2020 FORD F-53 coolant level

VEHICLE STORAGE
If you plan on storing your vehicle for 30
days or more, read the following
maintenance recommendations to make
sure your vehicle stays in good operating
condition.
We engineer and test all motor vehicles
and their components for reliable, regular
driving. Under various conditions,
long-term storage may lead to degraded
engine performance or failure unless you
use specific precautions to preserve engine
components.
General
•
Store all vehicles in a dry, ventilated
place.
• Protect from sunlight, if possible.
• If vehicles are stored outside, they
require regular maintenance to protect
against rust and damage.
Body
• Wash your vehicle thoroughly to
remove dirt, grease, oil, tar or mud from
exterior surfaces, rear-wheel housing
and the underside of front fenders.
• Periodically wash your vehicle if it is
stored in exposed locations.
• Touch-up exposed or primed metal to
prevent rust.
• Cover chrome and stainless steel parts
with a thick coat of auto wax to prevent
discoloration. Re-wax as necessary
when you wash your vehicle.
• Lubricate all hood, door and luggage
compartment hinges and latches with
a light grade oil.
• Cover interior trim to prevent fading.
• Keep all rubber parts free from oil and
solvents. Engine
•
Change the engine oil and filter prior to
storage because used engine oil
contains contaminates which may
cause engine damage.
• Start the engine every 15 days for a
minimum of 15 minutes. Run at fast
idle with the climate controls set to
defrost until the engine reaches normal
operating temperature.
• With your foot on the brake, shift
through all the gears while the engine
is running.
• We recommend that you change the
engine oil before you use your vehicle
again.
Fuel system
• Fill the fuel tank with high-quality fuel
until the first automatic shutoff of the
fuel pump nozzle.
Cooling system
• Protect against freezing temperatures.
• When removing your vehicle from
storage, check coolant fluid level.
Confirm that there are no cooling
system leaks and that fluid is at the
recommended level.
Disconnecting Your 12 Volt Battery
• Check and recharge as necessary. Keep
connections clean.
• If storing your vehicle for more than 30
days without recharging the battery,
we recommend that you disconnect
the battery cables to maintain battery
charge for quick starting.
Note: It is necessary to reset memory
features if you disconnect the battery
cables.
129
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201910, Second-Printing Vehicle Care

Brakes
•
Make sure the brakes and parking brake
release fully.
Tires
• Maintain recommended air pressure.
Miscellaneous
• Make sure all linkages, cables, levers
and pins under your vehicle are covered
with grease to prevent rust.
• Move vehicles at least 25 ft (7.5 m)
every 15 days to lubricate working parts
and prevent corrosion.
Removing Vehicle From Storage
When your vehicle is ready to come out of
storage, do the following:
• Wash your vehicle to remove any dirt
or grease film build-up on window
surfaces.
• Check windshield wipers for any
deterioration.
• Check under the hood for any foreign
material that may have collected
during storage such as mice or squirrel
nests.
• Check the exhaust for any foreign
material that may have collected
during storage.
• Check tire pressures and set tire
inflation per the Tire Label.
• Check brake pedal operation. Drive
your vehicle
15 ft (4.5 m) back and
forth to remove rust build-up.
• Check fluid levels (including coolant,
oil and gas) to make sure there are no
leaks, and fluids are at recommended
levels.
• If you remove the battery, clean the
battery cable ends and check for
damage. Contact an authorized dealer if you have
any concerns or issues.
130
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201910, Second-Printing Vehicle Care

Ford Motor Company has recommended
maintenance intervals for various parts
and component systems based upon
engineering testing. Ford Motor Company
relies upon this testing to determine the
most appropriate mileage for replacement
of oils and fluids to protect your vehicle at
the lowest overall cost to you and
recommends against maintenance
schedules that deviate from the scheduled
maintenance information.
We strongly recommend the use of only
genuine Ford, Motorcraft or
Ford-authorized re-manufactured
replacement parts engineered for your
vehicle.
Additives and Chemicals
This owner's manual and the Ford
Workshop Manual list the recommended
additives and chemicals for your vehicle.
We do not recommend using chemicals or
additives not approved by us as part of
your vehicle
’s normal maintenance. Please
consult your warranty information. Oils, Fluids and Flushing
In many cases, fluid discoloration is a
normal operating characteristic and, by
itself, does not necessarily indicate a
concern or that the fluid needs to be
changed. However, a qualified expert, such
as the factory-trained technicians at your
dealership, should inspect discolored fluids
that also show signs of overheating or
foreign material contamination
immediately.
Make sure to change your vehicle
’s oils and
fluids at the specified intervals or in
conjunction with a repair. Flushing is a
viable way to change fluid for many vehicle
sub-systems during scheduled
maintenance. It is critical that systems are
flushed only with new fluid that is the same
as that required to fill and operate the
system or using a Ford-approved flushing
chemical.
Owner Checks and Services
Make sure you perform the following basic
maintenance checks and inspections every
month or at six-month intervals. Check every month
Engine oil level.
Function of all interior and exterior lights.
Tires (including spare) for wear and proper pressure. Windshield washer fluid level. Check every six months
Battery connections. Clean if necessary.
Body and door drain holes for obstructions. Clean if necessary. Cooling system fluid level and coolant strength.
Door weatherstrips for wear. Lubricate if necessary.
167
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201910, Second-Printing Scheduled Maintenance

Check every six months
Hinges, latches and outside locks for proper operation. Lubricate if necessary. Parking brake for proper operation.
Safety belts and seat latches for wear and function.
Safety warning lamps (brake, ABS, airbag and safety belt) for operation.
Washer spray and wiper operation. Clean or replace blades as necessary.
Multi-point Inspection
In order to keep your vehicle running right,
it is important to have the systems on your
vehicle checked regularly. This can help
identify potential issues and prevent major
problems. We recommend having the
following multi-point inspection performed
at every scheduled maintenance interval
to help make sure your vehicle keeps
running great. Multi-point inspection
Horn operation
Accessory drive belt(s)
Radiator, cooler, heater and A/C hoses
Battery performance
Suspension component for leaks ordamage
Engine air filter
Steering and linkage
Exhaust system
Tires (including spare) for wear and properpressure**
Exterior lamps and hazard warning system
operation
Windshield for cracks, chips or pits
Fluid levels *
; fill if necessary
Washer spray and wiper operation
For oil and fluid leaks
* Brake, coolant recovery reservoir, automatic transmission, power steering and window
washer.
** If your vehicle is equipped with a temporary mobility kit, check the tire sealant expiration
Use By date on the canister. Replace as needed.
168
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201910, Second-Printing Scheduled Maintenance

Be sure to ask your dealership service
advisor or technician about the multi-point
vehicle inspection. It is a comprehensive
way to perform a thorough inspection of
your vehicle. Your checklist gives you
immediate feedback on the overall
condition of your vehicle.
NORMAL SCHEDULED MAINTENANCE
Note: Do not exceed the mileage or time intervals. Every 10,000 miles (16000 km), 12 months or 450 engine hours - whichever comes first
Change the engine oil and filter.
Rotate the tires, inspect tire wear and measure the tread depth. 1
Inspect the wheels and related components for abnormal noise, wear, looseness or
drag.
Perform a multi-point inspection.
Inspect the automatic transmission fluid level. Consult dealer for requirements.
Inspect the brake pads, shoes, rotors, drums, brake linings, hoses and the parking brake.
Inspect the engine coolant level/strength and hoses.
Inspect the exhaust system and heat shields.
Inspect the steering linkage, ball joints, suspension, tie-rod ends, drive shaft and U-joints.
Lubricate, if your vehicle has grease fittings.
1 Vehicles with dual rear wheels should rotate the front wheels when specified; rear wheels
only if you notice unusual wear. Brake Fluid Maintenance
1
Change the brake fluid. 2
Every 3 Years
1 Perform this maintenance item every 3 years. Do not exceed the designated time for
the interval.
2 Brake fluid servicing requires special equipment available at your authorized dealer.
169
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201910, Second-Printing Scheduled Maintenance

A
About This Manual...........................................5
ABS
See: Brakes.............................................................. 51
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes................................................................... 51
Accessories See: Replacement Parts
Recommendation............................................ 12
ACC See: Using Adaptive Cruise Control..............58
Adjusting the Steering Wheel....................16
Air Filter See: Changing the Engine Air Filter...............114
Appendices.....................................................184
Audible Warnings and Indicators.............26 Headlamps On Warning Chime...................... 26
Key in Ignition Warning Chime........................ 26
Parking Brake On Warning Chime.................. 26
Autolamps.........................................................19 Windshield Wiper Activated
Headlamps........................................................ 20
Automatic Transmission..............................47
Brake-Shift Interlock........................................... 49
If Your Vehicle Gets Stuck in Mud or Snow.................................................................... 50
Progressive Range Selection - PRS..............48
Understanding the Positions of Your Automatic Transmission............................... 47
Automatic Transmission Fluid Check..............................................................119
Adjusting automatic transmission fluid levels.................................................................... 121
Automatic transmission fluid filter................121
Correct fluid level................................................ 120
High fluid level....................................................... 121
Low fluid level...................................................... 120
B
Battery See: Changing the 12V Battery...................... 124
Brake Fluid Check..........................................121 Hydroboost............................................................ 122
Hydromax.............................................................. 122Brakes..................................................................51
General Information............................................. 51
Breaking-In.......................................................88
C
Canceling the Set Speed.............................57
Capacities and Specifications.................156 Air Conditioning System.................................. 156
Alternative Engine Oil for Extremely Cold Climates............................................................ 159
Automatic Transmission.................................. 156
Engine Coolant..................................................... 157
Engine Oil.............................................................. 158
Fuel Tank............................................................... 159
Grease..................................................................... 159
Hydroboost Brake System............................... 161
Hydromax Brake System................................. 160
Power Steering System..................................... 161
Rear Axle................................................................ 162
Washer Reservoir................................................ 162
Car Wash See: Cleaning the Exterior................................ 127
Catalytic Converter.......................................44
On-Board Diagnostics (OBD-II)..................... 45
Readiness for Inspection and Maintenance (I/M) Testing..................................................... 46
Changing a Fuse
...........................................108
Fuses....................................................................... 108
Changing a Road Wheel.............................147 Dissimilar Spare Wheel and Tire Assembly
Information....................................................... 147
Tire Change Procedure..................................... 149
Changing the 12V Battery..........................124 Battery relearn..................................................... 125
Changing the Engine Air Filter..................114
Cleaning the Engine.....................................128
Cleaning the Exterior....................................127 Cleaning the Headlamps.................................. 127
Exterior Chrome Parts....................................... 127
Exterior Plastic Parts.......................................... 127
Stripes or Graphics............................................. 127
Underbody............................................................ 128
Under Hood.......................................................... 128
Cleaning the Wheels...................................128
Connected Vehicle
.......................................163
Connecting the Vehicle to a Mobile
Network............................................................. 163
189
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201910, Second-Printing Index

W
Warning Lamps and Indicators.................24
Adaptive Cruise Control Indicator.................. 24
Anti-Lock Brake System Warning Lamp.................................................................... 24
Autolamps Indicator........................................... 24
Battery...................................................................... 24
Brake System Warning Lamp.......................... 24
Cruise Control Indicator..................................... 25
Direction Indicator................................................ 25
Electronic Throttle Control............................... 25
Engine Coolant Temperature Warning Lamp.................................................................... 25
Fasten Seatbelt Warning Lamp...................... 25
Headlamp High Beam Indicator..................... 25
Hydromax................................................................ 25
Lane Departure Warning Indicator................25
Low Fuel Level Warning Lamp........................ 25
Oil Pressure Warning Lamp.............................. 25
Parking Lamps....................................................... 25
Service Engine Soon........................................... 26
Stability Control Indicator................................. 26
Tow Haul Indicator............................................... 26
Traction Control Indicator................................. 26
Traction Control System Off............................ 26
Washers See: Cleaning the Exterior................................ 127
See: Wipers and Washers.................................. 18
What Is Cruise Control..................................57
Wheel Nuts See: Changing a Road Wheel......................... 147
Wheels and Tires...........................................131 Technical Specifications................................... 151
Windshield Washers......................................18
Windshield Wipers.........................................18
Wipers and Washers......................................18
194
Motorhome (TY3) Canada/United States of America, enUSA, Edition date: 201910, Second-Printing Index