2020 FORD F250 SUPER DUTY fuel filter location

You should drain water from the
module assembly whenever the
warning light illuminates or a
message appears in the information
display advising you to drain the water
separator. This occurs when approximately
6.76 fl oz (200 ml) of water accumulates
in the module. If you allow the water level to exceed this level, the water may pass
through to the engine and may cause fuel
injection equipment damage.
Filter Location
Use the tables below to find the location
of your filter.
Pick-up Truck Filter Location
Box Length
Cab Type
Left side of fuel tank.
8 ft (2.4 m)
Regular.
6.75 ft (2.057 m)
SuperCab.
In front of fuel tank.
8 ft (2.4 m)
6.75 ft (2.057 m)
Super Crew Cab.
Left side of fuel tank.
8 ft (2.4 m)
Chassis Cab Filter Location
Fuel Tank Type
Cab Type
Right side of fuel tank.
Single midship fuel tank
Chassis Cab.
Right side of midship fueltank.
Aft axle/midship fuel tanks
Chassis Cab.
Front of fuel tank.
Single aft axle fuel tank
Chassis Cab.
Draining the Diesel Fuel
Conditioner Module
1. Switch the engine off.
2. Access the underside of your vehicle.
356
Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201909, Second-Printing Maintenance

3. Use the table to find the location of
your fuel filter. 4. Drain the diesel fuel conditioner
module. Turn the drain plug
counterclockwise until it stops. Do not
use any tools to loosen the drain plug.
Drain the filter, approximately 0.5 gal
(2 L), into an appropriate container.
Do not re-use the fuel drained from the
module.
5. Tighten the drain plug, turn it clockwise
until it stops and you feel a strong
resistance. Do not use any tools to
tighten the drain plug.
6. Prime the system by turning the key to
the on position for 30 seconds. Turn
the key to the off position, then the on
position again for another 30 seconds.
Repeat this twice.
357
Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201909, Second-Printing MaintenanceE226475
2 E269861

4. Remove the bulb by pulling it straight
out.
License Plate Lamp Bulb 1.
Switch all of the lamps and the ignition
off.
2. To access the bulb, reach behind the bumper.
3. Turn the bulb holder counterclockwise
and remove it.
4. Remove the bulb by pulling it straight out.
LED Lamps (If Equipped)
LED lamps are not serviceable items. See
an authorized dealer if they fail.
The following lamps may be LED:
• Headlamps.
• Front fog lamps.
• Rear lamps.
• High stop lamp and cargo lamp.
• License plate bulb. CHANGING THE ENGINE-
MOUNTED AND DIESEL FUEL
CONDITIONER MODULE FUEL
FILTERS - 6.7L DIESEL WARNING:
Do not dispose of fuel
in the household refuse or the public
sewage system. Use an authorized waste
disposal facility.
Your vehicle has two fuel filters. The first
filter mounts on top of the engine on the
left-hand side. The second filter is inside
the diesel fuel conditioner module. The
module is attached to the fuel tank in
different locations depending on the
configuration of your truck. See table
below for configurations.
Note: The module is at the front of the fuel
tank or at the front of the aft-axle fuel tank
on some models.
Regular fuel filter changes are an
important part of engine maintenance;
failing to keep with the scheduled
maintenance could lead to engine
performance issues and fuel injection
system damage. See
Scheduled
Maintenance (page 557).
Use only recommended service parts
conforming to specifications. See
Motorcraft Parts
(page 437).
Note: Using fuel that has high levels of
impurities may require more frequent filter
replacements than the service interval
specifies.
Diesel Fuel Conditioner Module
Filter
Filter Location
Use the tables below to find the location
of your filter.
380
Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201909, Second-Printing MaintenanceE163830

Pick-up Truck
Filter Location
Box Length
Cab Type
Left side of fuel tank.
8 ft (2.4 m)
Regular.
6.75 ft (2.057 m)
SuperCab.
In front of fuel tank.
8 ft (2.4 m)
6.75 ft (2.057 m)
Super Crew Cab.
Left side of fuel tank.
8 ft (2.4 m)
Chassis Cab Filter Location
Fuel Tank Type
Cab Type
Right side of fuel tank.
Single midship fuel tank
Chassis Cab.
Right side of midship fueltank.
Aft axle/midship fuel tanks
Chassis Cab.
Front of fuel tank.
Single aft axle fuel tank
Chassis Cab.
Removal 1. For 2017 models, disconnect the fuel
line quick connect coupling from the in
tank fuel pump. For 2018 models and
later, skip this step but insure that the
fuel filler cap is closed before draining
the filter. Failure to close the fill cap
results in the siphoning of the entire
fuel tank contents when you open the
drain screw.
2. Locate your filter.
381
Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201909, Second-Printing MaintenanceE247666

Exceptions
Axle and Transfer Case Maintenance
Axle(s) and transfer case, 4X4 only, fluid
changes or level checks are not required
unless a leak is suspected or the assembly
has been submerged in water. During long
periods of trailer towing with outside
temperatures above 70°F (21°C) or at
wide-open throttle for long periods above
45 mph (72 km/h)
, change the rear axle
fluid every 30,000 mi (48,000 km) if the
rear axle is filled with non-synthetic fluid.
This interval can be waived and the
150,000 mi (240,000 km) service interval
can continue if the rear axle is filled with
75W140 synthetic gear fluid meeting Ford
specification WSL-M2C192-A, part number
XY-75W140-QL, or equivalent. Add friction
modifier XL-3 (EST-M2C118-A) or
equivalent for complete refill of
Traction-Lok rear axles. See
Capacities
and Specifications (page 433).
Additional Axle Maintenance for Dual
Rear Wheels
Change the rear axle fluid every
250,000 mi (400,000 km)
under normal
driving conditions on all commercial
applications. When you operate your
vehicle at or near maximum gross vehicle
weights, change the rear axle fluid every
60,000 mi (96,000 km)
. In addition,
follow this 60,000 mi (96,000 km)
schedule when you operate your vehicle
under the special operating conditions
where noted. California Fuel Filter Replacement
If you register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot Climate Oil Change Intervals
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 3,000 mi (5,000 km).
If the available API SM or SN oils are not
available, then the oil change interval is
2,000 mi (3,000 km)
.
Engine Air Filter and Cabin Air Filter
Replacement
The life of the engine air filter and cabin air
filter is dependent on exposure to dusty
and dirty conditions. Vehicles operated in
these conditions require frequent
inspection and replacement of the engine
air filter and cabin air filter.
Diesel Particulate Filter
Over time, a slight amount of ash builds
up in the diesel particulate filter, which is
not removed during the regeneration
process. The filter may need to be replaced
with a new or remanufactured part at
approximately 250,000 mi (400,000 km).
Actual mileage varies depending on engine
and vehicle operating conditions.
574
Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201909, Second-Printing Scheduled Maintenance

Alternative Engine Oil for Extremely Cold
Climates........................................................... 444
Automatic Transmission-Six Speed..........442
Automatic Transmission-Ten Speed.........442
Engine Coolant................................................... 443
Engine Oil............................................................. 443
Front Axle............................................................. 448
Fuel Tank.............................................................. 445
Grease.................................................................... 445
Hydraulic Brake System.................................. 446
Locks....................................................................... 447
Power Steering System.................................. 446
Rear Axle - 10.5.................................................. 448
Rear Axle - 11.8 ................................................... 449
Transfer Case....................................................... 447
Washer Reservoir.............................................. 449
Capacities and Specifications - 6.7L Diesel............................................................450
Air Conditioning System................................. 450
Alternative Engine Oil for Biodiesel Fuel Blends (B20 max)........................................ 454
Alternative Engine Oil for Extremely Cold Climates........................................................... 454
Alternative Engine Oil for Severe Duty Service.............................................................. 455
Automatic Transmission.................................. 451
Diesel Exhaust Fluid (DEF) Tank.................456
Engine Coolant................................................... 452
Engine Oil.............................................................. 452
Front Axle............................................................. 459
Fuel Tank.............................................................. 455
Grease .................................................................... 456
Hydraulic Brake System.................................. 457
Locks...................................................................... 458
Power Steering System................................... 457
Rear Axle - 10.5................................................... 459
Rear Axle - 10.8.................................................. 460
Rear Axle - 11.8 .................................................. 460
Transfer Case...................................................... 458
Washer Reservoir................................................ 461
Capacities and Specifications - 7.3L..................................................................461
Air Conditioning System................................. 462
Alternative Engine Oil for Extremely Cold Climates ........................................................... 464
Automatic Transmission................................ 462
Engine Coolant................................................... 463
Engine Oil............................................................. 463Front Axle.............................................................
468
Fuel Tank.............................................................. 465
Grease .................................................................... 465
Hydraulic Brake System................................. 466
Locks....................................................................... 467
Power Steering System.................................. 466
Rear Axle - 10.5.................................................. 468
Rear Axle - 10.8.................................................. 469
Rear Axle - 11.8 (With HD Tow Option)............................................................. 469
Rear Axle - 11.8 (Without HD Tow Option)............................................................. 470
Transfer Case...................................................... 467
Washer Reservoir................................................ 471
Capacities and Specifications................433
Cargo Lamps...................................................93
Car Wash See: Cleaning the Exterior.............................. 385
Catalytic Converter
......................................195
On-Board Diagnostics (OBD-II)................... 196
Readiness for Inspection and Maintenance (I/M) Testing.................................................... 197
Center Console
................................................171
Changing a Bulb............................................377 Cargo Lamp and Central High Mounted
Brake Lamp Bulbs........................................ 379
Fog Lamp Bulbs................................................. 378
Front Park and Direction Indicator Lamp Bulbs................................................................... 377
Headlamp Bulbs................................................. 377
LED Lamps.......................................................... 380
License Plate Lamp Bulb............................... 380
Rear Lamps, Brake Lamps, Rear Direction Indicator and Reversing Lamp
Bulbs.................................................................. 378
Changing a Fuse..........................................340 Fuses...................................................................... 340
Changing a Road Wheel...........................422 Dissimilar Spare Wheel and Tire Assembly
Information...................................................... 422
Location of the Spare Tire and Tools.........423
Stowing the Flat Tire or Spare Tire.............430
Tire Change Procedure.................................... 423
Changing the 12V Battery..........................373 Battery Management System....................... 374
Changing the Engine Air Filter - 6.2L..................................................................351
617
Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201909, Second-Printing Index

Connecting the Vehicle to a Mobile
Network........................................................474
Enabling the Modem Using FordPass........................................................... 474
Enabling the Modem Using the Touchscreen.................................................... 474
What Is the Modem.......................................... 474
Coolant Check See: Engine Coolant Check - 6.2L...............358
See: Engine Coolant Check - 6.7L
Diesel................................................................. 362
See: Engine Coolant Check - 7.3L................365
Crash Sensors and Airbag Indicator........53
Creating a MyKey............................................63
Programming or Changing Configurable
Settings............................................................... 63
Creating a Vehicle Wi-Fi Hotspot...........477 Connecting a Device to the Wi-Fi
Hotspot............................................................. 477
Finding the Wi-Fi Hotspot Name and Password.......................................................... 477
Cross Traffic Alert
........................................258
Cross Traffic Alert Behavior When Trailer
is Attached...................................................... 260
Cross Traffic Alert Indicator........................... 260
Cross Traffic Alert Information Messages......................................................... 260
Cross Traffic Alert System Limitations...................................................... 259
Cross Traffic Alert System Sensors............259
Switching the System On and Off..............260
Using Cross Traffic Alert................................. 258
Cruise Control................................................241
Cruise Control Indicators..........................242
Cruise Control - Vehicles With: Adaptive Cruise Control
...............................................85
Cruise Control - Vehicles With: Cruise Control............................................................84
Customer Assistance
..................................327
D
Data Recording.................................................12 Comfort, Convenience and Entertainment
Data....................................................................... 14
Event Data................................................................ 13
Service Data............................................................ 13
Services That Third Parties Provide...............14 Services That We Provide..................................
14
Vehicles With a Modem...................................... 14
Vehicles With an Emergency Call System.................................................................. 15
Vehicles With SYNC............................................. 15
Daytime Running Lamps - Vehicles With: Configurable Daytime Running
Lamps.............................................................90
Daytime Running Lamps - Vehicles With: Daytime Running Lamps (DRL).............91
Declaration of Conformity
........................613
Declaration of Conformity - Vehicles With: SYNC 3
...............................................613
Radio Frequency Statement.......................... 613
Diesel Particulate Filter.............................202 Oxidation Catalytic Converter and Diesel
Particulate Filter System........................... 202
Regeneration....................................................... 202
Digital Radio
..................................................482
HD Radio Reception and Station
Troubleshooting............................................ 483
Direction Indicators.......................................92
Doors and Locks.............................................66
Draining the Fuel Filter Water Trap - 6.7L Diesel
.............................................................355
Draining the Diesel Fuel Conditioner
Module.............................................................. 356
Filter Location..................................................... 356
Drive Control
..................................................267
Selectable Drive Modes................................... 267
Driver Alert.....................................................249 Using Driver Alert............................................... 249
Driver and Passenger Airbags...................46 Children and Airbags............................................ 51
Passenger Airbag On and Off Switch .........46
Proper Driver and Front Passenger Seating Adjustment....................................................... 50
Driving Aids
....................................................249
Driving Hints....................................................312
Driving Through Water
................................315
For Vehicles without Tremor Off-Road
Package............................................................. 315
For Vehicles with Tremor Off-Road Package............................................................. 316
619
Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201909, Second-Printing Index