2020 FORD EXPLORER warranty coverage

Important Information About List of Parts
Also covered by the two emissions warranties are all emissions-related
bulbs, hoses, clamps, brackets, tubes, gaskets, seals, belts, connectors,
non-diesel fuel lines, sensors, and wiring harnesses that are used with
components on the list of parts, above.
Concerning parts that should be replaced on a certain maintenance
schedule: these parts remain under warranty until : (a) the first
replacement time that is specified in yourOwner’s Manual; or (b) the
time or mileage limits of the Federal Defect and Performance Warranties
(whichever occurs first). Your Ford Motor Company dealer maintains a
complete list of parts covered by the emissions performance warranty.
For questions about emission-related parts, contact your dealer.
WHAT IS NOT COVERED?
Ford Motor Company may deny you emissions warranty coverage if your
vehicle or a part does not contain an emissions-related defect or has
failed because of abuse, neglect, improper maintenance, unapproved
modifications, or any items included in What Is Not Covered?,
pages 12-15.
If you need more information about getting service under the Federal
Emissions Performance Warranty, or if you want to report what you
believe to be violations of the terms of this warranty, you may contact:
U.S. Environmental Protection Agency
Office of Transportation and Air Quality
Compliance Division, Light-Duty Vehicle Group
Attn: Warranty Complaints
2000 Traverwood Drive
Ann Arbor, MI 48105
Email: [email protected]
21

6. California requirements for emissions warranties
QUICK REFERENCE: EMISSIONS WARRANTY COVERAGE
This chart shows the emission warranty that Ford Motor Company
provides for your vehicle under the emissions control warranty in
accordance with the regulations of the California Air Resources Board.
This coverage is in addition to Federal Emission warranties (Page 17).
22

Vehicles Eligible for California Emission Warranty Coverage
California emission warranty coverage applies if your vehicle meets the
following two requirements:
•Your vehicle is registered in a state
1that has adopted and is enforcing
California emission warranty regulations applicable for your vehicle at
the time of repair, and
• Your vehicle is certified for sale in California as indicated on the
vehicle emission control information label.
1Subject to change, the following states have adopted and are enforcing
California emission warranty regulations: -
Passenger Car & Light-duty Trucks (up to 8,500 pounds GVWR) -
California, Connecticut, Delaware, Maine, Maryland, Massachusetts,
New Jersey, New York, Oregon, Pennsylvania, Rhode Island, Vermont
and Washington
- Medium-Duty Passenger Vehicles (up to 10,000 pounds GVWR
designed primarily for the transportation of persons. Excludes
incomplete trucks, trucks with a seating capacity either over twelve
persons total or over nine persons rearward of the driver’s seat, or
trucks with an open cargo area of at least six feet of interior length):
California, Connecticut, Delaware, Maine, Maryland, Massachusetts,
New York, Oregon, Rhode Island, Vermont and Washington
- Medium-Duty Vehicles (over 8,500 pounds GVWR up to 14,000
pounds GVWR) - California, Connecticut, Delaware, Maine, Maryland,
Massachusetts, New York, Oregon, Rhode Island, and Vermont.
- Light Heavy-Duty Diesel Engine Vehicles (over 14,000 pounds
GVWR up to 19,500 pounds GVWR) - California, Maine and
Pennsylvania.
For full details about coverage under California requirements for
emissions control, see:
➡ Defects Warranties (pages 24-29)
➡ Performance Warranty (pages 24-26)
➡ What Is Covered? (pages 27-28)
➡ What Is Not Covered? (page 28)
23

EXPLANATION OF CALIFORNIA EMISSIONS WARRANTIES
Your Warranty Rights and Obligations
The California Air Resources Board and Ford Motor Company are
pleased to explain the emission control system warranty on your
2020-model vehicle. In California, new motor vehicles must be designed,
built, and equipped to meet the State’s stringent anti-smog standards.
Ford must warrant the emission control system on your vehicle for the
periods of time listed on pages 24-26, provided there has been no abuse,
neglect, or improper maintenance of your vehicle.
Your emission control system may include parts such as the fuel injection
system, the ignition system, catalytic converter, and the engine
computer. Also included may be hoses, belts, connectors, and other
emissions-related assemblies.
Where a warrantable condition exists, Ford Motor Company will repair
your vehicle at no cost to you including diagnosis, parts, and labor.
Manufacturer’s Warranty Coverage
For Vehicles Eligible for California Emission Warranty Coverage
If Gross Vehicle Weight Rating is 14,000 lbs. or less:
For 3 years or 50,000 miles (whichever first occurs):
1. If your vehicle fails a Smog Check inspection, all necessary repairs and
adjustments will be made by Ford to ensure that your vehicle passes the
inspection. This is your emission control system PERFORMANCE
WARRANTY.
2. If any emissions-related part on your vehicle is defective, the part will
be repaired or replaced by Ford. This is your short-term emission control
system DEFECTS WARRANTY.
For 7 years or 70,000 miles (whichever first occurs):
If a high-priced emissions-related part is defective or if its failure causes
your vehicle to fail a Smog Check inspection, the part will be repaired or
replaced by Ford. This is your long-term emission control system
DEFECTS WARRANTY.
24

Owner’s Warranty Responsibilities
As the vehicle owner, you are responsible for the performance of the
required maintenance listed in your owner’s manual. Ford Motor
Company recommends that you retain all receipts covering maintenance
on your vehicle, but Ford cannot deny warranty coverage solely for the
lack of receipts or for your failure to ensure the performance of all
scheduled maintenance.
You are responsible for presenting your vehicle to a Ford Motor
Company dealer as soon as a problem exists. The warranty repairs
should be completed in a reasonable amount of time, not to exceed 30
days.
As the vehicle owner, you should also be aware that Ford Motor
Company may deny you warranty coverage if your vehicle or a part has
failed due to abuse, neglect, improper maintenance, or unapproved
modifications.
If you have any questions regarding your warranty rights and
responsibilities, or if you want to report what you believe to be violations
of the terms of this warranty, you may contact the Ford Customer
Relationship Center at 1-800-392-3673 (FORD) or the California Air
Resources Board at:California Air Resources Board
9528 Telstar Avenue
El Monte, California 91731
26

Important Information about List of Parts
There may be additional coverage for these parts through the Bumper to
Bumper, Powertrain, or Diesel Engine limited warranties. In any case, the
warranty with the broadest coverage applies.
Also covered by this warranty are all emissions-related bulbs, hoses,
clamps, brackets, tubes, gaskets, seals, belts, connectors, non diesel fuel
lines, and wiring harnesses that are used with components on the list of
parts above.
Concerning parts that should be replaced on a certain maintenance
schedule: these parts remain under warranty until the first required
replacement time that is specified in yourOwner’s Manual.
NOTE: If the diagnosis does not reveal a defect, the Defects Warranty
does not apply.
Your Ford Motor Company dealer maintains a complete list of covered
parts. For more details about the specific parts that are covered by the
Defects Warranty, contact your dealer.
WHAT IS NOT COVERED?
Ford Motor Company may deny you emissions warranty coverage if your
vehicle or a part does not contain a defect that affects emissions or has
failed because of abuse, neglect, improper maintenance, unapproved
modifications, or any items included in What Is Not Covered?,
pages 12-15.
28

7. Additional information about your emissions warrantycoverage, under Federal and California requirements
HOW DO I GET WARRANTY SERVICE?
To get service under your emissions warranties, take your vehicle to any
Ford Motor Company dealer as soon as possible after illumination of the
Malfunction Indicator Light or it has failed an EPA-approved test or a
California Smog Check inspection. Be sure to show the dealer the
document that says your vehicle has failed the test.
Your dealer will determine whether the repair is covered by the warranty.
If the dealer has a question about Emissions Performance Warranty
coverage, it will forward the question to Ford Motor Company, which
must make a final decision within 30 days after you bring your vehicle in
for repair. (The decision will be made within a shorter time if state, local,
or federal law requires you to have the vehicle repaired more quickly in
order to avoid additional penalties.) The deadline for a determination
about Emissions Performance Warranty Coverage does not need to be
met if you request a delay, agree to a delay in writing, or if the delay is
caused by an event for which neither Ford nor your dealer is
responsible. If a question about Emissions Performance Warranty
coverage is referred to Ford Motor Company, you will be notified by Ford
Motor Company in writing if your claim for warranty coverage is denied.
The notice will explain the basis for denying your claim. If you fail to
receive this notice within a timely manner, as determined above, Ford
will perform the warranty repair for you free of charge.
HOW DO I HANDLE EMERGENCY REPAIRS?
If your vehicle needs an emergency warrantable repair and a Ford Motor
Company dealer is not available, or if a Ford Motor Company dealer
cannot perform warrantable repair(s) within 30 days of you bringing
your vehicle to the dealer, repairs may be performed at any service
establishment or by you using Ford equivalent replacement parts.
Ford will reimburse you for the cost of these warranty repairs including
diagnosis, if you take the part(s) that are replaced and the repair
receipt(s) to a Ford Motor Company dealer. The reimbursement shall not
exceed Ford’s suggested retail price for the warranted parts that are
replaced and labor charges based on Ford’s recommended time allowance
for the warranty repair and the geographically appropriate hourly rate.
29

WHAT REPLACEMENT PARTS SHOULD I USE?
Ford Motor Company recommends that you use genuine Ford
replacement parts. However, when you are having non-warranty work
done on your vehicle, you may choose to use non-Ford parts. If you
decide to use non-Ford parts, be sure they are equivalent to Ford parts
in performance, quality, and durability. If you use replacement parts that
are not equivalent to Ford parts, your vehicle’s emissions control systems
may not work as effectively, and you may jeopardize your emissions
warranty coverage.
Under the Federal and California emissions warranties, Ford will repair
or replace covered parts if they are properly installed Ford parts or the
equivalent, or non-Ford parts that have been certified by the U.S. EPA or
the California Air Resources Board (CARB). Ford is not responsible for
the cost or repairing or replacing non-Ford parts that are not equivalent
to Ford parts or that have not been certified by EPA or CARB.
The maintenance, replacement, or repair of emissions control
devices or systems can be performed by any automotive repair
establishment or individual using Ford replacement parts or the
equivalent, or EPA- or CARB-certified parts, without voiding your
emissions warranty coverage for future repairs during the
applicable warranty period.
PROPER MAINTENANCE PRESERVES YOUR WARRANTY
If you do not maintain your vehicle properly, Ford may have the right to
deny you warranty coverage.
To have repairs made under this warranty, you may have to show that
you have followed Ford’s instructions on properly maintaining and using
your vehicle. You will find these instructions in yourOwner’s Manual.
Be sure to save your service receipts and to keep accurate records of all
maintenance work.
CUSTOMER ASSISTANCE
If you are not satisfied with the handling of a warranty matter, see
Customer Assistance, on the inside front cover, and Better Business
Bureau (BBB) AUTO LINE program, page 33.
30