2022 VOLVO XC40 service

38
WARRANTY
Owner’s ObligationsFailure to make corrections of accident damage,
acts of nature, or to maintain the vehicle
properly, including washing and polishing as
described in the Owner’s Manual, voids this
warranty.
It is your responsibility to retain all maintenance
and repair documentation. To avoid potential
deterioration, your retailer must be notified as
soon as possible of any problems with the painted
surfaces.
NOTE
This warranty can be provided because
in manufacturing the vehicle, Volvo used
processes and materials which are designed to
help resist corrosion.
The application of additional rust proofing
products at the time of new car purchase, is not
recommended by Volvo. If non-Volvo products
were chemically incompatible with the Volvo
factory applied protection, they could cause
problems which would result in voiding this
warranty.
If an accident should occur, you must ensure
that the following conditions are met in order to
maintain coverage under the Corrosion Protection
Warranty:
• repairs are performed to Volvo standards,
• your Volvo retailer will identify the location of a
Volvo Certified Body and Paint Service Center,
• only genuine Volvo new replacement parts are
installed,
• undercoating and/or rust proofing is reapplied
wherever necessary. (See your Volvo retailer
for details on Volvo-approved rust prevention
materials.)
Seat belts and Supplemental
Restraint Systems, Limited Warranty–
U.S./Warranty–Canada
What Is Warranted
Volvo warrants that repairs required due to defects
in the material or workmanship to the seat belt
system and Supplemental Restraint System (SRS)
installed in your 2022 model year vehicle will be
performed free-of-charge during the warranty
period (except for those items listed under “What
Is Not Warranted”).
LimitationsNo implied warranty of merchantability or
fitness for a particular purpose shall apply
except during the applicable periods of this
warranty.
This warranty gives you specific legal rights, and
you may also have other rights which vary from
state to state, province to province. Some states/
provinces do not allow limitations on how
long an implied warranty lasts, so the above
limitations may not apply to you.
For a complete description, refer to the article
“Limitations and Disclaimers” in this booklet.

39
WARRANTY
The Warranty PeriodThe warranty period is five (5) years and has no
mileage/kilometer limitation.5 It begins with the
date the vehicle is sold/delivered to the first retail
purchaser or put into service, whichever occurs
first.
What Is Not Warranted• Seat belt system and Supplemental
Restraint System components which show
evidence of damage because of abuse,
misuse, negligence, tampering, or improper
installation.
• Replacement of seat belt system or
Supplemental Restraint System components
after a vehicle has been involved in a collision.
• The loss of vehicle use, loss of time,
inconvenience or other incidental charges,
such as telephone calls, towing, lodging,
car rental, or food, or other consequential
damages except where required by law.
• Repairs required as part of normal
maintenance.
• Replacement of components in accordance
with the maintenance schedule.
Seat belts: “Something We Believe In”
Seat belts are an integral part of the safety
system engineered into each Volvo.
Despite our strongest recommendations, and
your best intentions, not wearing a seat belt is
like believing “it’ll never happen to me!”
Volvo urges you and all adult occupants of your
car to properly wear seat belts in all seating
positions, and ensure that children are properly
restrained in the rear seats only, using an infant
car seat or booster seat determined by age,
weight and height.
Fact: In every state/province, some type of child
restraint legislation has been passed. Additionally,
most states/provinces have already made it
mandatory for occupants of a car to use seat
belts.
So, urging you to “buckle up” is not just our
recommendation – it’s becoming the law! The
few seconds it takes to buckle up may one day
allow you to say, “It’s a good thing I was wearing
my seat belt.”
Instructions for proper seat belt usage can be
found in your Owner’s Manual..
Emissions Warranties – U.S. and
Canada
Design and Defect Warranty
What Is Warranted–U.S.
Volvo warrants that your 2022 model year Volvo
was designed, built, and equipped to conform
at the time of sale to U.S. emission standards, in
accordance with Section 207(A) of the Federal
Clean Air Act, which was applicable when the
vehicle was manufactured.
What Is Warranted–Canada
Volvo warrants that your 2022 model year Volvo
was designed, built, and equipped to conform at
the time of sale to Canadian emission standards,
in accordance with the Canadian Motor Vehicle
Safety Act, which was applicable when the
vehicle was manufactured.
5 In the U.S., some states have mandated alternate warranty coverage for seat belts only. Contact your Volvo retailer for details of local requirements.

40
WARRANTY
In the U.S. and Canada
This warranty covers repairs resulting from any
defect in material or workmanship which would
cause the vehicle not to meet emission standards
during the applicable warranty period. Some
components considered part of the emission
system applicable to this warranty are listed in the
article “Emission Warranty Parts List – Federal –
U.S. and Canada” in this booklet.
This emission warranty is not conditionally based
on the use of genuine Volvo parts or service.
However, failures which occur as a result of
abuse or lack of maintenance are not eligible for
coverage.
Warranty Period
The federal emissions design and defect warranty
period is two (2) years or 24,000 miles/ 40,000
kilometers, whichever occurs first. Volvo continues
coverage under new car warranty to four (4) years
or 50,000 miles/80,000 kilometers, whichever
occurs first, except for certain specified major
emissions components for which the coverage
is eight (8) years or 80,000 miles/130,000
kilometers, whichever occurs first. These major
components include only the threeway catalytic
converter (TWC), engine control module (ECM),
electronic rear axle drive (ERAD) and the
onboard diagnostic system (OBD). (Refer to the
2022 Emission Warranty Parts List for specific
components’ coverage.) The warranty begins on
the date the vehicle is sold/delivered to the first
retail purchaser or put into service, whichever
occurs first. Any remaining portion of the warranty
is fully transferable to subsequent owners free-of-
charge. Where the warranty applies
This warranty applies to 2022 model year vehicles
sold by Volvo Car USA, LLC, or Volvo Car Canada
Limited, certified for sale, registered and normally
operated in any 50 states of the U.S., the District
of Columbia, any territories or commonwealths of
the United States, or any territories or provinces
of Canada.
Repairs and Service
The emission control system of your new 2022
model year Volvo passenger vehicle was designed,
built, and tested using genuine Volvo parts.
The car is certified to be in conformity with the
appropriate U.S. Federal or Canadian emission
control regulations at the time of production.
Servicing
It is recommended that any replacement parts
used for maintenance, repair, or replacement of
emission control systems be genuine Volvo parts
or genuine Volvo remanufactured parts.
You may elect to have maintenance, repair, or
replacement of the emission control devices
and systems performed by any automotive
repair establishment or individual. You may
also elect to use parts other than genuine
Volvo parts or genuine Volvo remanufactured
parts which have been certified by the part
manufacturer for such maintenance, repair, or
replacement without invalidating this warranty.
The cost of such service or parts, however, will
not be covered under the warranty. Parts
Use of replacement parts which are not equivalent
to Volvo quality may impair the effectiveness of
emission control systems. If other than genuine
Volvo parts or genuine Volvo remanufactured parts
are used for maintenance, repair, or replacement
of components affecting emission control, the
owner must obtain assurances that such parts are
warranted by their manufacturer to be equivalent
to genuine Volvo parts in performance and
durability. Volvo assumes no liability under this
warranty for parts other than genuine Volvo parts
or genuine Volvo remanufactured parts. However,
the use of non-Volvo replacement parts does not
invalidate the warranty on other components
unless the non-Volvo parts cause damage to
warranted parts or systems.

41
WARRANTY

Retailer Service
Repairs and service covered by this warranty will
be performed by an authorized Volvo retailer at his
place of business with no charge for parts or labor
(including diagnosis), using genuine Volvo parts or
genuine Volvo remanufactured parts for any part
of the emission control system covered by this
warranty and found defective.
If an emergency occurs and no authorized Volvo
retailer is available, repairs may be performed at
any available service establishment. Volvo will
reimburse the owner for such repairs (including
labor, in most cases) that are covered under this
warranty. Replaced parts and paid invoices must
be presented at a Volvo retail facility as a condition
of reimbursement for emergency repairs not
performed by a Volvo retailer.
We encourage you to have all recommended
maintenance and repairs on your new 2022 Volvo
vehicle completed. Volvo will not deny a warranty
claim solely because you have no record of
maintenance; however, Volvo may deny a warranty
claim if your failure to perform maintenance
resulted in the failure of a warranted part.
Receipts covering the performance of regular
maintenance must be retained for reference and
confirmation purposes.
What Is Not Warranted1. Required maintenance services as specified
in the Owner’s Manual and in the article
“Maintenance Service Operations” in this



booklet. Items that affect emissions and
require scheduled replacement are warranted
up to their first replacement point [such as
spark plugs, filters, belts, etc.]. Once these
parts have been replaced at the scheduled
replacement point, they are no longer covered
by this Emissions Warranty. The replaced
parts are covered by the two (2) year spare
parts warranty.
2. Malfunctions in any part caused by any of
the following: misuse, improper adjustments,
modification, alteration, tampering,
disconnection of system parts, and improper,
inadequate or non-maintenance.
3. Damage resulting from accidents, acts of
nature, and events beyond the control of
Volvo.
4. The use of fuel and/or oil, or other fluids which
do not meet the Volvo-approved standards
as set forth in the Owner’s Manual, Volvo
Service Literature or in the articles “Fuel
requirements” and “Engine oil” in this booklet,
which results in the failure of a warranted part
or system, may not be warranted.
5. Repairs on vehicles for which the true
odometer mileage cannot be readily
determined.
6. The cost incurred from the use of parts other
than genuine Volvo replacement parts or
genuine Volvo remanufactured parts used for
maintenance, repair or replacement affecting
components of the emission control system. 7.
Any loss of time, inconvenience, loss of vehicle
use or commercial loss.
Emission Performance Warranty–U.S.
and Canada
The warranty begins on the date the vehicle is
sold/delivered to the first retail purchaser or put
into service, whichever occurs first.
In accordance with Section 207(B) of the Clean
Air Act, Canadian MDU and Canadian Provincial
Warranty Regulations, Volvo warrants to the first
vehicle purchaser and each subsequent purchaser,
that if
1. the vehicle is maintained and operated in
accordance with the written instructions for
proper maintenance and use (Refer to the
Owner’s Manual under the section titled
“Service and Routine Maintenance” and
the article “2022 Service and Maintenance
Requirements” in this booklet), and
2. the vehicle fails to conform at any time during
the first 24,000 miles/40,000 kilometers
or two (2) years (whichever occurs first) to
the applicable emission standards as judged
by an EPA approved or Canadian Provincial
approved emission short test, and
3. such non-conformity will result in the vehicle
owner having to bear any penalty or other
sanction (including denial of the right to use
the vehicle) under local, state, federal or
provincial law, then Volvo shall remedy the
nonconformity at no cost to the owner.

42
WARRANTY
Some components considered part of the
two (2) Year/ 24,000 mile/40,000 kilometer
Emission Performance Warranty are listed in
the article “2022 Emission Warranty Parts List
– Federal – U.S. and Canada” in this booklet.
Exceptions1. If the vehicle has been in operation for more
than two (2) years or 24,000 miles/ 40,000
kilometers, Volvo will remedy only those
nonconformities resulting from failure of
certain specified emission control components
for which coverage is eight (8) years or
80,000 miles/130,000 kilometers, whichever
occurs first. These major components include
only the three-way catalytic converter (TWC),
engine control module (ECM), electronic rear
axle drive (ERAD) and the on-board diagnostic
system (OBD).
2. Volvo may deny an Emission Performance
Warranty claim on the basis of an uncertified
replacement part used in the maintenance and
repair of a vehicle if the part in question is either
defective in material or workmanship or not
equivalent from an emission standpoint to the
original equipment part.
3. An Emission Performance Warranty claim may
be denied on the basis of non-compliance by a
vehicle owner with the written instructions for
proper maintenance and use.
ServicingIt is recommended that any replacement parts
used for maintenance, repair or replacement of emission control systems be genuine Volvo parts
or genuine Volvo remanufactured parts.
You may elect to have maintenance, repair, or
replacement of the emission control devices and
systems performed by any automotive repair
establishment or individual. You may also elect
to use parts other than genuine Volvo parts or
genuine Volvo remanufactured parts which have
been certified by the part manufacturer for such
maintenance, repair or replacement without
invalidating this warranty. The cost of such
service or parts however, will not be covered
under the warranty.
Customer AssistanceVolvo wants to ensure that the Emission
Warranties are properly administered. If you do not
receive the warranty service to which you believe
you are entitled under these warranties, you should
contact:
In the U.S. and Canada
Volvo Car USA, LLC
Customer Care Center
933 MacArthur Blvd.
Mahwah, NJ 07430
1-800-458-1552
http://volvocars.com.us/support You may obtain further information concerning the
Emission Performance Warranty and Emission
Design and Defect Warranty or report violations of
the terms of these warranties, by contacting:
Compliance and Innovative Strategies Division
Warranty Claims
U.S. Environmental Protection Agency
2000 Traverwood Drive
Ann Arbor, MI 48105
Warranty Claim ProceduresAn Emission Performance Warranty claim may
be raised immediately upon the failure of an EPA approved or Canadian Provincial approved
emission test, if, as a result of that failure, an
owner is required by law to take action of any
kind in order to avoid imposition of a penalty or
sanction. A warranty claim may be generated by

43
WARRANTY
bringing vehicle to any authorized Volvo retailer.
To the extent required by any federal, state, or
provincial law, whether statutory or common
law, a vehicle manufacturer shall be required
to provide a means for non-franchised repair
facilities to perform Emission Performance
Warranty repairs.
However, to avoid delay and ensure proper
service, it is recommended that service under this
warranty be performed by an authorized Volvo
retailer.
When determining whether an owner has
complied with the written instructions for proper
maintenance and use, Volvo may require an
owner to submit evidence of compliance if it has
an objective reason for believing:
1. maintenance was not performed and,
2. that if not performed, it could be the cause
of the vehicle exceeding applicable emission
standards.
Failure to notify the owner of a decision to honor
or deny an Emission Performance Warranty claim
within thirty (30) days from the time the vehicle
is presented for repair shall result in the vehicle
manufacturer being responsible for repairing
the vehicle without charge to the vehicle owner,
unless such failure is attributable to the vehicle
owner or to events which are beyond the control
of the vehicle manufacturer or repair facility.
2022 Emission Warranty Parts List –
Federal – U.S. and Canada
The following are some items covered by the
Emission Warranty for (2) years or 24,000
miles/40,000 kilometers, whichever occurs
first. Volvo has continued coverage on these
items under the new car warranty for (4) years
or 50,000 miles/80,000 kilometers, whichever
occurs first. Components marked with “*” are
covered by the Long-Term Warranty for eight
(8) years or 80,000 miles/130,000 kilometers,
whichever occurs first. Components marked with
“**” are covered for eight (8) years or 100,000
miles/160,000 kilometers, whichever occurs first.
• Ambient Air Temp Sensor
• Camshaft Position Sensor
• Catalytic Converter*
• Charge Air Cooler
• Charge Air Cooler Intake Manifold
• Control Valve (Water Cooled CAC)
• Coolant Pump
• Coolant Temperature Sensor
• Coolant Thermostat
• Crankshaft Positon Sensor
• CVVT Solenoid Valve (Exhaust/Intake)
• CVVT Timing Device (Exhaust/Intake)
• EGR Cooler
• EGR Pressure Sensor
• EGR Valve
• Electrical Supercharger
• Electrical Supercharger Bypass Valve
• Electronic Throttle Module (ETM)
• Engine Control Module (ECM) Hardware*
• Engine Control Module (ECM) Software
• EVAP Carbon Canister
• EVAP Leakage Control Module (ECLM)
• Filler Pipe
• Fuel Filler Pipe (Capless)
• Fuel High-Pressure Sensor
• Fuel Injector
• Fuel Low-Pressure Sensor
• Fuel Pump
• Fuel Pump Electronic/H Module (PEM)
• Fuel Rail
• Fuel Tank
• Fuel Tank Isolation Valve (FTIV)
• Heated Oxygen Sensor(s)
• High-Pressure Fuel Pump
• Ignition Coil
• Integrated Starter Generator (C-ISG)
• Knock Sensor
• Manifold Absolute Pressure (MAP) Sensor
• Mass Air Flow (MAF) Sensor
• Oil Separator with Crankcase Pressure
Regulator
• On-Board Diagnostic System (OBD)*
• Purge Valve
• Purge Valve Assembly incl. Purge Valve
• Spark Plug (Kit)
• Supercharger
* Covered by the Long-Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.

47
WARRANTY
Oregon Department of Environmental Quality
811 SW 6th Avenue
Portland, OR 97204
State of Washington Department of Ecology
P.O. Box 47600
Olympia, WA 98504-7600
Maryland Department of The Environment
Mobil Source Control Program
1800 Washington Blvd., Suite 705
Baltimore, MD 21230-1720
Delaware Department of Natural Resources
Division of Air Quality
655 S. Bay Road
Dover, DE 19901
Bureau of Mobile Sources NYS Department of Environmental
Conservation
625 Broadway
Albany, NY 12233-3255Volvo’s Emission System Warranty
States of California, Connecticut,
Delaware, Maine, Massachusetts,
Maryland, New Jersey, New York,
Oregon, Pennsylvania, Rhode Island,
Vermont and Washington only
Volvo Car USA, LLC7 (“Volvo” or “VCUSA”)
warrants that your 2022 model year Volvo
passenger vehicle was designed, built and
equipped to conform to applicable California
emission standards as specified under the Health
and Safety Code 43205.
This warranty covers repairs resulting from any
defect in material or workmanship which would
cause any part installed on this vehicle which
affects any regulated emissions to not meet these
requirements or would cause the vehicle to fail
to pass a Smog Check test during the applicable
warranty period.
Warranty CoverageThe warranty period begins on the date the
vehicle is delivered to the first retail purchaser
or the initial date the vehicle is put into service,
whichever occurs first. The emission warranty is
transferable to subsequent owners.
The vehicle must be maintained and operated
under normal use in accordance with Volvo’s
written instructions for proper maintenance and
use, which are detailed in the Owner’s Manual
and in this booklet. Items and conditions listed
under “What Is Not Warranted” are excluded, if
any of these conditions exist.
NOTE
No implied warranty of merchantability or
fitness for a particular purpose shall apply
except during the applicable periods of this
warranty. Some states do not allow limitations
on how long an implied warranty lasts, so the
above limitations may not apply to you.
Volvo will repair, adjust, or replace a part when
performing a repair under the warranty.
The emission warranty is not conditionally based
on the use of genuine Volvo parts. Failures
which occur, however, because of abuse or lack
of required maintenance, are not eligible for
coverage.
7 Volvo Car USA, LLC, is sometimes referred to in this booklet as “Volvo”. All such references to “Volvo” are intended to refer to Volvo Car USA, LLC.

48
WARRANTY
Where The Warranty AppliesThis warranty applies to 2022 model year
vehicles originally sold by Volvo Car USA, LLC,
certified for sale and registered in the states
of California, Connecticut, Delaware, Maine,
Massachusetts, Maryland, New Jersey, New York,
Oregon, Pennsylvania, Rhode Island, Vermont and
Washington.
Repairs and ServiceThe emission control system of your new 2022
Volvo passenger vehicle was designed, built and
tested using genuine Volvo parts, and the car
is certified to be in conformity with California
emission control requirements.
According to Federal regulations, you are eligible
for additional emissions warranty coverage for
up to eight (8) years or 80,000 miles, whichever
first occurs for certain specific major emission
components. The Federal emissions warranty
starts on the date the vehicle is sold to the first
retail purchaser or put into service, whichever
occurs first. California and Federal Warranty
coverages are concurrent.
ServicingIt is recommended that any replacement parts
used for maintenance, repair or replacement
of emission control systems be genuine Volvo
parts or genuine Volvo remanufactured parts.
The owner may elect to have maintenance,
replacement, or repair of the emission control
devices and systems performed by any
automotive repair establishment or individual.
He/she may also elect to use parts other
than genuine Volvo parts or genuine Volvo
remanufactured parts for such maintenance,
replacement, or repair without invalidating
this warranty. The cost of such service parts,
however, will not be covered under the warranty
except in an emergency. (See Retailer Service.)Parts Replacement parts which are not equivalent to
Volvo quality may impair the effectiveness of
emission control systems. If other than genuine
Volvo parts or genuine Volvo remanufactured
parts are used for maintenance, replacement
or repair of components affecting emissions,
the owner should obtain assurances that such
parts are warranted by their manufacturer to be
equivalent to genuine Volvo Car USA, LLC parts in
performance and durability.
Volvo assumes no liability under this warranty for
parts other than genuine Volvo parts or genuine
Volvo remanufactured parts. The use of non-Volvo
replacement parts, however, does not invalidate
the warranty on other components unless non-
Volvo parts cause damage to those warranted
parts or systems.
Retailer ServiceRepairs, adjustments, and service covered by this
warranty will be performed by any authorized
Volvo retailer at his place of business. There
will be no charge for parts or labor (including
diagnosis) when genuine Volvo parts or genuine
Volvo remanufactured parts are used for any
part of the emission control system or for any
part which may affect emissions covered by this
warranty.