2020 VOLVO S60 T8 ESP

43
WARRANTY
bringing vehicle to any authorized Volvo retailer.
To the extent required by any federal, state, or
provincial law, whether statutory or common
law, a vehicle manufacturer shall be required
to provide a means for non-franchised repair
facilities to perform Emission Performance
Warranty repairs.
However, to avoid delay and ensure proper
service, it is recommended that service under this
warranty be performed by an authorized Volvo
retailer.
When determining whether an owner has
complied with the written instructions for proper
maintenance and use, Volvo may require an
owner to submit evidence of compliance if it has
an objective reason for believing:
1. maintenance was not performed and,
2. that if not performed, it could be the cause
of the vehicle exceeding applicable emission
standards.
Failure to notify the owner of a decision to honor
or deny an Emission Performance Warranty claim
within thirty (30) days from the time the vehicle
is presented for repair shall result in the vehicle
manufacturer being responsible for repairing
the vehicle without charge to the vehicle owner,
unless such failure is attributable to the vehicle
owner or to events which are beyond the control
of the vehicle manufacturer or repair facility.
2020 Emission Warranty Parts List –
Federal – U.S. and CanadaThe following are some items covered by the
Emission Warranty for two (2) years or 24,000
miles/40,000 km, whichever occurs first. Volvo
has continued coverage on these items under
new car warranty to four (4) years or 50,000
miles/80,000 kilometers, whichever occurs first.
Components marked with one
“*” are covered
by the Long Term Warranty for eight (8) years
or 80,000 miles/130,000 km, whichever
occurs first. Hybrid components marked with
“**” are covered for eight (8) years or 100,000
miles/160,000 kilometers, whichever occurs first.
•
Ambient Air Temperature Sensor
•
Camshaft Position Sensor
•
Capless Fuel Filler Pipe
•
Catalytic Converter
“*”
•
Charge Air Cooler
•
Coolant Thermostat
•
Crankshaft Position Sensor
•
CVVT Solenoid Valve
•
CVVT Timing Device
•
Electronic Throttle Module (ETM)
•
Engine Control Module Hardware
“*”
•
Engine Control Module Software
•
Engine Coolant Temperature Sensor
•
EVAP Canister Purge Valve
•
EVAP Carbon Canister
•
EVAP Hydrocarbon Scrubber
•
EVAP Leakage Control Module (ELCM)
•
EVAP Leakage Diagnostic Pump
•
Filler Pipe
•
Fuel High Pressure Sensor
•
Fuel Injector
•
Fuel Low Pressure Sensor
•
Fuel Pump including Pressure Regulator
•
Fuel Pump Electronic Module (PEM)
•
Fuel Rail (including fuel pressure sensor)
•
Fuel Tank
•
Fuel Tank Isolation Valve (FTIV)
•
Heated Oxygen Sensors
•
High Pressure Fuel Pump
•
Hybrid Powertrain Cooling (Radiator)
“**”
•
Hybrid Cooling Battery-Radiator
“**”
•
Hybrid Cooling Condenser including high
pressure sensor
“**”
•
Hybrid Cooling Fan (engine cooling)
“**”
•
Hybrid Cooling Fan (hybrid cooling circuit)
“**”
•
Hybrid Cooling Pump
“**”
•
Hybrid Cooling Temperature Sensor
“**”
•
Hybrid Cooling Thermostat
“**”
•
Hybrid Cooling Valve
“**”

* Covered by the Long Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.
** Hybrid components are covered for eight (8) years or 100,000 miles/160,000 kilometers, whichever occurs first.

46
WARRANTYFor seven (7) years or 70,000 miles, whichever
first occurs:
If an emission-related part listed in this warranty
booklet, specially noted with coverage for seven
(7) years or 70,000 miles
6, is defective, the part
will be repaired or replaced by Volvo. This is your
long-term emission control system DEFECTS
WARRANTY.
Owner’s Warranty ResponsibilitiesAs the vehicle owner, you are responsible for the
performance of the required maintenance listed
in your Owner’s Manual and this booklet. Volvo
recommends that you retain all receipts covering
maintenance on your vehicle, but Volvo cannot
deny warranty solely for the lack of receipts or
for your failure to ensure the performance of all
scheduled maintenance.
You are responsible for presenting your vehicle
to a Volvo retailer as soon as a problem exists.
The warranty repairs should be completed in a
reasonable amount of time, not to exceed thirty
(30) days.
As the vehicle owner, you should also be aware
that Volvo may deny you warranty coverage if
your vehicle or a part has failed due to abuse,
neglect, improper maintenance or unapproved
modifications.If you have any questions regarding your warranty
rights and responsibilities, you should contact:
Volvo Car USA, LLC
Customer Service Department
1 Volvo Drive
Rockleigh, NJ 07647
1-800-458-1552
California Air Resources Board
9528 Telstar Avenue
El Monte, CA 91731-2990
Massachusetts Department of Environmental
Protection
1 Winter Street
Boston, MA 02108
Vermont Agency of Natural Resources
Department of Environmental Conservation
Air Pollution Control Division
103 South Main Street
Waterbury, VT 05671-0402
Maine Department of Environmental
Protection
17 State House Station
Augusta, ME 04333
Connecticut Department of Environmental
Protection
Bureau of Air Management, Planning &
Standards Division
79 Elm Street
Hartford, CT 06106
Rhode Island Dept. of Environmental
Management
Office of Air Resources
235 Promenade Street
Providence, RI 02908-5767
Pennsylvania Dept. of Environmental
Protection
Bureau of Air Quality
Rachel Carson State Office Building, 12th Floor
P.O. Box 8468
Harrisburg, PA 17105-8468
New Jersey Department of Environmental
Protection
P.O. Box 402
Trenton, NJ 08625-0402

6 Hybrid Models: model year 2020 vehicles with engine VIN code BR or BK sold and registered in California, Connecticut, Maine, Massachusetts, Maryland, New Jersey, New York, Oregon, Rhode Island or Vermont
are classified as Transitional Zero Emissions (TZEV) vehicles. TZEV vehicles have a defects and performance emissions warranty on all emissions components for fifteen (15) years or 150,000 miles, whichever
occurs first.

49
WARRANTY
If an emergency occurs and an authorized Volvo
retailer is not reasonably available, repairs may be
performed at any available service establishment
or by any individual, using any replacement part.
When a warranted part is not available within
thirty (30) days or the repair cannot be completed
within thirty (30) days, repairs may be performed
at any available service establishment or by any
individual, using any replacement part.
Volvo will reimburse the owner for emergency
repairs (including diagnosis) that are covered
under this warranty. The expenses, however,
cannot exceed our suggested retail price for all
warranted parts replaced and labor charges,
based on Volvo’s recommended time allowance
for the warranty repair and the geographically
appropriate hourly labor rate. Replaced parts and
paid invoices must be presented at a Volvo retailer
as a condition of reimbursement for emergency
repairs not performed by a Volvo retailer.
Failure to notify the owner of a decision to
honor or deny a Performance Warranty Claim
within thirty (30) days from the time the vehicle
is initially presented for repair shall result in
the vehicle manufacturer being responsible for
repairing the vehicle without charge to the vehicle
owner, unless such failure is attributable to the
vehicle owner or to events beyond the control of
the vehicle manufacturer or the repair facility.You are advised to have all recommended
maintenance or repairs on your new 2020
Volvo vehicle performed. Volvo will not deny
a warranty claim solely because you have no
record of maintenance; however, we may deny a
warranty claim if your failure to perform required
maintenance resulted in the failure of a warranted
part.
Receipts and/or maintenance records covering
the performance of regular maintenance should,
therefore, be retained in the event questions arise
concerning maintenance.
Inspection ProgramCalifornia, Connecticut, Delaware, Maine,
Massachusetts, Maryland, New Jersey,
New York, Oregon, Pennsylvania, Rhode
Island, Vermont and Washington
Non-hybrid models The following provisions apply to vehicles
which fail to pass the California, Connecticut,
Delaware, Maine, Massachusetts, Maryland,
New Jersey, New York, Oregon, Pennsylvania,
Rhode Island, Vermont or Washington Smog
Inspection. Should your vehicle fail a smog check
test during the warranty period, you may choose
to have the vehicle repaired at any authorized
Volvo retailer. The authorized Volvo retailer will
make the necessary repairs within the three (3)
year/50,000-mile period so that the vehicle will
pass the inspection. After three (3) years/50,000
miles, but before a period of use of seven (7)
years/70,000 miles, the authorized Volvo dealer
will repair or replace only those parts listed in the
article “2020 Model Year Emission Parts List”
in this booklet. After seven (7) years/70,000
miles, but before a period of use of eight (8)
years/80,000 miles, the authorized Volvo retailer
will cover only the catalytic converter, engine
control module, central electronic module and
onboard diagnostic device. Volvo will pay for the
repair unless the failure was caused by abuse,
neglect, improper maintenance, or the use of
leaded fuel or fuels not recommended in your
Owner’s Manual or this booklet. If the failure is
covered under this warranty, Volvo shall be liable