2020 VOLKSWAGEN TRANSPORTER open bonnet

The actions should only be carried out in the specified order:
=>Fig. 307 Dipped beam/main beam bulb Side light bulb
8.
Bulb
Swing the sealing cap upwards, and swing the wire hook over the locking lugs on the sealing cap.
H4 W5W
The actions should only be carried out In the specified order·
=>Fig. 308 Daytime running light bulb Turn signal bulb
1. Follow the instructions on the checklist =>page 433.
2. Open the bonnet &. =>page 350.
3. Remove the sealing cap@. Remove the sealing cap Q).
Turn the bulb holder® anticlockwise as Turn the bulb holder@ anticlockwise as far 4. far as it will go and pull it out to the rear as it will go and pull it out to the rear along along with the bulb. with the bulb.
5. Push the bulb slightly into the bulb holder, turn it anti-clockwise, and pull it out straight.
6. Replace the defective bulb with a new bulb of the same type (see the last line in the table "Bulbs").
7. Insert the bulb holder, and turn it clockwise until it engages.
8. Fit the sealing cap.
Bulb BA15S I PY21W
m The illustrations show the left-hand H4 halo-L.!J gen headlight from behind. The right-hand halogen headlight is a mirror image of the one shown. 436 I If and when

Changing bulbs in H7 halogen headlights
Fig. 309 Changing the dipped beam bulb, the side light bulb and the turn signal bulb.
Fig. 310 Changing the main beam bulb and daytime running light bulb.
l""""'('n First read and observe the introductory L-Jo:.Jl information and safety warnings & on page 432.
The front halogen headlight does not need to be removed in order to change a bulb.
The actions should only be carried out in the specified order:
=>Fig. 309 Dipped beam bulb Side light bulb Turn signal bulb
1. Follow the instructions on the checklist =>page 433.
2. Open the bonnet&. =>page 350.
3. Push the wire hook@ firmly upwards over the locking lugs on the sealing cap G), and swing the sealing cap downwards (arrow) to open it.
Push the ends of the wire
4. hook together@] arrows), Pull the bulb and bulb hold-Pull the bulb and bulb holder and swing it over the er® out to the rear. @out to the rear. bulb@.
Tilt the bulb @, and pull it 5. towards rear out of the Pull the bulb straight out of the bulb holder. headlight Insert.
6. Replace the defective bulb with a new bulb of the same type (see the last line in the table "Bulbs").
Practical tips I 437

The actions should only be carried out in the specified order:
=>Fig. 309 Dipped beam bulb Side light bulb I Turn signal bulb
7
8.
Bulb
Swing the wire hook over the bulb, and push it into the catches.
Insert the bulb holder into the headlight, and push it all the way in.
Swing the sealing cap upwards, and swing the wire hook over the locking lugs on the sealing cap.
H7 I W5W I PW24W
The actions should only be carried out in the specified order·
=>Fig. 310 Main beam bulb Daytime running light bulb
1. Follow the instructions on the checklist =>page 433.
2. Open the bonnet Lh =>page 350.
3. Remove the sealing cap®. Remove the sealing cap G).
4. Push the ends of the wire hook together @I arrows), and swing it over the bulb @. Pull the bulb and bulb holder@ out to the rear.
5. Tilt the bulb@, and pull it towards rear Pull the bulb straight out of the bulb holder. out of the headlight insert.
6. Replace the defective bulb with a new bulb of the same type (see the last line in the table "Bulbs").
7. Swing the wire hook over the bulb, and Insert the bulb holder into the headlight, and push it into the catches. push it all the way in.
8. Fit the sealing cap.
Bulb H7
m The illustrations show the left-hand H7 halo-l!J gen headlight from behind. The right-hand halogen headlight is a mirror image of the one shown. Changing bulbs in the LED headlights
Fig. 311 Changing the turn signal bulb.
1"'"""111 First read and observe the introductory L-J,:.JJ information and safety warnings & on page 432.
438 I If and when
I W21W
The LED headlight does not need to be removed in order to change the bulb. .,..

The actions should only be carried out in the specified order·
311 Turn signal bulb
1. Observe and follow the instructions on the checklist ""page 433.
2. Open the bonnet.&. 350.
3. Remove the seating cap Q).
4. Release the connector@, and pull it off the bulb holder.
5. Turn the bulb holder@ anticlockwise as far as it will go and pull it out to the rear along with the bulb.
6. Push the bulb slightly into the bulb holder, turn it anti-clockwise, and pull it out straight.
7. Replace the defective bulb with a new bulb of the same type (see the last line in the table "Bulbs").
8. Insert the bulb holder into the headlight and turn it clockwise as far as it will go.
9. Fit the sealing cap.
Bulb H21W
m The illustrations show the left-hand LED W headlight from behind. The right-hand LED headlight is a mirror image of the one shown. Changing the bulbs in the fog light
Fig. 312 Changing the fog light bulb.
m First read and observe the introductory information and safety warnings & on page 432.
The actions should only be carried out in the specified order:
1. Follow the instructions on the checklist 433.
2.
3.
4.
5.
6.
When changing the right bulb, set the steering wheel to the left stop, and when chang-ing the left bulb, set the steering wheel to the right stop.
Use the screwdriver from the vehicle tool kit to open the service flap 312 Q) in the wheel housing liner.
Release the connector, and pull it off the bulb holder@.
Turn the bulb holder anticlockwise and pull it out towards the rear with the bulb.
Turn the new bulb holder with the same designation and working bulb clockwise to the original position until it clicks into place (see the last line in the table "Bulbs").
__ ___:7...:.. ___ ..::.sh...:.o:...:u:....ld::.....:.c:...:lic.::.k:....i:....nt.:..:.o-"p-'-la:....c:..:e...:.. ___
Practical tips 439

Vehicle identification data
A B
0--1674 16-5-0471 188 55 lN1,1ZZZ3C Z 9E134769
®-
360 5LD
PRSSRT Lim. TREND 155 kW D6F
®---CCZB KPZ
LRnJ QQ
BOA CIG GOK H08 JOH 091 IAT IG2 228 5RQ 5SL TQ3 352 STC Ql4 8AV SGV SRM 1211 L02 OVI> Q07 7116
en.(A71!
Fig. 322 data sticker: example shows a vehicle with engine code CCZB plate.
0 Engine and gearbox code, paint number, inte-rior equipment. In the example, the engine code is "CCZB" =)Fig. 322.
Fig. 323 In the windscreen: vehicle identification number.
r--('n First read and observe the introductory L-lc.J.I information and safety warnings & on page 450.
Vehicle data sticker
The vehicle data sticker =)Fig. 322 located in the =)Booklet SeNice schedule and contains the following data:
G) Vehicle identification number (chassis number)
® Vehicle type, engine power, gearbox type
G) Optional extras, PR numbers
Type plate
Open the bonnet &. to gain access to the type plate =)page 350.
The type plate =)Fig. 322 [[is attached to the right of the plenum chamber bulkhead. Vehicles for cer-tain export countries do not have a type plate.
The type plate contains the following data:
® Gross vehicle weight rating
® Gross combination weight (vehicle plus trailer)
Q) Gross axle weight rating, front
® Gross axle weight rating, rear
Vehicle identification number
The vehicle identification number can be read from outside the vehicle through a viewer in the wind-screen =)Fig. 323. The viewer is located in the low-er corner of the windscreen. Technical data 451

Dimensions
Fig. 324 Dimensions.
l""""'('n First read and observe the introductory L-J,.:.U information and safety warnings & on page 450.
The data in the table apply to the most basic mod-el.
Key for Fig. 324:
® Front track
Rear track
® Width
© Width across the mirrors
@ Height at kerb weight8l
® Height with open tailgate at kerb weight8l
® Height with open bonnet and kerb weight8l
@ Ground clearance in road-ready statecl between the axles
® Wheelbase
CD Length
-Turning circle diameter
•l Kerb weight without driver, without payload.
b) Figures were not available at time of publication.
c) Kerb weight with driver (75 kg) and service fluids.
452 I Technical data
The specified values can vary due to different tyre and wheel sizes, if additional equipment is fitted, for different model versions, for retrofitted accesso-ries, and for special vehicles. They can also vary in vehicles that have been manufactured for other countries.
Short wheelbase Long wheelbase
1,622 -1,634 mm
1,628 -1,640 mm
1,904 mm
2,297 mm
1,950-1 ,990 mm
b) b)
b) b)
178-202 mm
3,000 mm 3,400 mm
4,904-5,006 mm 5,304 -5,406 mm
11.9 m 13.2 m

Belt height adjuster . . . . . • . . . . . . . . . . . . . . 86
Belt tensioner . . . . . . . . . . . . . . . . . . . . . . . . . 86 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . 87 Service and disposal . . . . . . . . • . . . . . . . . 87
Bench seaUbed Drawer . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Bench seaUbed, California Load-through hatch . . . . . . . . . . . . . . . . . 212 Moving . . . . . . . . . . . . . . . . . . . . . . . . . . . 195 Removing and installing . . . . . . . . . . . . . . 195 Setting up the bed . . . . . . . . . . . . . . . . . . 196
Biodiesel . . . . . . . . . . . . . . . . . . . . . . . . . . . 346
Black ice warning . . . . . . . . . . . . . . . . . . . . . 21
Bluetooth . . . . . . . . . . . . . . . . . . . . . . . . . . . 188 Entering password for rear-seat telephony .1.90 Establishing a connection for rear-seat tel-ephony. . . . . . . . . . . . . . . . . 190
Bonnet Closing . . . . . • . . . . . . . . . . . • . . . . . . . . . 352 Opening . . . . . . . . . . . . . . . . . . . . . . . . . . 352
Boot lid see Tail gate . . . . . . . . . . . . . . . . . . . . . . . . 49
Bottle holders . . . . . . . . . . . . . . . . . . . . . . . 155
Brake Assist system (BAS) see Brake support systems . . . . . . . . . . . 275 Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 277 Specification . . . . . . . . . . . . . . . . . . . . . . . 277
Brakes . . . . . . . . . . . . . • . . . . . . . . . . . . . . . 269 Brake fluid . . . . . . . . . . . . . . . . . . . . . 277 Brake fluid level . . . . . . . . . . . . . . . . . . . . 277 Brake pads . . . . . . . . . . . . . . . . . . . • . . . . 272 Brake servo . . . . . . . . . . . . . . . . . . . . . . . 273 Brake support systems . . . . . . . . . . . . . . 274 Changing the brake fluid . . . . . . . . . . . . 277 Emergency brake lights for hard braking . 412 Fault . . . . . . . . . . . . . . . . . . . . . . . . . . 273 Handbrake . . . . . . . . . . . . . . . . . . . . . . . . 271 Indicator lamp . . . . . . . . . . . . . . . . . . . . . 270 Running in brake pads . . . . . . . . . . . . . . . 272 Warning lamp . . . . . . . . . . . . . . . . . . . . . . 270
Brake servo . . . . . . . . . . . . . . . . . . . . . 273, 274
Brake support systems . . . • . . . . . . . . . . . . 274 ABS ............................. 274 BAS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 274 EDL ............................. 274 ESC ............................. 274 TCS ............................. 274 Brake system . . . . . . . . . . . . . . . . . . . . . . . . 274 see Brakes . . . . . . . . . . . . . . . . . . . . . . . . 273
Breakdown Vehicle safety...................... 412
Breakdown set . . . . . . . . . . . . . . . . . . . . . . . 425 Contents . . . . . . . . . . . . . . . . . . . . . . . . . . 427 Inflating the tyre . . . . . . . . . . . . . . . . . . . . 428 More than one damaged tyre . . . . . . . . . . 425 Preparation . . . . . . . . . . . . . . . . . . . . . . . 427
Sealing the tyre . . . . . . . . . . . . . . . . . . . . 428 Storing . . . . . . . . . . . . . . . . . . . . . . . . . . . 426 Test after driving for 10 minutes . . . . . . . . 429 When not to use . . . . . . . . . . . . . . . . . . . . 425
Buckle straps . . . . . . . . . . . . . . . . . . . . . . . . 128 Bulb defect see Changing bulbs . . . . . . . • . . . . . . . . . 432 Business
c
2-seat arrangement . . . . • . . . . . . . . • . . . 182 Equipment . . . . . . . . . . . . . . . . . . . . . . . . 180 Rear-seat telephony . . . . . . . . . . . . . . . . . 187 Seat functions. rear . . . . . . . . . . . . . . . . . 182 Seat heater in the 2-seat arrangement 183 Vehicle overview . . . . . . . . . . . . . . . . . . . 180
California 12-volt socket . . . . . . . . . . . . . . . . . . . . . . 244 230-volt power supply . . . . . . . . . . . . . . . 245 Additional batteries . . . . . . . . . . . . . . . . . 248 Air conditioning system . . . . . . . . . . • . . . 250 Awning ........................... 226 Battery charger . . . . . . . . . . . . . . . . . . . . 247 Central control panel . . . . . . . . . . . . . . . . 204 Darkening the interior of the vehicle . . . . 215 Drink holder . . . . . . . . . . . . . . . . . . . . . . . 215 Electric pop-up roof . . . . . . . . . . . . . . . . . 221 Equipment . . . . . . . . . . . . . . . . . . . . . . . . 192 Gas system . . . . . . . . . . . . . . . . . . . . . . . 233 Interior lights . . . . . . . . . . . . . . . . . . . . . . 208 Manual pop-up roof . . . . . . . . . . . . . . . . . 218 Power supply in the vehicle . . . . . . . . . . . 242 Practical tips . . . . . . . . . . . . . . . . . . . . . . . 252 Seat functions, rear . . . . . . . . . . . . . • . . . 193 Stowage areas . . . . . . . . . . . . . . . . . . . . . 210 Supplementary heater . . . . . . . . . . . . . . . 251 Tables and camping chairs . . . . . . . . . . . 229 Vehicle overview . . . . . . . . . . . . . . . . . . . 192 Water supply and disposal . . . . . . . . . . . . 237
Camera ............................. 293 Camping chairs, California . . . . . . . . . . . . . 232 Camping equipment, California Camping chairs . . . . . . . . . . . . . . 232 Work table . . . . . . . . . . . • . . . . . . . . 230, 231
Capacities Ad Blue tank . . . . . . . . . . . . . . . . . . . • . . . 346 Fuel tank . . . . . . . . . . . . . . . . . . . 343 Washer fluid reservoir . . . . . . . . . . . . . . . 121
Car-Net see Volkswagen Car-Net . . . . . . . . . • . . . 402
Care see Vehicle care . . . . • . . • . . . . . . . . • . . . 380 Car telephone . . . . . . . . . . . . . . . . . . . . . . . . 398
Catalytic converter . . . . . . . . . . . . . . . . . . . 408 Fault . . . . . . . . . . . . . . . . . . . • . . . . . . . . . 408 Indicator lamp . . . . . . . . . . . . . . . . . . . . . 407
Index 467