a tire and
upon which the tire beads are seated.
Sidewall
:The portion of a tire between
the tread and the bead.
Speed Rating
:An alphanumeric code
assigned to a tire indicating the
maximum speed at which a tire can
operate.
Traction
:The friction between the tire
and the road surface. The amount of
grip provided.
Tread
:The portion of a tire that comes
into contact with the road. Treadwear Indicators
:Narrow bands,
sometimes called wear bars, that show
across the tread of a tire when only
1.6 mm (1/16 in) of tread remains. See
When It Is Time for New Tires 0281.
UTQGS (Uniform Tire Quality Grading
Standards)
:A tire information system
that provides consumers with ratings
for a tire's traction, temperature, and
treadwear. Ratings are determined by
tire manufacturers using government
testing procedures. The ratings are
molded into the sidewall of the tire.
See Uniform Tire Quality Grading 0283.
Vehicle Capacity Weight
:The number
of designated seating positions
multiplied by 68 kg (150 lb) plus the
rated cargo load. See Vehicle Load
Limits 0178.
Vehicle Maximum Load on the Tire
:
Load on an individual tire due to curb
weight, accessory weight, occupant
weight, and cargo weight.
Vehicle Placard
:A label permanently
attached to a vehicle showing the
vehicle capacity weight and the original equipment tire size and recommended
inflation pressure. See
“Tire and Loading
Information Label” underVehicle Load
Limits 0178.
Tire Pressure
Tires need the correct amount of air
pressure to operate effectively.
{Warning
Neither tire underinflation nor
overinflation is good. Underinflated
tires, or tires that do not have
enough air, can result in:
.Tire overloading and overheating,
which could lead to a blowout.
.Premature or irregular wear.
.Poor handling.
.Reduced fuel economy.
Overinflated tires, or tires that have
too much air, can result in:
.Unusual wear.
.Poor handling.
(Continued)

Chevrolet Colorado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
15274222) - 2022 - CRC - 11/2/21
Index 353
Driving (cont'd)Winter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 176
E
Electrical Equipment, Add-On . . . . . . . . . . . . 234
Electrical System
Engine Compartment Fuse Block . . . . . . . 262
Fuses and Circuit Breakers . . . . . . . . . . . . . 262
Instrument Panel Fuse Block . . . . . . . . . . . 267
Overload . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 260
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 343
Engine Air Cleaner/Filter . . . . . . . . . . . . . . . . . . . . . . 245
Check Light (Malfunction Indicator) . . . . . 87
Compartment Overview . . . . . . . . . . . . . . . . 239
Coolant Temperature Gauge . . . . . . . . . . . . 85
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . 246
Drive Belt Routing . . . . . . . . . . . . . . . . . . . . . 330
Exhaust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 190
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 250
Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 187
Oil Life System . . . . . . . . . . . . . . . . . . . . . . . . 244
Oil Pressure Light . . . . . . . . . . . . . . . . . . . . . . . 92
Overheating . . . . . . . . . . . . . . . . . . . . . . . . . . . 249
Power Messages . . . . . . . . . . . . . . . . . . . . . . . . 98
Running While Parked . . . . . . . . . . . . . . . . . 190
Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 186 Entry Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . 107
Equipment, Towing . . . . . . . . . . . . . . . . . . . . . . 228
Event Data Recorders . . . . . . . . . . . . . . . . . . . . .341
Exit Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 107
Extender, Seat Belt . . . . . . . . . . . . . . . . . . . . . . . .33
Exterior Cargo Lamps . . . . . . . . . . . . . . . . . . . . 105
Exterior Lamp Controls . . . . . . . . . . . . . . . . . . . 102
Exterior Lamps Off Reminder . . . . . . . . . . . . 103
Exterior Lighting Battery Saver . . . . . . . . . . 108
F
Fan
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 250
Filter, Engine Air Cleaner . . . . . . . . . . . . . . . . . . . . . 245
Flash-to-Pass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Flashers, Hazard Warning . . . . . . . . . . . . . . . . 104
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 286 Changing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 287
Floor Mats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 311
Fluid Automatic Transmission . . . . . . . . . . . . . . . 245
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 252
Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Fog Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
Folding Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Forward Collision Alert (FCA) System . . . . . 212 Four-Wheel
Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 254
Drive Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Drive System . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 339
Front Axle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 254
Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 206
Front Fog Lamp Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Front Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Heated . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Fuel Additives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 217
Economy, Driving for Better . . . . . . . . . . . 169
Filling a Portable Fuel Container . . . . . . . 219
Filling the Tank . . . . . . . . . . . . . . . . . . . . . . . . . 217
Foreign Countries . . . . . . . . . . . . . . . . . . . . . . . 217
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Low Fuel Warning Light . . . . . . . . . . . . . . . . 92
Management, Active . . . . . . . . . . . . . . . . . . . 190
Prohibited Fuels . . . . . . . . . . . . . . . . . . . . . . . . 217
Recommended . . . . . . . . . . . . . . . . . . . . . . . . . 216
Top Tier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 216
Full-Size Spare Tire . . . . . . . . . . . . . . . . . . . . . . . 297
Fuses Engine Compartment Fuse Block . . . . . . . 262

Chevrolet Colorado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
15274222) - 2022 - CRC - 11/2/21
356 Index
MessagesEngine Power . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Vehicle Speed . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Mirrors Automatic Dimming Rearview . . . . . . . . . . 18
Blind Spot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Convex . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Folding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Heated . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Manual Rearview . . . . . . . . . . . . . . . . . . . . . . . 18
Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Mirrors, Interior Rearview . . . . . . . . . . . . . . . . . .18
Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 205 Driver Control . . . . . . . . . . . . . . . . . . . . . . . . . 205
Monitor System, Tire Pressure . . . . . . . . . . . 276
Multi-band Antenna . . . . . . . . . . . . . . . . . . . . . . 119
N
Navigation Connected Services . . . . . . . . . . . . . . . . . . . . 347
Destination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Using the System . . . . . . . . . . . . . . . . . . . . . . 123
Navigation Symbols . . . . . . . . . . . . . . . . . . . . . 126
New Vehicle Break-In . . . . . . . . . . . . . . . . . . . . .183
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83 Odometer (cont'd)
Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Off-Road . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172 Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Recovery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Engine Oil Life System . . . . . . . . . . . . . . . . . 244
Pressure Light . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Older Children, Restraints . . . . . . . . . . . . . . . . . 44
Online Owner Center . . . . . . . . . . . . . . . . . . . . 333
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .341
OnStar Additional Information . . . . . . . . . . . 344
OnStar Emergency . . . . . . . . . . . . . . . . . . . . . . . 343
OnStar Overview . . . . . . . . . . . . . . . . . . . . . . . . . 342
OnStar Security . . . . . . . . . . . . . . . . . . . . . . . . . . 343
Operation Fog Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
Outlets Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
Overheating, Engine . . . . . . . . . . . . . . . . . . . . . 249
Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .110
Instrument Panel . . . . . . . . . . . . . . . . . . . . . . . . 4
P
ParkShifting Into . . . . . . . . . . . . . . . . . . . . . . . . . . . 188
Shifting Out of . . . . . . . . . . . . . . . . . . . . . . . . 189 Park Assist . . . . . . . . . . . . . . . . . . . . . . . . . . . 210, 212
Parking
Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 201
Brake and P (Park) MechanismCheck . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 255
Over Things That Burn . . . . . . . . . . . . . . . . . 189
Parking or Backing
Assistance Systems . . . . . . . . . . . . . . . . . . . . 210
Passenger Airbag Status Indicator . . . . . . . . . 86
Passenger Compartment Air Filter . . . . . . . 167
Passenger Sensing System . . . . . . . . . . . . . . . . 39
Perchlorate Materials Requirements, California . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 237
Personalization Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Phone
Apple CarPlay and Android Auto . . . . . . . 144
Bluetooth . . . . . . . . . . . . . . . . . . . . . . . . . 139, 140
Port USB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119
Positioning
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 133
Power Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Outlets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
Protection, Battery . . . . . . . . . . . . . . . . . . . . . 108
Retained Accessory (RAP) . . . . . . . . . . . . . . 188