2021 RAM CHASSIS CAB belt

374SERVICING AND MAINTENANCE

8. Pull the tension tether outward and reinstall the
glove compartment past the travel stops by
pushing in on the glove compartment sides.

Glove Compartment

NOTE:
Ensure the glove compartment door hinges and
glove compartment travel stops are fully
engaged.
9. Reattach the glove compartment tension tether by inserting the tether clip in the
glove compartment and sliding the clip
away from the face of the glove
compartment door.ACCESSORY DRIVE BELT INSPECTION
When inspecting accessory drive belts, small
cracks that run across ribbed surface of belt
from rib to rib, are considered normal. These
are not a reason to replace belt. However,
cracks running along a rib (not across) are not
normal. Any belt with cracks running along a rib
must be replaced. Also have the belt replaced if
it has excessive wear, frayed cords or severe
glazing.
Accessory Belt (Serpentine Belt)

Conditions that would require replacement:
Rib chunking (one or more ribs has sepa -
rated from belt body)
Rib or belt wear
Longitudinal belt cracking (cracks between
two ribs)
Belt slips
“Groove jumping" (belt does not maintain
correct position on pulley)
Belt broken (note: identify and correct
problem before new belt is installed)
Noise (objectionable squeal, squeak, or
rumble is heard or felt while drive belt is in
operation)
1 — Glove Compartment Travel Stop
2 — Glove Compartment Tension Tether
3 — Glove Compartment Door
WARNING!
Do not attempt to inspect an accessory
drive belt with vehicle running.
When working near the radiator cooling fan,
disconnect the fan motor lead. The fan is
temperature controlled and can start at any
time regardless of ignition mode. You could
be injured by the moving fan blades.

You can be badly injured working on or
around a motor vehicle. Only do service work
for which you have the knowledge and the
proper equipment. If you have any doubt
about your ability to perform a service job,
take your vehicle to a competent mechanic.

21_DPF_OM_EN_USC_t.book Page 374

SERVICING AND MAINTENANCE375
Some conditions can be caused by a faulty
component such as a belt pulley. Belt pulleys
should be carefully inspected for damage and
proper alignment.
Belt replacement on some models requires the
use of special tools, we recommend having your
vehicle serviced at an authorized dealer.
DRAINING FUEL/WATER SEPARATOR
F
ILTER
There are two fuel filter assemblies. One is
located on the driver's side of the engine.
The best access to this water drain valve is from
under the hood. The second one is on the under
body, located in front of the rear axle above the
drive shaft on pick-up models. The Chassis Cab
models second filter location is on the frame
behind the front axle. The best access to this
water drain valve is from under the vehicle. If water is detected in the water separator while
the engine is running, or while the ignition
switch is in the ON position, the “Water In Fuel
Indicator Light” will illuminate and an audible
chime will be heard five times. At this point you
should stop the engine and drain the water from
both of the filters.
If the “Water In Fuel Indicator Light” comes on
and a single chime is heard while you are
driving, or with the ignition switch in the ON
position, there may be a problem with your
water separator wiring or sensor. See an
authorized dealer for service.
Upon proper draining of the water from both
fuel filters, the “Water In Fuel Indicator Light”
will remain illuminated for approximately
10 seconds. If the water was drained while
the engine was running, the “Water In Fuel
Indicator Light” may remain on for
approximately three minutes.NOTE:
Care should be taken in disposing of used fluids
from your vehicle. Used fluids, indiscriminately
discarded, can present a problem to the envi
-
ronment. Contact an authorized dealer, service
station, or government agency for advice on
recycling programs and for where used fluids
and filters can be properly disposed of in your
area.

Drain the fuel/water separator filters when the
“Water In Fuel Indicator Light” is ON. Within
10 minutes of vehicle shutdown, turn the engine
mounted filter drain valve (located on the side of
the filter assembly) counterclockwise a quarter
turn, and turn the under body mounted filter
drain valve (located on the bottom of the filter
assembly) counterclockwise 1 full turn. Then turn
the ignition switch to the ON position, and allow
any accumulated water to drain. Leave the drain
valve open until all water and contaminants have
been removed. When clean fuel is visible, close
the drain valve following these guidelines:

1. Rotate the drain clockwise to close until you feel resistance from the internal seal.

2. Continue turning the drain half of a turn to properly compress the seal.
CAUTION!
Do not drain the fuel/water separator filter
when the engine is running.
Diesel fuel will damage blacktop paving
surfaces. Drain the filter into an appro-
priate container.
CAUTION!
If the “Water In Fuel Indicator Light” remains
on, DO NOT START the engine before you
drain water from the fuel filters to avoid
engine damage.
8

21_DPF_OM_EN_USC_t.book Page 375

SERVICING AND MAINTENANCE429
Stain Repel Fabric Cleaning Procedure — If
Equipped
Stain Repel seats may be cleaned in the
following manner:
Remove as much of the stain as possible by
blotting with a clean, dry towel.
Blot any remaining stain with a clean, damp
towel.
For tough stains, apply Mopar Total Clean, or
a mild soap solution to a clean, damp cloth
and remove stain. Use a fresh, damp towel to
remove soap residue.
For grease stains, apply Mopar Multi-Purpose
Cleaner to a clean, damp cloth and remove
stain. Use a fresh, damp towel to remove
soap residue.
Do not use any harsh solvents or any other
form of protectants on Stain Repel products.
Seat Belt Maintenance
Do not bleach, dye or clean the belts with
chemical solvents or abrasive cleaners.
This will weaken the fabric. If the belts need cleaning, use a mild soap
solution or lukewarm water. Do not remove the
belts from the vehicle to wash them. Dry with a
soft cloth.
Sun damage can also weaken the fabric.
Replace the belts if they appear frayed or worn
or if the buckles do not work properly.
NOTE:
If the belts retract slowly, inspect the upper
turning loop for soiling. If soiling is present,
clean with a wet soft cloth until all residue is
removed.
PLASTIC AND COATED PARTS
Use Mopar Total Clean to clean vinyl upholstery.
Cleaning Plastic Instrument Cluster
Lenses
The lenses in front of the instruments in this
vehicle are molded in clear plastic. When
cleaning the lenses, care must be taken to
avoid scratching the plastic.
Clean with a wet soft cloth. A mild soap solution
may be used, but do not use high alcohol
content or abrasive cleaners. If soap is used,
wipe clean with a clean damp cloth. Dry with a
soft cloth.
WARNING!
A frayed or torn belt could rip apart in a
collision and leave you with no protection.
Inspect the belt system periodically, checking
for cuts, frays, or loose parts. Damaged parts
must be replaced immediately. Do not
disassemble or modify the system. Seat belt
assemblies must be replaced after a collision
if they have been damaged (i.e., bent
retractor, torn webbing, etc.).
CAUTION!
Direct contact of air fresheners, insect
repellents, suntan lotions, or hand sani
-
tizers to the plastic, painted, or decorated
surfaces of the interior may cause perma -
nent damage. Wipe away immediately.
Damage caused by these type of products
may not be covered by your New Vehicle
Limited Warranty.
8

21_DPF_OM_EN_USC_t.book Page 429

451
Belts, Seat
..................................................... 330Bluetooth Connecting To A Particular Mobile Phone Or Audio Device After Pairing
................262Body Builders Guide........................................ 10Body Mechanism Lubrication........................ 380B-Pillar Location............................................. 411Brake Assist System...................................... 274Brake Control System.................................... 274Brake Fluid.......................................... 387, 444Brake System...................................... 387, 431Fluid Check............................................... 387Master Cylinder......................................... 387Parking...................................................... 137Warning Light............................................ 107Brake/Transmission Interlock....................... 141Bulb Replacement......................................... 401Bulbs, Light.......................................... 332, 401
C
Cab Top Clearance Lights.............................. 405Camera.......................................................... 186Camera, AUX........................................ 188, 194Camera, Rear...................................... 186, 189Capacities, Antifreeze (Engine Coolant)......... 439Capacities, Fluid............................................ 439Caps, FillerOil (Engine)................................................ 364Power Steering.......................................... 163Radiator (Coolant Pressure)...................... 385
Car Washes................................................... 428Carbon Monoxide Warning............................ 333Cargo Light....................................................... 54CD................................................................. 255Cellular Phone.............................................. 269Center High Mounted Stop Light................... 405Center Seat Storage Compartment.................. 67Changing A Flat Tire...................................... 339Charge Air Cooler.......................................... 386Chart, Tire Sizing........................................... 407Check Engine Light (Malfunction
Indicator Light).............................................. 117Checking Your Vehicle For Safety................. 330Checks, Safety.............................................. 330Child Restraint.............................................. 312Child RestraintsBooster Seats........................................... 315Child Seat Installation..................... 323, 325How To Stow An unused ALR Seat Belt.... 322Infant And Child Restraints....................... 313Locating The LATCH Anchorages.............. 320Lower Anchors And Tethers For Children.. 317Older Children And Child Restraints......... 314Seating Positions...................................... 316Clean Air Gasoline......................................... 433CleaningWheels..................................................... 421Climate Control................................................ 58Automatic.................................................... 59Manual........................................................ 62
Cold Weather Operation................................ 122Compact Spare Tire...................................... 419Contract, Service........................................... 446Controls........................................................ 247Cooling Pressure Cap (Radiator Cap)............ 385Cooling System............................................. 383Adding Coolant (Antifreeze)...................... 384Coolant Level................................... 384, 386Cooling Capacity....................................... 439Disposal Of Used Coolant......................... 385Drain, Flush, And Refill............................. 384Inspection................................................. 386Points To Remember................................ 386Pressure Cap............................................ 385Radiator Cap............................................. 385Selection Of Coolant (Antifreeze)..... 384, 440Corrosion Protection..................................... 427Cruise Control (Speed Control)............. 164, 166Cruise Light................................................... 115Customer Assistance.................................... 445Cybersecurity................................................ 220
D
Daytime Running Lights...................................51Dealer Service............................................... 367Defroster, Rear Window...................................62Defroster, Windshield............................ 62, 331Delay (Intermittent) Wipers..............................57Deleting A Phone........................................... 262Diagnostic System, Onboard......................... 116
11

21_DPF_OM_EN_USC_t.book Page 451

454 J
Jack Location
................................................. 339Jack Operation............................................... 339Jacking And Tire Changing............................. 339Jump Starting................................................ 344
K
Key Fob Programming Additional Key Fobs
.............. 17Key Fob Battery Service (Remote
Keyless Entry).................................................. 16Key Fob Programming (Remote
Keyless Entry).................................................. 17Keyless Enter-N-Go........................26, 118, 123Passive Entry............................................... 26Keys................................................................. 15
L
Lane Change And Turn Signals........................ 54Lane Change Assist......................................... 54LaneSense.................................................... 183Latches.......................................................... 332Hood........................................................... 79Lead Free Gasoline........................................ 433Leaks, Fluid................................................... 332Life Of Tires................................................... 417Light Bulbs........................................... 332, 401
Lights............................................................ 332Air Bag.................................... 107, 303, 331Automatic High Beam.................................. 52Brake Assist Warning............................... 277Brake Warning.......................................... 107Bulb Replacement.................................... 401Cab Top Clearance................................... 405Cargo........................................................... 54Center Mounted Stop............................... 405Courtesy/Reading....................................... 55Cruise....................................................... 115Daytime Running......................................... 51Electronic Stability Program(ESP) Indicator............................................... 108Exterior...............................................50, 332Fog........................................................... 404Four Wheel Drive Indicator....................... 162Hazard Warning Flasher........................... 334Headlights............................................ 50, 52High Beam................................................... 51Hill Descent Control Indicator................... 278Illuminated Entry......................................... 56Interior......................................................... 55Lights On Reminder..................................... 53Low Fuel................................................... 111Malfunction Indicator (Check Engine)....... 110Park.......................................................... 115Passing........................................................ 52
Seat Belt Reminder.................................. 107Security Alarm.......................................... 108Service...................................................... 401Traction Control........................................ 277Transfer Case........................................... 162Turn Signals..................... 54, 115, 332, 402Warning Instrument Cluster Descriptions................................ 108, 115Limited-Slip Differential....................... 162, 391Load Shed Battery Saver Mode..................... 105Load Shed Battery Saver On......................... 105Load Shed Electrical Load Reduction........... 105Load Shed Intelligent Battery Sensor............ 105Loading Vehicle............................................. 199Tires.......................................................... 411LocksAutomatic Door............................................28Child Protection...........................................28Power Door..................................................25Low Tire Pressure System............................. 284Lubrication, Body.......................................... 380Lug Nuts/Bolts..................................... 342, 432
M
Maintenance Free Battery............................ 366Maintenance Plan......................................... 359Maintenance Schedule............... 353, 357, 359Malfunction Indicator Light (Check Engine).. 110

21_DPF_OM_EN_USC_t.book Page 454

456 Power Steering Fluid
...................................... 444Pregnant Women And Seat Belts...................300Preparation For Jacking................................. 339Presets.......................................................... 253PTO (Power Take-Off)..................................... 163
R
Radial Ply Tires.............................................. 416Radiator Cap (Coolant Pressure Cap).. 384, 385Radio Presets...................................................... 253Radio Controls............................................... 247Radio Mode................................................... 247Radio Operation.................................. 247, 269Radio Remote Controls.................................. 247Rain Sensitive Wiper System........................... 58Rear Axle (Differential)......................... 390, 391Rear Camera................................................. 189Rear ParkSense System................................ 177Rear Window, Sliding....................................... 78Recreational Towing...................................... 214Shifting Into Transfer Case Neutral (N)..... 216Shifting Out Of Transfer Case Neutral (N).. 217Reformulated Gasoline.................................. 433Refrigerant.................................................... 372Release, Hood................................................. 79Reminder, Seat Belt...................................... 294Remote Keyless Entry...................................... 15Programming Additional Key Fobs.............. 17Remote Sound System (Radio) Control......... 247
Remote Start (Diesel)...................................... 22Remote Start (Gasoline).................................. 20Remote StartingExit Remote Start Mode.............................. 21Replacement Bulbs...................................... 401Replacement Tires........................................ 417Reporting Safety Defects.............................. 447Resetting Perform Service Indicator............. 358Restraints, Child........................................... 312Restraints, Head.............................................. 38Rotation, Tires.............................................. 424
S
Safety........................................................... 246Safety Checks Inside Vehicle........................ 330Safety Checks Outside Vehicle..................... 332Safety Defects, Reporting............................. 447Safety Features............................................. 246Safety Information, Tire................................ 406Safety Tips.................................................... 330Safety, Exhaust Gas...................................... 333Satellite Radio.............................................. 249Saved Radio Stations................................... 253Schedule, Maintenance................................ 353Seat BeltAutomatic Locking Retractor (ALR)........... 301Seat Belt Reminder....................................... 107Seat Belts............................................ 293, 330Adjustable Shoulder Belt.......................... 297
Adjustable Upper Shoulder Anchorage..... 297Adjustable Upper Shoulder Belt Anchorage............................................ 297Child Restraints........................................ 312Extender................................................... 299Front Seat........................................ 293, 296Inspection................................................. 330Lap/Shoulder Belt Operation.................... 296Lap/Shoulder Belt Untwisting................... 297Operating Instructions.............................. 296Pregnant Women...................................... 300Reminder.................................................. 294Seat Belt Extender.................................... 299Seat Belt Reminder.................................. 294Untwisting Procedure................................ 297Seat Belts Maintenance................................ 429Seats.................................................. 33, 34, 35Adjustment...........................................33, 35Easy Entry....................................................36Folding Floor................................................70Head Restraints...........................................38Memory.......................................................32Power...........................................................35Rear Folding................................................33Tilting...........................................................33Security Alarm........................................ 23, 108Selection Of Coolant (Antifreeze).................. 440Sentry Key (Immobilizer)..................................17Service Assistance........................................ 445Service Contract............................................ 446

21_DPF_OM_EN_USC_t.book Page 456

458 Rotation
.................................................... 424Safety.............................................. 406, 414Sizes.......................................................... 407Snow Tires................................................. 419Spare Tires............................. 419, 420, 421Spinning.................................................... 416Trailer Towing............................................ 206Tread Wear Indicators............................... 417Wheel Nut Torque..................................... 432To Open Hood.................................................. 79Tongue Weight/Trailer Weight....................... 205Torque Converter Clutch................................ 151Towing................................................. 200, 350Disabled Vehicle........................................ 350Guide......................................................... 205Recreational.............................................. 214Weight....................................................... 205Towing Behind A Motorhome......................... 214Traction......................................................... 218Traction Control............................................. 281Trailer Sway Control (TSC)............................. 281Trailer Towing................................................ 200Hitches...................................................... 204Minimum Requirements............................ 205Mirrors......................................................... 46Tips........................................................... 211Trailer And Tongue Weight........................ 205Wiring........................................................ 209Trailer Towing Guide...................................... 205Trailer Weight................................................ 205
Transfer Case............................................... 391Electronically Shifted....................... 153, 156Fluid......................................................... 444Transmission................................................ 141Automatic............................... 141, 146, 387Fluid......................................................... 444Maintenance............................................ 387Shifting..................................................... 140Transporting Pets.......................................... 330Tread Wear Indicators.................................. 417Turn Signals.................................. 54, 115, 402
U
UconnectPhone Call Features
................................. 264Things You Should Know About Your Uconnect Phone................................... 267Uconnect Phone.................................. 259, 260Answer Or Ignore An Incoming Call — Call Currently In Progress..................... 265Answer Or Ignore An Incoming Call — No Call Currently In Progress................ 265Bluetooth Communication Link................ 269Call Continuation...................................... 266Call Controls............................................. 264Call Termination....................................... 266Cancel Command..................................... 260Connecting To A Particular Mobile Phone Or Audio Device After Pairing............... 262
Help Command......................................... 260Join Calls.................................................. 266Making A Phone Or Audio Device A Favorite................................................ 262Making A Second Call While Current Call Is In Progress................................. 266Managing Your Favorites.......................... 263Natural Speech......................................... 259Operation.................................................. 259Overview................................................... 258Pair (Link) Uconnect Phone To A Mobile Phone....................................... 260Phonebook Download............................... 263Place/Retrieve A Call From Hold............... 266Power-Up.................................................. 269Recent Calls.............................................. 264Redial....................................................... 266To Remove A Favorite............................... 263Toggling Between Calls............................. 266Touch-Tone Number Entry........................ 264Transfer Call To And From Mobile Phone.. 266Voice Command....................................... 267Uconnect SettingsCustomer Programmable Features..............26Passive Entry Programming.........................26Uconnect System.......................................... 244Uniform Tire Quality Grades.......................... 425Unleaded Gasoline........................................ 433Untwisting Procedure, Seat Belt.................... 297USB..................................................................72

21_DPF_OM_EN_USC_t.book Page 458