2022 HYUNDAI SANTA FE maintenance

Maintenance
9-50
Fuse/relay panel description
Instrument panel fuse panel
OTM090019
Inside the fuse/relay box cover, you can
find the fuse/relay label describing fuse/
relay names and ratings.
Information
Not all fuse panel descriptions in this
manual may be applicable to your vehicle;
the information is accurate at the time of
printing. When you inspect the fuse box on
your vehicle, refer to the fuse box label.
OTMA090026

Maintenance
9-52
Instrument panel fuse panel
Fuse NameFuse
RatingCircuit Protected
ISG15ALow DC-DC Converter (AMP), Instrument Cluster, Front
A/C Control Module, A/V & Navigation Head Unit, Head Up
Display, Audio
RR SEAT(LH)25A2nd Seat Warmer LH Control Module, 2nd Seat LH Folding
Actuator
CLUSTER7.5A Instrument Cluster, Head Up Display
MDPS10AMDPS Unit
❈ MDPS(Motor Driven Power Steering) is the same as
EPS(Electric Power Steering).
A/C7.5A E/R Junction Block (Blower Relay, PTC Heater Relay)
CHILD LOCK15A ICM Relay Box (Child Lock/Unlock Relay)
DOOR LOCK20ADoor Lock Relay, Door Unlock Relay, Tailgate Relay, Driver
Door Unlock Relay
SUNROOF 120A Panorama Sunroof
P/WINDOW LH25ADriver Safety Power Window Module, Rear Power Window
Switch LH, Rear Safety Power Window LH
MODULE 37.5A IBU
MODULE 67.5AAudio, A/V & Navigation Head Unit, A/V & Navigation
Keyboard, Front A/C Control Module, Front Wireless
Charger, Electro Chromic Mirror, Low DC-DC Converter
WASHER15A Multifunction Switch
RR SEAT(RH)25A2nd Seat Warmer RH Control Module, 2nd Seat RH Folding
Actuator
WIPER RR15A Rear Wiper Relay, Rear Wiper Motor
AMP25A Low DC-DC Converter (With AMP)
ACC7.5AIBU, Front USB Charger, Low DC-DC Converter,
Rear USB Charger LH/RH, IAU (Identity Authentication
Unit)
P/SEAT (PASS)30A Passenger Seat Manual Switch
P/SEAT (DRV)30A Driver IMS Control Module, Driver Seat Manual Switch

Maintenance
9-54
Engine compartment fuse panel (Engine room junction block)
Type Fuse NameFuse
RatingCircuit Protected
MULTI
FUSE 1
(10P)COOLING FAN180A [BLDC 600W] Cooling Fan Controller
COOLING FAN260A [BLDC 400W] Cooling Fan Controller
B+450AICU Junction Block (Fuse - MODULE8,
SUNROOF1, AMP, P/WINDOW RH, S/HEATER
DRV/PASS)
B+250AICU Junction Block (IPS 8 SPOC+/IPS 10/IPS 11/
IPS 13/IPS 14/IPS 15)
B+350AICU Junction Block (Fuse - E-SHIFTER1, P/
SEAT (DRV, P/SEAT (PASS), P/WINDOW LH, RR
SEAT(LH))
BLOWER40A Blower Relay
IG240A Start Relay, PCB Block (PDM (IG2) Relay)
ABS 230A ESC Module
MULTI
FUSE 2
(10P)MDPS100A MDPS Unit
ABS 360A ESC Module
B+660A PCB Block (B+)
DCT60A TCM
E-CVVT150A PCB Block (E-CVVT Relay)
REAR HEATED40A Rear Heated Relay
INVERTER40A AC Inverter Module
E-SHIFTER 140A SCU
FUSEHEATED
MIRROR10ARear Heated Relay, Driver/Passenger Outside
Mirror, Front A/C Control Module
E-CVVT320A PCM, PCB Block (E-CVVT Relay)
E-CVVT220A PCM, PCB Block (E-CVVT Relay)
A/C210A Blower Relay, Front A/C Control Module
VACUUM
PUMP210A ESC Module, Vacuum Pump Relay, Vacuum Pump
B+550AICU Junction Block (Fuse - DOOR LOCK,
IBU1, IBU2, BRAKE SWITCH, CHILD LOCK, RR
SEAT(RH), SUNROOF2)
EOP260A [G4KP] Electronic Oil Pump

Maintenance
9-56
Engine compartment fuse panel (PCB block)
Fuse NameFuse
RatingCircuit Protected
IG140A PDM (IG1) Relay
TCU210A TCM
SENSOR320A Injector #2/#4
SENSOR110A Injector #1/#3
ECU310A PCM
EOP310A [G4KN] Electronic Oil Pump
POWER OUTLET120A Luggage Power Outlet
WIPER210A IBU, PCM
HORN15A Horn Relay
ABS410A ESC Module
ECU220A PCM
SENSOR210A[G4KN] Canister Close Valve, Cooling Fan Controller,
Variable Oil Pump Solenoid Valve, Purge Control Solenoid
Valve, Oil Control Valve, Variable Intake Solenoid Valve, A/
CON Relay
[G4KP] Canister Close Valve, Cooling Fan Controller,
Variable Oil Pump Solenoid Valve, Purge Control Solenoid
Valve, Oil Control Valve, RCV Control Solenoid Valve, A/CON
Relay
SENSOR415A Oxygen Sensor (Up/Down)
IGN COIL20A Ignition Coil #1/#2/#3/#4
ACC20A ICU Junction Block (Fuse - ACC)
POWER
OUTLET220A Front Power Outlet
WIPER FRT130A Front Wiper Motor, Front Wiper (Low) Relay
E-SHIFTER310A SCU
FCA10A Front Radar Unit
ECU115A PCM
A/C110A TCM
TCU120A PCM
REAR
HEATED210A E/R Junction Block (Rear Heated Relay)

Maintenance
9-58
Information

[A normally functioning lamp may
flicker momentarily to stabilize the
vehicle’s electrical control system.
However, if the lamp goes out after
flickering momentarily, or continues to
flicker, have the system be checked by
an authorized HYUNDAI dealer.

[The position lamp may not turn on
when the position lamp switch is turned
on, but the position lamp and headlamp
switch may turn on when the headlamp
switch is turned on. This may be caused
by network failure or vehicle electrical
control system malfunction. If this
occurs, have the system be checked by
an authorized HYUNDAI dealer.
Information
The headlamp aiming should be adjusted
after an accident or after the headlamp
assembly is reinstalled.
Information
Traffic Change (For Europe)
The low beam light distribution is
asymmetric. If you go abroad to a country
with opposite traffic direction, this
asymmetric part will dazzle oncoming car
driver. To prevent dazzle, ECE regulation
demand several technical solutions (ex.
automatic change system, adhesive
sheet, down aiming). This headlamps are
designed not to dazzle opposite drivers. So,
you need not change your headlamps in a
country with opposite traffic direction.
Headlamp, position lamp, turn
signal lamp, Daytime Running
Light (DRL) replacement
Type A
OTMA090019
(1) Headlamp (High)
(2) Headlamp (Low)
(3) Daytime running light/Position light
(4) Turn signal lamp
(5) Side marker lamp
Turn signal lamp
1. Engage the parking brake and
disconnect the negative battery cable.
OTM090022
2. Remove wheel guard clips (under the
front bumper : 4 pieces).

Maintenance
9-60

[Always handle them carefully, and
avoid scratches and abrasions. If
the bulbs are lit, avoid contact with
liquids.

[Never touch the glass with bare
hands. Residual oil may cause the
bulb to overheat and burst when lit.

[A bulb should be operated only when
installed in a headlamp.

[If a bulb becomes damaged or
cracked, replace it immediately and
carefully dispose of it.
Lamps
If the LED lamp does not operate, have
the vehicle checked by an authorized
HYUNDAI dealer.
Side repeater lamp replacement
OTM090023
If the LED lamp (1) does not operate,
have the system be inspected by an
authorized HYUNDAI dealer.
The LED lamps cannot be replaced as
a single unit because it is an integrated
unit. The LED lamps has to be replaced
with the unit.
A skilled technician should check or
repair the LED lamp, for it may damage
related parts of the vehicle.
Rear combination lamp
replacement
Type A
OTMA090021
(1) Tail/Stop lamp
(2) Tail lamp
(3) Turn signal lamp
(4) Reverse lamp
(5) Side marker lamp
OTM090044
Stop/Tail lamp (Outside), Reverse lamp
1. Turn off the engine.
2. Open the liftgate.
3. Loosen the lamp assembly retaining
screws with a cross-tip screwdriver.
4. Remove the rear combination lamp
assembly from the body of the
vehicle.
5. Remove the socket from the
assembly by turning the socket
counterclockwise until the tabs on
the socket align with the slots on the
assembly.

Maintenance
9-62
7. Install the socket into the assembly by
aligning the tabs on the socket with
the slots in the assembly. Push the
socket into the assembly and turn the
socket clockwise.
8. Reinstall the lamp assembly to the
body of the vehicle.
Turn signal lamp
If these lamps do not operate, have
the vehicle checked by an authorized
HYUNDAI dealer.
Type B
OTMA090022
(1) Tail/Stop lamp
(2) Stop lamp
(3) Turn signal lamp
(4) Reverse lamp
(5) Side marker lamp
OTM090044
Reverse lamp
1. Turn off the engine.
2. Open the liftgate.
3. Loosen the lamp assembly retaining
screws with a cross-tip screwdriver.
4. Remove the rear combination lamp
assembly from the body of the
vehicle.
5. Remove the socket from the
assembly by turning the socket
counterclockwise until the tabs on
the socket align with the slots on the
assembly.

Maintenance
9-64
License plate lamp replacement
OTM090047
1. Using a flat-blade screwdriver, gently
pry the lens cover from the lamp
housing.
2. Remove the bulb by pulling it straight
out.
3. Install a new bulb.
4. Reinstall in the reverse order.
Interior light replacement
Map lamp (LED/Bulb type), Room
lamp (LED type)
„Map lamp (LED type)
OTM050247L
„Map lamp (Bulb type)
OTM050248L
„Room lamp (Personnal lamp)
OTM078014
If the map lamp (LED/Bulb) (1) and the
room lamp (LED type) (1) do not operate,
have the system be checked by an
authorized HYUNDAI dealer.