2022 FORD RANGER high

(2) Your vehicle's safety belts and air bag Supplemental
Restraint System (SRS) are covered for an extended Safety
Restraint Coverage Period, which lasts for five years or 60,000
miles, whichever occurs first.
(3) Your vehicle’s body sheet metal panels are covered for an
extended Corrosion Coverage Period, which lasts for five years,
regardless of miles driven. The extended warranty coverage only
applies if a body sheet metal panel becomes perforated due to
corrosion during normal use due to a manufacturing defect in
factory-supplied materials or factory workmanship. If aluminum
body panels have corrosion or rust damage, and the damage is
not the result of abnormal usage, vehicle accident, customer
actions and/or extreme environmental conditions, the corrosion
or rust damage repairs are covered for 5 years, unlimited miles.
For damage caused by airborne material (environmental fallout)
where there is no factory-related defect involved and therefore
no warranty − our policy is to provide free repair of paint damage
due to the airborne material for 12 months or 12,000 miles,
whichever occurs first.
(4) Your vehicle's direct injection diesel engine and certain engine
components are covered during the Diesel Engine Coverage
Period, which lasts for five years or 100,000 miles, whichever
occurs first. The following parts are covered during this extended
coverage period: the engine, cylinder block, heads and all internal
parts, intake and exhaust manifolds, timing gear, harmonic
balancer, valve covers, oil pan and pump, water pump, fuel
system (excluding fuel lines, fuel tank and frame mounted fuel
conditioning module sometimes referred to as the frame
mounted pump/filter/water separator or frame mounted fuel
filter/water separator), high pressure lines, gaskets and seals,
glow plugs, turbocharger, two-stage turbocharger assembly,
turbocharger actuator, powertrain control module, high pressure
fuel injection pump assembly, injectors, injection pressure sensor,
fuel rail pressure sensor, exhaust back pressure regulator and
sensor, exhaust pressure sensor, manifold pressure sensor,
intake air temperature sensor, crankshaft position sensor,
camshaft position sensor, accelerator switch.
12

(5) The electrical drivetrain system of your vehicle is covered by
the Hybrid & Electric Vehicle Unique Component coverage for
eight years or 100,000 miles, whichever comes first. The
components in the electrical drivetrain system of your vehicle will
vary, depending on whether your vehicle is a hybrid, plug-in
hybrid, but you can rest assured knowing that your vehicle’s
electrical drivetrain system is covered by this comprehensive
warranty. Depending on your vehicle, electrical drivetrain system
components covered by this warranty may include, and are not
limited to: high-voltage battery, high-voltage battery connector,
battery energy control module (BECM), on-board charger,
inverter system controller (ISC), DC/DC converter, hybrid
continuously variable transmission or electric driveline motor and
transmission range sensor. If an electrical drivetrain system
component requires replacement under warranty, it may be
replaced with a new, factory remanufactured, or factory
refurbished component, at Ford’s discretion. Refurbished battery
components selected for your vehicle will align with your
vehicle’s age and mileage, and meet Ford’s stringent
requirements and standards. (see "Note: High-Voltage Battery
Gradual Capacity Loss" below).
Note: High Voltage Battery Gradual Capacity Loss
The high voltage battery will experience gradual capacity loss
with time and use, similar to all batteries, which is considered
normal wear and tear. Loss of battery capacity due to or resulting
from gradual capacity loss is NOT covered under the New Vehicle
Limited Warranty. See your Owner’s Manual for important tips on
how to maximize the life and capacity of the high voltage battery.
NOTE:Some components may also be covered by the Emissions
Warranties. For more information, see pages 22-41.
If you own or lease a 2022-model Next Generation Police
Interceptor Vehicle (NGPI), refer to the Warranty Addendum Card
that was given to you when you took delivery of your vehicle for
further explanation of Amendments to the New Vehicle Limited
Warranty. The Warranty Addendum applies only the NGPI
vehicles delivered in the State of Florida and New York.
13

Tire Wear or Damage
The New Vehicle Limited Warranty does not cover normal wear or
worn out tires. Tires will not be replaced (unless required by a
warranty repair) for wear or damage including:
• tire damage from road hazard such as cuts, snags, bruises,bulges, puncture, and impact breaks
• tire damage due to under or over inflation, tire chain use, racing, spinning (as when stuck in snow or mud), improper mounting
or dismounting, or tire repair
Other Items or Conditions Not Covered
The New Vehicle Limited Warranty does not cover:
• vehicles that have had the odometer disconnected, altered, or inoperative for an extended period of time with the result that
the actual mileage cannot be determined
• vehicles that have ever been labeled or branded as dismantled, fire, flood, junk, rebuilt, reconstructed, or salvaged; this will void
the New Vehicle Limited Warranty
• vehicles that have been determined to be a total loss by an insurance company; this will void the New Vehicle Limited
Warranty
• converted ambulances that are not equipped with the Ford Ambulance Prep Package, see important information about
ambulance conversions (page 47)
• aftermarket parts or components, sometimes installed by Ford Motor Company or an authorized Ford dealership, may not be
covered by the New Vehicle Limited Warranty. Any damage
caused to Ford components due to the failure of aftermarket
parts (other than a certified emissions part) is not covered.
• high-voltage battery replacement due to improper vehicle storage. Refer to the Owner’s Manual for the proper ways your
vehicle’s battery must be maintained in the event the vehicle is
not driven or is stored for an extended period of time.
18

WHAT IS COVERED?
For your vehicle if these parts contain an emissions-related
defect, they are covered by both the Emissions Defect Warranty
and the Emissions Performance Warranty.
• Active Air Dam (3.0L dieselF-150 only)
• Active Grill Shutters (3.0L diesel F-150 only)
• Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
• Brake Hydraulic/Electric Control Assembly (Plug-in
Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles
only)
• Catalytic Converters (including Selective Catalytic
Reduction and Diesel
Oxidation Catalysts)
•
Charger and Bracket
Assembly High Voltage
Battery (Hybrid and Plug-in
Hybrid vehicles only)
• Cold Start Enrichment System (diesel only)
• Controls for Deceleration (diesel only)
• Converter and Bracket Assembly High Voltage to Low Voltage (Hybrid and
Plug-in Hybrid vehicles only)
• Diesel Exhaust Fluid System
• Diesel Particulate Filter
• Electronic Ignition System (diesel only)
• Electronic Engine Control Sensors and Switches
• Powertrain Control Module (PCM)/ Engine Control
Module (ECM)*
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
• Fuel Filler Door Sensor (Hybrid and Plug-in Hybrid
vehicles only)
• Fuel Filler Tube and Seal (non-diesel only)
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank (non-diesel only)
• Fuel Tank Pressure Control Valve
26

• Heating Element of BackWindow (3.0L diesel F-150
only)
• High Voltage Battery (Hybrid and Plug-in Hybrid vehicles
only)
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Intercooler Assembly - Engine Charger
• Inverter System Controller (Plug-in Hybrid vehicles
only)
• Jumper Assembly Charge Inlet to Charger (Hybrid and
Plug-in Hybrid vehicles only)
• Jumper Assembly DC/DC Converter to High Voltage
Panel (Hybrid and Plug-in
Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic
(OBD) System
• Module and Bracket Assembly Transmission
Inverter Control (Hybrid and
Plug-in Hybrid vehicles only) • Motor Electronics Coolant
Pump (Plug-in Hybrid
vehicles only)
• PCV system and Oil Filler Cap
• Onboard Charger (Plug-in Hybrid vehicles only)
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles
only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid
vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in
Hybrid vehicles only)
• Transmission Control Module (TCM) and
Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only
27

6. California requirements for emissions warranties
QUICK REFERENCE: EMISSIONS WARRANTY COVERAGE
This chart shows the emission warranty that Ford Motor Company
provides for your vehicle under the emissions control warranty in
accordance with the regulations of the California Air Resources Board.
This coverage is in addition to Federal Emission warranties (Page 22).
* Gross Vehicle Weight Rating
** These specific parts were selected on the basis of their estimated replacement cost at the time the California Air Resources Board certified your vehicle for sale in California
(up through 14,000 pounds GVWR).
***
Refer to your Vehicle Emission Control Information label for emissions certification information.
**** Except for the high voltage battery, which is covered for 10 years or 150,000 miles (whichever occurs first).
NOTE: Fully-electric vehicles are not eligible for any emissions
warranties described in this booklet.
TRANSITIONAL ZERO EMISSION VEHICLES (TZEV)***
DEFECTS AND PERFORMANCE WARRANTY**** 15/150,000
EMISSIONS DEFECTS WARRANTY FOR
VEHICLE WITH GVWR OVER 14,000 LBS.***
(Gasoline engines)
(2021 and earlier engine
model year diesel engines)
(2022 and later engine
model year diesel engines)
EMISSIONS PERFORMANCE WARRANTY (Vehicles of 14,000 LBS.* & under)
EMISSIONS DEFECTS WARRANTY FOR
VEHICLES WITH GVWR*
OF 14,000 LBS. & UNDER
Short-Term Warranty
Long-Term Warranty**
3/50,000
3/50,000
7/70,000
5/50,000 5/100,000
5/110,000
Emissions Warranties for California Certified Vehicles
TYPE OF
COVERAGE YEARS IN
SERVICE/MILES DRIVEN
29

EXPLANATION OF CALIFORNIA EMISSIONS WARRANTIES
Your Warranty Rights and Obligations
The California Air Resources Board and Ford Motor Company are
pleased to explain the emission control system warranty on your
2022-model vehicle. In California, new motor vehicles must be
designed, built, and equipped to meet the State's stringent
anti-smog standards. Ford must warrant the emission control
system on your vehicle for the periods of time listed on pages 32-35,
provided there has been no abuse, neglect, or improper maintenance
of your vehicle.
Your emission control system may include parts such as the fuel
injection system, the ignition system, catalytic converter, and the
engine computer. Also included may be hoses, belts, connectors,
and other emissions-related assemblies.
Where a warrantable condition exists, Ford Motor Company will
repair your vehicle at no cost to you including diagnosis, parts,
and labor.
Manufacturer's Warranty Coverage
For Vehicles Eligible for California Emission Warranty Coverage
If Gross Vehicle Weight Rating is 14,000 lbs. or less:
For 3 years or 50,000 miles (whichever occurs first):
1. If your vehicle fails a Smog Check inspection, all necessary
repairs and adjustments will be made by Ford to ensure that your
vehicle passes the inspection. This is your emission control
system PERFORMANCE WARRANTY.
2. If any emissions-related part on your vehicle is defective, the
part will be repaired or replaced by Ford. This is your short-term
emission control system DEFECTS WARRANTY.
For 7 years or 70,000 miles (whichever occurs first):
If a high-priced emissions-related part is defective or if its failure
causes your vehicle to fail a Smog Check inspection, the part will
be repaired or replaced by Ford. This is your long-term emission
control system DEFECTS WARRANTY.
32

For a list of the high-priced emission-related parts that are
covered for 7 years or 70,000 miles, go to www.owner.ford.com /
Owner Manuals.
Select the list that corresponds to the model and the model year
of your vehicle. NOTE: This list is vehicle specific and may not be
the same for all vehicles. It is based on the replacement cost of
each specific part, which can vary between vehicle lines.
If Gross Vehicle Weight Rating is 8,501 lbs. through 14,000 lbs.:
• For 5 years or 50,000 miles (whichever occurs first) forcomponents whose failure would increase the vehicle’s
emissions of air conditioning refrigerants.
• Only for HDVs designated as "vocational vehicles" on the
underhood "VEHICLE EMISSION CONTROL INFORMATION"
label: Tire defects that affect compliance with greenhouse gas
requirements are covered for 2 years or 24,000 miles,
whichever comes first.
If Gross Vehicle Weight Rating is over 14,000 lbs.:
For 5 years or 50,000 miles (gasoline engines), 5 years or
100,000 miles (2021 and earlier engine model year diesel
engines), and 5 years or 110,000 miles (2022 and later engine
model year diesel engines) (whichever occurs first). Warranty
coverage of 5 years or 50,000 miles (whichever occurs first)
applies for components whose failure would increase the
vehicle’s emissions of air conditioning refrigerants. Only for HDVs
designated as "vocational vehicles" on the underhood
"VEHICLE EMISSION CONTROL INFORMATION" label: Tire
defects that affect compliance with greenhouse gas
requirements are covered for 2 years or 24,000 miles, whichever
comes first.
33