2021 VOLVO V60 RECHARGE sensor

7
SERVICE AND MAINTENANCE
Demanding driving
In demanding driving conditions, such as
operating the vehicle in hot weather, towing a
trailer, or driving for extended periods at higher
altitudes than normal, it may be advisable to
switch to higher octane fuel (91 or higher) or
to change gasoline brands to fully utilize your
engine’s capacity, and for the smoothest possible
operation.
NOTE
When switching to higher octane fuel or
changing gasoline brands, it may be necessary
to fill the tank more than once before a
difference in engine operation is noticeable.
Fuel FormulationsDo not use gasoline that contains lead as a knock
inhibitor, and do not use lead additives. Besides
damaging the exhaust emission control systems
on your vehicle, lead has been strongly linked to
certain forms of cancer.
Many fuels contain benzene as a solvent.
Unburned benzene has been strongly linked to
certain forms of cancer. If you live in an area where
you must fill your own gas tank, take precautions.
These may include:
• standing upwind away from the filler nozzle
while refueling
• refueling only at gas stations with vapor
recovery systems that fully seal the mouth of
the filler neck during refueling
• wearing neoprene gloves while handling a fuel
filler nozzle.
WARNING
California Proposition 65
Operating, servicing and maintaining a
passenger vehicle can expose you to chemicals
including engine exhaust, carbon monoxide,
phthalates, and lead, which are known to
the State of California to cause cancer and
birth defects or other reproductive harm. To
minimize exposure, avoid breathing exhaust, do
not idle the engine except as necessary, service
your vehicle in a well ventilated area and wear
gloves or wash your hands frequently when
servicing your vehicle. For more information
go to www.P 65Warnings.ca.gov/passenger-
vehicle.
Use of AdditivesWith the exception of gas line antifreeze during
winter months, do not add solvents, thickeners,
or other store-bought additives to your vehicle’s
fuel, cooling, or lubricating systems. Overuse may
damage your engine, and some of these additives
contain organically volatile chemicals. Do not
needlessly expose yourself to these chemicals.
WARNING
Never carry a cell phone that is switched
on while refueling your vehicle. If the phone
rings, this may cause a spark that could ignite
gasoline fumes, resulting in fire and injury.
WARNING
Carbon monoxide is a poisonous, colorless, and
odorless gas. It is present in all exhaust gases.
If you ever smell exhaust fumes inside the
vehicle, make sure the passenger compartment
is ventilated, and immediately return the
vehicle to a trained and qualified Volvo service
technician for correction.
Deposit control gasoline (detergent
additives)
Volvo recommends the use of detergent gasoline
to control engine deposits. Detergent gasoline
is effective in keeping injectors and intake valves
clean. Consistent use of deposit control gasolines
will help ensure good drivability and fuel economy.
If you are not sure whether the gasoline contains
deposit control additives, check with the service
station operator.
NOTE
Volvo does not recommend the use of external
fuel injector cleaning systems.
Unleaded fuelEach Volvo has a three-way catalytic converter
and must use only unleaded gasoline. U.S. and
Canadian regulations require that pumps delivering
unleaded gasoline be labeled “UNLEADED”. Only
these pumps have nozzles which fit your vehicle’s
filler inlet. It is unlawful to dispense leaded fuel into
a vehicle labeled “unleaded gasoline only”. Leaded
gasoline damages the threeway catalytic converter
and the heated oxygen sensor system. Repeated
use of leaded gasoline will lessen the effectiveness

43
WARRANTY
bringing vehicle to any authorized Volvo retailer.
To the extent required by any federal, state, or
provincial law, whether statutory or common
law, a vehicle manufacturer shall be required
to provide a means for non-franchised repair
facilities to perform Emission Performance
Warranty repairs.
However, to avoid delay and ensure proper
service, it is recommended that service under this
warranty be performed by an authorized Volvo
retailer.
When determining whether an owner has
complied with the written instructions for proper
maintenance and use, Volvo may require an
owner to submit evidence of compliance if it has
an objective reason for believing:
1. maintenance was not performed and,
2. that if not performed, it could be the cause
of the vehicle exceeding applicable emission
standards.
Failure to notify the owner of a decision to honor
or deny an Emission Performance Warranty claim
within thirty (30) days from the time the vehicle
is presented for repair shall result in the vehicle
manufacturer being responsible for repairing
the vehicle without charge to the vehicle owner,
unless such failure is attributable to the vehicle
owner or to events which are beyond the control
of the vehicle manufacturer or repair facility.
2021 Emission Warranty Parts List –
Federal – U.S. and Canada
The following are some items covered by the
Emssion Warranty for (2) years or 24,000
miles/40,000 kilometers, whichever occurs
first. Volvo has continued coverage on these
items under the new car warranty for (4) years
or 50,000 miles/80,000 kilometers, whichever
occurs first. Components marked with “*” are
covered by the Long-Term Warranty for eight
(8) years or 80,000 miles/130,000 kilometers,
whichever occurs first. Components marked with
“**” are covered for eight (8) years or 100,000
miles/160,000 kilometers, whichever occurs first.
• Ambient Air Temp Sensor
• Camshaft Position Sensor
• Catalytic Converter*
• Charge Air Cooler
• Coolant Temperature Sensor
• Coolant Thermostat
• Crankshaft Positon Sensor
• CVVT Solenoid Valve (Exhaust/Intake)
• CVVT Timing Device (Exhaust/Intake)
• Electronic Throttle Module (ETM)
• Engine Control Module (ECM) Hardware*
• Engine Control Module (ECM) Software
• Engine Cooling Fan
• EVAP Carbon Canister
• EVAP Leakage Control Module (ECLM)
• Filler Pipe
• Filler Pipe (Capless Unit)
• Fuel High-Pressure Sensor
• Fuel Injector
• Fuel Low-Pressure Sensor
• Fuel Pump
• Fuel Pump ElectronIC/H Module (PEM)
• Fuel Rail
• Fuel Tank
• Fuel Tank Isolation Valve
• Heated Oxygen Sensor(s)
• High-Pressure Fuel Pump
• Ignition Coil
• Knock Sensor
• Manifold Absolute Pressure (MAP) Sensor
• Mass Air Flow (MAF) Sensor
• Oil Separator with Crankcase Pressure
Regulator
• On-Board Diagnostic System (OBD)*
• Purge Valve
• Purge Valve Assembly incl. Purge Valve
• Spark Plug (Kit)
• Supercharger
• Supercharger Bypass Valve
• Supercharger Pressure Sensor
• Temp & Manifold Air Pressure Sensor (TMAP)
• Transmission Control Module (TCM)
Hardware
* Covered by the Long-Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.

44
WARRANTY
• Transmission Control Module (TCM) Software
• Turbocharger
HYBRID (T8) SPECIFIC Emission
Components
• AC Compressor (Electrical)
• Active Brake Booster
• Battery Coolant Pump
• Battery Energy Control Module HW (BECM)
• Battery Energy Control Module SW (BECM)
• Booster Pedal Travel Sensor
• Brake Control Module (BCM2)
• Brake Control Module Software
• Chiller Shut-Off Valve
• Chiller Shut-Off Valve (Kit)
• Combined Inverter DC/DC (CIDD)
• Combined Inverter DC/DC Software
(CIDD SW)
• Condensor
• Coolant Temperature Sensor (ED)
• Coolant Thermostat Kit (ED)
• Cooling Fan (Hybrid)
• Electric Drive Coolant Pump
• Electric Oil Pump (EOP)
• Electric Oil Pump Control Module
• Electric Rear Axle Drive (ERAD)*
• Electric Vacuum Pump (EVP)
• Electric Vacuum Pump Control Unit (EVP)
• Electrical 3-Way Valve (ED)
• Rear AC with Shut-Off Valve
• High-Voltage Battery**
• Hybrid ED (Electric Drive) Radiator
• Integrated Starter Generator (C-ISG)
• Inverter Electric Motor HW
• Inverter SW
• On Board Charger (OBC) HW
• On Board Charger (OBC) SW
• Pedal Angle Sensor
• Pressure Sensor AC Hybrid
• Rotor Position Sensor (C-ISG)
• SRS Unit
• Steering Wheel Angle Sensor (SAS)
• Thermal Expansion Valve (TXV) with Shut-Off
Valve
• Vacuum Sensor in Active Brake Booster
• Wheel Speed Sensor (Front)
• Wheel Speed Sensor (Rear) Miscellaneous items used in above systems
Manifolds, hoses, clamps, fittings, tubing, sealing
gaskets or devices, pulleys, belts, fuel lines, wiring
harnesses and mounting hardware and electronic
controls (all models) used with the components
listed above.
NOTE
Parts listed under the 2021 Emission Warranty
Parts List – Federal – U.S. and Canada are
only covered components when they apply to
specific engine variants. Not all parts listed
apply to all engine types.
NOTE
Model year 2021 vehicles with engine VIN
code BR or BK sold and registered in California,
Connecticut, Maine, Massachusetts, Maryland,
New Jersey, New York, Oregon, Rhode Island
or Vermont are classified as Transitional Zero
Emissions (TZEV) vehicles. TZEV vehicles have
a defects and performance emissions warranty
on all emissions components, except the hybrid
battery, for fifteen (15) years or 150,000 miles,
whichever occurs first.
* Covered by the Long-Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.
** Covered for eight (8) years or 100,000 miles/160,000 kilometers, whichever occurs first.

54
WARRANTY
ENGINE VIN CODE NUMBERBK BR
Electric Vacuum Pump (EVP) XX
Electric Vacuum Pump Control Unit (EVP) XX
Engine Control Module (ECM) Hardware* XX
Engine Cooling Fan XX
Electronic Throttle Module (ETM) XX
Filler Pipe XX
Fuel Pump XX
Fuel Rail XX
Fuel Tank XX
Fuel Tank Isolation Valve XX
High Pressure Fuel Pump XX
High-Voltage Battery** XX
Hybrid ED (Electric Drive) Radiator (S90,S60,V60) XX
Integrated Starter Generator (C-ISG) XX
Inverter Electric Motor HW XX
On Board Charger (OBC) HW XX
Pressure Sensor AC Hybrid XX
Rear AC with Shut-Off Valve (XC90 only) X
SRS Unit XX