2020 CHEVROLET LOW CAB FORWARD headlamp

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
272 Vehicle Care
8. Remove the rubber boot (2).Push the right side of the
clip (1) that holds the bulb (3)
in place and slide it upwards to
disengage the clip.9. Remove the bulb (1) from thesocket (2) and replace with a
new one.
10. After replacing the bulb, reverse steps 1-8 to install.
Do not touch the glass of the bulb
with your hand. Soiling the glass will
cause the bulb to blow out.
When attaching the rubber boot,
press in both the outside and inside
circumference of it. Make sure that
the rubber boot, the headlamp
assembly, and the bulb are securely
installed without any raised section. If the rubber boot is not firmly in
place, water could get inside the
headlamp and lead to a breakdown.
Replacing Parking Lamps
1. Refer to
“Replacing the
Headlamps” and remove the
headlamp assembly.
2. Pull the bulb out from the parking lamp socket and
replace with a new one.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Service and Maintenance 333
Front
1. Roofmarker Lamp(Identification/
Clearance Lamp)
2. Front Turn Signal Lamp
3. Side Turn Signal Lamp/ Sidemarker Lamp
4. Cornering Lamp
5. Side Reflector
6. Headlamp/Parking Lamp
Rear
1. Rear Turn Signal Lamp
2. Back-up Lamp
3. License Plate Lamp
4. Taillamp/Stoplamp
Lubrication
One of the most important items of
good vehicle care is the lubrication
of all necessary points with the
Right Lubricant, at the Right Time
and in the Right Way. It is the
owner's responsibility to maintain
proper lubrication practices as
recommended in the following
pages. Greasing Chassis Components
The type (characteristics) of the
grease specified for use with a
chassis component differs from that
of the grease specified for use with
another component. Be sure to use
only the specified grease for each
component and perform greasing
according to the Maintenance
Schedule.
King pins (left and right)

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Service and Maintenance 337
one side, unusual sounds when
braking, increased brake pedal
travel or harder pedal. The front and
rear brakes are attached to an auto
adjuster mechanism. If there are no
defects, as the pedal travel is
properly maintained, adjustments
are not necessary. Check regularly
that the brake fluid reservoir
(left-hand side of the instrument
panel) or HBB reservoir (5500HD,
5500XD models: left side behind the
cab) is properly filled and check for
fluid leaks. Any of these conditions
could indicate the need for brake
system inspection and/or service.
G: Exhaust System :Be alert for
any changes in the sound of the
exhaust system or any smell of
fumes. These are signs the system
may be leaking. Have it checked
and/or repaired at once. (Refer to
"Engine Exhaust Emissions Caution
(Carbon Monoxide)" under Engine
Exhaust 0168).
H: Windshield Wipers and
Washers : Check operation and
condition of the wiper blades. Check
the flow of the washer spray. I: Defroster :
Turn the outlet
selector knob to "Defroster" and the
fan speed control knob to the fully
clockwise position. Then check the
airflow from the ducts at the inside
base of the windshield.
J: Rearview Mirrors and Sun
Visors : Check that friction joints
hold mirrors and sun visors in place.
K: Horn : Sound the horn, now and
then, to be sure it works.
L: Lap-Shoulder Belts : Check the
seat belt system (including webbing,
buckles, latch plates and anchors)
for proper operation, and for
damage.
M: Seat Adjusters : When
adjusting the driver's manual seat,
be sure the seat adjusters latch by
pushing the seat forward and
backward. Do not attempt to adjust
the seat when the vehicle is in
motion.
N: Lamps : Check panel lighting,
warning lamps, indicator lamps and
interior lamps. On the outside,
check: license plate lamps, side
marker lamps, reflectors on outside mirrors, headlamps, parking lamps,
identification and clearance lamps,
taillights, brake lamps, turn signals,
cornering lamps, backup lamps and
hazard warning flashers. Have
headlamp aim checked immediately
if beams seem improperly aimed.
O: Glass, Mirrors, Lights and/or
Reflectors Condition :
Look for
broken, scratched, dirty or damaged
glass, mirrors, lamps or reflectors
that could reduce the view or
visibility, or cause injury. Replace,
clean or repair promptly.
P: Door Latches : Check that doors
close, latch and lock tightly. Check
for broken, damaged or missing
parts that might prevent tight
latching.
Q :Tilt Cab (Driving Position) : Be
sure the tilt lever is down and
locked.
R: Fluid Leaks : Check for fuel,
water, oil or other fluid leaks by
looking at the surface beneath the
vehicle after it has been parked for

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
366 Index
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . 253Antilock . . . . . . . . . . . . . . . . . . . . . . . 207
Exhaust Light . . . . . . . . . . . . . . . . . . . 65
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 258
Parking . . . . . . . . . . . . . . . . . . . . . . . .211
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 134
Break-In, New Vehicle . . . . . . . . . . 156
Bulb Replacement Headlamp Aiming . . . . . . . . . . . . . 267
Headlamps . . . . . . . . . . . . . . . . . . . 267
Headlamps and Front TurnSignal . . . . . . . . . . . . . . . . . . . . . . . 270
Interior Lamps . . . . . . . . . . . . . . . . 277
License Plate Lamps . . . . . . . . . 276
Roofmarker Lamps . . . . . . . . . . . 274
Sidemarker Lamps . . . . . . . . . . . 274
Taillamps, Turn Signal, Stoplamps, and Back-up
Lamps . . . . . . . . . . . . . . . . . . . . . . 276
Buzzers, Warning . . . . . . . . . . . . . . . . 79
C
Cab Tilting . . . . . . . . . . . . . . . . . . . . . . 233
California Perchlorate MaterialsRequirements . . . . . . . . . . . . . . . 230 California
Proposition
65 Warning . . . . . . . . . .230, 259, 301,
Back Cover
Capacities and Specifications . . . . . . . . . . . . . . . . . 349
Carbon Monoxide
Engine Exhaust . . . . . . . . . . . . . . . 168
Winter Driving . . . . . . . . . . . . . . . . 142
Cargo Lamp . . . . . . . . . . . . . . . . . . . . . 84
Caution, Danger, and Warning . . . . 3
CD Player . . . . . . . . . . . . . . . . . . . . . . . 90
Check Engine Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . . 61
Child Restraints
Systems . . . . . . . . . . . . . . . . . . . . . . . . 39
Cleaning Exterior Care . . . . . . . . . . . . . . . . . 307
Interior Care . . . . . . . . . . . . . . . . . . 313
Climate Control Systems . . . . . . . 121
Air Conditioning . . . . . . . . . . . . . . 121
Heating . . . . . . . . . . . . . . . . . . . . . . . 121
Cluster, Instrument . . . . . . . . . . . . . . 57
Cold Weather Operation . . . . . . . . 221
Collision Damage Repair . . . . . . . 359 Compartments
Storage . . . . . . . . . . . . . . . . . . . . . . . . . 42
Control of a Vehicle . . . . . . . . . . . . . 130
Coolant Engine . . . . . . . . . . . . . . . . . . . . . . . . 243
Engine Temperature Gauge . . . . 60
Cooling . . . . . . . . . . . . . . . . . . . . . . . . . 121
Cornering Lamps . . . . . . . . . . . . . . . . 83
Cover
Engine . . . . . . . . . . . . . . . . . . . . . . . . 235
Covers
Winter . . . . . . . . . . . . . . . . . . . . . . . . 163
Cruise Control . . . . . . . . . . . . . . . . . . 214 Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
Cupholders . . . . . . . . . . . . . . . . . . . . . . 44
Customer Assistance . . . . . . . . . . . 357 Offices . . . . . . . . . . . . . . . . . . . . . . . . 357
Text Telephone (TTY)Users . . . . . . . . . . . . . . . . . . . . . . . 357
Customer Information Publications Ordering
Information . . . . . . . . . . . . . . . . . . 362
Customer Satisfaction Procedure . . . . . . . . . . . . . . . . . . . . . 356
Cybersecurity . . . . . . . . . . . . . . . . . . . 364

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
368 Index
Fluid (cont'd)Power Steering . . . . . . . . . . . . . . . 252
Washer . . . . . . . . . . . . . . . . . . . . . . . 252
Frequency Statement
Radio . . . . . . . . . . . . . . . . . . . . . . . . . 362
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 26
Fuel Biodiesel . . . . . . . . . . . . . . . . . . . . . 219
Cold Weather Operation . . . . . . 221
Diesel Engines . . . . . . . . . . . . . . . 218
Economy, Driving for Better . . . 129
Filling the Tank . . . . . . . . . . . . . . . 225
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 260
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Running out of Fuel . . . . . . . . . . . 224
Water in Fuel . . . . . . . . . . . . . . . . . 221
Fuel for Diesel Engines . . . . . . . . . 218
G
Gauges
Diesel Exhaust Fluid (DEF) . . . . . 60
Engine Coolant Temperature . . . 60
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Odometer . . . . . . . . . . . . . . . . . . . . . . . 58
Speedometer . . . . . . . . . . . . . . . . . . . 58
Tachometer . . . . . . . . . . . . . . . . . . . . . 59
Trip Odometer . . . . . . . . . . . . . . . . . . 58 Gauges (cont'd)
Warning Lights and
Indicators . . . . . . . . . . . . . . . . . . . . . 56
General Information
Vehicle Care . . . . . . . . . . . . . . . . . . 230
Getting In and Out of the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 17
Glove Box . . . . . . . . . . . . . . . . . . . . . . . 43
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 358
H
Hazard Warning Flashers . . . . . . . . 82
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 267
Bulb Replacement . . . . . . . 267, 270
Daytime Running Lamps(DRL) Indicator Light . . . . . . . . . . 69
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 81
High-Beam On Light . . . . . . . . . . . . 69
High/Low Beam Changer . . . . . . . 81
Heated Mirrors . . . . . . . . . . . . . . . . . . . 22
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 163
Heating . . . . . . . . . . . . . . . . . . . . . . . . . 121
High Idle System . . . . . . . . . . . . . . . 165
High-Beam On Light . . . . . . . . . . . . . 69
Hill and Mountain Roads . . . . . . . . 141 Hooks
Shopping Bag . . . . . . . . . . . . . . . . . . 45
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
HVAC . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
I
Idle Shutdown . . . . . . . . . . . . . . . . . . 164
Idle Shutdown Light . . . . . . . . . . . . . 68
Ignition Positions . . . . . . . . . . . . . . . 157
Information Publication Ordering . . . . . . . . . . 362
Information on Loading the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 46
Instrument Cluster . . . . . . . . . . . . . . . 57
Instrument Panel Storage Area . . . . . . . . . . . . . . . . . . . 43
Instrument Panel
Overview . . . . . . . . . . . . . . . . . 8, 10, 11
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 301
K
Keyless EntryRemote (RKE) System . . . . . . . . . 14
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13