2021 VOLVO XC40 battery replacement

34
WARRANTY
Damage/Deterioration/Corrosion• Vehicles severely damaged and/or declared to
be a total loss by an insurer.
• Vehicles substantially reassembled or repaired
from parts obtained from another vehicle
previously in operation.
• The use of fuel and/or oil, or other fluids which
do not meet the Volvo-approved standards
as set forth in the Owner’s Manual, Volvo
Service Literature or in the articles “Fuel
requirements” and “Engine oil” in this booklet.
• Failures resulting from misuse, abuse,
negligence, overloading, modifications
(including the electronic management
system(s), accidents or racing.
• Defects or failures resulting from the use of
new parts not sold or approved by Volvo,
or used parts, or the resultant damage to
associated parts or systems.
• Defects or failures resulting from incorrect
diagnosis by an independent repair shop.
• Failures resulting from continued operation
of the vehicle after a warning light, gauge
reading, or other indication advises of a
mechanical or operational problem (e.g., dash
instrumentation indicates overheat, loss of oil
pressure, etc.).
• Environmental damage to the vehicle’s surface
which is beyond Volvo’s control, such as
airborne fall-out (including chemicals, tree
sap, etc.) or other atmospheric conditions,
hailstones, road hazards, stone chips or other
acts of nature. Exterior painted surfaces are
covered by the Corrosion Protection Limited
Warranty, see the article “Volvo’s Corrosion
Protection, Limited Warranty–U.S./Warranty–
Canada” in this booklet.
• Damage to the interior (soft trim, upholstery,
and seating areas) resulting from normal wear
and tear, misuse, abuse, or negligence.
Glass
Glass breakage, unless it occurs because of
defects in material or workmanship.
Odometer Tampering
Repairs on vehicles for which the true odometer
mileage cannot be readily determined.
Inconvenience/Incidental Charges
The loss of vehicle use, loss of time, telephone
calls, towing, lodging, car rental, food, and other
incidental and consequential damages.
NOTE
Parts replaced free of charge under the terms
of the New Vehicle Limited Warranty (U.S.),
New Vehicle Warranty (Canada) are not subject
to the warranty coverage of the Genuine Volvo
Replacement Parts and Accessories Limited
Warranty. Those parts will be warranted for
90 days or the remainder of the New Vehicle
Limited Warranty (U.S.), New Vehicle Warranty
(Canada), whichever is greater.
Batteries
12 Volt and Support Batteries
Under the New Vehicle Limited Warranty, the
original equipment 12 volt and support batteries
installed in your 2021 Volvo are covered against
defects in parts and labor labor for four (4) years
or 50,000 miles/80,000 kilometers, whichever
occurs first.
Hybrid Battery
Under the New Hybrid Vehicle Limited Warranty,
the original equipment hybrid battery installed in
your 2021 Volvo is covered against defects in parts
and labor for eight (8) years or 100,000 miles/
160,000 kilometers, whichever occurs first.
2
NOTE
Batteries are subject to natural wear out due
to ageing and usage. If the battery capacity is
lower than 55% of original status (according
to specification) at 8 years or 100,000 miles/
160,000 kilometers, whichever occurs first
3,
the battery will be replaced free of charge.
2 California Hybrid Battery coverage, applicable to TZEV models only, is ten (10) years or 150,000 miles, whichever occurs first.3 Model year 2021 vehicles sold and registered in California, Connecticut, Maine, Massachusetts, Maryland, New Jersey, New York, Oregon, Rhode Island or Vermont, are classified as TZEV vehicles. If the battery
capacity is lower than 50% of original status at 10 years or 150,000 miles, whichever occurs first, the battery will be replaced free of charge.

49
WARRANTY
If an emergency occurs and an authorized Volvo
retailer is not reasonably available, repairs may be
performed at any available service establishment
or by any individual, using any replacement part.
When a warranted part is not available within
thirty (30) days or the repair cannot be completed
within thirty (30) days, repairs may be performed
at any available service establishment or by any
individual, using any replacement part.
Volvo will reimburse the owner for emergency
repairs (including diagnosis) that are covered
under this warranty. The expenses, however,
cannot exceed our suggested retail price for all
warranted parts replaced and labor charges,
based on Volvo’s recommended time allowance
for the warranty repair and the geographically
appropriate hourly labor rate. Replaced parts and
paid invoices must be presented at a Volvo retailer
as a condition of reimbursement for emergency
repairs not performed by a Volvo retailer.
Failure to notify the owner of a decision to
honor or deny a Performance Warranty Claim
within thirty (30) days from the time the vehicle
is initially presented for repair shall result in
the vehicle manufacturer being responsible for
repairing the vehicle without charge to the vehicle
owner, unless such failure is attributable to the
vehicle owner or to events beyond the control of
the vehicle manufacturer or the repair facility. You are advised to have all recommended
maintenance or repairs on your new 2021
Volvo vehicle performed. Volvo will not deny
a warranty claim solely because you have no
record of maintenance; however, we may deny a
warranty claim if your failure to perform required
maintenance resulted in the failure of a
warranted part.
Receipts and/or maintenance records covering
the performance of regular maintenance should,
therefore, be retained in the event questions arise
concerning maintenance.
Inspection Program
California, Connecticut, Delaware, Maine,
Massachusetts, Maryland, New Jersey,
New York, Oregon, Pennsylvania, Rhode
Island, Vermont and Washington
The following provisions apply to vehicles
which fail to pass the California, Connecticut,
Delaware, Maine, Massachusetts, Maryland,
New Jersey, New York, Oregon, Pennsylvania,
Rhode Island, Vermont or Washington Smog
Inspection. Should your vehicle fail a smog check
test during the warranty period, you may choose
to have the vehicle repaired at any authorized
Volvo retailer. The authorized Volvo retailer will
make the necessary repairs within the three (3)
year/50,000-mile period so that the vehicle will
pass the inspection. After three (3) years/50,000
miles, but before a period of use of seven (7)
years/70,000 miles, the authorized Volvo dealer
will repair or replace only those parts listed in the
article “2021 Model Year Emission Parts List”
in this booklet. After seven (7) years/70,000
miles, but before a period of use of eight (8)
years/80,000 miles, the authorized Volvo
retailer will cover only the catalytic converter,
engine control module, electronic rear axle drive
(ERAD) and onboard diagnostic device. TZEV
vehicles identified in the article “Volvo’s 2021
New Vehicle Warranties” in this booklet have
all emission components except for the hybrid
battery covered for a period of fifteen (15) years
or 150,000 miles. Volvo will pay for the repair
unless the failure was caused by abuse, neglect,
improper maintenance, or the use of leaded