2022 FORD SUPER DUTY run flat

HYDRAULIC POWER
STEERING
HYDRAULIC POWER STEERING
GUIDELINES
To help prevent damage to the power
steering system:
•
Do not hold the steering wheel at its
furthest turning points for more than
three to five seconds when the engine
is running.
• Avoid continuously steering back and
forth with elevated engine RPM as this
may overheat the system. If trying to
free a stuck vehicle, pause between
attempts to allow the power steering
system to cool or seek assistance.
Typical steering and driving maneuvers
allow the system to cool.
• Do not operate the vehicle if the power
steering pump fluid level is below the
MIN mark on the reservoir.
• Some noise is normal during operation.
If excessive, check for low power
steering pump fluid level before
seeking service by your dealer.
• Heavy or uneven efforts may be caused
by low power steering fluid. Check for
low power steering pump fluid level
before seeking service by your dealer.
• Do not fill the power steering pump
reservoir above the MAX mark on the
reservoir, as this may result in leaks
from the reservoir.
If the power steering system breaks down
or if you switch the engine off, you can
steer the vehicle manually, but it takes
more effort. If you have any steering components
serviced or replaced, install new fasteners.
Many fasteners have coatings with thread
adhesive, or have prevailing torque
features you cannot reuse. Do not reuse a
bolt or nut. Torque fasteners to
specifications.
Steering Tips
If the steering wanders or pulls, check for:
•
An improperly inflated tire.
• Uneven tire wear.
• Loose or worn suspension
components.
• Loose or worn steering components.
• Improper vehicle alignment.
Note: A high crown in the road or high
crosswinds may also make the steering
seem to wander or pull.
Electronic Torque Overlay Steering
(If Equipped) WARNING: The electric power
steering system has diagnostic checks
that continuously monitor the system. If
a fault is detected, a message displays
in the information display. Stop your
vehicle as soon as it is safe to do so.
Switch the ignition off. After at least 10
seconds, switch the ignition on and
watch the information display for a
steering system warning message. If a
steering system warning message
returns, have the system checked as
soon as possible. WARNING:
If the system detects
an error, you may not feel a difference in
the steering, however a serious condition
may exist. Have your vehicle checked as
soon as possible. Failure to do so may
result in loss of steering control.
256
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Steering

COLD WEATHER
PRECAUTIONS
The functional operation of some
components and systems can be affected
at temperatures below approximately
-13°F (-25°C).
BREAKING-IN
Your vehicle requires a break-in period. For
the first 1,000 mi (1,600 km), avoid driving
at high speeds, heavy braking, aggressive
shifting or using your vehicle to tow. During
this time, your vehicle may exhibit some
unusual driving characteristics.
DRIVING ECONOMICALLY
The following helps to improve fuel
consumption:
• Drive smoothly, accelerate gently and
anticipate the road ahead to avoid
heavy braking.
• Regularly check your tire pressures and
make sure that they are inflated to the
correct pressure.
• Follow the recommended maintenance
schedule and carry out the
recommended checks.
• Plan your journey and check the traffic
before you set off. It is more efficient
to combine errands into a single trip
whenever possible.
• Avoid idling the engine in cold weather
or for extended periods. Start the
engine only when you are ready to set
off.
• Do not carry unnecessary weight in your
vehicle as extra weight wastes fuel. •
Do not add unnecessary accessories
to the exterior of your vehicle, for
example running boards. If you use a
roof rack, remember to fold it down or
remove it when not in use.
• Do not shift into neutral when you are
braking or when your vehicle is slowing
down.
• Shut all windows when driving at high
speeds.
• Switch off all electric systems when
not in use, for example air conditioning.
Make sure that you unplug any
accessories from the auxiliary power
points when not in use.
DRIVING THROUGH SHALLOW
WATER WARNING:
Do not attempt to
cross a deep or flowing body of water.
Failure to follow this instruction could
result in the loss of control of your
vehicle, personal injury or death.
Note: Driving through standing water can
cause vehicle damage.
Note: Engine damage can occur if water
enters the air filter.
Before driving through standing water,
check the depth. Never drive through water
that is higher than the bottom of the wheel
hubs.
373
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Driving Hints

When weather temperature
changes occur, tire inflation
pressures also change. A 10°F
(6°C) temperature drop can
cause a corresponding drop of 1
psi (7 kPa) in inflation pressure.
Check your tire pressures
frequently and adjust them to the
proper pressure which can be
found on the Safety Compliance
Certification Label or Tire Label.
Steel Carcass Plies
WARNING: An inflated tire
and rim can be very dangerous
if improperly used, serviced or
maintained. To reduce the risk
of serious injury, never attempt
to re-inflate a tire which has
been run flat or seriously
under-inflated without first
removing the tire from the wheel
assembly for inspection. Do not
attempt to add air to tires or
replace tires or wheels without
first taking precautions to
protect persons and property. All tires with Steel Carcass Plies
(if equipped):
This type of tire utilizes steel cords
in the sidewalls. As such, they
cannot be treated like normal light
truck tires. Tire service, including
adjusting tire pressure, must be
performed by personnel trained,
supervised and equipped
according to Federal Occupational
Safety and Health Administration
regulations. For example, during
any procedure involving tire
inflation, the technician or
individual must utilize a remote
inflation device, and ensure that
all persons are clear of the
trajectory area.
WARNING: Always inflate
steel carcass tires with a remote
air fill with the person inflating
standing at a minimum of
12 ft
(3.66 m) away from the wheel
and tire assembly.
443
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Tire Care

F
Fastening and Unfastening the
Seatbelts........................................................50
Feature Bar....................................................598
Filling the Selective Catalytic Reduction System Tank................................................219
Filling the Selective Catalytic Reduction System Tank in Cold Weather................... 219
Filling the Selective Catalytic Reduction System Tank Using a Fuel Station
Pump.................................................................. 219
Filling the Selective Catalytic Reduction System Tank Using a Portable
Container......................................................... 220
Flat Tire See: Changing a Flat Tire................................ 455
Floor Mats.......................................................374
Folding the Exterior Mirrors - Vehicles With: Manual Folding Mirrors................129
Folding the Exterior Mirrors - Vehicles With: Power Folding Mirrors..................129
Foot Pedals See: Adjusting the Pedals................................. 114
Ford Protect..................................................620
Four-Wheel Drive Driving Hints..............232 Driving In Sand.................................................... 232
Driving on Hilly or Sloping Terrain................233
Driving on Snow and Ice.................................. 233
Driving Through Mud and Water.................. 232
Emergency Maneuvers..................................... 232
Four-Wheel Drive.........................................228 Four-Wheel Drive Driving Hints.................... 232
Four-Wheel Drive Modes................................. 231
Four-Wheel Drive – Troubleshooting.........234
Four-Wheel Drive Indicators....................232
Four-Wheel Drive Limitations
................230
Four-Wheel Drive Modes...........................231 Four-Wheel Drive High...................................... 231
Four-Wheel Drive Low...................................... 231
Two-Wheel Drive High...................................... 231
Four-Wheel Drive Precautions...............228
Four-Wheel Drive – Troubleshooting........................................234
Four-Wheel Drive – Information Messages......................................................... 235
Four-Wheel Drive – Warning Lamps..........234 Front Axle Fluid Capacity and
Specification..............................................490
Front Exterior...................................................33
Front Seat Precautions..............................158
Front Seats
.....................................................158
Heated Seats....................................................... 165
Manual Seats....................................................... 159
Massage Seats.................................................... 164
Power Seats........................................................... 161
Ventilated Seats.................................................. 165
Fuel and Refueling......................................203 Fuel and Refueling – Troubleshooting........211
Fuel Quality......................................................... 204
Refueling.............................................................. 209
Running Out of Fuel......................................... 208
Fuel and Refueling Precautions.............203
Fuel and Refueling – Troubleshooting..........................................211
Fuel and Refueling – Information Messages........................................................... 211
Fuel and Refueling – Warning Lamps..........211
Fuel Gauge......................................................136 Fuel Gauge Limitations.................................... 136
Locating the Fuel Filler Door.......................... 136
What Is Distance to Empty............................. 136
What Is the Fuel Gauge.................................... 136
What Is the Low Fuel Reminder.................... 136
Fuel Quality
...................................................204
Selecting the Correct Fuel............................. 204
Selecting the Correct Fuel for Cold Weather............................................................ 205
Switching Between E85 and Gasoline........................................................... 208
Fuel Tank Capacity - Diesel......................481
Fuel Tank Capacity........................................211
Fuel Tank Capacity - Gasoline
................482
Fuse Precautions.........................................387
Fuses................................................................387 Body Control Module Fuse Box.................... 392
Fuses – Troubleshooting................................ 395
Under Hood Fuse Box...................................... 387
Fuses – Troubleshooting..........................395 Fuses – Frequently Asked Questions........395
G
Garage Door Opener....................................176
Garage Door Opener Limitations
............176
724
2022 Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 202103, First-Printing Index