2020 VOLVO XC90 fuel pressure

6
SERVICE AND MAINTENANCEThis support is an important advantage to you,
the Volvo owner, as systems become more
sophisticated and intricate.
Servicing your Volvo should be done at your
convenience. Therefore, plan to make your
appointments ahead of time so that your retailer
can schedule the right personnel and equipment to
be available for the work your Volvo requires.
Should you have any questions concerning service,
parts, or warranty coverage, your Volvo retailer
will be happy to answer them for you. Should
you require additional information, they can
further assist you by contacting Volvo’s Regional
personnel for clarification.
Remember – you should always exercise your
right to:•
Receive an estimate of costs before any repair
work is performed;
•
Receive prior notification of any additional
repairs;
•
Receive a copy of the repair order, including
those for warranty repairs;
•
Review repairs completed under warranty.
ServicingItems you should check at regular maintenance
intervals and periodically when refueling:•
Engine oil level
•
Coolant level
•
Washer fluid
•
Tire inflation pressure
•
Brake system fluid levels
•
Exterior lights (headlights, turn-signals, etc.)
Fuel requirementsConsult your Owner’s Manual for fuel
requirements.Octane RatingTOP TIER Detergent Gasoline
Volvo endorses the use of “TOP TIER Detergent
Gasoline” where available to help maintain engine
performance and reliability. TOP TIER Detergent
Gasoline meets a new standard jointly established
by leading automotive manufactures to meet the
needs of today’s advanced engines. Qualifying
gasoline retailers (stations) will, in most cases,
identify their gasoline as having met the “TOP
TIER Detergent Gasoline” standards.
NOTE
Information about TOP TIER Detergent
Gasoline is available at www.toptiergas.com.


34
WARRANTY

Damage/Deterioration/Corrosion•
Vehicles severely damaged and/or declared to
be a total loss by an insurer.
•
Vehicles substantially reassembled or repaired
from parts obtained from another vehicle
previously in operation.
•
The use of fuel and/or oil, or other fluids which
do not meet the Volvo-approved standards
as set forth in the Owner’s Manual, Volvo
Service Literature or in the articles “Fuel
requirements” and “Engine oil” in this booklet.
•
Failures resulting from misuse, abuse,
negligence, overloading, modifications
(including the electronic management
system(s), accidents or racing.
•
Defects or failures resulting from the use of
new parts not sold or approved by Volvo,
or used parts, or the resultant damage to
associated parts or systems.
•
Defects or failures resulting from incorrect
diagnosis by an independent repair shop.
•
Failures resulting from continued operation
of the vehicle after a warning light, gauge
reading, or other indication advises of a
mechanical or operational problem (e.g., dash
instrumentation indicates overheat, loss of oil
pressure, etc.).
•
Environmental damage to the vehicle’s surface
which is beyond Volvo’s control, such as
airborne fall-out (including chemicals, tree
sap, etc.) or other atmospheric conditions,
hailstones, road hazards, stone chips or other
acts of nature. Exterior painted surfaces are
covered by the Corrosion Protection Limited
Warranty, see the article “Volvo’s Corrosion
Protection, Limited Warranty–U.S./Warranty–
Canada” in this booklet.
•
Damage to the interior (soft trim, upholstery,
and seating areas) resulting from normal wear
and tear, misuse, abuse, or negligence.
Glass
Glass breakage, unless it occurs because of
defects in material or workmanship.
Odometer Tampering
Repairs on vehicles for which the true odometer
mileage cannot be readily determined.
Inconvenience/Incidental Charges
The loss of vehicle use, loss of time, telephone
calls, towing, lodging, car rental, food, and other
incidental and consequential damages.
NOTE
Parts replaced free of charge under the terms
of the New Vehicle Limited Warranty (U.S.),
New Vehicle Warranty (Canada) are not subject
to the warranty coverage of the Genuine Volvo
Replacement Parts and Accessories Limited
Warranty. Those parts will be warranted for
90 days or the remainder of the New Vehicle
Limited Warranty (U.S.), New Vehicle Warranty
(Canada), whichever is greater.Hybrid models onlyHybrid battery
Under the New Hybrid Vehicle Limited Warranty,
the original equipment battery installed in your
2020 Volvo is covered against defects in parts
and labor for eight (8) years or 100,000 miles/
160,000 kilometers, whichever occurs first.
2
NOTE
Batteries are subject to natural wear out due
to ageing and usage. If the battery capacity is
lower than 55% of original status (according
to specification) at 8 years or 100,000 miles/
160,000 kilometers, whichever occurs first
3,
the battery will be replaced free of charge.
2 California Hybrid Battery coverage is ten (10) years or 150,000 miles, whichever occurs first.3 Model year 2020 vehicles sold and registered in California, Connecticut, Maine, Massachusetts, Maryland, New Jersey, New York, Oregon, Rhode Island or Vermont if the battery capacity is lower than 50% of
original status at 10 years or 150,000 miles , whichever occurs first will have the battery replaced free of charge..

43
WARRANTY
bringing vehicle to any authorized Volvo retailer.
To the extent required by any federal, state, or
provincial law, whether statutory or common
law, a vehicle manufacturer shall be required
to provide a means for non-franchised repair
facilities to perform Emission Performance
Warranty repairs.
However, to avoid delay and ensure proper
service, it is recommended that service under this
warranty be performed by an authorized Volvo
retailer.
When determining whether an owner has
complied with the written instructions for proper
maintenance and use, Volvo may require an
owner to submit evidence of compliance if it has
an objective reason for believing:
1. maintenance was not performed and,
2. that if not performed, it could be the cause
of the vehicle exceeding applicable emission
standards.
Failure to notify the owner of a decision to honor
or deny an Emission Performance Warranty claim
within thirty (30) days from the time the vehicle
is presented for repair shall result in the vehicle
manufacturer being responsible for repairing
the vehicle without charge to the vehicle owner,
unless such failure is attributable to the vehicle
owner or to events which are beyond the control
of the vehicle manufacturer or repair facility.
2020 Emission Warranty Parts List –
Federal – U.S. and CanadaThe following are some items covered by the
Emission Warranty for two (2) years or 24,000
miles/40,000 km, whichever occurs first. Volvo
has continued coverage on these items under
new car warranty to four (4) years or 50,000
miles/80,000 kilometers, whichever occurs first.
Components marked with one
“*” are covered
by the Long Term Warranty for eight (8) years
or 80,000 miles/130,000 km, whichever
occurs first. Hybrid components marked with
“**” are covered for eight (8) years or 100,000
miles/160,000 kilometers, whichever occurs first.
•
Ambient Air Temperature Sensor
•
Camshaft Position Sensor
•
Capless Fuel Filler Pipe
•
Catalytic Converter
“*”
•
Charge Air Cooler
•
Coolant Thermostat
•
Crankshaft Position Sensor
•
CVVT Solenoid Valve
•
CVVT Timing Device
•
Electronic Throttle Module (ETM)
•
Engine Control Module Hardware
“*”
•
Engine Control Module Software
•
Engine Coolant Temperature Sensor
•
EVAP Canister Purge Valve
•
EVAP Carbon Canister
•
EVAP Hydrocarbon Scrubber
•
EVAP Leakage Control Module (ELCM)
•
EVAP Leakage Diagnostic Pump
•
Filler Pipe
•
Fuel High Pressure Sensor
•
Fuel Injector
•
Fuel Low Pressure Sensor
•
Fuel Pump including Pressure Regulator
•
Fuel Pump Electronic Module (PEM)
•
Fuel Rail (including fuel pressure sensor)
•
Fuel Tank
•
Fuel Tank Isolation Valve (FTIV)
•
Heated Oxygen Sensors
•
High Pressure Fuel Pump
•
Hybrid Powertrain Cooling (Radiator)
“**”
•
Hybrid Cooling Battery-Radiator
“**”
•
Hybrid Cooling Condenser including high
pressure sensor
“**”
•
Hybrid Cooling Fan (engine cooling)
“**”
•
Hybrid Cooling Fan (hybrid cooling circuit)
“**”
•
Hybrid Cooling Pump
“**”
•
Hybrid Cooling Temperature Sensor
“**”
•
Hybrid Cooling Thermostat
“**”
•
Hybrid Cooling Valve
“**”

* Covered by the Long Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.
** Hybrid components are covered for eight (8) years or 100,000 miles/160,000 kilometers, whichever occurs first.

44
WARRANTY•
Hybrid System including Hybrid Battery
“**”
•
Ignition Coil
•
Knock Sensor
•
Manifold Absolute Pressure (MAP) Sensor
•
Mass Air Flow (MAF) Sensor
•
Oil Separator with Crankcase Pressure
Regulator
•
Spark Plug
•
Supercharger
•
Supercharger Bypass Valve
•
Supercharger Pressure Sensor
•
Temperature and Manifold Air Pressure Sensor
(TMAP)
•
Transmission Control Module (TCM) Hardware
and Software
•
Turbocharger Assembly including Wastegate
Miscellaneous items used in above systems
Manifolds, hoses, clamps, fittings, tubing, sealing
gaskets or devices, pulleys, belts, fuel lines, wiring
harnesses and mounting hardware and electronic
controls (all models) used with the components
listed above.
NOTE
Parts listed under the 2020 Emission Warranty
Parts List – Federal – U.S. and Canada are
only covered components when they apply to
specific engine variants. Not all parts listed
apply to all engine types.
NOTE
Model year 2020 vehicles with engine VIN
code BR or BK sold and registered in California,
Connecticut, Maine, Massachusetts, Maryland,
New Jersey, New York, Oregon, Rhode Island
or Vermont are classified as Transitional Zero
Emissions (TZEV) vehicles. TZEV vehicles have
a defects and performance emissions warranty
on all emissions components for fifteen (15)
years or 150,000 miles, whichever occurs first.
** Hybrid components are covered for eight (8) years or 100,000 miles/160,000 kilometers, whichever occurs first.