2020 FORD POLICE INTERCEPTOR climate control

We recommend that you disconnect the
negative battery cable terminal from the
battery if you plan to store your vehicle for
an extended period.
Note:
If you only disconnect the negative
battery cable terminal, make sure it is
isolated or placed away from the battery
terminal to avoid unintended connection or
arcing.
If you replace the battery make sure it
matches the electrical requirements of
your vehicle.
If you disconnect or replace the battery
and your vehicle has an automatic
transmission, it must relearn its adaptive
strategy. Because of this, the transmission
may shift firmly when first driven. This is
normal operation while the transmission
fully updates its operation to optimum
shift feel.
Battery Management System (If
Equipped)
The battery management system monitors
battery conditions and takes actions to
extend battery life. If excessive battery
drain is detected, the system temporarily
disables some electrical systems to
protect the battery.
Systems included are:
• Heated rear window.
• Heated seats.
• Climate control.
• Heated steering wheel.
• Audio unit.
• Navigation system.
A message may appear in the information
displays to alert you that battery
protection actions are active. These
messages are only for notification that an
action is taking place, and not intended to
indicate an electrical problem or that the
battery requires replacement. After battery replacement, or in some
cases after charging the battery with an
external charger, the battery management
system requires eight hours of vehicle sleep
time to relearn the battery state of charge.
During this time your vehicle must remain
fully locked with the ignition switched off.
Note:
Prior to relearning the battery state
of charge, the battery management system
may temporarily disable some electrical
systems.
Electrical Accessory Installation
To make sure the battery management
system works correctly, do not connect an
electrical device ground connection
directly to the battery negative post. This
can cause inaccurate measurements of
the battery condition and potential
incorrect system operation.
Note: If you add electrical accessories or
components to the vehicle, it may adversely
affect battery performance and durability.
This may also affect the performance of
other electrical systems in the vehicle.
Remove and Reinstall the Battery
To disconnect or remove the battery, do
the following:
1. Apply the parking brake and switch the
ignition off.
2. Switch all electrical equipment off, for
example lights and radio.
3. Wait a minimum of two minutes before
disconnecting the battery.
Note: The engine management system has
a power hold function and remains powered
for a period of time after you switch the
ignition off. This is to allow diagnostic and
adaptive tables to be stored. Disconnecting
the battery without waiting can cause
damage not covered by the vehicle
Warranty.
232
Explorer (CTW) Police, Canada/United States of America, Police, enUSA, Edition date: 201902, Second-Printing Maintenance

Do not clean the wheels when they are hot.
Note:
Some car washes could damage
wheel rims and covers.
Note: Using non-recommended cleaners,
harsh cleaning products, chrome wheel
cleaners or abrasive materials could
damage wheel rims and covers.
VEHICLE STORAGE
If you plan on storing your vehicle for 30
days or more, read the following
maintenance recommendations to make
sure your vehicle stays in good operating
condition.
We engineer and test all motor vehicles
and their components for reliable, regular
driving. Under various conditions,
long-term storage may lead to degraded
engine performance or failure unless you
use specific precautions to preserve engine
components.
General
• Store all vehicles in a dry, ventilated
place.
• Protect from sunlight, if possible.
• If vehicles are stored outside, they
require regular maintenance to protect
against rust and damage.
Body
• Wash your vehicle thoroughly to
remove dirt, grease, oil, tar or mud from
exterior surfaces, rear-wheel housing
and the underside of front fenders.
• Periodically wash your vehicle if it is
stored in exposed locations.
• Touch-up exposed or primed metal to
prevent rust. •
Cover chrome and stainless steel parts
with a thick coat of auto wax to prevent
discoloration. Re-wax as necessary
when you wash your vehicle.
• Lubricate all hood, door and luggage
compartment hinges and latches with
a light grade oil.
• Cover interior trim to prevent fading.
• Keep all rubber parts free from oil and
solvents.
Engine
• Change the engine oil and filter prior to
storage because used engine oil
contains contaminates which may
cause engine damage.
• Start the engine every 15 days for a
minimum of 15 minutes. Run at fast
idle with the climate controls set to
defrost until the engine reaches normal
operating temperature.
• With your foot on the brake, shift
through all the gears while the engine
is running.
• We recommend that you change the
engine oil before you use your vehicle
again.
Fuel system
• Fill the fuel tank with high-quality fuel
until the first automatic shutoff of the
fuel pump nozzle.
Cooling system
• Protect against freezing temperatures.
• When removing your vehicle from
storage, check coolant fluid level.
Confirm that there are no cooling
system leaks and that fluid is at the
recommended level.
245
Explorer (CTW) Police, Canada/United States of America, Police, enUSA, Edition date: 201902, Second-Printing Vehicle Care

U.S. Department of
Transportation Tire quality
grades: The U.S. Department of
Transportation requires Ford
Motor Company to give you the
following information about tire
grades exactly as the government
has written it.
Treadwear
The treadwear grade is a
comparative rating based on the
wear rate of the tire when tested
under controlled conditions on a
specified government test course.
For example, a tire graded 150
would wear 1½ times as well on
the government course as a tire
graded 100. The relative
performance of tires depends
upon the actual conditions of their
use, however, and may depart
significantly from the norm due to
variations in driving habits, service
practices, and differences in road
characteristics and climate.
Traction AA A B C WARNING:
The traction
grade assigned to this tire is
based on straight-ahead braking
traction tests, and does not
include acceleration, cornering,
hydroplaning or peak traction
characteristics. The traction grades, from highest
to lowest are AA, A, B, and C. The
grades represent the tire
’s ability
to stop on wet pavement as
measured under controlled
conditions on specified
government test surfaces of
asphalt and concrete. A tire
marked C could have poor traction
performance.
Temperature A B C WARNING:
The
temperature grade for this tire is
established for a tire that is
properly inflated and not
overloaded. Excessive speed,
underinflation, or excessive
loading, either separately or in
combination, can cause heat
buildup and possible tire failure.
The temperature grades are A
(the highest), B and C,
representing the tire ’s resistance
to the generation of heat and its
ability to dissipate heat when
tested under controlled conditions
on a specified indoor laboratory
test wheel. Sustained high
temperature can cause the
material of the tire to degenerate
and reduce tire life, and excessive
temperature can lead to sudden
tire failure. The grade C
corresponds to a level of
performance which all passenger
car tires must meet under the
249
Explorer (CTW) Police, Canada/United States of America, Police, enUSA, Edition date: 201902, Second-Printing Wheels and Tires

A
A/C
See: Climate Control......................................... 102
About Cruise Control..................................166
About Drive Mode Control.........................179
About the Cabin Air Filter..........................107
About This Manual...........................................7
ABS See: Brakes............................................................ 152
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes................................................................. 153
Accessories See: Replacement Parts
Recommendation............................................ 13
Adjusting the Headlamps.........................234 Vertical Aim Adjustment................................. 234
Adjusting the Steering Wheel...................66
Airbag Disposal...............................................54
Air Conditioning See: Climate Control......................................... 102
Air Filter See: Changing the Engine Air Filter -
3.0L..................................................................... 237
See: Changing the Engine Air Filter - 3.3L..................................................................... 238
Alarm See: Anti-Theft Alarm........................................ 64
All-Wheel Drive
.............................................145
Anti-Theft Alarm............................................64
Alarm System........................................................ 64
Arming the Alarm................................................. 64
Disarming the Alarm........................................... 64
Object Detection.................................................. 65
Police Perimeter Alert Settings....................... 65
Police Perimeter Alert System........................ 64
Switching the Police Perimeter Alert On and Off................................................................ 64
System Configuration......................................... 65
System Error........................................................... 65
Triggering the Alarm........................................... 64
Appendices.....................................................351
At a Glance........................................................18
Audible Warnings and Indicators.............83 Automatic Transmission Warning
Chime.................................................................. 84
Headlamps On Warning Chime...................... 83Key in Ignition Warning Chime........................
83
Parking Brake On Warning Chime.................84
Audio Control
..................................................66
Auxiliary Steering Wheel Controls.................67
You can operate the following functions
with the control:.............................................. 66
Audio System
................................................307
General Information......................................... 307
Audio Unit
.......................................................307
Accessing the Sound Settings...................... 307
Accessing the System Settings................... 308
Adjusting the Volume...................................... 308
Changing Radio Stations............................... 308
Pausing or Playing Media............................... 308
Returning to the Previous Screen...............308
Scrolling Through the Menu Options........308
Selecting a Menu Option............................... 309
Selecting Media................................................. 308
Selecting the Radio.......................................... 309
Switching the Audio Unit On and Off........309
Switching the Display On and Off..............309
Using a Cell Phone........................................... 309
Using Seek, Fast Forward and Reverse............................................................. 309
Autolamps..........................................................71 Windshield Wiper Activated
Headlamps.......................................................... 71
Automatic Climate Control......................102 Directing the Airflow.......................................... 102
Setting the Blower Motor Speed.................. 102
Setting the Temperature................................. 102
Switching Auto Mode On and Off................102
Switching Maximum Air Conditioning On and Off.............................................................. 104
Switching Maximum Defrost On and Off....................................................................... 104
Switching Recirculated Air On and Off....................................................................... 104
Switching the Air Conditioning On and Off....................................................................... 103
Switching the Climate Control On and Off....................................................................... 103
Automatic Transmission............................143 If Your Vehicle Gets Stuck in Mud or
Snow................................................................... 143
Understanding the Positions of Your Automatic Transmission............................. 143
381
Explorer (CTW) Police, Canada/United States of America, Police, enUSA, Edition date: 201902, Second-Printing Index

License Plate Lamp..........................................
236
Rear Direction Indicator and Reversing Lamp.................................................................. 235
Changing a Fuse............................................217 Fuses........................................................................\
217
Changing a Road Wheel...........................269 Dissimilar Spare Wheel and Tire Assembly
Information...................................................... 270
Tire Change Procedure...................................... 271
Changing the 12V Battery
..........................231
Battery Management System....................... 232
Remove and Reinstall the Battery...............232
Changing the Cabin Air Filter....................107
Changing the Engine Air Filter - 3.0L.................................................................237
Changing the Engine Air Filter - 3.3L.................................................................238
Changing the Front Wiper Blades.........233
Changing the Rear Wiper Blades...........234
Checking the Wiper Blades
......................233
Child Restraint and Seatbelt Maintenance.................................................38
Child Restraint Positioning
.........................30
Child Safety......................................................20 General Information............................................ 20
Child Safety Locks..........................................32 Left-Hand Side...................................................... 32
Right-Hand Side................................................... 32
Cleaning Products
.......................................240
Materials............................................................... 240
Cleaning the Engine....................................242
Cleaning the Exterior
..................................240
Cleaning the Headlamps................................. 241
Exterior Chrome Parts....................................... 241
Exterior Plastic Parts......................................... 241
Stripes or Graphics............................................. 241
Underbody............................................................. 241
Under Hood........................................................... 241
Cleaning the Instrument Panel and Instrument Cluster Lens.........................243
Cleaning the Interior...................................243 Mirrors.................................................................... 243
Cleaning the Wheels
..................................244
Cleaning the Windows and Wiper Blades...........................................................242
Climate Control
.............................................102
Cold Weather Precautions........................192 Collision, Damage or Fire Event..............198
Guidance for Ford Motor Company Electric
and Hybrid-Electric Vehicles Equipped
With High Voltage Batteries...................... 198
Coolant Check See: Engine Coolant Check............................ 225
Crash Sensors and Airbag Indicator.......48 Airbags and Police Equipment....................... 49
Cross Traffic Alert..........................................172 Cross Traffic Alert Behavior When Trailer
is Attached........................................................ 174
Cross Traffic Alert Indicator............................. 174
Cross Traffic Alert Information Messages........................................................... 174
Cross Traffic Alert System Limitations........................................................ 173
Cross Traffic Alert System Sensors..............173
Switching the System On and Off................174
Using Cross Traffic Alert................................... 172
Cruise Control..................................................67
Cruise Control Indicators
............................167
Customer Assistance.................................202
D
Data Recording
..................................................9
911 Assist Privacy Notice..................................... 13
Comfort, Convenience and Entertainment Data........................................................................\
11
Event Data................................................................. 11
Service Data............................................................ 10
Services That Third Parties Provide...............12
Services That We Provide.................................. 12
Vehicles With a Modem...................................... 12
Vehicles With SYNC............................................. 12
Daytime Running Lamps - Vehicles With: Configurable Daytime Running
Lamps..............................................................72
Daytime Running Lamps - Vehicles With: Daytime Running Lamps (DRL).............72
Declaration of Conformity........................379
Declaration of Conformity - Vehicles With: SYNC 3
..............................................379
Radio Frequency Statement......................... 379
Decommissioning Requirements
..........350
Dark Car................................................................ 350
OBD-II Split Connector................................... 350
Police Engine Idle.............................................. 350
383
Explorer (CTW) Police, Canada/United States of America, Police, enUSA, Edition date: 201902, Second-Printing Index

Police Perimeter Alert......................................
350
Pre-Collision Assist Disable.......................... 350
Rear Camera On Demand.............................. 350
Vehicle Sealing of Aftermarket Equipment...................................................... 350
Decommissioning the Vehicle................350
Direction Indicators........................................73
Doors and Locks.............................................59
Drive Mode Control......................................179 Drive Modes.......................................................... 179
Drive Modes....................................................179 Deep Snow/Sand............................................... 179
Normal................................................................... 180
Driver and Passenger Airbags....................42 Children and Airbags........................................... 43
Proper Driver and Front Passenger Seating Adjustment........................................................ 42
Driver and Passenger Knee Airbags........46
Driving Aids.....................................................168
Driving Hints
....................................................191
Driving Through Water................................192
DRL See: Daytime Running Lamps - Vehicles With:
Configurable Daytime Running Lamps....72
See: Daytime Running Lamps - Vehicles With: Daytime Running Lamps (DRL).................72
E
Economical Driving
.......................................191
Electric Parking Brake.................................153 Applying the Electric Parking Brake.............153
Automatically Releasing the Electric
Parking Brake.................................................. 154
Manually Releasing the Electric Parking Brake................................................................... 154
Releasing the Electric Parking Brake if the Vehicle Battery is Running Out of
Charge................................................................ 155
Electromagnetic Compatibility
...............351
Emission Law.................................................138
Noise Emissions Warranty, Prohibited
Tampering Acts and Maintenance..........139
Tampering With a Noise Control System............................................................... 138
End User License Agreement..................353 VEHICLE SOFTWARE END USER LICENSE
AGREEMENT (EULA) ................................. 353Engine Block Heater
....................................120
Using the Engine Block Heater....................... 121
Engine Coolant Check................................225 Adding Coolant................................................... 225
Coolant Change.................................................. 227
Engine Coolant Temperature Management.................................................. 228
Fail-Safe Cooling................................................ 227
Recycled Coolant............................................... 226
Severe Climates.................................................. 227
Engine Emission Control............................138
Engine Oil Check..........................................223 Adding Engine Oil............................................... 223
Engine Oil Dipstick - 3.0L..........................223
Engine Oil Dipstick - 3.3L..........................223
Engine Specifications - 3.0L.....................277 Drivebelt Routing................................................ 277
Engine Specifications - 3.3L, Hybrid Electric Vehicle (HEV).............................278
Drivebelt Routing............................................... 278
Engine Specifications - 3.3L.....................277 Drivebelt Routing............................................... 278
Environment......................................................17
EPB See: Electric Parking Brake.............................. 153
Essential Towing Checks
...........................188
Before Towing a Trailer..................................... 189
Hitches................................................................... 188
Launching or Retrieving a Boat or Personal Watercraft (PWC)......................................... 189
Safety Chains....................................................... 188
Trailer Brakes....................................................... 188
Trailer Lamps....................................................... 188
When Towing a Trailer...................................... 189
Event Data Recording See: Data Recording.............................................. 9
Export Unique Options
.................................16
Exterior Mirrors................................................76
Blind Spot Information System....................... 77
Fold-Away Exterior Mirrors................................ 77
Heated Exterior Mirrors ...................................... 77
Integrated Blind Spot Mirror............................. 77
Power Exterior Mirrors......................................... 76
F
Fastening the Seatbelts..............................34 Seatbelt Locking Modes.................................... 35
384
Explorer (CTW) Police, Canada/United States of America, Police, enUSA, Edition date: 201902, Second-Printing Index

Using Seatbelts During Pregnancy................34
Flat Tire See: Changing a Road Wheel....................... 269
Floor Mats.......................................................193
Fog Lamps - Front See: Front Fog Lamps......................................... 72
Ford Credit
.........................................................13
US Only..................................................................... 13
Ford Protect
...................................................328
Ford Protect Extended Service Plan
(CANADA ONLY).......................................... 329
Ford Protect Extended Service Plans (U.S. Only).................................................................. 328
Front Fog Lamps.............................................72 Front Fog Lamp Indicator.................................. 73
Switching the Front Fog Lamps On or Off........................................................................\
.. 72
Front Passenger Sensing System............43
Front Wiper Blades See: Changing the Front Wiper Blades.......233
Fuel and Refueling
.......................................126
Fuel Consumption........................................136
Advertised Capacity.......................................... 136
Calculating Fuel Economy.............................. 136
Filling the Fuel Tank........................................... 136
Fuel Filler Funnel Location........................129
Fuel Filter.........................................................231
Fuel Quality - E85
........................................126
Choosing the Right Fuel - Flex Fuel
Vehicles............................................................. 126
Switching Between E85 and Gasoline............................................................. 127
Fuel Quality - Gasoline
...............................128
Choosing the Right Fuel................................... 128
Fuel Quality - Hybrid Electric Vehicle (HEV).............................................................128
Choosing the Right Fuel................................... 128
Fuel Shutoff
....................................................195
Fuses................................................................209
Fuse Specification Chart
..........................209
Engine Compartment Fuse Box.................. 209
Passenger Compartment Fuse Panel.........214
G
Gauges................................................................79 Engine Coolant Temperature Gauge............80
Fuel Gauge.............................................................. 79Information Display.............................................
79
Speedometer......................................................... 79
Gearbox See: Transmission.............................................. 143
General Information on Radio Frequencies...................................................56
General Maintenance Information.......330 Multi-Point Inspection..................................... 332
Owner Checks and Services........................... 331
Protecting Your Investment........................... 330
Why Maintain Your Vehicle?......................... 330
Why Maintain Your Vehicle at Your Dealership?..................................................... 330
Getting Assistance Outside the U.S. and Canada.........................................................205
Getting the Services You Need...............202 Away From Home.............................................. 202
Global Opening
...............................................76
Remote Control Front Windows..................... 76
H
Hazard Flashers............................................195
Headlamp Adjusting See: Adjusting the Headlamps..................... 234
Headrest See: Head Restraints........................................ 108
Head Restraints............................................108 Adjusting the Head Restraints...................... 109
Second Row Center Seat Head Restraint ........................................................................\
...... 109
Second Row Outermost Seat Head Restraints.......................................................... 110
Tilting Head Restraints ..................................... 110
Heated Exterior Mirrors..............................106
Heated Rear Window.................................106
Heating See: Climate Control......................................... 102
High Voltage Battery
...................................142
General Information.......................................... 142
Hill Start Assist..............................................155 Switching the System On and Off...............155
Using Hill Start Assist........................................ 155
Hints on Controlling the Interior Climate..........................................................104
Defogging the Side Windows in Cold Weather............................................................ 105
General Hints....................................................... 104
385
Explorer (CTW) Police, Canada/United States of America, Police, enUSA, Edition date: 201902, Second-Printing Index

Using the Pre-Collision Assist
System............................................................... 176
Protecting the Environment........................17
Puncture See: Changing a Road Wheel....................... 269
R
Rear Parking Aid...........................................160 Object Distance Indicator................................ 162
Rear Passenger Climate Controls..........105 Directing Air to the Overhead Air
Vents.................................................................. 105
Directing Air to the Rear Footwell Air Vents.................................................................. 105
Rear Climate Control Lock Indicator...........105
Setting the Rear Blower Motor Speed................................................................ 106
Setting the Rear Temperature....................... 106
Switching the Rear Climate Control On and Off....................................................................... 106
Switching the Rear Heated Seats On and Off....................................................................... 106
Rear Seats........................................................113
Adjusting the Seat Backrest............................ 113
Folding the Seat Backrest Flat....................... 113
Rear View Camera........................................162 Camera Guidelines............................................ 163
Manual Zoom....................................................... 165
Obstacle Distance Indicator........................... 164
Rear Camera Delay............................................ 165
Rear Camera On Demand............................... 165
Using the Rear View Camera System.........163
Rear View Camera See: Rear View Camera.................................... 162
Rear Window Wiper and Washers..........68 Rear Camera Washer......................................... 69
Rear Window Washer......................................... 69
Rear Window Wiper Blade............................... 69
Rear Wiper Blades See: Changing the Rear Wiper Blades.......234
Recommended Towing Weights
.............187
Reduced Engine Performance..................191
Refueling - Excluding: Hybrid Electric Vehicle (HEV)...............................................131
Refueling System Overview............................. 131
Refueling System Warning.............................. 133
Refueling Your Vehicle....................................... 131Refueling - Hybrid Electric Vehicle
(HEV).............................................................133
Fuel Filler Door Manual Override Lever................................................................... 135
System Warnings................................................ 135
Remote Control
..............................................56
Changing the Remote Control Battery.........57
Opening the Liftgate With the Liftgate
Button ................................................................. 58
Sounding the Panic Alarm................................ 58
Repairing Minor Paint Damage..............244
Replacement Parts Recommendation........................................13
Collision Repairs.................................................... 14
Scheduled Maintenance and Mechanical Repairs.................................................................. 14
Warranty on Replacement Parts..................... 14
Replacing a Lost Key or Remote Control............................................................58
Reporting Safety Defects (Canada Only)..............................................................207
Reporting Safety Defects (U.S. Only)..............................................................207
Resuming the Set Speed...........................167
Roadside Assistance
...................................194
Vehicles Sold in Canada: Getting Roadside
Assistance........................................................ 195
Vehicles Sold in the United States: Getting Roadside Assistance.................................... 194
Vehicles Sold in the United States: Using Roadside Assistance.................................... 194
Roadside Emergencies
...............................194
Running-In See: Breaking-In................................................... 191
Running Out of Fuel.....................................129 Adding Fuel From a Portable Fuel
Container.......................................................... 130
Filling a Portable Fuel Container.................. 129
S
Safety Canopy ™
............................................46
Safety Precautions.......................................126
Scheduled Maintenance Record...........339
Scheduled Maintenance
..........................330
Seatbelt Extensions......................................39
Seatbelt Height Adjustment......................36
388
Explorer (CTW) Police, Canada/United States of America, Police, enUSA, Edition date: 201902, Second-Printing Index