2020 Ram 1500 differential

6
STARTING AND OPERATING
STARTING THE ENGINE .............................................. 290
Automatic Transmission ............................................ 291
Tip Start Feature ......................................................... 291
Keyless Enter-N-Go — Ignition................................. 291
Normal Starting Using ENGINE START/STOP
Button ............................................................................ 292
Cold Weather Operation (Below –22°F Or
−30°C) ........................................................................... 296
After Starting................................................................ 296
 ENGINE BLOCK HEATER — IF EQUIPPED .............. 296
 ENGINE BREAK-IN RECOMMENDATIONS ............ 297
 PARKING BRAKE ............................................................ 297
Electric Park Brake (EPB) ........................................... 297
 AUTOMATIC TRANSMISSION ................................... 302
Ignition Park Interlock ................................................ 303
Brake/Transmission Shift Interlock System ........... 304
Eight-Speed Automatic Transmission ..................... 304
 FOUR-WHEEL DRIVE OPERATION — IF
 EQUIPPED ........................................................................ 310
Four-Position Electronically Shifted Transfer Case
(Eight Speed Transmission Only) — If
Equipped ...................................................................... 311
Five-Position Electronically Shifted Transfer Case
(Eight Speed Transmission Only) — If
Equipped ...................................................................... 314 
ACTIVE-LEVEL FOUR CORNER AIR SUSPENSION
SYSTEM — IF EQUIPPED ...............................................319
Description.................................................................... 319
Air Suspension Modes ................................................322
Instrument Cluster Display Messages ......................323
Operation ......................................................................323
 ACTIVE-LEVEL FOUR CORNER AIR SUSPENSION
SYSTEM (REBEL MODELS ONLY) — IF
EQUIPPED .........................................................................325
Description.................................................................... 325
Air Suspension Modes ................................................328
Instrument Cluster Display Messages ......................329
Operation ......................................................................329
 AXLE LOCKER SYSTEM — IF EQUIPPED ..................331
 LIMITED-SLIP DIFFERENTIAL — IF EQUIPPED ...... 332
 POWER STEERING ..........................................................333
Electric Power Steering ..............................................333
 FUEL SAVER TECHNOLOGY 5.7L ENGINES ONLY —
IF EQUIPPED .....................................................................333
 STOP/START SYSTEM — IF EQUIPPED .....................334
Automatic Mode ..........................................................334
Possible Reasons The Engine Does Not
Autostop........................................................................334
To Start The Engine While In Autostop Mode ........335
2020_DT_1500_OM_US.book Page 6

210 SAFETY

6. Push the “ESC Off” button located in the lower switch bankbelow the climate control four times within 20 seconds. The
“ESC Off Indicator Light” should turn on and turn off two
times.

7. Rotate the steering wheel back to center and then an addi -
tional slightly more than one-half turn to the right.
8. Turn the ignition to the OFF mode and then back to ON. If the sequence was completed properly, the “ESC Off
Indicator Light” will blink several times to confirm HSA
is disabled.
9. Repeat these steps if you want to return this feature to its previous setting.
Traction Control System (TCS)
The Traction Control System (TCS) monitors the amount of
wheel spin of each of the driven wheels. If wheel spin is
detected, the TCS may apply brake pressure to the spinning
wheel(s) and/or reduce engine power to provide enhanced
acceleration and stability. A feature of the TCS, Brake
Limited Differential (BLD), functions similar to a limited slip
differential and controls the wheel spin across a driven axle.
If one wheel on a driven axle is spinning faster than the other,
the system will apply the brake of the spinning wheel. This will allow more engine torque to be applied to the wheel that
is not spinning. BLD may remain enabled even if TCS and
ESC are in a reduced mode.
Trailer Sway Control (TSC)
Trailer Sway Control (TSC) uses sensors in the vehicle to
recognize an excessively swaying trailer and will take the
appropriate actions to attempt to stop the sway. TSC will
become active automatically once an excessively swaying
trailer is recognized.
NOTE:
TSC cannot stop all trailers from swaying. Always use
caution when towing a trailer and follow the trailer tongue
weight recommendations. Refer to “Trailer Towing” in
“Starting And Operating” for further information.
When TSC is functioning, the “ESC Activation/Malfunction
Indicator Light” will flash, the engine power may be reduced
and you may feel the brakes being applied to individual
wheels to attempt to stop the trailer from swaying. TSC is
disabled when the ESC system is in the “Partial Off” or “Full
Off” modes.
WARNING!
If TSC activates while driving, slow the vehicle down,
stop at the nearest safe location, and adjust the trailer
load to eliminate trailer sway.
2020_DT_1500_OM_US.book Page 210

STARTING AND OPERATING 331
AXLE LOCKER SYSTEM — IF EQUIPPED
This vehicle is equipped with an electronically locking rear
differential. This differential, when engaged, mechanically
lock together the axle shafts forcing the wheels to spin at an
equal rate. The locking of the rear differential should only be
engaged during low-speed, extreme off-road situations
where one wheel is likely to not be in contact with the
ground. It is not recommended to drive the vehicle with the
differentials locked on pavement due to the reduced ability
to turn and speed limitations.Axle Lock Button The locking rear axle is controlled by the AXLE LOCKER
button.
Under normal driving conditions, the rear axle should be
unlocked.
During the command to lock the rear axle, the indicator light
will flash until the axle is locked. After the lock command has
been successfully executed, the light will remain on solid.
Operating in 4WD LOW the locker can be engaged up to
40 mph (64 km/h) and will remain engaged throughout the
4WD LOW speed range.
CAUTION!
• Do not lock the rear axle on hard surfaced roads. The ability to steer the vehicle is reduced and damage to the
drivetrain may occur when the axle is locked on hard
surfaced roads.
• Do not try to lock the rear axle if the vehicle is stuck and the tires are spinning. You can damage drivetrain
components. Lock the rear axle before attempting situ -
ations or navigating terrain, which could possibly
cause the vehicle to become stuck.
5
2020_DT_1500_OM_US.book Page 331

332 STARTING AND OPERATING
Operating the locker in 2WD, 4WD AUTO, and 4WD
LOCK/HIGH the locker can be engaged up to 20 mph
(32 km/h). While driving with the locker engaged, if speed
exceeds 25 mph (40 km/h), the locker will automatically
disengage, but will automatically reengage at 20 mph
(32 km/h).
NOTE:
Left to right wheel speed difference may be necessary to
allow the rear axle to fully lock. If the indicator light is
flashing after selecting the rear axle lock mode, drive the
vehicle in a turn or on loose gravel to expedite the locking
action.
The axle locker could become torque locked due to side to
side loads on the rear axle. Driving slowly while turning the
steering wheel from a left hand turn to a right hand turn or
driving in REVERSE for a short distance may be required to
release the torque lock and unlock the axles.
To unlock the rear axle; push the AXLE LOCK button. The
AXLE LOCK indicator light will go out when the rear axle is
unlocked.
LIMITED-SLIP DIFFERENTIAL — IF EQUIPPED
The limited-slip differential provides additional traction on
snow, ice, mud, sand and gravel, particularly when there is a difference between the traction characteristics of the
surface under the right and left rear wheels. During normal
driving and cornering, the limited-slip unit performs simi
-
larly to a conventional differential. On slippery surfaces,
however, the differential delivers more of the driving effort
to the rear wheel having the better traction.
The limited-slip differential is especially helpful during slip -
pery driving conditions. With both rear wheels on a slippery
surface, a slight application of the accelerator will supply
maximum traction. When starting with only one rear wheel
on an excessively slippery surface, slight momentary appli -
cation of the parking brake may be necessary to gain
maximum traction.
Care should be taken to avoid sudden accelerations when
both rear wheels are on a slippery surface. This could cause
both rear wheels to spin, and allow the vehicle to slide side -
ways on the crowned surface of a road or in a turn.
WARNING!
When servicing vehicles equipped with a limited-slip or
locking differential never run the engine with one rear
wheel off the ground since the vehicle may drive
through the rear wheel remaining on the ground and
result in unintended movement.
2020_DT_1500_OM_US.book Page 332

SERVICING AND MAINTENANCE 515
Rear Axle And 4x4 Front Driving Axle Fluid Level
For normal service, periodic fluid level checks are not
required. When the vehicle is serviced for other reasons the
exterior surfaces of the axle assembly should be inspected. If
gear oil leakage is suspected inspect the fluid level. Refer to
“Fluids And Lubricants” in “Technical Specifications” for
further information. This inspection should be made with
the vehicle in a level position.
The fluid level should be even with the bottom of the fill hole
(within 1/4 in (6.4 mm) of edge of hole) for the front axle and
rear axle.
Lubricant Selection
Refer to “Fluids And Lubricants” in “Technical Specifica-
tion” for further information.
NOTE:
The presence of water in the gear lubricant will result in
corrosion and possible failure of differential components.
Operation of the vehicle in water, as may be encountered in
some off-highway types of service, will require draining and
refilling the axle to avoid damage. Limited-Slip Differentials
Rear axles equipped with a Limited Slip Differential require
that 5 oz. (148 ml) Mopar Limited Slip Additive be added to
the gear lubricant. Refer to “Fluids And Lubricants” in
“Technical Specification” for further information. The
Mopar Limited Slip Additive should be added to the gear
lubricant whenever a fluid change is made to an axle
equipped with a Limited Slip Differential.
NOTE:
When refilling a limited slip differential axle which requires
a friction modification additive, the additive should be
added before the gear lubricant to ensure proper additive
fill.
Drain And Refill
Refer to the “Maintenance Plan” for the proper maintenance
intervals.
Transfer Case
Selection Of Lubricant
Use only the manufacturer's recommended fluid. Refer to
“Fluids And Lubricants” in “Technical Specifications” for
further information.
7
2020_DT_1500_OM_US.book Page 515

516 SERVICING AND MAINTENANCE
Fluid Level Check

This fluid level can be checked by removing the filler plug. The
fluid level should be to the bottom edge of the filler plug hole (or
within 1/8 inch of the bottom) with the vehicle in a level position.

Drain And Refill
Refer to the “Maintenance Plan” in this section for the proper
maintenance intervals.
HOISTING
A conventional floor jack may be used at the jacking loca-
tions. Refer to the graphics that show jacking locations.
However, a floor jack or frame hoist must never be used on
any other parts of the underbody.
TIRES
Tire Safety Information

Tire safety information will cover aspects of the following infor -
mation: Tire Markings, Tire Identification Numbers, Tire Termi -
nology and Definitions, Tire Pressures, and Tire Loading.
Tire Markings
Tire MarkingsCAUTION!

Never use a floor jack directly under the differential housing
of a loaded truck or damage to your vehicle may result.
1 — US DOT Safety Standards Code (TIN)
2 — Size Designation
3 — Service Description
4 — Maximum Load
5 — Maximum Pressure
6 — Treadwear, Traction and Temperature Grades
2020_DT_1500_OM_US.book Page 516

660
Differential, Limited Slip ....................................................... 332
Disable Vehicle Towing ......................................................... 478
Disposal Antifreeze (Engine Coolant) .............................................. 509
Do Not Disturb ........................................................................ 646
Door Ajar.......................................................................... 182, 183
Door Ajar Light ............................................................... 182, 183
Door Locks Automatic ............................................................................... 41
Doors........................................................................................... 35
Drag And Drop Menu ............................................................ 557
Driver’s Seat Back Tilt .............................................................. 42
Driving Through Flowing, Rising, Or Shallow Standing
Water ..................................................................................... 427
Dual Rear Wheels ................................................................... 547 E
Electric Brake Control System ............................................... 199 Anti-Lock Brake System ..................................................... 198
Electronic Roll Mitigation .......................................... 200, 210
Electric Parking Brake ............................................................ 297
Electrical Power Outlets......................................................... 128
Electronic Range Select (ERS)................................................ 309
Electronic Speed Control (Cruise Control).......................... 337
Electronic Stability Control (ESC) ........................................ 201
Electronic Throttle Control Warning Light ......................... 181 Electronically Shifted Transfer Case ............................311, 314
Emergency, In Case Of
Freeing Vehicle When Stuck ..............................................477Hazard Warning Flasher ....................................................431
Jump Starting .......................................................................472
Emission Control System Maintenance ...............................196
Engine .......................................................................................487 Air Cleaner ...........................................................................494
Block Heater .........................................................................296
Break-In Recommendations...............................................297Compartment .......................................................487, 488, 489Compartment Identification ..............................487, 488, 489Coolant (Antifreeze)............................................................ 554
Exhaust Gas Caution................................................... 286, 552Fails To Start.........................................................................295
Flooded, Starting .................................................................295
Fuel Requirements ......................................................548, 553
Jump Starting .......................................................................472Oil ..........................................................................492, 553, 554
Oil Filler Cap ................................................................487, 493
Oil Filter ................................................................................494Oil Selection .................................................................492, 553
Oil Synthetic .........................................................................493
Overheating..........................................................................475
Starting..................................................................................292
Engine Oil Viscosity................................................................493
2020_DT_1500_OM_US.book Page 660

661
Engine Oil Viscosity Chart .................................................... 493
Enhanced Accident Response Feature ......................... 262, 481
Entry System, Illuminated ....................................................... 75
Ethanol...................................................................................... 550
Exhaust Gas Cautions .................................................... 286, 552
Exhaust System ............................................................... 286, 505
Exterior Lighting ....................................................................... 66 Exterior Lights ................................................................... 66, 289 F
Filters Air Cleaner ........................................................................... 494Air Conditioning ........................................................... 93, 497
Engine Oil..................................................................... 494, 554
Engine Oil Disposal ............................................................ 494
Flashers Turn Signals ........................................................... 71, 193, 289
Flash-To-Pass ............................................................................. 69
Flat Tire Stowage .................................................................... 468
Fluid Capacities ....................................................................... 553
Fluid Leaks ............................................................................... 289
Fluid Level Checks Brake ..................................................................................... 512
Fluid, Brake .............................................................................. 556
Fluids And Lubricants ........................................................... 554
Fog Lights........................................................................... 71, 441
Fold-Flat Seats ........................................................................... 42 Forward Collision Warning................................................... 222
Four Wheel Drive .................................................................... 310
Four-Way Hazard Flasher .....................................................431
Freeing A Stuck Vehicle .........................................................477
Front Axle (Differential) .........................................................515
Fuel ............................................................................................548 Adding ..................................................................................403
Additives ..............................................................................550
Clean Air...............................................................................549
Ethanol ..................................................................................550
Gasoline ................................................................................548Light ...................................................................................... 185
Materials Added ..................................................................550
Methanol...............................................................................550
Octane Rating.......................................................548, 549, 554Requirements ...............................................................548, 553Tank Capacity ......................................................................553
Fuses..........................................................................................444 G
Garage Door Opener (HomeLink) ........................................109
Gasoline, Clean Air .................................................................549
Gasoline, Reformulated..........................................................549
General Information ...............................................................233
Glass Cleaning .........................................................................545
Grocery Bag Retainer ................................................................54
Gross Axle Weight Rating .....................................................408
11
2020_DT_1500_OM_US.book Page 661