2022 RAM 1500 engine overheat

SERVICING AND MAINTENANCE421
(Continued)
Under normal operating conditions, the catalytic
converter will not require maintenance. However, it
is important to keep the engine properly tuned to
assure proper catalyst operation and prevent
possible catalyst damage.
NOTE:Intentional tampering with emissions control
systems can result in civil penalties being
assessed against you.
In unusual situations involving grossly
malfunctioning engine operation, a scorching odor
may suggest severe and abnormal catalyst
overheating. If this occurs, stop the vehicle, turn off
the engine and allow it to cool. Service, including a
tune-up to manufacturer's specifications, should
be obtained immediately. To minimize the possibility of catalytic converter
damage:
Do not interrupt the ignition when the transmis
-
sion is in gear and the vehicle is in motion.
Do not try to start the vehicle by pushing or
towing the vehicle.
Do not idle the engine with any ignition compo -
nents disconnected or removed, such as when
diagnostic testing, or for prolonged periods
during very rough idle or malfunctioning oper -
ating conditions.
COOLING SYSTEM
Engine Coolant Checks
Check the engine coolant (antifreeze) protection
every 12 months (before the onset of freezing
weather, where applicable). If the engine coolant is
dirty or rusty in appearance, the system should be
drained, flushed and refilled with fresh coolant.
Check the front of the A/C condenser (if equipped)
or radiator for any accumulation of bugs, leaves,
etc. If dirty, clean by gently spraying water from a
garden hose vertically down the face of the A/C
condenser (if equipped) or the back of the radiator
core.
Check the engine cooling system hoses for brittle
rubber, cracking, tears, cuts and tightness of the
connection at the coolant recovery bottle and
radiator. Inspect the entire system for leaks.
DO NOT REMOVE THE COOLANT PRESSURE CAP
WHEN THE COOLING SYSTEM IS HOT.
Damage to the catalytic converter can result if
your vehicle is not kept in proper operating
condition. In the event of engine malfunction,
particularly involving engine misfire or other
apparent loss of performance, have your
vehicle serviced promptly. Continued opera -
tion of your vehicle with a severe malfunction
could cause the converter to overheat,
resulting in possible damage to the converter
and vehicle.
CAUTION!
WARNING!
You or others can be badly burned by hot
engine coolant (antifreeze) or steam from your
radiator. If you see or hear steam coming from
under the hood, do not open the hood until the
radiator has had time to cool. Never open a
cooling system pressure cap when the radi -
ator or coolant bottle is hot.
Keep hands, tools, clothing, and jewelry away
from the radiator cooling fan when the hood is
raised. The fan starts automatically and may
start at any time, whether the engine is
running or not.
When working near the radiator cooling fan,
disconnect the fan motor lead or turn the igni -
tion to the OFF mode. The fan is temperature
controlled and can start at any time the igni -
tion is in the ON mode.
WARNING!
8

22_DT_OM_EN_USC_t.book Page 421

SERVICING AND MAINTENANCE423
NOTE:
It is the owner's responsibility to maintain the
proper level of protection against freezing
according to the temperatures occurring in the
area where the vehicle is operated.
Some vehicles require special tools to add
coolant properly. Failure to fill these systems
properly could lead to severe internal engine
damage. If any coolant is needed to be added to
the system, please contact an authorized
dealer.
Mixing engine coolant types is not recom -
mended and can result in cooling system
damage. If HOAT and OAT coolant are mixed in
an emergency, have an authorized dealer drain,
flush, and refill with OAT coolant (conforming to
MS.90032) as soon as possible.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
engine coolant (antifreeze), and to ensure that
engine coolant will return to the radiator from the
coolant expansion bottle/recovery tank (if
equipped). The cap should be inspected and cleaned if there
is any accumulation of foreign material on the
sealing surfaces.
Disposal Of Used Coolant
Used ethylene glycol-based coolant (antifreeze) is
a regulated substance requiring proper disposal.
Check with your local authorities to determine the
disposal rules for your community. To prevent
ingestion by animals or children, do not store
ethylene glycol-based coolant in open containers
or allow it to remain in puddles on the ground,
clean up any ground spills immediately. If ingested,
seek emergency assistance immediately.
Checking Coolant Level — 3.6L Engine
The level of the coolant in the pressurized coolant
bottle should be between the “MIN” and “MAX”
range on the bottle when the engine is cold.
The radiator normally remains completely full, so
there is no need to remove the cap unless
checking for coolant freeze point or replacing
engine coolant (antifreeze). Advise your service
attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle
need only be checked once a month. When
additional engine coolant is needed to maintain
the proper level, it should be added to the coolant
bottle. Do not overfill.
WARNING!
Do not open hot engine cooling system. Never
add engine coolant (antifreeze) when the
engine is overheated. Do not loosen or
remove the cap to cool an overheated engine.
Heat causes pressure to build up in the
cooling system. To prevent scalding or injury,
do not remove the pressure cap while the
system is hot or under pressure.
Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or
engine damage may result.
8

22_DT_OM_EN_USC_t.book Page 423

TECHNICAL SPECIFICATIONS469
(Continued)
METHYLCYCLOPENTADIENYL
M
ANGANESE TRICARBONYL (MMT) IN
G
ASOLINE
MMT is a manganese-containing metallic additive
that is blended into some gasoline to increase
octane. Gasoline blended with MMT provides no
performance advantage beyond gasoline of the
same octane number without MMT. Gasoline
blended with MMT reduces spark plug life and
reduces emissions system performance in some
vehicles. The manufacturer recommends that
gasoline without MMT be used in your vehicle. The
MMT content of gasoline may not be indicated on
the gasoline pump; therefore, you should ask the
gasoline retailer whether the gasoline contains
MMT. MMT is prohibited in Federal and California
reformulated gasoline.
FUEL SYSTEM CAUTIONSNOTE:Intentional tampering with the emissions control
system can result in civil penalties being assessed
against you.
FUEL REQUIREMENTS – DIESEL ENGINE
Federal law requires that you must fuel this vehicle
with Ultra Low Sulfur Highway Diesel fuel (15 ppm
Sulfur maximum) and prohibits the use of Low
Sulfur Highway Diesel fuel (500 ppm Sulfur
maximum) to avoid damage to the emissions
control system.
Use good quality diesel fuel from a reputable
supplier in your vehicle. For most year-round
service, No. 2 diesel fuel meeting ASTM (formerly
known as the American Society for Testing and
Materials) specification D-975 Grade S15 will
provide good performance. If the vehicle is
exposed to extreme cold (below 20°F or -7°C), or
is required to operate at colder-than-normal
conditions for prolonged periods, use Climatized
Number 2 diesel fuel or dilute the Number 2 diesel
fuel with 50% Number 1 diesel fuel. This will
provide better protection from fuel gelling or
wax-plugging of the fuel filters.
CAUTION!
Follow these guidelines to maintain your
vehicle’s performance:
The use of leaded gasoline is prohibited by
Federal law. Using leaded gasoline can impair
engine performance and damage the emis -
sions control system.
An out-of-tune engine or certain fuel or ignition
malfunctions can cause the catalytic
converter to overheat. If you notice a pungent
burning odor or some light smoke, your engine
may be out of tune or malfunctioning and may
require immediate service. Contact an autho -
rized dealer for service assistance.
The use of fuel additives, which are now being
sold as octane enhancers, is not recom -
mended. Most of these products contain high
concentrations of methanol. Fuel system
damage or vehicle performance problems
resulting from the use of such fuels or addi -
tives is not the responsibility of the manufac-
turer and may void or not be covered under
the New Vehicle Limited Warranty.
CAUTION!
WARNING!
Do not use alcohol or gasoline as a fuel blending
agent. They can be unstable under certain
conditions and hazardous or explosive when
mixed with diesel fuel.9

22_DT_OM_EN_USC_t.book Page 469

484 Oil Selection
.................................... 409, 472Oil Synthetic.............................................. 409Oil Temperature........................................ 130Overheating............................................... 387Starting........................................... 141, 144Enhanced Accident Response
Feature................................................ 352, 392Entry System, Illuminated................................ 60Ethanol.......................................................... 468Exhaust Gas Cautions.................................... 370Exhaust System................................... 370, 420Exterior Lights......................................... 54, 370
F
Family Alerts.................................................. 296FiltersAir Cleaner................................................. 410Air Conditioning.................................. 68, 416Engine Fuel............................................... 412Engine Oil........................................ 409, 473Engine Oil Disposal................................... 409FlashersTurn Signals.................................... 137, 370Flash-To-Pass.................................................. 55Flat Tire Stowage........................................... 382Fluid Capacities............................................. 472Fluid Leaks.................................................... 370Fluid Level ChecksBrake........................................................ 425Fluid, Brake................................................... 476
Fog Lights..................................... 57, 136, 442Fold-Flat Seats................................................. 35Forward Collision Warning.......... 133, 135, 325Four Wheel Drive............... 133, 135, 137, 160Four-Way Hazard Flasher.............................. 371Freeing A Stuck Vehicle................................ 389Front Axle (Differential)................................. 427Fuel............................................. 208, 467, 469Adding............................................. 207, 208Additives................................................... 468Clean Air................................................... 468Ethanol..................................................... 468Filter......................................................... 412Gasoline................................................... 467Light......................................................... 132Materials Added....................................... 468Methanol.................................................. 468Octane Rating.................................. 467, 473Requirements......................... 467, 469, 472Specifications........................................... 470Tank Capacity........................................... 472Fuel Saver Technology.................................. 174Fuses............................................................ 427
G
Garage Door Opener (HomeLink)..................... 49Gasoline, Clean Air........................................ 468Gasoline, Reformulated................................ 468GaugesVoltage..................................................... 146
Glass Cleaning.............................................. 465Grocery Bag Retainer.......................................41Gross Axle Weight Rating.............................. 213Gross Combination Weight Rating................ 213Gross Trailer Weight...................................... 213Gross Vehicle Weight Rating......................... 213GuideBody Builders...............................................11GVWR............................................................ 211
H
HazardDriving Through Flowing, Rising, Or Shallow Standing Water
................... 231Hazard Warning Flashers.............................. 371Head Restraints...............................................41Head Rests......................................................41Headlights............................................ 136, 440Cleaning.................................................... 462Delay...........................................................56High Beam......................................... 55, 137High Beam/Low Beam Select Switch..........55Lights On Reminder.....................................56On With Wipers............................................56Passing........................................................55Switch..........................................................54Heads Up Display (HUD)....................... 121, 122Heated Mirrors.................................................49Heated Seats...................................................39Heated Steering Wheel....................................34

22_DT_OM_EN_USC_t.book Page 484

487
Power Folding
.............................................. 48Rearview............................................ 45, 372Tilt Side In Reverse..................................... 49Trailer Towing.............................................. 49Vanity.......................................................... 46Mobile App.................................................... 284Modifications/Alterations Vehicle........................................................ 13Monitor, Tire Pressure System....................... 328Mopar Parts................................................... 479MP3 Control.................................................... 75Multi-Function Control Lever............................ 55Multifunction Tailgate...................................... 87
N
New Vehicle Break-In Period.......................... 150
O
Occupant Restraints...................................... 334Octane Rating, Gasoline (Fuel)...................... 467Off Road Pages.............................................. 306Accessory Gauges..................................... 309Pitch And Roll............................................ 310Status Bar................................................. 307Vehicle Dynamics...................................... 308Off-Pavement Driving (Off-Road).................... 232Off-Road Driving (Off-Pavement).................... 232Oil Filter, Change........................................... 409Oil Filter, Selection......................................... 409
Oil Pressure Light.......................................... 130Oil, Engine............................................ 409, 473Capacity.................................................... 472Dipstick.................................................... 407Disposal................................................... 409Filter................................................ 409, 473Filter Disposal........................................... 409Identification Logo.................................... 409Materials Added To.................................. 409Pressure Warning Light............................ 130Recommendation............................ 409, 472Synthetic.................................................. 409Viscosity................................................... 472Onboard Diagnostic System.......................... 138Operating Precautions.................................. 138Operator ManualOwner's Manual........................................ 480Outside Rearview Mirrors................................ 47Overheating, Engine...................................... 387
P
Paddle Shifters............................................. 159Paint Care..................................................... 461Pair (Link) Uconnect Phone To A
Mobile Phone
b
........................................ 274Parallel Parking............................................. 193Parking Brake...................................... 131, 150Parking Lights.................................................. 56ParkSense Active Park Assist........................ 192
ParkSense System, Rear............................... 186Passive Entry....................................................30Pedals, Adjustable...........................................44Pedestrian Warning System.......................... 327Performance Features.................................. 118Pets............................................................... 368Phone Mode.................................................. 272Pickup Box................................................92, 94Pinch Protection........................................83, 85Placard, Tire And Loading Information.......... 448PowerDistribution Center (Fuses).............. 428, 433Door Locks...................................................29Mirrors.........................................................48Outlet (Auxiliary Electrical Outlet)..........76, 77Seats...........................................................38Side Steps...................................................30Sliding Rear Window....................................81Steering........................................... 130, 173Sunroof.................................................82, 83Windows......................................................79Power SeatsDown...........................................................38Forward.......................................................38Rearward.....................................................38Recline.........................................................38Tilt................................................................38Up................................................................3811

22_DT_OM_EN_USC_t.book Page 487