2022 TOYOTA GR YARIS manual transmission

138
Owner's Manual_Europe_M52P63_en
4-2. Driving procedures
■Maximum allowable speeds
Observe the following maximum allow-
able speeds in each gear when maxi- mum acceleration is necessary.
The iMT optimally controls the
engine speed to suit the driver’s
operation of the clutch pedal and
shift lever, helping the driver to shift
Shift positionMaximum speed
km/h (mph)
158 (36)
292 (57)
3135 (84)
4178 (111)
5225 (140)
NOTICE
■To prevent damage to the vehicle
When shifting gears, observe the fol-
lowing precautions. Failure to do so may cause damage to the engine, manual transmission, and/or clutch.
●Do not shift the shift lever to R with-out depressing the clutch pedal.
●Do not lift up the ring section except when shifting the lever to R.
●Shift the shift lever to R only when the vehicle is stationary.
●Do not rest your hand on or hold the shift lever any time other than when shifting.
●In order to not cause the engine to overrev, make sure to only shift
gears sequentially.
●Do not release the clutch pedal
suddenly.
iMT (Intelligent Manual
Transmission)

195
4
Owner's Manual_Europe_M52P63_en
4-5. Using the driving support systems
Driving
●Installation and removal of electrical
components and wireless devices may affect the Stop & Start system. Contact any authorized Toyota retailer
or Toyota authorized repairer, or any reliable repairer for details.
●When stopping the vehicle for a lon-ger period of time, turn the engine switch off to stop the engine com-
pletely.
●When the engine is restarted by the
Stop & Start system, the steering wheel may temporarily feel heavy.
■Operating conditions
●The Stop & Start system is operational when all of the following conditions are met:
• The vehicle has been driven a certain amount of time.• The clutch pedal is not depressed.
• The shift lever is in N. • The driver’s seat belt is fastened.• The driver’s door is closed.
• The selected driving modes are nor- mal mode and track mode.• The windshield defogger is off.
• The engine is adequately warmed up. • The outside temperature is -5°C (23°F) or higher.
• The hood and back door are closed. ( P.195)
●In the following situations the engine may not be stopped by the Stop & Start system. This is not a malfunction
of the Stop & Start system. • When the air conditioning system is being used.
• When the battery is undergoing a peri- odic recharge.• When the battery is not sufficiently
charged, such as if the vehicle has been parked for a long time and the battery charge has decreased, the
electric load is large, the battery fluid temperature is excessively low or the battery has deteriorated.
• When the brake booster vacuum is low.• When the elapsed time since the
engine was restarted is short. • When the vehicle is stopped fre-
quently, such as when in a traffic jam.
• When the engine coolant temperature or transmission fluid temperature is extremely low or high.
• When the steering wheel is being operated.• When the vehicle is being driven in a
high altitude area. • When the battery fluid temperature is extremely low or high.
• For a while after the battery terminals have been disconnected and recon-nected.
●When the engine is stopped by the S t o p & S t a r t s y s t e m , t h e e n g i n e w i l l b e
restarted automatically if any of the following conditions are met:
(To enable the engine to be stopped by
the Stop & Start system again, drive the
vehicle.)
• The air conditioning system is turned
on. • The windshield defogger is turned on.• The driver’s seat belt is unfastened.
• The driver’s door is opened. • The driving mode is changed from normal mode and track mode to
another mode. • The Stop & Start cancel switch is pressed.
• The steering wheel is operated. • The vehicle starts to roll on an incline.
●When the engine is stopped by the Stop & Start system, the engine may restart automatically in the following
situations: (To enable the engine to be stopped by the Stop & Start system again, drive the vehicle.)
• When the brake pedal is pumped or strongly depressed.• When the air conditioning system is
being used. • When a switch of the air conditioning system is operated (windshield defog-
ger switch, etc.). • If the battery charge becomes low.
■When the hood is opened
If the hood is opened while the engine is
stopped by the Stop & Start system, the engine will stall and will not be able to be

264
Owner's Manual_Europe_M52P63_en
6-3. Maintenance
request that a record of maintenance
be kept.
■Does your vehicle need repairs?
Be on the alert for changes in perfor- mance and sounds, and visual tip-offs
that indicate service is needed. Some important clues are:
●Engine misses (misfire), stumbling or pinging
●Appreciable loss of power
●Strange engine noises
●A fluid leak under the vehicle (How-ever, water dripping from the air con-
ditioning system after use is normal.)
●Change in exhaust sound (This may
indicate a dangerous carbon monox- ide leak. Drive with the windows open and have the exhaust system checked
immediately.)
●Flat-looking tires, excessive tire
squeal when cornering, uneven tire wear
●Vehicle pulls to one side when driven straight on a level road
●Strange noises related to suspension movement
●Loss of brake effectiveness, spongy feeling brake pedal or clutch pedal (vehicles with a manual transmission),
pedal almost touches the floor, vehicle pulls to one side when braking
●Engine coolant temperature continu-ally higher than normal ( P.81, 84)
If you notice any of these clues, take
your vehicle to any authorized Toyota
retailer or Toyota authorized repairer, or
any reliable repairer as soon as possi-
ble. Your vehicle may need adjustment
or repair.

308
Owner's Manual_Europe_M52P63_en
7-2. Steps to take in an emergency
The following may indicate a prob-
lem with your transmission. Contact
any authorized Toyota retailer or
Toyota authorized repairer, or any
reliable repairer or commercial tow-
ing service before towing.
 The engine is running but the
vehicle does not move.
 The vehicle makes an abnormal
sound.
From the front
Use a towing dolly under the rear
wheels.
From the rear
Use a towing dolly under the front
wheels.
NOTICE
■To prevent damage to the vehicle when towing using a wheel-lift
type truck
●Do not tow the vehicle from the rear when the engine switch is off. The
steering lock mechanism is not strong enough to hold the front wheels straight.
●When raising the vehicle, ensure adequate ground clearance for tow-
ing at the opposite end of the raised vehicle. Without adequate clear-ance, the vehicle could be dam-
aged while being towed.
■To prevent damage to the vehicle
when towing with a sling-type truck
Do not tow with a sling-type truck,
either from the front or rear.
■To prevent damage to the vehicle
during emergency towing
Do not secure cables or chains to the suspension components.
■When towing a vehicle equipped with the Stop & Start system
If it is necessary to tow the vehicle with all four wheels on the ground, perform the following procedure
before towing the vehicle in order to protect the system. Turn the engine switch off and then start the engine or
turn the engine switch to ON.
Situations when it is neces-
sary to contact dealers
before towing
Towing with a wheel-lift type
truck

352
Owner's Manual_Europe_M52P63_en
8-1. Specifications
Ignition system (spark plug)
MakeDILKAR8U7G
Gap0.7 mm (0.027 in.)
NOTICE
■Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark pl ug gap.
Electrical system (battery)
Open voltage at 20°C (68°F):
12.3 V or higher
If the specific voltage is lower than the standard
value, charge the battery.
(Voltage is checked 20 minutes after the engine
and all lights are turned off.)
Charging rates5 A max.
Manual transmission
Gear oil capacity (Reference)
Vehicles with a LSD
2.0 L (2.1 qt., 1.7 Imp. qt.)
Vehicles without a LSD
2.1 L (2.2 qt., 1.8 Imp. qt.)
Gear oil type“TOYOTA Genuine Manual Transmission Gear
Oil LV GL-4 75W” or equivalent
NOTICE
■Manual transmission gear oil type
●Please be aware that depending on the particular characteristic s of the gear oil
used or the operating conditions, idle sound, shift feeling and /or fuel efficiency may be different or affected and, in the worst case, damage to the vehicle’s transmission.
Toyota recommends to use “TOYOTA Genuine Manual Transmission Ge ar Oil LV GL-4 75W” to achieve optimal performance.

353
8
Owner's Manual_Europe_M52P63_en
8-1. Specifications
Vehicle specifications
*: If a fluid type with “TOYOTA GENUINE BRAKE FLUID DOT4, CLASS6”, FMVSS
No.116 DOT4 or SAE J1704LV is not available, fluid type with TO YOTA GENU-
INE BRAKE FLUID DOT3, FMVSS No.116 DOT3 or SAE J1703 may be used
with no detriment to brake durability.
Your Toyota vehicle is filled with “Toyota Genuine Differential Gear Oil” at
the factory.
Use Toyota approved “Toyota Genuine Differential Gear Oil” or a n equiva-
lent of matching quality to satisfy the above specification. Pl ease contact
any authorized Toyota retailer or Toyota authorized repairer, o r any reliable
repairer for further details.
NOTICE
●Your Toyota vehicle is filled with “TOYOTA Genuine Manual Trans mission Gear Oil LV GL-4 75W” at the factory.
Use Toyota approved “TOYOTA Genuine Manual Transmission Gear Oi l LV GL- 4 75W” or an equivalent oil of matching quality that satisfies the above specifica- tions.
Please contact any authorized Toyota retailer or Toyota authori zed repairer, or any reliable repairer for further details.
Clutch (Manual transmission)
Pedal free play3  15 mm (0.1  0.6 in.)
Fluid type
“TOYOTA GENUINE BRAKE FLUID DOT4,
CLASS6”*, FMVSS No.116 DOT4 or SAE
J1704LV*
Transfer
Oil capacity0.45 L (0.48 qt., 0.40 Imp.qt.)
Oil type and viscosityToyota Genuine Differential gear oil LT 75W-85
GL-5 or equivalent
NOTICE
■Transfer oil type precaution
Using transfer oil other than the specified oil may cause abnor mal noise or vibra- tion, or damage the transfer of your vehicle.

460
Owner's Manual_Europe_M52P63_en
Alphabetical Index
K
Keyless entry
Smart entry & start system......... 107
Wireless remote control ............... 99
Keys ................................................. 98
Battery-saving function .............. 108
Electronic key............................... 98
Engine switch ............................. 134
If the electronic key does not operate
properly.................................... 337
If you lose your keys .................. 336
Key number plate ......................... 98
Keyless entry ............. 101, 105, 107
Mechanical key ............................ 98
Replacing the battery ................. 293
Warning buzzer .......................... 107
Wireless remote control ............... 99
L
Lane Tracing Assist (LTA) ............ 170
Operation ................................... 170
Warning lights ............................ 317
Warning messages .................... 179
Language (multi-information dis-
play) ............................................... 88
Lever
Auxiliary catch lever ................... 266
Hood lock release lever ............. 266
Shift lever ................................... 137
Turn signal lever ........................ 140
Wiper lever ................................. 148
License plate lights
Light switch ................................ 142
Replacing light bulbs .................. 299
Wattage ...................................... 355
Light bulbs
Replacing ...................................299
Lights
Automatic High Beam system .... 145
Extended Headlight Lighting ...... 143
Fog light switch .......................... 148
Front interior lights ..................... 235
Headlight switch ......................... 142
Interior lights............................... 235
Interior lights list ......................... 235
Personal lights............................ 236
Rear interior lights ...................... 235
Replacing light bulbs ..................299
Turn signal lever ......................... 140
Wattage ...................................... 355
Lock steering column................... 134
LTA (Lane Tracing Assist) ............170
Operation ...................................170
Warning lights.............................317
Warning messages..................... 179
Luggage compartment features .. 239
Luggage cover .............................. 240
M
Maintenance
Do-it-yourself maintenance ........ 265
Maintenance data.......................348
Maintenance requirements......... 263
Malfunction indicator lamp .......... 314
Manual headlight leveling dial ..... 144
Manual transmission .................... 137
Gear Shift Indicator .................... 139
Matt paint care guide .... 252, 256, 259
Menu icons ...................................... 85

461
Owner's Manual_Europe_M52P63_en
Alphabetical Index
Meter
Clock ............................................ 81
Indicators ..................................... 79
Instrument panel light control ....... 84
Meter control switches ................. 85
Meters .......................................... 81
Multi-information display .............. 84
Settings ........................................ 88
Warning lights ............................ 313
Warning message ...................... 321
Mirrors
Inside rear view mirror ............... 119
Outside rear view mirror defoggers
................................................. 230
Outside rear view mirrors ........... 120
Vanity mirrors ............................. 242
Multi-information display ............... 84
Audio system-linked display......... 87
Clock ............................................ 83
Driving information display ........... 86
Driving support system information
display ....................................... 87
Dynamic radar cruise control ..... 179
Fuel economy .............................. 86
LTA (Lane-Tracing Assist) .......... 175
Menu icons................................... 85
Meter control switches ................. 85
Navigation system-linked display . 87
Settings ........................................ 88
Stop & Start system information .. 89
Tire inflation pressure .................. 87
Tire pressure .............................. 277
Toyota parking assist-sensor ..... 204
Vehicle information display .......... 87
Warning message ...................... 321
N
Navigation system-linked display87,
90
O
Odometer......................................... 82
Odometer and trip meter display
Display change button.................. 82
Display items ................................ 83
Oil
Engine oil ...................................350
Manual transmission ..................352
Rear differential oil ..................... 354
Transfer oil ................................. 353
Oil Pressure Gauge ........................ 88
Oil Temperature Gauge .................. 88
Opener
Back door ...................................105
Fuel filler door ............................ 151
Hood........................................... 266
Outside rear view mirrors
Adjustment ................................. 120
BSM (Blind Spot Monitor)........... 199
Folding ....................................... 121
Outside rear view mirror defoggers
................................................. 230
RCTA (Rear Crossing Traffic Alert)
................................................. 210
Outside temperature................. 81, 93
Overheating ...................................344