2020 KIA OPTIMA PHEV Maintenance

Your vehicle is equipped with a cat-
alytic converter emission control
device.
Therefore, the following precautions
must be observed:
Use only UNLEADED FUEL forgasoline engines.
Do not operate the vehicle when there are signs of engine malfunc-
tion, such as misfire or a noticeable
loss of performance.
Do not misuse or abuse the engine. Examples of misuse are
coasting with the ignition off and
descending steep grades in gear
with the ignition off.
Do not operate the engine at high idle speed for extended periods (5
minutes or more).
Do not modify or tamper with any part of the engine or emission con-
trol system. All inspections and
adjustments must be made by an
authorized Kia dealer.
Avoid driving with an extremely low fuel level. Running out of fuel could
cause the engine to misfire, dam-
aging the catalytic converter. Failure to observe these precautions
could result in damage to the catalyt-
ic converter and to your vehicle.
Additionally, such actions could void
your warranties.
Perchlorate Material-special handling
may apply, See www.dtsc.ca.gov/haz-
ardouswaste/ perchlorate.
Notice to California Vehicle Dismantlers:
Perchlorate containing materials,
such as air bag inflators, seatbelt
pretensioners and keyless remote
entry batteries, must be disposed of
according to Title 22 California Code
of Regulations Chapter 67384.10
(a).
CALIFORNIA
PERCHLORATE NOTICE
7 102
Maintenance

815
Specifications, Consumer information, Reporting safety defects
If you believe that your vehicle has a defect which could
cause a crash or could cause injury or death, you should
immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying Kia
Motors America, Inc.
If NHTSA receives similar complaints, it may open an
investigation, and if it finds that a safety defect exists in a
group of vehicles, it may order a recall and remedy cam-
paign. However, NHTSA cannot become involved in indi-
vidual problems between you, your dealer, or Kia Motors
America, Inc.
To contact NHTSA, you may call the Vehicle Safety
Hotline toll-free at 1-888-327-4236 (TTY: 1-800-424-
9153); go to http://www.safercar.gov; download the
SaferCar mobile application; or write to: Administrator,
NHTSA, 1200 New Jersey Ave. SE., Washington, DC
20590. You can also obtain other information about
motor vehicle safety from http://www.safercar.gov.The following publications are available on
www.KiaTechinfo.com
Service manual:
This manual covers maintenance and recommended pro-
cedures for repair to engine and chassis components. It
is written for the Journeyman mechanic, but is simple
enough for most mechanically inclined owners to under-
stand.
Electrical troubleshooting manual:
This manual complements the Service Manual by provid-
ing indepth troubleshooting information for each electrical
circuit in your vehicle.
Owner's manual:
This manual describes the overall features and operating
procedures for the vehicle.
REPORTING SAFETY DEFECTS
(U.S. ONLY)
ONLINE FACTORY AUTHORIZED MANUALS
(U.S. ONLY)

Index
4I
Operating door locks from inside the vehicle ............4-14
Operating door locks from outside the vehicle ..........4-13
Drive mode integrated control system ..........................5-96 Hybrid vehicle ............................................................5-96
Limitation of ECO operation ......................................5-97
When ECO is activated ..............................................5-97
Driver Attention Warning (DAW)................................5-125 Resetting the system ................................................5-127
System disabled ........................................................5-127
System malfunction ..................................................5-128
System setting and activation ..................................5-125
ECO system ..................................................................5-98 Limitation of ECO operation ......................................5-99
Plug-in hybrid vehicle ................................................5-98
When ECO is activated ..............................................5-99
Economical operation ..................................................5-130
Electrical equipment (U.S. only) ..................................8-14 Installation of a mobile two-way radio system ..........8-14
Emergency starting ..........................................................6-5 Jump starting ................................................................6-5
Push-starting ................................................................6-6 Emission control system ................................................7-99
Crankcase emission control system ............................7-99
Evaporative emission control (including ORVR : Onboard Refueling Vapor Recovery) system ..........7-99
Exhaust emission control system ..............................7-100
Engine ........................................................................\
......8-2
Engine compartment ................................................2-6, 7-3
Engine maintenance mode (for plug-in Hybrid) ..........7-20 Starting Engine Maintenance Mode ..........................7-20
Stopping Engine Maintenance Mode..........................7-20
Engine number ................................................................8-9
Engine oil ......................................................................7-\
18 Changing the engine oil and filter ..............................7-19
Checking the engine oil level ....................................7-18
Engine start/stop button ..................................................5-7 Engine start/stop button position ..................................5-7
Illuminated engine start/stop button ............................5-7
Starting the hybrid system ............................................5-9
Explanation of scheduled maintenance items ..............7-14
Exterior overview ............................................................2-2
Forward Collision-avoidance Assist (FCA) system ......5-43 Brake operation ..........................................................5-47
FCA sensor (Front view camera)................................5-48
FCA warning message and system control ................5-45
Limitation of the system ............................................5-51
E
F

I7
Index
Front turn signal lamp (Bulb type) bulb replacement (Headlamp Type A) ..................................................7-80
Front turn signal lamp (Bulb type) bulb replacement (Headlamp Type B) ..................................................7-80
Glove box lamp (Bulb type) bulb replacement ..........7-88
Headlamp (High beam) bulb replacement (Headlamp Type A) ..................................................7-78
Headlamp (Low beam) bulb replacement (Headlamp Type A) ..................................................7-77
Headlamp (Low/High beam) (LED type) bulb replacement (Headlamp Type B) ..............................7-79
High mounted stop lamp (LED type) bulb replacement ..............................................................7-86
License plate lamp (Bulb type) bulb replacement ......7-85
Light bulb position (Front) ........................................7-75
Light bulb position (Rear) ..........................................7-76
Light bulb position (Side) ..........................................7-76
Map lamp (LED type) bulb replacement ..................7-86
Personal lamp (LED type) bulb replacement ............7-88
Position lamp + DRL (LED type) bulb replacement..7-81
Rear turn signal lamp bulb replacement ....................7-82
Room lamp (Bulb type) bulb replacement ................7-87
Side repeater lamp (LED type) bulb replacement ......7-82
Stop lamp (LED type) bulb replacement (Sedan) ......7-84
Tail lamp (LED type) bulb replacement (Sedan)........7-84
Trunk lamp (LED type) bulb replacement..................7-89
Vanity mirror lamp (Bulb type) bulb replacement ....7-87 Lighting........................................................................\
4-103
Battery saver function ..............................................4-103
Check headlight ......................................................4-110
Daytime running light ..............................................4-103
Dynamic Bending Light ..........................................4-111
Front fog light ..........................................................4-110
Headlight leveling device..........................................4-110
High Beam Assist ....................................................4-106
High beam operation ................................................4-105
Lighting control ........................................................4-103
Turn signals and lane change signals........................4-109
Luggage volume ..............................................................8-5
Maintenance services ......................................................7-4 Owner maintenance precautions ..................................7-5
Owner’s responsibility ..................................................7-4
Mirrors ........................................................................\
..4-48 Inside rearview mirror ................................................4-48
Outside rearview mirror ..............................................4-50
Online factory authorized manuals (U.S. only) ............8-15 Electrical troubleshooting manual ..............................8-15
Owner's manual ..........................................................8-15
Service manual ............................................................8-15
M
O

Index
8I
Owner maintenance ........................................................7-6Owner maintenance schedule ......................................7-6
Panoramic sunroof ........................................................4-38 Closing the sunroof ....................................................4-43
Resetting the sunroof ..................................................4-43
Sliding the sunroof ......................................................4-41
Sunroof open warning ................................................4-39
Sunshade ....................................................................4-40\
Tilting the sunroof ......................................................4-42
Parking brake ................................................................7-27 Checking the parking brake ........................................7-27
Parking distance warning - reverse ................................4-99 Non-operational conditions of the parking distance warning-reverse system ..........................................4-100
Operation of the parking distance warning-reverse ....4-99
Parking distance warning-reverse system precautions ..............................................................4-101
Self-diagnosis............................................................4-101
Rearview monitor ........................................................4-102
Recommended lubricants and capacities ........................8-6 Recommended SAE viscosity number ........................8-7
Refrigerant label ............................................................8-10 Reporting safety defects (U.S. only) ............................8-15
Road warning ..................................................................6-2
Hazard warning flasher ................................................6-2
Scheduled maintenance service ......................................7-8
Seat ........................................................................\
..........3-4 Driver position memory system (for power seat) ......3-11
Front seat adjustment - manual ....................................3-7
Front seat adjustment - power ......................................3-8
Headrest (for front seat) ..............................................3-12
Rear seat adjustment ..................................................3-15
Seatback pocket ..........................................................3-15
Seat belts ........................................................................\
3-21 Care of seat belts ........................................................3-32
Pre-tensioner seat belt ................................................3-28
Seat belt precautions ..................................................3-30
Seat belt restraint system ............................................3-21
Smart cruise control with Stop & Go system ................5-76 Limitations of the system............................................5-9\
0
Smart Cruise Control speed ........................................5-78
Smart Cruise Control switch ......................................5-78
To adjust the sensitivity of smart cruise control ........5-89
To convert to cruise control mode ..............................5-89
Vehicle to vehicle distance setting ..............................5-83
When the lane ahead is clear ......................................5-84
When there is a vehicle ahead of you in your lane ....5-85
R
S
P

I9
Index
Smart key ........................................................................\
4-4Battery replacement ......................................................4-8
Loss of the smart key ....................................................4-7
Record your key number ..............................................4-4
Smart key function ........................................................4-4
Smart key immobilizer system ....................................4-8
Smart key precautions ..................................................4-7
Smart trunk ....................................................................4-18\
Detecting area ............................................................4-22
Emergency trunk safety release ..................................4-22
How to deactivate the Smart Trunk function using the smart key ..................................................................4-21
How to use the Smart Trunk ......................................4-18
Special driving conditions ..........................................5-132 Driving at night ........................................................5-133
Driving in flooded areas ..........................................5-135
Driving in the rain ....................................................5-134
Hazardous driving conditions ..................................5-132
Highway driving ......................................................5-135
Rocking the vehicle ..................................................5-132
Smooth cornering ......................................................5-133
Steering wheel ..............................................................4-44 Electric Power Steering (EPS) ....................................4-44
Heated steering wheel ................................................4-46
Horn ........................................................................\
....4-47
Tilt and telescopic steering ........................................4-45 Storage compartments ................................................4-138
Center console storage ..............................................4-138
Glove box ..................................................................4-139
Sunglass holder ........................................................4-139
Theft-alarm system ........................................................4-10 Armed stage ................................................................4-10
Disarmed stage ............................................................4-11
Theft-alarm stage ........................................................4-11
Tire Pressure Monitoring System (TPMS) ......................6-9 Changing a tire with TPMS ........................................6-13
Check tire pressure.....................................................\
...6-9
Low tire pressure position telltale ..............................6-11
Tire specification and pressure label ..............................8-9
Tires and wheels ....................................................7-39, 8-4 All season tires ..........................................................7-51
Checking tire inflation pressure ..................................7-40
Radial-ply tires ............................................................7-52
Recommended cold tire inflation pressures................7-39
Snow tires....................................................................7-51\
Summer tires ..............................................................7-51
Tire care ......................................................................7-\
39
Tire chains ..................................................................7-52
Tire maintenance ........................................................7-44
Tire pressure................................................................7-40
Tire replacement ........................................................7-43
T