2020 MERCEDES-BENZ SPRINTER light

#
Open ther ear-end doors. #
Place ascrew driver int orecesses 2and
th en pr yoffco vers 1 . #
Using thel ug wrenc hfromt hevehicle tool kit,
unscr ewthen ow visible bolts counter-clock‐
wise byappr oximatel y20turns. #
Slightly raise spar ewheel car rier 4 and
unhook left-hand saf etyh ook 3. #
Assemble thep um pleve rfor thej acka nd
slide it int osleeve5 onther ight-ha ndside
of spar ewheel car rier 4. #
Raise spar ewheel car rier 4 withthe pump
le ve ra nd unhook right-han dsafet yh ook 3. #
Slowl ylow er spar ewhee lcarrier 4 tothe
ground. #
Lift spar ewheel car rier 4 slightl yand pull
th ep um pleve rout of thes lee ve. #
Use thep um pleve rtol iftt he spar ewheel
be yond ther ear edg eofsparew heel car rier
4. #
Carefully remo vethes par ew heel from spare
wheel car rier 4.T he spar ewheel is heavy.
When thes par ew heel is remo ved, thec enter
of gr avity changes due totheh eavy weight of
th ew heel. The spar ewheel ma yslip down or
tip ove r.
Ve hicles with rear wheel drive: installin gthe
spar ewheel (Cargo Van/Passenger Van) #
Carefully place thes par ew heel ont ospare
wheel car rier 4.T he spar ewheel is heavy.
When youp lacethe spar ewheel ont ospare
wheel car rier 4,t he center of gravity
ch anges due tothew eight of thew heel. The
spar ewheel ma yslip down or tip over. #
Slide thep um pleve rfor thej acki ntos leeve
5 on spar ewheel car rier 4. #
Raise spar ewheel car rier 4 withthe pump
le ve ra nd attac hright-ha ndsafetyh ook 3. #
Slight lyraise spar ewheel car rier 4 and
attac hleft-hand saf etyh ook 3. #
Pull thep um pleve rout of slee ve5 . #
Using thel ug wrench, tighten saf etyh ook
bolts 3byturning them clockwise. #
Replace and engag ecovers 1. #
Close ther ear-end doors.
Ve hicles with rear wheel drive: removing the
spar ewheel (vehicl ewithl ow ered chassis) Bolt co
vers fort he saf etyh ooks (exa mp le: Cargo
Va n) Wheel
sand tires 241

#
Open ther ear-end doors. #
Place ascrew driver int orecesses 2and
th en pr yoffco vers 1 . #
Using thel ug wrenc hfromt hevehicle tool kit,
unscr ewthen ow visible bolts counter-clock‐
wise byappr oximatel y20turns. #
Slightly raise spar ewheel car rier 4 and
unhook left-hand saf etyh ook 3. #
Assemble thep um pleve rfor thej acka nd
slide it int osleeve5 onther ight-ha ndside
of spar ewheel car rier 4. #
Raise thes par ew heel car rier wit hthe pump
le ve ra nd unhook right-han dsafet yh ook 3. #
Position loop 7ofextraction device 6on
th es par ew heel so that youw ill later be able
to attac hlug wrench 8. #
Prepar ethe jac k. #
Place thej ackb eneat hthe cor responding
jac ksuppor tpoint. #
Movethep um pleve rupa nd down until the
tir eisr aised amaximum of 1.18 in (3 cm) off
th eg round. #
Hook lug wrench 8intoloop 7ofextrac‐
tio nd evice 6 onthes par ew heel. #
Carefully remo vethes par ew heel from spare
wheel car rier 4.T he spar ewheel is heavy.
When thes par ew heel is remo ved, thec enter
of gr avity changes due totheh eavy weight of
th ew heel. The spar ewheel ma yslip down or
tip ove r. #
Remo vethes par ew heel extraction device
and stor eitinas afep lace. Youc an now
ins tallth es par ew heel on your vehicle. #
Lowe rthe vehicle.
Ve hicles with rear wheel drive: installin gthe
spar ewheel (vehicle with lo weredc hassis)
% In
thee vent of aflat tire, youm aystor et he
fa ulty wheel inside thev ehicle onl y.An intact
whee lmaybe stored in thes par ew heel car‐
ri er onl ywhen thev ehicle is unladen. Aladen
ve hicle mus tfirst be raised. #
Carefull yplace thes par ew heel ont ospare
wheel car rier 4.T he spar ewheel is heavy.
When youp lacethe spar ewheel ont ospare
wheel car rier 4,t he center of gravity
ch anges due tothew eight of thew heel. The
spar ewheel ma yslip down or tip over. #
Slide thep um pleve rfor thej acki ntos leeve
5 on spar ewheel car rier 4. #
Raise spar ewheel car rier 4 withthe pump
le ve ra nd attac hright-ha ndsafetyh ook 3. #
Slight lyraise spar ewheel car rier 4 and
attac hleft-hand saf etyh ook 3. #
Pull thep um pleve rout of slee ve5 . #
Using thel ug wrench, tighten saf etyh ook
bolts 3byturning them clockwise. #
Replace and engag ecovers 1. #
Close ther ear-end doors. 242
Wheels and tires

Ve
hicles with rear wheel drive: removing the
spar ewheel (chassis) #
Loosen wing nuts 3manually and then
re mo vethem. #
Loosen nuts 2asfarast hethre ad end. #
Slightly raise spar ewheel car rier 4 and
unhook left-hand saf etyh ook 1. #
Assemble thep um pleve rfor thej acka nd
slide it int othe slee veon ther ight-ha ndside
of spar ewheel car rier 4. #
Raise spar ewheel car rier 4 withthe pump
le ve ra nd unhook right-han dsafet yh ook 1. #
Slowl ylow er spar ewhee lcarrier 4 tothe
ground. #
Lift spar ewheel car rier 4 slightl yand pull
th ep um pleve rout of thes lee ve. #
Use thep um pleve rtol iftt he spar ewheel
be yond ther ear edg eofthe spar ewheel car‐
ri er. #
Carefully remo vethes par ew heel from the
spar ewheel car rier .T he spar ewheel is heavy.
When thes par ew heel is remo ved, thec enter
of gr avity changes due totheh eavy weight of
th ew heel. The spar ewheel ma yslip down or
tip ove r.
Ve hicles with rear wheel drive: installin gthe
spar ewheel (chassis) #
Carefully place thes par ew heel ont ospare
wheel car rier 4.T he spar ewheel is heavy.
When youp lacethe spar ewheel ont othe
spar ewheel car rier ,t he center of gr avity
ch anges due tothew eight of thew heel. The
spar ewheel ma yslip down or tip over. #
Slide thep um pleve rfor thej acki ntot he
slee veon spar ewheel car rier 4. #
Raise spar ewheel car rier 4 withthe pump
le ve ra nd attac hright-ha ndsafetyh ook 1. #
Slight lyraise thes par ew heel car rier and
attac hleft-hand saf etyh ook 1. #
Pull thep um pleve rout of thes lee ve. #
Tighten nuts 2. #
Put wing nuts 3in place and tighten them. Wheels and tires
243

#
Mak esuret hat no windshield washer
concentrat espills out next tothef iller
opening. *
NO
TEDama getothee xterio rlighting
due tounsuitable windshield washer fluid Uns
uitable windshield washer fluid ma ydam‐
ag et he plastic sur face of thee xterio rlighting. #
Onlyuse windshield washer fluid which
is also suitable foru se on plast ic surfa‐
ces, e.g. MB SummerFit or MB Winter‐
Fit. *
NO
TEBlocked spr aynozzle scaused by
mixing windshield washer fluids #
Do no tmix MB SummerFit and MB Win‐
te rFit wit hother windshield washer flu‐
ids. Do no
tuse distilled or de-ionize dwater .Other‐
wise, thef ill le vels ensor ma ygiveaf alse reading.
Information on thew indshield washer fluid
Re commended windshield washer fluid:
R abovefreezing point :e.g. MB SummerFit
R below freezing point :e.g. MB WinterFit
Mixin gratio
Fo rthe cor rect mixing ratio ,refer tothei nforma‐
tion on thea nti-freeze container.
Mix thew ashe rfluid wit hwindshield washer fluid
all year round.
Fi lling capacities
Wi ndshield washer sy stem
Wa sher fluid
5.8 qt (5.5 l)Re
frigerant Note
sonr efrigerant
Obser vethen otes on operating fluids
(/ page247).
% Yo
ur vehicle's climat econt rols ystemc an be
fi lled wit hR‑134a refrigerant. The refrigerant
R‑134a contains fluorinated greenhouse gas.
If yo ur vehicle is filled wit hR‑134a refrigerant, the
fo llowing informatio napplies: *
NO
TEDama gecaused byincor rect refrig‐
erant If
th ei ncor rect refrigerant is used ,this can
damag ethe climat econt rols ystem. #
Use onl yR‑134a refrigerant or theP AG
oil appr ovedfor your vehicle by
Mercedes-Benz. #
The appr ovedPAG oil ma ynotbe mixed
wit ha ny ot herPAGo ilth at is not
appr ovedfor R‑134a refrigerant. Maintenance
work,s uc hasa dding refrigerant or
re placing components, ma ybecarried out only
by aq ualified specialis tworks hop. All thea pplica‐
ble regulations relatin gtot his and theS AE J639
st andar dmustbea dhered to.
All workon thec limat econt rols ystems hould
alw aysbec arried out at aqualified specialist
wo rkshop. Example:
refrigerant warning label
1 Warning symbols
2 Refrigerant capacity
3 Applicabl estandards
4 PAGo il par tnumber
5 Refrigerant type
Wa rning symbols 1refertot hefollowing:
R Potential dangers
R The per form anc eofm aintenance workat a
qu alified specialis tworks hop Ve
hicl edata Information on
vehicl edimensions The
following section con tains impor tant tech ni‐
cal da tafory our vehicle. Your vehicle documents
contain fur ther vehicle-specific and equipment-
dependent tech nica ldatas uchasv ehicle dimen‐
sions and weights. Te
ch nica ldata 255

Saf
etys ystems Displa
ymessages
Possible causes/consequences and 0050 0050Solutions
0075
Left Side Curtain Airbag
Malfunction Service
Required (exa mp le) *T
herespectiv ewindo wcurtain airbag is malfunctioning
(/ page35). &
WARNING Risk of inju ryor fata linjur ydue tomalfunctions
in thew indo wairbag
If th ew indo wairbag is malfunctioning, it might be triggered
unintentionall yormight no tbetriggered at all in thee vent of an
accident wi thhigh deceleration. #
Have thew indo wairbag checkeda nd repaired immediately
at aq ualified specialis tworks hop. #
Consult aqualified specialis tworks hop immediatel y.
0075 Front Left Malfunction
Service Required (exa m‐
ple) *T
herespectiv erestraint sy stem is malfunctioning (/ page31). &
WARNING Risk of inju rydue tomalfunctions in ther estraint
sy stem
If th er estraint sy stem is malfunctioning, restra int sy stem com‐
ponents ma ybetriggered unintentionall yormaynotd eplo yas
intended during an accident .This ma yaffect theE mer gency Ten‐
sioning Device sorairbags, fore xamp le. #
Have ther estraint sy stem checkeda nd repaired immedi‐
atel yataq ualified specialis tworks hop. Re
cognition of arestraint sy stem malfunction:
R The 0075 restra int sy stem warning lam pdoes no tlight up when
th ei gnition is switched on.
R The 0075 restra int sy stem warning lam plight supc ontinuously
or repeatedly during ajourne y. #
Consult aqualified specialis tworks hop immediatel y.
0075 SRS Malfunction Service
Required *T
herestra int sy stem is malfunctioning (/ page31). &
WARNING Risk of inju rydue tomalfunctions in ther estraint
sy stem
If th er estraint sy stem is malfunctioning, restra int sy stem com‐
ponents ma ybetriggered unintentionally or ma ynotdeplo yas
intended during an accident .This ma yaffect theE mer gency Ten‐
sioning Device sorairbags, fore xamp le. #
Have ther estraint sy stem checkeda nd repaired immedi‐
atel yataq ualified specialis tworks hop. Re
cognition of arestraint sy stem malfunction:
R The 0075 restra int sy stem warning lam pdoes no tlight up when
th ei gnition is switched on.
R The 0075 restra int sy stem warning lam plight supc ontinuously
or repeatedly during ajourne y. #
Consult aqualified specialis tworks hop immediatel y. Displ
aymessa gesa nd warning and indicator lamps 263

Displa
ymessages
Possible causes/consequences and 0050 0050Solutions #
Wait until thee ngine has cooled down. #
Ensur ethat thea ir supply tothee ngine radiator is no tobstruc‐
te d. #
Avoiding high engine loads, continue tothen eares tqualified
specialis tworks hop. Ensur ethat thec oolant temp eratur edis‐
pla yremain sbelo w2 48°F (120°C).
00AC Check Coolant Level See
Operator's Manual *T
he coolant le velist oo lo w. &
WARNING Risk of scalding from ho tcoolant
The engine cooling sy stem is pressurized, particularly when the
engine is warm.Ify ou open thec ap, youc oul dbes calded byhot
coolant spr aying out. #
Letthe engine cool down befor eopening thec ap. #
When opening thec ap, wear pr otectiv eglove sa nd saf ety
gl asses. #
Open thec ap slowl ytorelease pressure. *
NO
TEEngine damag eduetoinsuf ficient coolant #
Avoid long journe yswit hinsuf ficient coolant. #
Topupc oolant (/ page189).
Regeneration Not Possi-
ble *N
otall condition shave been me tfor rege neration of thed iesel par‐
ticulat efilter . #
Continue driving as normal until all condition shave been me tfor
re ge neration of thed iesel particulat efilter.
The load condition of thed iesel particulat efilter is over50% and the
messag estilla ppear sonthe instrument clus ter. #
Consult aqualified specialis tworks hop. DEF (Diesel Exhaus
tFluid) Displa
ymessages
Possible causes/consequences and 0050 0050Solutions
00E2
Refill Additive See Opera-
tor's Manual *
In addition, they ellow 00E2 DEFindicator lam plight supont he
instrument clus tera nd aw arning tone sounds.
The DEF supply ha sfallen belo wthe firs tw arning thre shold. #
Addatl east2.5gal(9. 5l)ofD EF (/pag e137).
The 00E2 DEF indica torlamp onl ydisappea rswhen thev ehicle
is stationar y,at thel ates tafter 20 seconds, as soon as you
switc hont he ignition or star tt he engine af tert opping up. 274
Displaymessa gesa nd warning and indicator lamps

Displa
ymessages
Possible causes/consequences and 0050 0050Solutions
00E2
Refill Additive Starts
until Emerg .Op.: XXX
See Operator's Manual *I
na ddit ion, they ello wD EFindicator lam plight supa ndaw arning
to ne sounds.
The DEF supply ha sfallen belo wthe reser vemar k.
Af tert he messag eappear sfor thef irst time ,the remaining DEF sup‐
ply willl astfor appr oxima tely 12 00 mile s(19 00 km) .The engine can
th en onl ybestarted ano ther 16 times. The numbe rofremaining
engine starts XX(16to1)iss hown inthem essag eevery time the
engine is star ted. #
Addatl east2.5gal(9. 5l)ofD EF (/pag e137).The 00E2 DEF
indica torlamp onl ydisappea rswhen thev ehicle is stationar y,at
th el ates tafter 20 seconds, as soon as yous wit ch on thei gni‐
tion or star tt he engine af tert opping up.
00E2
Refill Additive Emer-
gency Op.: XXX mph See
Operator's Manual *
In addition, they ello wD EFindicator lamp 00E2lightsupont he
instrument clus tera nd aw arning tone sounds.
If the Refill Additiv eEmergency Op.: XXX mph See Operator's Man-
ual displa ymessag eisshown, youc an only driv ethe vehicle at a
maximum speed of 5mph (8 km/h). #
Addatl east2.5gal(9. 5l)ofD EF (/pag e137).
Th eD EF indica torlamp 00E2 only disappea rswhen thev ehicle
is stationar y,at thel ates tafter 20 seconds, as soon as you
switc hont he ignition or star tt he engine af terr efilling.
0099
Additive System Fault
See Operator's Manual *
In addition, they ellow 00B9CheckEngine warning lam ponthe
instrument clus terl ights up and awarning tone sounds.
The DEF reducing agent is con taminated, diluted or is no tcompliant
wit hISO 222 41 . #
Have theD EFsuppl ytank cleaned an drefilled at aqualified spe‐
cialis tworks hop as soon as possible.
0099 Additive System Fault
Starts until Emerg. Op.:
XXX See Operator's Man-
ual *
In addition, they ellow 00B9CheckEngine warning lam ponthe
instrument clus terl ights up and awarning tone sounds.
The DEF reducing agent is con taminated, diluted or is no tcompliant
wit hISO 222 41 .
The exhaus tgas af tertre atment sy stem is defectiv eoranemissions-
re leva nt malfunction ha soccu rred. This malfunction or defect can
damag ethe exhaus tgas af tertre atment sy stem.
Af tert he messag eappear sfor thef irst time ,the engine can onl ybe
st ar teda nother 10 times. The numbe rofremaining engine starts XX
(1 0to1)iss hown inthem essag eevery time thee ngine is star ted. #
Visit aq ualified specialis tworks hop immediately.
0099 Additive System Fault
EmergencyO p.: XXX
mph See Operator's
Manual *
In addition, they ellow 00B9CheckEngine warning lam ponthe
instrument clus terl ights up and awarning tone sounds.
Yo uc an only driv ethe vehicle at amaximum speed of 5mph
(8 km/h). #
Visit aq ualified specialis tworks hop immediately. Displa
ymessages and warning and indicator lamps 275

Displa
ymessages
Possible causes/consequences and 0050 0050Solutions
x
Vehicle Tracker has
been activated. Details:
see manual or associ-
ated mobile app. or
Vehicle locating activa-
ted –see manual or
mobile app. *T
hevehicle features activated services from Mercedes PRO.
Locatin gthe vehicle ma ybepossible within thef rame workof
Mercedes PR Oconnect. #
Chec kthe status of thea ctivated services at http://
mercedes.pro. #
Ask thev ehicle owner fort he de tails.
g
Step Not Extended See
Operator's Manual or
Step Not Extended Mal-
function *T
he electrical step is not, or is onl ypartially ,extended. #
Ensu rether eiss ufficient clea rance fort he electrical step. #
Open or close thes liding door again. #
Ifth ee lectrical step does no tcomple tely ex tend again, push it in
manually (emergency release) (/ page58). #
Infor mpassen gers that thes tepism issing befor etheye xit the
ve hicle.
g
Step Not Retracted See
Operator's Manualor
Step Not Retracted Mal-
function *T
he electrical step is not, or is onl ypartially ,retra cted. #
Ensu rether eiss ufficient clea rance fort he electrical step. #
Open or close thes liding door again. #
Ifth ee lectrical step does no tcomple tely retract again, push it in
manually (emergency release) (/ page58). Lights
Displa
ymessa ges
Possible causes/consequences and 0050 0050Solutions
Adaptive Highbeam
Assist Camera View
Restricted See Opera-
tor's Manual *
The camer aviewisr educed. Possible causes:
R Dirtont he windshield in thec amera's field of vision
R Heavy precipitation or fog
Driving sy stems and driving saf etys ystems ma ybem alfunctioning
or temp orarily una vailable.
When thec auses ha vebeen eliminated, thed riving sy stems and
driving saf etys ystems ar eavailable again.
If th ed ispla ymessag edoes no tgoout: #
Stop in asafel ocation. #
Clean thew indshield.
Adaptive Highbeam
Assist Currently Unavail-
able See Operator's Man-
ual *A
daptiv eHighbeam Assis tistemporarily una vailable.
The sy stem limits ha vebeen reached (/ page86). #
Continue driving.
When thec auses ha vebeen eliminated, thes ystemw ill be avail‐
able again. The displa ymessage AdaptiveHighbeam Assist Now
Available appears. Displa
ymessages and warning and indicator lamps 281