2022 VOLVO S60 RECHARGE fuel filter

9
SERVICE AND MAINTENANCE
Oil viscosity
Incorrect viscosity oil can shorten engine life under
normal use. SAE 0W-20 will provide good fuel
economy and engine protection.
Turbocharger Operating Tips
In order to maximize the efficiency and
operation of your vehicle, the following points
should be observed:
1. Oil change and filter replacement every
10,000 miles/16,000 km, or at a time interval
based on the type of driving and conditions as
detailed in your Owner’s Manual. You should
maintain a record of these services (repair
order receipts).
2. Do not use engine oil additives as they may
adversely affect the engine.
CAUTION
Never race the engine immediately after
starting. Oil flow may not reach some
lubricating points fast enough to prevent
turbocharger damage.
Before switching off the engine, let it operate
at idle for a short time to allow the spinning of
the turbocharger compressor’s turbine vanes to
slow. After hard driving, this idle time should last
a couple of minutes, during which the vanes will
slow and the compressor will cool down while
still receiving oil lubrication. If the turbine vanes
are spinning at high speeds when the engine is
switched off, there is a great risk of heat damage
and/or turbine seizure due to lack of lubrication. Do not race the engine just prior to switching
off!

10
SERVICE AND MAINTENANCE
Maintenance Service Operations
Non-hybrid models only (Engine Codes AC, A2, L1, 06, 10 and 16)
Service operationSchedule of services
All Non-hybrid
Models miles x 1000
1020 30 40 5060 7080 90100 110120 130 140 150
km x 1000 1632 48 6480 96112 128 144160 176192208 224240
Engine
Engine oil and filter, replace XXXXXXXXXXXXXXX
Engine/Transmission/Timing gear check for
leaks
AX XXXXXX
Service Reminder Indicator (SRI), reset XXXXXXXXXXXXXXX
Fuel lines and fuel filter, check for leakage
and damage X
XX
Engine Air cleaner (ACL), clean the air
cleaner housing/replace filter
B. X
XX
Spark plugs, replace XX
Engine coolant check & adjust antifreeze
rating & anti-corrosion agent X
XXXXXXXXXXXXXX
Accessory drive belt, belt tensioner & idler
pulley, replace
CX
Timing belt tensioner & idler pulley, replace
CX
Steering, Front and Rear Suspension
Power steering fluid level, check/adjust XXXXXXXXXXXXXXX

14
SERVICE AND MAINTENANCE
Hybrid models only (Engine Codes BK and BR)
Service operationSchedule of services
Hybrid Models miles x 10001020 30 40 5060 7080 90100 110120 130 140 150
km x 1000 1632 48 6480 96112 128 144160 176192208 224240
Engine
Engine oil and filter, replace XXXXXXXXXXXXXXX
Engine/Transmission/Timing gear check for
leaks
AX XXXXXX
Service Reminder Indicator (SRI), reset XXXXXXXXXXXXXXX
Fuel lines and fuel filter, check for leakage
and damage X
XX
Engine Air cleaner (ACL), clean the air
cleaner housing/replace filter
B. X
XX
Spark plugs, replace XX
Engine coolant check & adjust antifreeze
rating & anti-corrosion agent X
XXXXXXXXXXXXXX
Accessory drive belt, belt tensioner & idler
pulley, replace
CX
Timing belt tensioner & idler pulley, replace
CX
Steering, Front and Rear Suspension
Power steering fluid level, check/adjust XXXXXXXXXXXXXXX

41
WARRANTY

Retailer Service
Repairs and service covered by this warranty will
be performed by an authorized Volvo retailer at his
place of business with no charge for parts or labor
(including diagnosis), using genuine Volvo parts or
genuine Volvo remanufactured parts for any part
of the emission control system covered by this
warranty and found defective.
If an emergency occurs and no authorized Volvo
retailer is available, repairs may be performed at
any available service establishment. Volvo will
reimburse the owner for such repairs (including
labor, in most cases) that are covered under this
warranty. Replaced parts and paid invoices must
be presented at a Volvo retail facility as a condition
of reimbursement for emergency repairs not
performed by a Volvo retailer.
We encourage you to have all recommended
maintenance and repairs on your new 2022 Volvo
vehicle completed. Volvo will not deny a warranty
claim solely because you have no record of
maintenance; however, Volvo may deny a warranty
claim if your failure to perform maintenance
resulted in the failure of a warranted part.
Receipts covering the performance of regular
maintenance must be retained for reference and
confirmation purposes.
What Is Not Warranted1. Required maintenance services as specified
in the Owner’s Manual and in the article
“Maintenance Service Operations” in this



booklet. Items that affect emissions and
require scheduled replacement are warranted
up to their first replacement point [such as
spark plugs, filters, belts, etc.]. Once these
parts have been replaced at the scheduled
replacement point, they are no longer covered
by this Emissions Warranty. The replaced
parts are covered by the two (2) year spare
parts warranty.
2. Malfunctions in any part caused by any of
the following: misuse, improper adjustments,
modification, alteration, tampering,
disconnection of system parts, and improper,
inadequate or non-maintenance.
3. Damage resulting from accidents, acts of
nature, and events beyond the control of
Volvo.
4. The use of fuel and/or oil, or other fluids which
do not meet the Volvo-approved standards
as set forth in the Owner’s Manual, Volvo
Service Literature or in the articles “Fuel
requirements” and “Engine oil” in this booklet,
which results in the failure of a warranted part
or system, may not be warranted.
5. Repairs on vehicles for which the true
odometer mileage cannot be readily
determined.
6. The cost incurred from the use of parts other
than genuine Volvo replacement parts or
genuine Volvo remanufactured parts used for
maintenance, repair or replacement affecting
components of the emission control system. 7.
Any loss of time, inconvenience, loss of vehicle
use or commercial loss.
Emission Performance Warranty–U.S.
and Canada
The warranty begins on the date the vehicle is
sold/delivered to the first retail purchaser or put
into service, whichever occurs first.
In accordance with Section 207(B) of the Clean
Air Act, Canadian MDU and Canadian Provincial
Warranty Regulations, Volvo warrants to the first
vehicle purchaser and each subsequent purchaser,
that if
1. the vehicle is maintained and operated in
accordance with the written instructions for
proper maintenance and use (Refer to the
Owner’s Manual under the section titled
“Service and Routine Maintenance” and
the article “2022 Service and Maintenance
Requirements” in this booklet), and
2. the vehicle fails to conform at any time during
the first 24,000 miles/40,000 kilometers
or two (2) years (whichever occurs first) to
the applicable emission standards as judged
by an EPA approved or Canadian Provincial
approved emission short test, and
3. such non-conformity will result in the vehicle
owner having to bear any penalty or other
sanction (including denial of the right to use
the vehicle) under local, state, federal or
provincial law, then Volvo shall remedy the
nonconformity at no cost to the owner.

50
WARRANTY
fuel or fuels not recommended in your Owner’s
Manual or this booklet. If the failure is covered
under this warranty, Volvo shall be liable for
diagnostic and repair expenses. If the failure is
caused by a combination of warrantable and
nonwarrantable conditions, the owner shall not be
liable for the portion of diagnostic and repair costs
relating to the warrantable condition. If the failure
is caused by a nonwarrantable condition, the
vehicle owner shall be liable for all diagnostic and
repair expenses, but not to exceed the maximum
permissible under the inspection program. The
owner may choose to have the vehicle repaired at
a facility other than a Volvo retailer; however, if a
warrantable condition is found, the owner must
bring the vehicle to an authorized Volvo retailer to
have the repairs completed at no cost for parts,
labor, and diagnosis. Volvo will not reimburse
the owner for diagnostic costs incurred at the
unauthorized service facility except in the case of
an emergency.
What Is Not Warranted (applies to all
models)
1. Required maintenance services as specified in
the article “Maintenance Service Operations”
in this booklet. Items that affect emissions
and require scheduled replacement are
warranted up to their first replacement point
[such as spark plugs, filters, belts, etc.].
Once these parts have been replaced at the
scheduled replacement point, they are no
longer covered by this Emission Warranty.
2. Malfunctions in any part caused by misuse,
improper adjustments (by other than a
Volvo dealer during warranty repair work),
modification, alteration, tampering or
disconnection of system parts.
3. Damage resulting from accidents, acts of
nature, or events beyond the control of Volvo.
4. The use of fuel and/or oil, or other fluids which
do not meet the Volvo-approved standards
as set forth in the Owner’s Manual or in the
articles “Fuel requirements” and “Engine oil”
in this booklet, may not be warranted. 5.
Repairs on vehicles for which the true
odometer mileage cannot be readily
determined.
6. Parts other than genuine Volvo replacement or
remanufactured parts used for maintenance,
repair or replacement affecting components of
the emission control system.
7. Any loss of time, inconvenience, loss of vehicle
use or commercial loss.