2020 FORD F-250 fuel

Off-road Operation
Replace the wheel bearing grease and grease seals if you
use non-sealed bearings. Two-wheel drive vehicles.
Change the rear axle fluid. Dana rear axles only - some F-
350s; all F-450s and F-550s.
Every 50,000 mi
(80,000 km)
Change the transfer case fluid. Four-wheel drive vehicles.
Inspect the front axle fluid. Four-wheel drive vehicles.
1 Rotate the front wheels on vehicles with dual rear wheels when specified. Only rotate
the rear wheels if you notice unusual wear.
2 Reset the engine air filter information monitor after you replace the air filter.
3 Reset the Intelligent Oil-Life Monitor after engine oil and filter changes. Using Biodiesel, up to and Including 20% Biodiesel (B20)
Change the engine oil and filter as indicated by the
information display, and perform the services listed in the
scheduled maintenance chart.
As required
Replace the engine-mounted and frame-mounted fuel
filters.
Every
15,000 mi
(24,000 km), six months or
300 engine hours Using Fuel Other Than Ultra-low Sulfur Diesel Fuel - Vehicles Operated Where Ultra-low
Sulfur Diesel Fuel is not Required or Available
Change the engine oil and filter.
Every
2,500 mi (4,000 km)
or three months (if using
high sulfur fuel with more
than 500 ppm sulfur)
Change the engine oil and filter.
Every
5,000 mi (8,000 km)
or six months (if using high
sulfur fuel with fewer than
500 ppm sulfur)
569
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Scheduled Maintenance

Exceptions
Axle and Transfer Case Maintenance
Axle(s) and transfer case, 4X4 only, fluid
changes or level checks are not required
unless a leak is suspected or the assembly
has been submerged in water. During long
periods of trailer towing with outside
temperatures above 70°F (21°C) or at
wide-open throttle for long periods above
45 mph (72 km/h)
, change the rear axle
fluid every 30,000 mi (48,000 km) if the
rear axle is filled with non-synthetic fluid.
This interval can be waived and the
150,000 mi (240,000 km) service interval
can continue if the rear axle is filled with
75W140 synthetic gear fluid meeting Ford
specification WSL-M2C192-A, part number
XY-75W140-QL, or equivalent. Add friction
modifier XL-3 (EST-M2C118-A) or
equivalent for complete refill of
Traction-Lok rear axles. See
Capacities
and Specifications (page 429).
Additional Axle Maintenance for Dual
Rear Wheels
Change the rear axle fluid every
250,000 mi (400,000 km)
under normal
driving conditions on all commercial
applications. When you operate your
vehicle at or near maximum gross vehicle
weights, change the rear axle fluid every
60,000 mi (96,000 km)
. In addition,
follow this 60,000 mi (96,000 km)
schedule when you operate your vehicle
under the special operating conditions
where noted. California Fuel Filter Replacement
If you register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot Climate Oil Change Intervals
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 3,000 mi (5,000 km).
If the available API SM or SN oils are not
available, then the oil change interval is
2,000 mi (3,000 km)
.
Engine Air Filter and Cabin Air Filter
Replacement
The life of the engine air filter and cabin air
filter is dependent on exposure to dusty
and dirty conditions. Vehicles operated in
these conditions require frequent
inspection and replacement of the engine
air filter and cabin air filter.
Diesel Particulate Filter
Over time, a slight amount of ash builds
up in the diesel particulate filter, which is
not removed during the regeneration
process. The filter may need to be replaced
with a new or remanufactured part at
approximately 250,000 mi (400,000 km).
Actual mileage varies depending on engine
and vehicle operating conditions.
570
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Scheduled Maintenance

ELECTROMAGNETIC
COMPATIBILITY
WARNING: Do not place objects
or mount equipment on or near the
airbag cover, on the side of the front or
rear seatbacks, or in areas that may
come into contact with a deploying
airbag. Failure to follow these
instructions may increase the risk of
personal injury in the event of a crash. WARNING: Do not fasten antenna
cables to vehicle wiring, fuel pipes and
brake pipes. WARNING:
Keep antenna and
power cables at least 4 in (10 cm) from
any electronic modules and airbags. Note:
We test and certify your vehicle to
meet electromagnetic compatibility
legislation. It is your responsibility to make
sure that any equipment an authorized
dealer installs on your vehicle complies with
applicable local legislation and other
requirements. Installation of some
aftermarket electronic devices could
degrade the performance of vehicle
functions, which use radio frequency signals
such as broadcast radio receiver, tire
pressure monitoring system, push button
start, Bluetooth connectivity or satellite
navigation.
Note: Any radio frequency transmitter
equipment in your vehicle (such as cellular
telephones and amateur radio transmitters)
must keep to the parameters in the
following illustrations and table. We do not
provide any other special provisions or
conditions for installations or use.
Car/SUV 581
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- AppendicesE239120

Alternative Engine Oil for Extremely Cold
Climates.......................................................... 440
Automatic Transmission-Six Speed..........438
Automatic Transmission-Ten Speed.........438
Engine Coolant................................................... 439
Engine Oil............................................................. 439
Front Axle............................................................. 444
Fuel Tank............................................................... 441
Grease..................................................................... 441
Hydraulic Brake System.................................. 442
Locks...................................................................... 443
Power Steering System................................... 442
Rear Axle - 10.5.................................................. 444
Rear Axle - 11.8 ................................................... 445
Transfer Case...................................................... 443
Washer Reservoir............................................... 445
Capacities and Specifications - 6.7L Diesel............................................................446
Air Conditioning System................................. 446
Alternative Engine Oil for Biodiesel Fuel Blends (B20 Max)........................................ 450
Alternative Engine Oil for Extremely Cold Climates ........................................................... 450
Alternative Engine Oil for Severe Duty Service............................................................... 451
Automatic Transmission................................. 447
Diesel Exhaust Fluid (DEF) Tank.................452
Engine Coolant................................................... 448
Engine Oil............................................................. 448
Front Axle............................................................. 455
Fuel Tank................................................................ 451
Grease.................................................................... 452
Hydraulic Brake System.................................. 453
Locks...................................................................... 454
Power Steering System................................... 453
Rear Axle - 10.5................................................... 455
Rear Axle - 10.8.................................................. 456
Rear Axle - 11.8 ................................................... 456
Transfer Case...................................................... 454
Washer Reservoir............................................... 457
Capacities and Specifications - 7.3L..................................................................457
Air Conditioning System................................. 458
Alternative Engine Oil for Extremely Cold Climates.......................................................... 460
Automatic Transmission................................ 458
Engine Coolant................................................... 459
Engine Oil............................................................. 459Front Axle.............................................................
464
Fuel Tank............................................................... 461
Grease..................................................................... 461
Hydraulic Brake System.................................. 462
Locks...................................................................... 463
Power Steering System................................... 462
Rear Axle - 10.5.................................................. 464
Rear Axle - 10.8.................................................. 465
Rear Axle - 11.8 (With HD Tow Option)............................................................. 465
Rear Axle - 11.8 (Without HD Tow Option)............................................................ 466
Transfer Case...................................................... 463
Washer Reservoir............................................... 467
Capacities and Specifications................429
Cargo Lamps...................................................90
Car Wash See: Cleaning the Exterior............................... 381
Catalytic Converter......................................189 On-Board Diagnostics (OBD-II)................... 190
Readiness for Inspection and Maintenance (I/M) Testing.................................................... 191
Center Console..............................................165
Changing a Bulb...........................................372 Cargo Lamp and Central High Mounted
Brake Lamp Bulbs......................................... 374
Fog Lamp Bulbs.................................................. 373
Front Park and Direction Indicator Lamp Bulbs.................................................................. 372
Headlamp Bulbs................................................. 372
LED Lamps........................................................... 375
License Plate Lamp Bulb................................ 375
Rear Lamps, Brake Lamps, Rear Direction Indicator and Reversing Lamp
Bulbs.................................................................. 373
Changing a Fuse...........................................335 Fuses...................................................................... 335
Changing a Road Wheel.............................417 Dissimilar Spare Wheel and Tire Assembly
Information....................................................... 417
Jacking the Vehicle............................................ 422
Location of the Spare Tire and Tools..........418
Stowing the Flat Tire or Spare Tire..............427
Tire Change Procedure..................................... 418
Changing the 12V Battery.........................368 Battery Management System...................... 369
Changing the Engine Air Filter - 6.2L................................................................346
615
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index

Changing the Engine Air Filter - 6.7L
Diesel.............................................................347
Air Filter Restriction Gauge............................ 348
Changing the Engine Air Filter - 7.3L.................................................................349
Changing the Engine-Mounted and Diesel Fuel Conditioner Module Fuel
Filters - 6.7L Diesel....................................375
Diesel Fuel Conditioner Module Filter........375
Engine-mounted Fuel Filter........................... 378
Changing the Engine Oil and Oil Filter...............................................................345
Engine Lubrication for Severe Service Operation......................................................... 345
Changing the Vehicle Wi-Fi Hotspot Name or Password...................................473
Changing the Wiper Blades......................371
Checking MyKey System Status...............63 MyKey Distance.................................................... 63
Number of Admin Keys...................................... 63
Number of MyKeys.............................................. 63
Checking the Wiper Blades.......................371
Child Restraint and Seatbelt Maintenance.................................................42
Child Restraint Positioning
.........................33
Child Safety......................................................20 General Information............................................ 20
Child Safety Locks
.........................................35
Left-Hand Side...................................................... 35
Right-Hand Side................................................... 35
Cleaning Leather Seats.............................385 With King Ranch Edition................................. 386
Without King Ranch Edition.......................... 385
Cleaning Products......................................380 Materials............................................................... 380
Cleaning the Engine....................................382
Cleaning the Exhaust - 6.7L Diesel.......382
Cleaning the Exterior...................................381 Cleaning the Headlamps................................. 381
Exterior Chrome Parts...................................... 381
Exterior Plastic Parts......................................... 381
Stripes or Graphics............................................. 381
Underbody........................................................... 382
Under Hood......................................................... 382
Cleaning the Instrument Panel and Instrument Cluster Lens
........................385
Cleaning the Interior...................................383
Cleaning the Wheels..................................387 Cleaning the Windows and Wiper
Blades...........................................................383
Clearing All MyKeys.......................................62
Climate.............................................................519 Accessing Rear Climate Controls.................521
Accessing the Climate Control Menu.........519
Directing the Airflow.......................................... 519
Rear Climate Control Lock Indicator...........521
Setting the Blower Motor Speed.................. 519
Setting the Temperature................................. 519
Switching Auto Mode On and Off................519
Switching Dual Zone Mode On and Off...................................................................... 520
Switching Maximum Air Conditioning On and Off............................................................. 520
Switching Maximum Defrost On and Off...................................................................... 520
Switching Rear Auto Mode On and Off........................................................................\
521
Switching Recirculated Air On and Off........................................................................\
521
Switching the Air Conditioning On and Off....................................................................... 519
Switching the Climate Controlled Seats On and Off............................................................. 520
Switching the Climate Control On and Off...................................................................... 520
Switching the Heated Exterior Mirrors On and Off............................................................. 520
Switching the Heated Rear Window On and Off...................................................................... 520
Switching the Heated Seats On and Off...................................................................... 520
Switching the Heated Steering Wheel On and Off............................................................. 520
Switching the Heated Windshield On and Off...................................................................... 520
Switching the Rear Climate Controlled Seats On and Off........................................... 521
Switching the Rear Heated Seats On and Off........................................................................\
521
Switching the Rear Ventilated Seats On and Off............................................................... 521
Switching the Ventilated Seats On and Off........................................................................\
521
Climate Control.............................................139
616
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index

Connecting the Vehicle to a Mobile
Network........................................................470
Enabling the Modem Using FordPass.......................................................... 470
Enabling the Modem Using the Touchscreen................................................... 470
What Is the Modem.......................................... 470
Coolant Check See: Engine Coolant Check - 6.2L...............353
See: Engine Coolant Check - 6.7L
Diesel................................................................. 357
See: Engine Coolant Check - 7.3L...............360
Crash Sensors and Airbag Indicator.........51
Creating a MyKey............................................61 Programming or Changing Configurable
Settings............................................................... 62
Creating a Vehicle Wi-Fi Hotspot..........473 Connecting a Device to the Wi-Fi
Hotspot............................................................. 473
Finding the Wi-Fi Hotspot Name and Password.......................................................... 473
Cross Traffic Alert........................................253
Cross Traffic Alert Behavior When Trailer
is Attached...................................................... 255
Cross Traffic Alert Indicator........................... 255
Cross Traffic Alert Information Messages......................................................... 255
Cross Traffic Alert System Limitations...................................................... 254
Cross Traffic Alert System Sensors............254
Switching the System On and Off..............255
Using Cross Traffic Alert.................................. 253
Cruise Control...............................................236
Cruise Control Indicators
...........................237
Cruise Control - Vehicles With: Adaptive Cruise Control................................................81
Cruise Control - Vehicles With: Cruise Control.............................................................81
Customer Assistance.................................322
D
Data Recording
................................................10
Comfort, Convenience and Entertainment
Data....................................................................... 12
Event Data................................................................. 11
Service Data............................................................. 11
Services That Third Parties Provide...............12 Services That We Provide..................................
12
Vehicles With a Modem...................................... 12
Vehicles With an Emergency Call System.................................................................. 13
Vehicles With SYNC............................................. 13
Daytime Running Lamps - Vehicles With: Configurable Daytime Running
Lamps..............................................................87
Daytime Running Lamps - Vehicles With: Daytime Running Lamps (DRL)............88
Declaration of Conformity.......................609
Declaration of Conformity - Vehicles With: SYNC 3.............................................609
Radio Frequency Statement........................ 609
Diesel Particulate Filter..............................196 Oxidation Catalytic Converter and Diesel
Particulate Filter System............................ 196
Regeneration........................................................ 196
Digital Radio..................................................478 HD Radio Reception and Station
Troubleshooting............................................ 479
Direction Indicators
.......................................89
Doors and Locks.............................................65
Draining the Fuel Filter Water Trap - 6.7L Diesel............................................................350
Draining the Diesel Fuel Conditioner Module............................................................... 351
Filter Location...................................................... 351
Drive Control..................................................262 Selectable Drive Modes.................................. 262
Driver Alert
.....................................................244
Using Driver Alert............................................... 244
Driver and Passenger Airbags...................44 Children and Airbags.......................................... 49
Passenger Airbag On and Off Switch ..........44
Proper Driver and Front Passenger Seating Adjustment....................................................... 48
Driving Aids....................................................244
Driving Hints
...................................................307
Driving Through Water...............................310
For Vehicles without Tremor Off-Road
Package............................................................. 310
For Vehicles with Tremor Off-Road Package.............................................................. 311
617
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index

Launching or Retrieving a Boat or Personal
Watercraft (PWC)........................................ 304
Safety Chains...................................................... 299
Trailer Brakes....................................................... 299
Trailer Lamps...................................................... 303
Trailer Towing Connector................................ 295
When Towing a Trailer..................................... 303
Event Data Recording See: Data Recording............................................ 10
Export Unique Options.................................16
Exterior Mirrors................................................95 Blind Spot Information System...................... 98
Clearance Lamps ................................................. 97
Direction Indicator Mirrors ................................ 97
Fold-Away Exterior Mirrors............................... 95
Heated Exterior Mirrors ...................................... 97
Memory Mirrors .................................................... 97
Power Exterior Mirrors........................................ 95
PowerScope ™ Power Telescoping
Mirrors................................................................. 96
Puddle Lamps........................................................ 97
Spot Lamps............................................................ 97
Telescoping Mirrors............................................. 96
Trailer Towing Camera System....................... 97
F
Fastening the Seatbelts...............................37 Fastening the Cinch Tongue............................ 38
Seatbelt Locking Modes.................................... 39
Using Seatbelts During Pregnancy................38
Using the Seatbelt with Cinch Tongue (Front Center Seat on Super Cab and
Crew Cab)........................................................... 37
Fire Extinguisher
............................................316
Flat Tire See: Changing a Road Wheel......................... 417
Floor Mats........................................................313
Fog Lamps - Front See: Front Fog Lamps........................................ 88
Foot Pedals See: Adjusting the Pedals................................. 83
Ford Credit
.........................................................14
US Only..................................................................... 14
Ford Protect....................................................551 Ford Protect Extended Service Plan
(CANADA ONLY).......................................... 552Ford Protect Extended Service Plans (U.S.
Only)................................................................... 551
Four-Wheel Drive.........................................207
Front Fog Lamps............................................88 Front Fog Lamp Indicator................................. 88
Switching the Front Fog Lamps On or Off........................................................................\
. 88
Fuel and Refueling.......................................178
Fuel Consumption........................................187 Advertised Capacity........................................... 187
Fuel Economy....................................................... 187
Fuel Filter - 6.2L/7.3L...................................371
Fuel Quality - Diesel.....................................181 Biodiesel................................................................. 182
Diesel Fuel Additives ........................................ 183
Fuel Requirements - Choosing The Right Fuel: Vehicles Operated Where Ultra Low
Sulfur Diesel Fuel Is Not Required ...........181
Fuel Requirements - Choosing The Right Fuel: Vehicles Operated Where Ultra Low
Sulfur Diesel Fuel Is Required (United
States/Canada/Puerto Rico/U.S. Virgin
Islands And Other Locales) ....................... 181
Fuel Quality - E85.........................................179 Choosing the Right Fuel - Flex Fuel
Vehicles.............................................................. 179
Switching Between E85 and Gasoline............................................................ 180
Fuel Quality - Gasoline..............................180 Choosing the Right Fuel.................................. 180
Fuel Shutoff
....................................................316
Fuses................................................................329
Fuse Specification Chart
..........................329
Engine Compartment Fuse Box................... 329
Passenger Compartment Fuse Panel........333
G
Garage Door Opener...................................158
Garage Door Opener See: Universal Garage Door Opener...........158
Gauges..............................................................101 DEF Gauge............................................................ 103
Engine Coolant Temperature Gauge..........103
Engine Oil Pressure Gauge.............................. 103
Fuel Gauge............................................................ 103
Transmission Fluid Temperature Gauge................................................................. 103
619
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index

Diesel Messages..................................................
125
Doors and Locks.................................................. 127
Driver Alert............................................................. 128
Drivetrain................................................................ 128
Engine..................................................................... 128
Fuel........................................................................\
.. 129
Keys and Remote Controls............................. 129
Lane Keeping System....................................... 130
Maintenance........................................................ 130
MyKey....................................................................... 131
Off Road.................................................................. 131
Park Aid................................................................... 132
Park Brake.............................................................. 132
Power Steering..................................................... 133
Pre-Collision Assist............................................ 133
Remote Start........................................................ 134
Seats........................................................................\
134
Starting System ................................................. 134
Tailgate................................................................... 134
Tire Pressure Monitoring System.................. 135
Trail Control.......................................................... 135
Trailer....................................................................... 136
Installing Child Restraints...........................22 Child Seats.............................................................. 22
Combining Seatbelt and LATCH Lower Anchors for Attaching Child
Restraints........................................................... 28
Front Seat Tether Strap Attachment (Regular Cab)................................................... 29
Rear Seat Tether Strap Attachment (Crew Cab and Super Cab)...................................... 30
Use of Inboard Lower Anchors from the Outboard Seating Positions (Center
Seating Use) ..................................................... 27
Using Lap and Shoulder Belts (Except Front Center Position of Super Cab and Crew
Cab)...................................................................... 22
Using Lap and Shoulder Belts (Front Center Position of Super Cab and Crew
Cab)...................................................................... 24
Using Lower Anchors and Tethers for CHildren (LATCH)........................................... 26
Using Tether Straps............................................. 28
Instrument Cluster........................................101
Instrument Lighting Dimmer......................87
Instrument Panel............................................18
Interior Air Quality........................................146 Interior Lamps
.................................................89
Front Interior Lamp............................................. 89
Rear Interior Lamps............................................ 90
Interior Mirror
...................................................98
Auto-Dimming Mirror......................................... 98
Manual Dimming Mirror..................................... 98
Introduction.........................................................7
J
Jump Starting the Vehicle..........................317 Connecting the Jumper Cables...................... 317
Jump Starting....................................................... 318
Preparing Your Vehicle...................................... 317
Removing the Jumper Cables........................ 318
K
Keyless Entry
...................................................68
SECURICODE™ KEYLESS ENTRY
KEYPAD.............................................................. 68
Keyless Starting
............................................169
Keys and Remote Controls.........................53
L
Lane Keeping System
................................245
Switching the System On and Off..............246
System Display................................................... 246
System Settings................................................. 246
Troubleshooting.................................................. 247
Lighting Control..............................................86 Flashing the Headlamp High Beam..............87
Headlamp High Beam....................................... 86
Lighting..............................................................86 General Information........................................... 86
Limited Slip Differential.............................215
Load Carrying
................................................265
Load Limit.......................................................265
Special Loading Instructions for Owners of
Pick-up Trucks and Utility-type
Vehicles............................................................ 269
Vehicle Loading - with and without a Trailer................................................................. 265
Locating the Cabin Air Filter.....................146
Locking and Unlocking.................................65 Activating Intelligent Access............................ 65
Autolock................................................................... 67
621
Super Duty (TFE), enUSA, Edition date: 201909, Third-Printing- Index