2020 FORD FUSION/HYBRID battery

is no factory-related defect involved and therefore no warranty our
policy is to provide free repair of paint damage due to the airborne
material for 12 months or 12,000 miles, whichever occurs first.
(4) The electrical drivetrain system of your vehicle is covered by the
Hybrid & Electric Vehicle Unique Component coverage for eight years or
100,000 miles, whichever comes first. The components in the electrical
drivetrain system of your vehicle will vary, depending on whether your
vehicle is a hybrid, plug-in hybrid, or all-electric vehicle, but you can rest
assured knowing that your vehicle’s electrical drivetrain system is
covered by this comprehensive warranty.
Depending on your vehicle, electrical drivetrain system components
covered by this warranty may include, and are not limited to:
high-voltage battery, high-voltage battery connector, high-voltage battery
isolation switch (manual disconnect switch), battery pack fan assembly,
battery pack sensor module (HBPSM), battery energy control module
(BECM), on-board charger, on-board charger fan assembly, inverter
system controller (ISC), DC/DC converter, hybrid continuously variable
transmission or electric driveline motor and transmission range sensor.
If an electrical drivetrain system component requires replacement under
warranty, it may be replaced with a new, factory remanufactured, or
factory refurbished component, at Ford’s discretion. Refurbished battery
components selected for your vehicle will align with your vehicle’s age
and mileage, and meet Ford’s stringent requirements and standards. (see
Note: High-Voltage Battery Gradual Capacity Lossbelow).
Note: High Voltage Battery Gradual Capacity Loss
The high voltage battery will experience gradual capacity loss with time
and use, similar to all batteries, which is considered normal wear and
tear. Loss of battery capacity due to or resulting from gradual capacity
loss is NOT covered under the New Vehicle Limited Warranty. See your
Owner’s Manual for important tips on how to maximize the life and
capacity of the high voltage battery.
12

Other Items or Conditions Not Covered
The New Vehicle Limited Warranty does not cover:
•high-voltage battery replacement due to improper vehicle storage.
Refer to the Owner’s Manual for the proper ways your vehicle’s battery
must be maintained in the event the vehicle is not driven or is stored
for an extended period of time
• The Lithium-ion battery (EV battery) will experience gradual capacity
loss with time and use (similar to all lithium-ion batteries), which is
considered normal wear and tear. Loss of battery capacity due to or
resulting from gradual capacity loss is NOT covered under the New
Vehicle Limited Warranty. See your Owner’s Manual for important tips
on how to maximize the life and capacity of the Lithium-ion battery.
• vehicles that have had the odometer disconnected, altered, or
inoperative for an extended period of time with the result that the
actual mileage cannot be determined
• vehicles that have ever been labeled or branded as dismantled,fire,
flood, junk,rebuilt, reconstructed,orsalvaged; this will void
the New Vehicle Limited Warranty
• vehicles that have been determined to be a total lossby an insurance
company; this will void the New Vehicle Limited Warranty
• Aftermarket parts or components, sometimes installed by Ford Motor
Company or an authorized Ford dealership, may not be covered by the
New Vehicle Limited Warranty. Any damage caused due to the failure
of aftermarket parts (other than a certified emission part) is not
covered.
16

4. In addition ...
ROADSIDE SERVICE ASSISTANCE
Your vehicle is covered by the complimentary Ford Roadside Assistance
Program (unless you are driving a daily rental unit). Under this program,
Ford will cover:
•Towing to the nearest Ford Motor Company dealership, or towing to
your selling dealership if within 35 miles of the disablement
• Flat tire change (vehicle must have useable spare)
• Fuel delivery (limited to two occurrences in a 12-month period up to
2 gal. gasoline)
• 12V Battery jump starts
• Lock-out assistance (replacement key cost is customer responsibility)
• Winch out services: includes pulling a vehicle within 100 feet of a
paved or county maintained road. No recoveries.
The Roadside Assistance Program is separate from the New Vehicle
Limited Warranty. It begins at the warranty start date and lasts for five
years or 60,000 miles (whichever occurs first). If you need towing
beyond the five years or 60,000 miles (whichever occurs first) period,
Ford can arrange roadside assistance and charge your credit card. If the
reason for the vehicle disablement is later found to be covered by
another Ford warranty, Ford will provide a refund for the tow charge
under the other warranty, through the dealership.
For emergency roadside assistance, call 1-800-241-3673 (FORD),
24 hours a day, 365 days a year.
Ford rental cars (FRCS) and Dealer Daily Rental (DDR) vehicles that
must be towed because a covered repair has failed during the warranty
coverage period, Ford will cover towing to the nearest Ford Motor
Company dealership.
Ford Motor Company reserves the right to modify or discontinue
Roadside Assistance at any time. Certain restrictions apply to Roadside
Assistance benefits. Call 1-800-241-3673 for further details.
17

EMISSIONS DEFECTS WARRANTY COVERAGE
During the warranty coverage period, Ford Motor Company warrants that:
•your vehicle or engine is designed, built, and equipped to meet - at
the time it is sold - the emissions regulations of the U.S.
Environmental Protection Agency (EPA).
• your vehicle or engine is free from emissions-related defects in
factory-supplied materials or workmanship, which are defects that
could prevent the vehicle or engine from conforming with applicable
EPA regulations.
•
you will not be charged for diagnosis, repair, replacement, or adjustment
of parts containing an emissions-related defect. A list of emission-related
parts can be found in What is Covered?
on pages 20-22.
The emissions defects warranty coverage period for passenger cars and
light duty trucks (applies to vehicles up to 8,500 pounds GVWR is as
follows:
• 8 years or 80,000 miles (whichever occurs first) for catalytic
converters, electronic emissions control unit, and onboard emissions
diagnostic devices, including the Battery Energy Control Module
(BECM).
• 2 years or 24,000 miles (whichever occurs first) for all other covered
parts. (NOTE: Ford’s 3-year, 36,000-mile bumper-to-bumper coverage,
as described above, surpasses this mandatory federal coverage.)
EMISSIONS PERFORMANCE WARRANTY COVERAGE
Under Emissions Performance Warranty Coverage, Ford Motor Company
will repair, replace, or adjust - with no charge for labor, diagnosis, or
parts - any emissions control device or system, if you meet all of the
following conditions:
• You have maintained and operated your vehicle according to the
instructions on proper care in the Owner’s Manual, and this booklet.
• Your vehicle fails to conform, during the warranty coverage period, to
the applicable national EPA standards as determined by an EPA
approved inspection and maintenance program.
19

•You are subject to a penalty or sanction under local, state, or federal
law because your vehicle has failed to conform to the emissions
standards. (A penalty or sanction can include being denied the right
to use your vehicle.)
• Your vehicle has not been tampered with, misused, or abused.
The warranty coverage period for:
Passenger cars and light duty trucks (applies to vehicles up to
8,500 pounds GVWR) as follows: -
8 years or 80,000 miles (whichever occurs first) for catalytic converters,electronic emissions control unit, and onboard emissions diagnostic
devices, including the Battery Energy Control Module (BECM).
- 2 years or 24,000 miles (whichever occurs first) for all other covered parts.
See WHAT IS COVERED below for list of covered parts.
Note that the warranty period begins on the Warranty Start Dateas
specified on page 2 of this booklet.
WHAT IS COVERED?
For your vehicle, if these parts contain an emissions-related defect, they
are covered by both the Emissions Defects Warranty and the Emissions
Performance Warranty.
• Air Flow Sensor
• Air/Fuel Feedback Control System and Sensors
• Air Induction System
• Battery Energy Control Module (BECM)
•
Brake Hydraulic/Electric Control Assembly (Plug-in Hybrid vehicles only)
• Brake Vacuum Pump (Plug-in Hybrid vehicles only)
• Catalytic Converter
• Electronic Engine Control Sensors and Switches
• Evaporative Emission Control System
• Exhaust Gas Recirculation (EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to Catalyst)
20

•Fuel Filler Door Sensor
• Fuel Filler Tube and Seal
• Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank
• High Voltage Battery
• HVAC Controller (Plug-in Hybrid vehicles only)
• Ignition Coil and/or Control Module
• Intake Manifold
• Inverter System Controller (Plug-in Hybrid vehicles only)
• Malfunction Indicator Lamp (MIL)/On-Board Diagnostic (OBD) System
• Motor Electronics Coolant Pump (Plug-in Hybrid vehicles only)
• PCV System and Oil Filler Cap
• PHEV Onboard Charger
• Powertrain Control Module (PCM)/Engine Control Module (ECM)*
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in Hybrid vehicles only)
• Vacuum Distribution System
* Includes hardware and emission related software changes only
21

6. California requirements for emissions warranties
QUICK REFERENCE: EMISSIONS WARRANTY COVERAGE
This chart shows the emissions warranty Ford Motor Company provides
for your vehicle under the emissions control warranty in accordance with
the regulations of the California Air Resources Board. This coverage is in
addition to Federal Emissions warranties (page 18).
NOTE: Fully-electric vehicles are not eligible for any emissions
warranties described in this booklet.
STANDARD EMISSIONS DEFECTS
WARRANTY FOR VEHICLES WITH GVWR* OF 14,000 LBS. & UNDER
Short- Term Warranty
Long-Term Warranty**
3/50,000
7/70,000
3/50,000
EMISSIONS PERFORMANCE
WARRANTY
(Vehicles of 14,000 LBS.* and under)
15/150,000
TRANSITIONAL ZERO
EMISSION VEHICLES (TZEV)*** DEFECTS AND
PERFORMANCE WARRANTY****
* Gross Vehicle Weight Rating
** These specific parts were selected on the basis of their estimated
replacement cost at the time the California Air Resources Board ce\
rtified
your vehicle for sale in California (up to 14,000 pounds GVWR).
*** Refer to your Vehicle Emission Control Information label for emissi\
ons
certification information.
**** Except for the high voltage battery, which is covered for 10 years \
or
150,000 miles (whichever occurs first).
23

For 7 years or 70,000 miles (whichever first occurs):
If a high-priced emissions-related part is defective or if its failure causes
your vehicle to fail a Smog Check inspection, the part will be repaired or
replaced by Ford. This is your long-term emission control system
DEFECTS WARRANTY.
For a list of the high-priced emission-related parts that are covered for 7
years or 70,000 miles, go to www.owner.ford.com / Owner Manuals.
Select the list that corresponds to the model and the model year of your
vehicle. NOTE: This list is vehicle specific and may not be the same for
all vehicles. It is based on the replacement cost of each specific part,
which can vary between vehicle lines.
For Vehicles Eligible for California TZEV Emission Warranty Coverage
Except as noted below, for 15 years or 150,000 miles (whichever first
occurs):
1. If your vehicle fails a Smog Check inspection, all necessary repairs and
adjustments will be made by Ford to ensure that your vehicle passes the
inspection. This is your emission control system PERFORMANCE
WARRANTY.
2. If any emissions-related part on your vehicle is defective, the part will
be repaired or replaced by Ford. This is your short-term emission control
system DEFECTS WARRANTY.
NOTE: The TZEV warranty period for the high-voltage battery is
10 years or 150,000 miles (whichever first occurs).
26