2021 KIA RIO ignition

Maintenance
64
7
Fuse NameFuse ratingCircuit Protected
DOOR LOCK20ATail Gate Unlock Relay, Door Lock/Unlock Relay, Two Turn Unlock Relay
POWER OUTLET20APower Outlet
SAFETY P/WINDOW25ADriver Safety Power Window Module
STOP LAMP15AStop Signal Electronic Module
T/SIGNAL LAMP15ABCM (Body Control Module), SLM (Seat Belt & Lighting Module)
C/LIGHTER20ACigarette Lighter
HEATED
MIRROR10ADriver Power Outside Mirror, Passenger Power Outside Mirror, Air Conditioner Control Module, ECM
(Engine Control Module)/PCM (Power train Control Module)
DRL210ABCM (Body Control Module)
P/WINDOW RH25APower Window Main Switch, Passenger Power Window Switch
S/HEATER20AFront Seat Warmer Control Module
DRL110A-
START7.5AWith Immobilizer : ECM (Engine Control Module)/PCM (Power train Control Module), Engine Room
Junction Block(Start Relay), Smart Key Control Module, Ignition Lock Switch, Transaxle Range Switch
Without Immobilizer : Burglar Alarm Relay
TAIL LAMP RH7.5AHead Lamp Right Handle side, Rear Combination Lamp (OUT) Right Handle side, License Lamp Right
Handle side, Rear Combination Lamp (IN) Right Handle side, Illumination (+)
MODULE210ABCM (Body Control Module), Blind-Spot View Monitor Left Handle side/Right Handle side, Crash Pad
Switch, Front View Camera
Instrument panel (Driver’s side fuse panel)
SC PE USA 7.qxp 10/23/2020 6:07 PM Page 64

769
Maintenance
Engine room compartment fuse panel
Fuse NameFuse ratingCircuit Protected
MDPS80AMDPS (Motor Driven Power Steering) Unit
ALT150AFuse - ABS1, BAS2, BLOWER, REAR HEATED
REAR HEATED40AInstrument Panel Junction Block (Rear Defogger Relay)
ABS140AESC (Electronic Stability Control) Module
ABS240AESC (Electronic Stability Control) Module
BLOWER40ABlower Relay
WIPER10A[With BCM (Body Control Module)] Front Wiper Motor, Multifunction Switch,
[With Out BCM (Body Control Module)] Wiper Low Relay
ECU415AECM (Engine Control Module)/PCM (Power train Control Module)
SENSOR10AOil Control Valve #1/#2, Cooling Fan1/2 Relay, Oxygen Sensor (Up), Oxygen Sensor (Down), Variable
Intake Solenoid Valve, Air Conditioner Relay, Purge Control Solenoid Valve, Canister Close Valve
ECU215AECM (Engine Control Module)/PCM (Power train Control Module)
ECU320AECM (Engine Control Module)/PCM (Power train Control Module)
HEAD LAMP RH10AHead Lamp Right Handle side
HEAD LAMP LH10AHead Lamp Left Handle side
IGN COIL20AIgnition Coil #1~#4
ECU515AECM (Engine Control Module)/PCM (Power train Control Module), Fuel Pump Relay, Injector #1~#4
SC PE USA 7.qxp 10/23/2020 6:07 PM Page 69

Maintenance
70
7
Fuse NameFuse ratingCircuit Protected
B/UP LAMP10ABack-Up Lamp Switch
B+140AInstrument Panel Junction Block (Fuse - DRL2, FOGLAMP FRONT, STOP LAMP, MODULE6, Power
Connector (AUDIO, ROOM LAMP))
B+250AInstrument Panel Junction Block (Fuse - IMMO, SMART KEY, BRAKE SWITCH, SAFETY P/WINDOW,
S/HEATER, SUNROOF, Power Window Relay)
IG240AIgnition Switch, IG2 Relay, Start Relay
COOLING FAN40ACooling Fan1/2 Relay
ECU130AFuse - ECU3, ECU4, Main Relay
HEAD LAMP20AHead Lamp Relay
H/LAMP HI20AWith CANADA DRL : SLM(Seat Belt & Lighting Module) or BCM(Body Control Module)
Without CANADA DRL : Head Lamp HI Relay
FUEL PUMP20AFuel Pump Relay
HORN15AHorn Relay/ Burglar Alarm Horn Relay
A/C10AAir Conditioner Relay
AMS10ABattery Sensor
B+340AInstrument Panel Junction Block (Fuse - T/SIGNAL LAMP, DOOR LOCK, Tail Lamp Relay)
IG140AStart Relay, [With Smart Key] IG1 Relay, ACC Relay,
[With Out Smart Key] Ignition Switch
POWER OUTLET40AInstrument Panel Junction Block (Power Outlet Relay)
SC PE USA 7.qxp 10/23/2020 6:07 PM Page 70

Maintenance
72
7
LIGHT BULBS
Bulb replacement precaution
Please keep extra bulbs on hand
with appropriate wattage ratings in
case of emergencies.
Refer to “Bulb Wattage” in chapter 8.
When changing lamps, first turn off
the engine at a safe place, firmly
apply the parking brake and detach
the battery’s negative (-) terminal.
Use only bulbs of the specified
wattage. net-work failure
The headlamp, taillight, and fog light
may light up when the head lamp
switch is turned ON, and not light up
when the taillight or for light switch is
turned ON. This may be cause by
network failure or vehicle electrical
control system malfunction. If there is
a problem, we recommend the sys-
tem be serviced by an authorized Kia
dealer.
trical control system stabilization
A normally functioning lamp may
flicker momentarily. This momentary
occurrence is due to stabilization
function of the vehicle's electrical on
control system. If the lamp soon
returns to normal, the vehicle does
not require service.
However, if the lamp goes out after
the momentary flickering, or the flick-
ering continues, we recommend the
system be serviced by an authorized
Kia dealer.
WARNING- Working on the lights
Prior to working on the light,
firmly apply the parking brake,
ensure that the ignition switch
is turned to the LOCK position
and turn off the lights to avoid
sudden movement of the vehi-
cle and burning your fingers or
receiving an electric shock.
CAUTION -Light replace-
ment
Be sure to replace the burned- out bulb with one of the samewattage rating. Otherwise, itmay cause damage to the fuseor electric wiring system.
CAUTION -Headlamp
Lens
To prevent damage, do notclean the headlamp lens withchemical solvents or strongdetergents.
SC PE USA 7.qxp 10/23/2020 6:07 PM Page 72

Your vehicle is equipped with a cat-
alytic converter emission control
device.
Therefore, the following precautions
must be observed:
Use only UNLEADED FUEL forgasoline engines.
Do not operate the vehicle when there are signs of engine malfunc-
tion, such as misfire or a noticeable
loss of performance.
Do not misuse or abuse the engine. Examples of misuse are
coasting with the ignition off and
descending steep grades in gear
with the ignition off.
Do not operate the engine at high idle speed for extended periods (5
minutes or more).
Do not modify or tamper with any part of the engine or emission con-
trol system. All inspections and
adjustments must be made by an
authorized Kia dealer.
Avoid driving with an extremely low fuel level. Running out of fuel could
cause the engine to misfire, dam-
aging the catalytic converter. Failure to observe these precautions
could result in damage to the catalyt-
ic converter and to your vehicle.
Additionally, such actions could void
your warranties.
Perchlorate Material-special handling
may apply, See www.dtsc.ca.gov/haz-
ardouswaste/ perchlorate.
Notice to California Vehicle Dismantlers:
Perchlorate containing materials,
such as air bag inflators, seatbelt
pretensioners and keyless remote
entry batteries, must be disposed of
according to Title 22 California Code
of Regulations Chapter 67384.10
(a).
CALIFORNIA
PERCHLORATE NOTICE
7 114
Maintenance
SC PE USA 7.qxp 10/23/2020 6:10 PM Page 114

Index
6I
Room lamp ................................................................4-106
Trunk/Liftgate room lamp ........................................4-108
Vanity mirror lamp ....................................................4-109
Interior overview ............................................................2-5
Key positions ..................................................................5-7 Ignition switch position ................................................5-7
Starting the engine ........................................................5-9
Keys ........................................................................\
........4-4 Battery replacement ......................................................4-8
Immobilizer system ......................................................4-9
Key operations ..............................................................4-4
Record your key number ..............................................4-4
Remote keyless entry system operations ......................4-5
Transmitter precautions ................................................4-7
Lane Following Assist (LFA) ........................................5-91 Detecting sensor ..........................................................5-91
Function malfunction and limitations ........................5-95
Function operation ......................................................5-92
Function settings ........................................................5-92
Lane Keeping Assist (LKA) ..........................................5-61 Detecting sensor ..........................................................5-61
Function malfunction and limitations ........................5-66 Function operation ......................................................5-63
Function settings ........................................................5-62
LCD display (for type B cluster) ..................................4-65 Driving Assist mode ..................................................4-66
LCD Display Mode ....................................................4-65
User Settings Mode (for type B cluster) ....................4-67
Warning messages (for type B cluster) ......................4-75
Liftgate (for 5 door) ......................................................4-30 Opening the liftgate ....................................................4-30
Closing the liftgate ......................................................4-30
Emergency liftgate safety release ..............................4-31
Light bulbs ....................................................................7-72\
Back-up lamp bulb replacement (for 4 door) ............7-94
Back-up lamp bulb replacement (for 5 door) ............7-87
Bulb replacement precaution ....................................7-72
Front fog lamp (Bulb type) bulb replacement ..........7-83
Front turn signal lamp bulb replacement (Headlamp Type A) ..................................................7-80
Front turn signal lamp bulb replacement (Headlamp Type B, C) ..............................................7-80
Glove box lamp bulb replacement ..........................7-100
Headlamp (Low/High beam) (Bulb type) bulb replacement (Headlamp Type A) ..............................7-77
Headlamp (Low/High beam) (Bulb type) bulb replacement (Headlamp Type B) ..............................7-78
Headlamp (Low/High beam) (LED type) bulb replacement (Headlamp Type C) ..............................7-84
L
K
SC PE USA Index.qxp 10/23/2020 6:23 PM Page 6

I11
Index
Defogging logic ........................................................4-138
Manual climate control system ................................4-136
Winter driving ..............................................................5-112 Carry emergency equipment ....................................5-116
Change to "winter weight" oil if necessary ..............5-115
Check battery and cables ..........................................5-114
Check spark plugs and ignition system ....................5-115
Don't let ice and snow accumulate underneath ........5-115
Don't let your parking brake freeze ..........................5-115
Snowy or Icy conditions ..........................................5-112
To keep locks from freezing ....................................5-115
Use approved window washer anti-freeze in system 5-115
Use high quality ethylene glycol coolant ................5-114
Wiper blades ..................................................................7-35 Blade inspection ..........................................................7-35
Blade replacement ....................................................7-35
Wipers and washers ....................................................4-100 Rear window wiper and washer switch (for 5 door) ..4-104
Windshield washers (front) ......................................4-102
Windshield wipers ....................................................4-101
SC PE USA Index.qxp 10/23/2020 6:23 PM Page 11