2022 FORD F-350 battery

For Vehicles Eligible for California TZEV Emission Warranty
Coverage
Except as noted below, for 15 years or 150,000 miles (whichever
first occurs):
1. If your vehicle fails a Smog Check inspection, all necessary
repairs and adjustments will be made by Ford to ensure that your
vehicle passes the inspection. This is your emission control
system PERFORMANCE WARRANTY.
2. If any emissions-related part on your vehicle is defective, the
part will be repaired or replaced by Ford. This is your short-term
emission control system DEFECTS WARRANTY.
NOTE:The TZEV warranty period for the high-voltage battery is
10 years or 150,000 miles (whichever first occurs).
34

WHAT IS COVERED?
If the parts on the following list contains a defect that affects
emissions, they are covered by the Defects Warranties.
• Active Air Dam (3.0L dieselF-150 only)
• Active Grill Shutters (3.0L diesel F-150 only)
• Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
• Brake Hydraulic/Electric Control Assembly (Plug-in
Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles
only)
• Catalytic Converters (including Selective Catalytic
Reduction and Diesel
Oxidation Catalysts)
• Charger and Bracket Assembly High Voltage
Battery (Hybrid and Plug-in
Hybrid vehicles only)
• Cold Start Enrichment System (diesel only)
• Controls for Deceleration (diesel only)
• Converter and Bracket Assembly High Voltage to Low Voltage (Hybrid and
Plug-in Hybrid vehicles only)
• Diesel Exhaust Fluid System
• Diesel Particulate Filter
• Electronic Ignition System (diesel only)
• Electronic Engine Control Sensors and Switches
• Powertrain Control Module (PCM)/Engine Control
Module (ECM)*
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
• Fuel Filler Door Sensor (Hybrid and Plug-in Hybrid
vehicles only)
• Fuel Filler Tube and Seal (non-diesel only)
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank (non-diesel only)
• Fuel Tank Pressure Control Valve
36

• Heating Element of BackWindow (3.0L diesel F-150
only)
• High Voltage Battery (Hybrid and Plug-in Hybrid vehicles
only)
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Intercooler Assembly - Engine Charger
• Inverter System Controller (Plug-in Hybrid vehicles
only)
• Jumper Assembly Charge Inlet to Charger (Hybrid and
Plug-in Hybrid vehicles only)
• Jumper Assembly DC/DC Converter to High Voltage
Panel (Hybrid and Plug-in
Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic
(OBD) System
• Module and Bracket Assembly Transmission
Inverter Control (Hybrid and
Plug-in Hybrid vehicles only) • Motor Electronics Coolant
Pump (Plug-in Hybrid
vehicles only)
• PCV System and Oil Filler Cap
• Onboard Charger (Plug-in Hybrid vehicles only)
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles
only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid
vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in
Hybrid vehicles only)
• Transmission Control Module (TCM) and
Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only
37