2021 VOLVO S90 RECHARGE engine

14
SERVICE AND MAINTENANCE
Hybrid models only
Service operationSchedule of services
Hybrid Models miles x 10001020 30 40 5060 7080 90100 110120 130 140 150
km x 1000 1632 48 6480 96112 128 144160 176192208 224240
Engine
Engine oil and filter, replace XXXXXXXXXXXXXXX
Engine/Transmission/Timing gear check for
leaks
AX XXXXXX
Service Reminder Indicator (SRI), reset XXXXXXXXXXXXXXX
Fuel lines and fuel filter, check for leakage
and damage X
XX
Engine Air cleaner (ACL), clean the air
cleaner housing/replace filter
B. X
XX
Spark plugs, replace XX
Engine coolant check & adjust antifreeze
rating & anti-corrosion agent X
XXXXXXXXXXXXXX
Accessory drive belt, belt tensioner & idler
pulley, replace
CX
Timing belt tensioner & idler pulley, replace
CX
Steering, Front and Rear Suspension
Power steering fluid level, check/adjust XXXXXXXXXXXXXXX

29
WARRANTY
Transitional Zero Emissions VehiclesEmissions Defects and Performance Model year 2021 vehicles with engine VIN code BR or BK sold and registered
in California, Connecticut, Maine, Massachusetts, Maryland, New Jersey,
New York, Oregon, Rhode Island or Vermont are classified as Transitional Zero Emissions (TZEV) vehicles. TZEV vehicles have a defects and performance
emissions warranty on all emissions components, except the hybrid battery, for fifteen (15) years or 150,000 miles, whichever occurs first.
Volvo On Call Warranty Coverage, Roadside Assistance, U.S./Canada 4 years unlimited mileage (refer to the separate booklet in the Owner’s Wallet)
Tow For Life (U.S. Only) Complimentary towing provided for all out-of-warranty vehicles to an
authorized Volvo retailer, within a 25-mile radius
A Remote Keyless Entry, Navigation, DVD and Headphone System batteries are covered for 4 years/50,000 miles/80,000 km.
B California Hybrid Battery Warranty is only applicable on TZEV vehicles.
C Volvo continues coverage under the new car warranty for four (4) years or 50,000 miles/80,000 kilometers, whichever occurs first.
Non-hybrid models only
New Vehicle Limited Warranty (U.S.),
New Vehicle Warranty (Canada) 4 years/50,000 miles/80,000 kilometers
Battery Warranty (12V and Support Battery)
A4 years/50,000 miles/80,000 kilometers, Full Coverage
Adjustments 1 year/12,000 miles/20,000 kilometers
Seat belts and S.R.S. 5 years/unlimited mileage/kilometers
Corrosion Protection 12 years/unlimited mileage/kilometers
Emission Defects and Performance, U.S./Canada Short-Term
B2 years/24,000 miles/40,000 kilometers
Long-Term 8 years/80,000 miles/130,000 kilometers
California Emissions Warranty –
California, Connecticut, Delaware, Maine, Massachusetts, Maryland, New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont and Washington

34
WARRANTY
Damage/Deterioration/Corrosion• Vehicles severely damaged and/or declared to
be a total loss by an insurer.
• Vehicles substantially reassembled or repaired
from parts obtained from another vehicle
previously in operation.
• The use of fuel and/or oil, or other fluids which
do not meet the Volvo-approved standards
as set forth in the Owner’s Manual, Volvo
Service Literature or in the articles “Fuel
requirements” and “Engine oil” in this booklet.
• Failures resulting from misuse, abuse,
negligence, overloading, modifications
(including the electronic management
system(s), accidents or racing.
• Defects or failures resulting from the use of
new parts not sold or approved by Volvo,
or used parts, or the resultant damage to
associated parts or systems.
• Defects or failures resulting from incorrect
diagnosis by an independent repair shop.
• Failures resulting from continued operation
of the vehicle after a warning light, gauge
reading, or other indication advises of a
mechanical or operational problem (e.g., dash
instrumentation indicates overheat, loss of oil
pressure, etc.).
• Environmental damage to the vehicle’s surface
which is beyond Volvo’s control, such as
airborne fall-out (including chemicals, tree
sap, etc.) or other atmospheric conditions,
hailstones, road hazards, stone chips or other
acts of nature. Exterior painted surfaces are
covered by the Corrosion Protection Limited
Warranty, see the article “Volvo’s Corrosion
Protection, Limited Warranty–U.S./Warranty–
Canada” in this booklet.
• Damage to the interior (soft trim, upholstery,
and seating areas) resulting from normal wear
and tear, misuse, abuse, or negligence.
Glass
Glass breakage, unless it occurs because of
defects in material or workmanship.
Odometer Tampering
Repairs on vehicles for which the true odometer
mileage cannot be readily determined.
Inconvenience/Incidental Charges
The loss of vehicle use, loss of time, telephone
calls, towing, lodging, car rental, food, and other
incidental and consequential damages.
NOTE
Parts replaced free of charge under the terms
of the New Vehicle Limited Warranty (U.S.),
New Vehicle Warranty (Canada) are not subject
to the warranty coverage of the Genuine Volvo
Replacement Parts and Accessories Limited
Warranty. Those parts will be warranted for
90 days or the remainder of the New Vehicle
Limited Warranty (U.S.), New Vehicle Warranty
(Canada), whichever is greater.
Batteries
12 Volt and Support Batteries
Under the New Vehicle Limited Warranty, the
original equipment 12 volt and support batteries
installed in your 2021 Volvo are covered against
defects in parts and labor labor for four (4) years
or 50,000 miles/80,000 kilometers, whichever
occurs first.
Hybrid Battery
Under the New Hybrid Vehicle Limited Warranty,
the original equipment hybrid battery installed in
your 2021 Volvo is covered against defects in parts
and labor for eight (8) years or 100,000 miles/
160,000 kilometers, whichever occurs first.
2
NOTE
Batteries are subject to natural wear out due
to ageing and usage. If the battery capacity is
lower than 55% of original status (according
to specification) at 8 years or 100,000 miles/
160,000 kilometers, whichever occurs first
3,
the battery will be replaced free of charge.
2 California Hybrid Battery coverage, applicable to TZEV models only, is ten (10) years or 150,000 miles, whichever occurs first.3 Model year 2021 vehicles sold and registered in California, Connecticut, Maine, Massachusetts, Maryland, New Jersey, New York, Oregon, Rhode Island or Vermont, are classified as TZEV vehicles. If the battery
capacity is lower than 50% of original status at 10 years or 150,000 miles, whichever occurs first, the battery will be replaced free of charge.

39
WARRANTY
The Warranty PeriodThe warranty period is five (5) years and has no
mileage/kilometer limitation.5 It begins with the
date the vehicle is sold/delivered to the first retail
purchaser or put into service, whichever occurs
first.
What Is Not Warranted• Seat belt system and Supplemental
Restraint System components which show
evidence of damage because of abuse,
misuse, negligence, tampering, or improper
installation.
• Replacement of seat belt system or
Supplemental Restraint System components
after a vehicle has been involved in a collision.
• The loss of vehicle use, loss of time,
inconvenience or other incidental charges,
such as telephone calls, towing, lodging,
car rental, or food, or other consequential
damages except where required by law.
• Repairs required as part of normal
maintenance.
• Replacement of components in accordance
with the maintenance schedule.
Seat belts: “Something We Believe In”
Seat belts are an integral part of the safety
system engineered into each Volvo.
Despite our strongest recommendations, and
your best intentions, not wearing a seat belt is
like believing “it’ll never happen to me!”
Volvo urges you and all adult occupants of your
car to properly wear seat belts in all seating
positions, and ensure that children are properly
restrained in the rear seats only, using an infant
car seat or booster seat determined by age,
weight and height.
Fact: In every state/province, some type of child
restraint legislation has been passed. Additionally,
most states/provinces have already made it
mandatory for occupants of a car to use seat
belts.
So, urging you to “buckle up” is not just our
recommendation – it’s becoming the law! The
few seconds it takes to buckle up may one day
allow you to say, “It’s a good thing I was wearing
my seat belt.”
Instructions for proper seat belt usage can be
found in your Owner’s Manual..
Emissions Warranties – U.S. and
Canada
Design and Defect Warranty
What Is Warranted–U.S.
Volvo warrants that your 2021 model year Volvo
was designed, built, and equipped to conform
at the time of sale to U.S. emission standards, in
accordance with Section 207(A) of the Federal
Clean Air Act, which was applicable when the
vehicle was manufactured.
What Is Warranted–Canada
Volvo warrants that your 2021 model year Volvo
was designed, built, and equipped to conform at
the time of sale to Canadian emission standards,
in accordance with the Canadian Motor Vehicle
Safety Act, which was applicable when the
vehicle was manufactured.
5 In the U.S., some states have mandated alternate warranty coverage for seat belts only. Contact your Volvo retailer for details of local requirements.

40
WARRANTY
In the U.S. and Canada
This warranty covers repairs resulting from any
defect in material or workmanship which would
cause the vehicle not to meet emission standards
during the applicable warranty period. Some
components considered part of the emission
system applicable to this warranty are listed in the
article “Emission Warranty Parts List – Federal –
U.S. and Canada” in this booklet.
This emission warranty is not conditionally based
on the use of genuine Volvo parts or service.
However, failures which occur as a result of
abuse or lack of maintenance are not eligible for
coverage.
Warranty Period
The federal emissions design and defect warranty
period is two (2) years or 24,000 miles/ 40,000
kilometers, whichever occurs first. Volvo continues
coverage under new car warranty to four (4) years
or 50,000 miles/80,000 kilometers, whichever
occurs first, except for certain specified major
emissions components for which the coverage
is eight (8) years or 80,000 miles/130,000
kilometers, whichever occurs first. These major
components include only the threeway catalytic
converter (TWC), engine control module, electronic
rear axle drive (ERAD) and the onboard diagnostic
system (OBD). (Refer to the 2021 Emission
Warranty Parts List for specific components’
coverage.) The warranty begins on the date
the vehicle is sold/delivered to the first retail
purchaser or put into service, whichever occurs
first. Any remaining portion of the warranty is fully
transferable to subsequent owners free-of-charge. Where the warranty applies
This warranty applies to 2021 model year vehicles
sold by Volvo Car USA, LLC, or Volvo Car Canada
Limited, certified for sale, registered and normally
operated in any 50 states of the U.S., the District
of Columbia, any territories or commonwealths of
the United States, or any territories or provinces
of Canada.
Repairs and Service
The emission control system of your new 2021
model year Volvo passenger vehicle was designed,
built, and tested using genuine Volvo parts.
The car is certified to be in conformity with the
appropriate U.S. Federal or Canadian emission
control regulations at the time of production.
Servicing
It is recommended that any replacement parts
used for maintenance, repair, or replacement of
emission control systems be genuine Volvo parts
or genuine Volvo remanufactured parts.
You may elect to have maintenance, repair, or
replacement of the emission control devices
and systems performed by any automotive
repair establishment or individual. You may
also elect to use parts other than genuine
Volvo parts or genuine Volvo remanufactured
parts which have been certified by the part
manufacturer for such maintenance, repair, or
replacement without invalidating this warranty.
The cost of such service or parts, however, will
not be covered under the warranty. Parts
Use of replacement parts which are not equivalent
to Volvo quality may impair the effectiveness of
emission control systems. If other than genuine
Volvo parts or genuine Volvo remanufactured parts
are used for maintenance, repair, or replacement
of components affecting emission control, the
owner must obtain assurances that such parts are
warranted by their manufacturer to be equivalent
to genuine Volvo parts in performance and
durability. Volvo assumes no liability under this
warranty for parts other than genuine Volvo parts
or genuine Volvo remanufactured parts. However,
the use of non-Volvo replacement parts does not
invalidate the warranty on other components
unless the non-Volvo parts cause damage to
warranted parts or systems.

41
WARRANTY

Retailer Service
Repairs and service covered by this warranty will
be performed by an authorized Volvo retailer at his
place of business with no charge for parts or labor
(including diagnosis), using genuine Volvo parts or
genuine Volvo remanufactured parts for any part
of the emission control system covered by this
warranty and found defective.
If an emergency occurs and no authorized Volvo
retailer is available, repairs may be performed at
any available service establishment. Volvo will
reimburse the owner for such repairs (including
labor, in most cases) that are covered under this
warranty. Replaced parts and paid invoices must
be presented at a Volvo retail facility as a condition
of reimbursement for emergency repairs not
performed by a Volvo retailer.
We encourage you to have all recommended
maintenance and repairs on your new 2021 Volvo
vehicle completed. Volvo will not deny a warranty
claim solely because you have no record of
maintenance; however, Volvo may deny a warranty
claim if your failure to perform maintenance
resulted in the failure of a warranted part.
Receipts covering the performance of regular
maintenance must be retained for reference and
confirmation purposes.
What Is Not Warranted1. Required maintenance services as specified
in the Owner’s Manual and in the article
“Maintenance Service Operations” in this



booklet. Items that affect emissions and
require scheduled replacement are warranted
up to their first replacement point [such as
spark plugs, filters, belts, etc.]. Once these
parts have been replaced at the scheduled
replacement point, they are no longer covered
by this Emissions Warranty. The replaced
parts are covered by the two (2) year spare
parts warranty.
2. Malfunctions in any part caused by any of
the following: misuse, improper adjustments,
modification, alteration, tampering,
disconnection of system parts, and improper,
inadequate or non-maintenance.
3. Damage resulting from accidents, acts of
nature, and events beyond the control of
Volvo.
4. The use of fuel and/or oil, or other fluids which
do not meet the Volvo-approved standards
as set forth in the Owner’s Manual, Volvo
Service Literature or in the articles “Fuel
requirements” and “Engine oil” in this booklet,
which results in the failure of a warranted part
or system, may not be warranted.
5. Repairs on vehicles for which the true
odometer mileage cannot be readily
determined.
6. The cost incurred from the use of parts other
than genuine Volvo replacement parts or
genuine Volvo remanufactured parts used for
maintenance, repair or replacement affecting
components of the emission control system. 7.
Any loss of time, inconvenience, loss of vehicle
use or commercial loss.
Emission Performance Warranty–U.S.
and Canada
The warranty begins on the date the vehicle is
sold/delivered to the first retail purchaser or put
into service, whichever occurs first.
In accordance with Section 207(B) of the Clean
Air Act, Canadian MDU and Canadian Provincial
Warranty Regulations, Volvo warrants to the first
vehicle purchaser and each subsequent purchaser,
that if
1. the vehicle is maintained and operated in
accordance with the written instructions for
proper maintenance and use (Refer to the
Owner’s Manual under the section titled
“Service and Routine Maintenance” and
the article “2021 Service and Maintenance
Requirements” in this booklet), and
2. the vehicle fails to conform at any time during
the first 24,000 miles/40,000 kilometers
or two (2) years (whichever occurs first) to
the applicable emission standards as judged
by an EPA approved or Canadian Provincial
approved emission short test, and
3. such non-conformity will result in the vehicle
owner having to bear any penalty or other
sanction (including denial of the right to use
the vehicle) under local, state, federal or
provincial law, then Volvo shall remedy the
nonconformity at no cost to the owner.

42
WARRANTY
Some components considered part of the
two (2) Year/ 24,000 mile/40,000 kilometer
Emission Performance Warranty are listed in
the article “2021 Emission Warranty Parts List
– Federal – U.S. and Canada” in this booklet.
Exceptions1. If the vehicle has been in operation for more
than two (2) years or 24,000 miles/ 40,000
kilometers, Volvo will remedy only those
nonconformities resulting from failure of
certain specified emission control components
for which coverage is eight (8) years or
80,000 miles/130,000 kilometers, whichever
occurs first. These major components include
only the three-way catalytic converter (TWC),
engine control module, electronic rear axle
drive (ERAD) and the on-board diagnostic
system (OBD).
2. Volvo may deny an Emission Performance
Warranty claim on the basis of an uncertified
replacement part used in the maintenance and
repair of a vehicle if the part in question is either
defective in material or workmanship or not
equivalent from an emission standpoint to the
original equipment part.
3. An Emission Performance Warranty claim may
be denied on the basis of non-compliance by a
vehicle owner with the written instructions for
proper maintenance and use.
ServicingIt is recommended that any replacement parts
used for maintenance, repair or replacement of emission control systems be genuine Volvo parts
or genuine Volvo remanufactured parts.
You may elect to have maintenance, repair, or
replacement of the emission control devices and
systems performed by any automotive repair
establishment or individual. You may also elect
to use parts other than genuine Volvo parts or
genuine Volvo remanufactured parts which have
been certified by the part manufacturer for such
maintenance, repair or replacement without
invalidating this warranty. The cost of such
service or parts however, will not be covered
under the warranty.
Customer AssistanceVolvo wants to ensure that the Emission
Warranties are properly administered. If you do not
receive the warranty service to which you believe
you are entitled under these warranties, you should
contact:
In the U.S.
Volvo Car USA, LLC
Customer Care Center
1 Volvo Drive
Rockleigh, NJ 07647-0914
1-(800) 458-1552
http://volvo.custhelp.com/ You may obtain further information concerning the
Emission Performance Warranty and Emission
Design and Defect Warranty or report violations of
the terms of these warranties, by contacting:
Compliance and Innovative Strategies Division
Warranty Claims
U.S. Environmental Protection Agency
2000 Traverwood Drive
Ann Arbor, MI 48105
In Canada
Volvo Car Canada Limited
Customer Care Centre
9130 Leslie Street, Suite 101
Richmond Hill, Ontario L4B 0B9
1-(800) 663-8255
[email protected]
Warranty Claim ProceduresAn Emission Performance Warranty claim may
be raised immediately upon the failure of an EPA approved or Canadian Provincial approved
emission test, if, as a result of that failure, an
owner is required by law to take action of any
kind in order to avoid imposition of a penalty or
sanction. A warranty claim may be generated by

43
WARRANTY
bringing vehicle to any authorized Volvo retailer.
To the extent required by any federal, state, or
provincial law, whether statutory or common
law, a vehicle manufacturer shall be required
to provide a means for non-franchised repair
facilities to perform Emission Performance
Warranty repairs.
However, to avoid delay and ensure proper
service, it is recommended that service under this
warranty be performed by an authorized Volvo
retailer.
When determining whether an owner has
complied with the written instructions for proper
maintenance and use, Volvo may require an
owner to submit evidence of compliance if it has
an objective reason for believing:
1. maintenance was not performed and,
2. that if not performed, it could be the cause
of the vehicle exceeding applicable emission
standards.
Failure to notify the owner of a decision to honor
or deny an Emission Performance Warranty claim
within thirty (30) days from the time the vehicle
is presented for repair shall result in the vehicle
manufacturer being responsible for repairing
the vehicle without charge to the vehicle owner,
unless such failure is attributable to the vehicle
owner or to events which are beyond the control
of the vehicle manufacturer or repair facility.
2021 Emission Warranty Parts List –
Federal – U.S. and Canada
The following are some items covered by the
Emssion Warranty for (2) years or 24,000
miles/40,000 kilometers, whichever occurs
first. Volvo has continued coverage on these
items under the new car warranty for (4) years
or 50,000 miles/80,000 kilometers, whichever
occurs first. Components marked with “*” are
covered by the Long-Term Warranty for eight
(8) years or 80,000 miles/130,000 kilometers,
whichever occurs first. Components marked with
“**” are covered for eight (8) years or 100,000
miles/160,000 kilometers, whichever occurs first.
• Ambient Air Temp Sensor
• Camshaft Position Sensor
• Catalytic Converter*
• Charge Air Cooler
• Coolant Temperature Sensor
• Coolant Thermostat
• Crankshaft Positon Sensor
• CVVT Solenoid Valve (Exhaust/Intake)
• CVVT Timing Device (Exhaust/Intake)
• Electronic Throttle Module (ETM)
• Engine Control Module (ECM) Hardware*
• Engine Control Module (ECM) Software
• Engine Cooling Fan
• EVAP Carbon Canister
• EVAP Leakage Control Module (ECLM)
• Filler Pipe
• Filler Pipe (Capless Unit)
• Fuel High-Pressure Sensor
• Fuel Injector
• Fuel Low-Pressure Sensor
• Fuel Pump
• Fuel Pump ElectronIC/H Module (PEM)
• Fuel Rail
• Fuel Tank
• Fuel Tank Isolation Valve
• Heated Oxygen Sensor(s)
• High-Pressure Fuel Pump
• Ignition Coil
• Knock Sensor
• Manifold Absolute Pressure (MAP) Sensor
• Mass Air Flow (MAF) Sensor
• Oil Separator with Crankcase Pressure
Regulator
• On-Board Diagnostic System (OBD)*
• Purge Valve
• Purge Valve Assembly incl. Purge Valve
• Spark Plug (Kit)
• Supercharger
• Supercharger Bypass Valve
• Supercharger Pressure Sensor
• Temp & Manifold Air Pressure Sensor (TMAP)
• Transmission Control Module (TCM)
Hardware
* Covered by the Long-Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.