2020 CHEVROLET SUBURBAN engine overheat

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/
Mexico-13566622) - 2020 - CRC - 4/15/19
304 Vehicle Care
Caution
Failure to follow the specific
coolant fill procedure could cause
the engine to overheat and could
cause system damage. If coolant
is not visible in the surge tank,
contact your dealer.
If no coolant is visible in the surge
tank, add coolant.
1. Remove the coolant surge tank pressure cap when the cooling
system, including the coolant
surge tank pressure cap and
upper radiator hose, is no
longer hot. Turn the pressure cap slowly
counterclockwise about one full
turn. If a hiss is heard, wait for
that to stop. A hiss means
there is still some pressure left.
2. Keep turning the pressure cap slowly, and remove it.
3. Fill the coolant surge tank withthe proper mixture to the full
cold mark.
4. With the coolant surge tank pressure cap off, start the
engine and let it run until the
engine coolant temperature
gauge indicates approximately
90 °C (195 °F). By this time, the coolant level
inside the coolant surge tank
may be lower. If the level is
lower, add more of the proper
mixture to the coolant surge
tank until the level reaches the
full cold mark.
5. Replace the pressure cap tightly.
6. Verify coolant level after the engine is shut off and the
coolant is cold. If necessary,
repeat coolant fill procedure
Steps 1–6.
Caution
If the pressure cap is not tightly
installed, coolant loss and engine
damage may occur. Be sure the
cap is properly and tightly
secured.

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/
Mexico-13566622) - 2020 - CRC - 4/15/19
Vehicle Care 305
Engine Overheating
Caution
Running the engine without
coolant may cause damage or a
fire. Vehicle damage would not be
covered by the vehicle warranty.
The vehicle has several indicators
to warn of engine overheating.
There is a coolant temperature
gauge in the vehicle's instrument
cluster. See Engine Coolant
Temperature Gauge 0134.
In addition, there are ENGINE
OVERHEATED STOP ENGINE,
ENGINE OVERHEATED IDLE
ENGINE, and ENGINE POWER IS
REDUCED messages in the Driver
Information Center (DIC).
If the decision is made not to lift the
hood when this warning appears,
get service help right away.
If the decision is made to lift the
hood, make sure the vehicle is
parked on a level surface. Check to see if the engine cooling
fan(s) are running. If the engine is
overheating, the fans should be
running. If they are not, do not
continue to run the engine. Have the
vehicle serviced.
Caution
Do not run the engine if there is a
leak in the engine cooling system.
This can cause a loss of all
coolant and can damage the
system and vehicle. Have any
leaks fixed right away.
If Steam is Coming from the
Engine Compartment
{Warning
Steam and scalding liquids from a
hot cooling system are under
pressure. Turning the pressure
cap, even a little, can cause them
to come out at high speed and
you could be burned. Never turn
(Continued)
Warning (Continued)
the cap when the cooling system,
including the pressure cap, is hot.
Wait for the cooling system and
pressure cap to cool.
If No Steam is Coming from
the Engine Compartment
The ENGINE OVERHEATED STOP
ENGINE or the ENGINE
OVERHEATED IDLE ENGINE
message, along with a low coolant
condition, can indicate a serious
problem.
If there is an engine overheat
warning, but no steam is seen or
heard, the problem may not be too
serious. Sometimes the engine can
get a little too hot when the vehicle:
.Climbs a long hill on a hot day.
. Stops after high-speed driving.
. Idles for long periods in traffic.
. Tows a trailer; see Trailer Towing
0 267.

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/
Mexico-13566622) - 2020 - CRC - 4/15/19
306 Vehicle Care
If the ENGINE OVERHEATED
STOP ENGINE or the ENGINE
OVERHEATED IDLE ENGINE
message appears with no sign of
steam, try this for a minute or so:1. Turn the air conditioning off.
2. Turn the heater on to the highest temperature and to the
highest fan speed. Open the
windows as necessary.
3. When it is safe to do so, pull off the road, shift to P (Park) or
N (Neutral), and let the
engine idle.
If the engine coolant temperature
gauge is no longer in the overheat
zone or an overheat warning no
longer displays, the vehicle can be
driven. Continue to drive the vehicle
slowly for about 10 minutes. Keep a
safe vehicle distance from the
vehicle in front. If the warning does
not come back on, continue to drive
normally and have the cooling
system checked for proper fill and
function. If the warning continues, pull over,
stop, and park the vehicle
right away.
If there is still no sign of steam and
the vehicle is equipped with an
engine driven cooling fan, push
down the accelerator until the
engine speed is about twice as fast
as normal idle speed for at least
five minutes while the vehicle is
parked. If the warning is still there,
turn off the engine and get everyone
out of the vehicle until it cools down.
If there is no sign of steam, idle the
engine for five minutes while
parked. If the warning is still
displayed, turn off the engine until it
cools down.
Engine Fan
If the vehicle has electric cooling
fans, the fans may be heard
spinning at low speed during most
everyday driving. The fans may turn
off if no cooling is required. Under
heavy vehicle loading, trailer towing,
high outside temperatures,
or operation of the air conditioningsystem, the fans may change to
high speed and an increase in fan
noise may be heard. This is normal
and indicates that the cooling
system is functioning properly. The
fans will change to low speed when
additional cooling is no longer
required.
The electric engine cooling fans
may run after the engine has been
turned. off. This is normal and no
service is required.
Washer Fluid
What to Use
When windshield washer fluid needs
to be added, be sure to read the
manufacturer's instructions before
use. Use a fluid that has sufficient
protection against freezing in an
area where the temperature may fall
below freezing.
Adding Washer Fluid
The vehicle has a low washer fluid
message on the DIC that comes on
when the washer fluid is low. The
message is displayed for

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/-
Mexico-13566622) - 2020 - CRC - 4/24/19
428 Index
Power Locks . . . . . . . . . . . . . . . . . . . . 25
Drive Belt Routing, Engine . . . . . . 399
Driver Assistance Systems . . . . . 243
Driver Information
Center (DIC) . . . . . . . . . . . . . 145, 147
Driving Assistance Systems . . . . . . . . . . 248
Better Fuel Economy . . . . . . . . . 187
Characteristics and
Towing Tips . . . . . . . . . . . . . . . . . 262
Defensive . . . . . . . . . . . . . . . . . . . . . 188
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 188
Hill and Mountain Roads . . . . . . 196
If the Vehicle is Stuck . . . . . . . . . 198
Loss of Control . . . . . . . . . . . . . . . 190
Off-Road . . . . . . . . . . . . . . . . . . . . . 191
Off-Road Recovery . . . . . . . . . . . 190
Vehicle Load Limits . . . . . . . . . . . 200
Wet Roads . . . . . . . . . . . . . . . . . . . 196
Winter . . . . . . . . . . . . . . . . . . . . . . . . 197
Dual Automatic Climate
Control System . . . . . . . . . . . . . . . . 178
E
E85 or FlexFuel . . . . . . . . . . . . . . . . 258
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 282 Electrical System
Engine Compartment Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 320
Fuses and Circuit Breakers . . . 319
Instrument Panel Fuse Block . . . . . . . . . . . . . . . . . . . 324, 327
Overload . . . . . . . . . . . . . . . . . . . . . 319
Rear Compartment Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 329
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 415
Engine Air Cleaner/Filter . . . . . . . . . . . . . 300
Check Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . 137
Compartment Overview . . . . . . . 288
Coolant Temperature
Gauge . . . . . . . . . . . . . . . . . . . . . . 134
Cooling System . . . . . . . . . . . . . . . 301
Drive Belt Routing . . . . . . . . . . . . 399
Exhaust . . . . . . . . . . . . . . . . . . . . . . 215
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 306
Heater . . . . . . . . . . . . . . . . . . . . . . . . .211
Oil Life System . . . . . . . . . . . . . . . 295
Oil Pressure Gauge . . . . . . . . . . 133
Overheating . . . . . . . . . . . . . . . . . . 305
Power Messages . . . . . . . . . . . . . 154
Running While Parked . . . . . . . . 216 Starting . . . . . . . . . . . . . . . . . . . . . . . 209
Entry Lighting . . . . . . . . . . . . . . . . . . . 174
Equipment, Towing . . . . . . . . . . . . . 272
Event Data Recorders . . . . . . . . . . 412
Exit Lighting . . . . . . . . . . . . . . . . . . . . 175
Extended Parking . . . . . . . . . . . . . . . 214
Extender, Seat Belt . . . . . . . . . . . . . . 72
Exterior Lamp Controls . . . . . . . . . 167
Exterior Lamps Off Reminder . . . 169
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 176
F
Fan
Engine . . . . . . . . . . . . . . . . . . . . . . . . 306
Filter, Engine Air Cleaner . . . . . . . . . . . 300
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 170
Flashers, Hazard Warning . . . . . . 171
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 351 Changing . . . . . . . . . . . . . . . . . . . . . 353
FlexFuel E85 . . . . . . . . . . . . . . . . . . . . . . . . . . . 258
Floor Console Storage . . . . . . . . . . 113
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 379
Fluid AutomaticTransmission . . . . . . . . . . . 296, 299

Chevrolet Tahoe/Suburban Owner Manual (GMNA-Localizing-U.S./Canada/-
Mexico-13566622) - 2020 - CRC - 4/24/19
432 Index
N
NavigationConnected Services . . . . . . . . . . 422
Net, Convenience . . . . . . . . . . . . . . 113
New Vehicle Break-In . . . . . . . . . . . 204
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . 131 Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
Off-Road . . . . . . . . . . . . . . . . . . . . . . . 191 Driving . . . . . . . . . . . . . . . . . . . . . . . . 191
Recovery . . . . . . . . . . . . . . . . . . . . . 190
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . 293
Engine Oil Life System . . . . . . . 295
Engine Oil Pressure Gauge . . . 133
Older Children, Restraints . . . . . . . 87
Online Owner Center . . . . . . . . . . . 403
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . 413
OnStar Additional Information . . . . . . . . . . . . . . . . . . . . 416
OnStar Emergency . . . . . . . . . . . . . 415
OnStar Overview . . . . . . . . . . . . . . . 414
OnStar Security . . . . . . . . . . . . . . . . 416
Operation Fog Lamps . . . . . . . . . . . . . . . . . . . 172 Outlets
Power . . . . . . . . . . . . . . . . . . . . . . . . 121
Overheating, Engine . . . . . . . . . . . . 305
Overview Instrument Panel . . . . . . . . . . . . . . . . 5
P
ParkShifting Out of . . . . . . . . . . . . . . . . 214
Park Assist . . . . . . . . . . . . . . . . . . . . . 244
Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . 228
Brake and P (Park)
Mechanism Check . . . . . . . . . . 312
Extended . . . . . . . . . . . . . . . . . . . . . 214
Over Things That Burn . . . . . . . 214
Parking or Backing
Assistance Systems . . . . . . . . . . 244
Passenger Airbag Status Indicator . . . . . . . . . . . . . . . . . . . . . . 136
Passenger Compartment Air
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 184
Passenger Sensing System . . . . . 81
Perchlorate Materials Requirements, California . . . . . . 285
Personalization
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 154 Power
Door Locks . . . . . . . . . . . . . . . . . . . . . 25
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Outlets . . . . . . . . . . . . . . . . . . . . . . . 121
Protection, Battery . . . . . . . . . . . . 176
Retained Accessory (RAP) . . . 212
Seat Adjustment . . . . . . . . . . . . . . . . 47
Windows . . . . . . . . . . . . . . . . . . . . . . . 40
Power Assist Steps . . . . . . . . . . . . . . 32
Pregnancy, Using Seat Belts . . . . 71
Privacy Vehicle Data Recording . . . . . . . 412
Program Courtesy Transportation . . . . . . 406
Prohibited Fuels . . . . . . . . . . . . . . . . 257
Proposition 65 Warning,
California . . . . . . . . . . . .285, 309, 363, Back Cover
Publication Ordering Information . . . . . . . . . . . . . . . . . . . . 409
R
Radio Frequency Statement . . . . 410
Reading Lamps . . . . . . . . . . . . . . . . . 174
Rear Axle . . . . . . . . . . . . . . . . . . . . . . . 311