2020 CHEVROLET EXPRESS towing
[x] Cancel search: towingPage 295 of 356
Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
294 Vehicle Care
Caution
Do not tow this vehicle with two
wheels on the ground, or vehicle
damage could occur. This
damage would not be covered by
the vehicle warranty.
The vehicle was neither designed
nor intended to be towed with any of
its wheels on the ground. If the
vehicle must be towed, see Towing
the Vehicle 0291.
Appearance Care
Exterior Care
Locks
Locks are lubricated at the factory.
Use a de-icing agent only when
absolutely necessary, and have the
locks greased after using. See
Recommended Fluids and
Lubricants 0313.
Washing the Vehicle
To preserve the vehicle's finish,
wash it often and out of direct
sunlight.
Caution
Do not use petroleum-based,
acidic, or abrasive cleaning
agents as they can damage the
vehicle's paint, metal, or plastic
parts. If damage occurs, it would
not be covered by the vehicle
warranty. Approved cleaning
products can be obtained from
(Continued)
Caution (Continued)
your dealer. Follow all
manufacturer directions regarding
correct product usage, necessary
safety precautions, and
appropriate disposal of any
vehicle care product.
Caution
Avoid using high-pressure
washes closer than 30 cm (12 in)
to the surface of the vehicle. Use
of power washers exceeding
8 274 kPa (1,200 psi) can result
in damage or removal of paint
and decals.
Caution
Do not power wash any
component under the hood that
has this
esymbol.
(Continued)
Page 305 of 356
Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
304 Service and Maintenance
Caution (Continued)
approved by GM could damage
the vehicle, requiring expensive
repairs that are not covered by
the vehicle warranty.
The Tire Rotation and Required
Services are the responsibility of the
vehicle owner. It is recommended to
have your dealer perform these
services every 12 000 km/7,500 mi.
Proper vehicle maintenance helps to
keep the vehicle in good working
condition, improves fuel economy,
and reduces vehicle emissions.
Because of the way people use
vehicles, maintenance needs vary.
There may need to be more
frequent checks and services. The
Additional Required Services -
Normal are for vehicles that:
. Carry passengers and cargo
within recommended limits on
the Tire and Loading Information
label. See Vehicle Load Limits
0 158. .
Are driven on reasonable road
surfaces within legal driving
limits.
. Use the recommended fuel. See
Recommended Fuel 0192.
Refer to the information in the
Maintenance Schedule Additional
Required Services - Normal chart.
The Additional Required Services -
Severe are for vehicles that are:
. Mainly driven in heavy city traffic
in hot weather
. Mainly driven in hilly or
mountainous terrain
. Frequently towing a trailer
. Used for high speed or
competitive driving
. Used for taxi, police, or delivery
service
Refer to the information in the
Maintenance Schedule Additional
Required Services - Severe chart.
{Warning
Performing maintenance work can
be dangerous and can cause
serious injury. Perform
maintenance work only if the
required information, proper tools,
and equipment are available.
If they are not, see your dealer to
have a trained technician do the
work. See Doing Your Own
Service Work 0216.
Page 327 of 356
Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
326 Customer Information
.Lock-Out Service: Service to
unlock the vehicle if you are
locked out. A remote unlock may
be available if you have OnStar.
For security reasons, the driver
must present identification
before this service is given.
. Emergency Tow from a Public
Road or Highway: Tow to the
nearest Chevrolet dealer for
warranty service, or if the vehicle
was in a crash and cannot be
driven. Assistance is not given
when the vehicle is stuck in the
sand, mud, or snow.
. Flat Tire Change: Service to
change a flat tire with the spare
tire. The spare tire, if equipped,
must be in good condition and
properly inflated. It is the owner's
responsibility for the repair or
replacement of the tire if it is not
covered by the warranty.
. Battery Jump Start: Service to
jump start a dead battery.
. Trip Interruption Benefits and
Assistance: If your trip is
interrupted due to a warranty
event, incidental expenses may be reimbursed within the
Powertrain warranty period.
Items considered are reasonable
and customary hotel, meals,
rental car, or a vehicle being
delivered back to the customer,
up to 500 miles.
Services Not Included in
Roadside Assistance
.
Impound towing caused by
violation of any laws
. Legal fines
. Mounting, dismounting,
or changing of snow tires,
chains, or other traction devices
Service is not provided if a vehicle
is in an area that is not accessible
to the service vehicle or is not a
regularly traveled or maintained
public road, which includes ice and
winter roads. Off-road use is not
covered.
Services Specific to
Canadian-Purchased Vehicles
. Fuel Delivery: Reimbursement
is up to 7 liters. If available,
diesel fuel delivery may be restricted. Propane and other
fuels are not provided through
this service.
. Lock-Out Service: Vehicle
registration is required.
. Trip Interruption Benefits and
Assistance: Must be over
150 km from where your trip was
started to qualify.
Pre-authorization, original
detailed receipts, and a copy of
the repair orders are required.
Once authorization has been
received, the Roadside
Assistance advisor will help to
make arrangements and explain
how to receive payment.
. Alternative Service: If
assistance cannot be provided
right away, the Roadside
Assistance advisor may give
permission to get local
emergency road service. You will
receive payment, up to $100,
after sending the original receipt
to Roadside Assistance.
Mechanical failures may be
covered, however any cost for
Page 330 of 356
Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Customer Information 329
collisions. Aftermarket parts are not
covered by the GM New Vehicle
Limited Warranty, and any vehicle
failure related to such parts is not
covered by that warranty.
Repair Facility
GM also recommends that you
choose a collision repair facility that
meets your needs before you ever
need collision repairs. Your dealer
may have a collision repair center
with GM-trained technicians and
state-of-the-art equipment, or be
able to recommend a collision repair
center that has GM-trained
technicians and comparable
equipment.
Insuring the Vehicle
Protect your investment in the GM
vehicle with comprehensive and
collision insurance coverage. There
are significant differences in the
quality of coverage afforded by
various insurance policy terms.
Many insurance policies provide
reduced protection to the GM
vehicle by limiting compensation for
damage repairs through the use ofaftermarket collision parts. Some
insurance companies will not
specify aftermarket collision parts.
When purchasing insurance, we
recommend that you ensure that the
vehicle will be repaired with GM
original equipment collision parts.
If such insurance coverage is not
available from your current
insurance carrier, consider switching
to another insurance carrier.
If the vehicle is leased, the leasing
company may require you to have
insurance that ensures repairs with
Genuine GM Original Equipment
Manufacturer (OEM) parts or
Genuine Manufacturer replacement
parts. Read the lease carefully, as
you may be charged at the end of
the lease for poor quality repairs.If a Crash Occurs
If there has been an injury, call
emergency services for help. Do not
leave the scene of a crash until all
matters have been taken care of.
Move the vehicle only if its position
puts you in danger, or you are
instructed to move it by a police
officer.Give only the necessary information
to police and other parties involved
in the crash.
For emergency towing see
Roadside Assistance Program
0
325.
Gather the following information:
. Driver name, address, and
telephone number
. Driver license number
. Owner name, address, and
telephone number
. Vehicle license plate number
. Vehicle make, model, and
model year
. Vehicle Identification
Number (VIN)
. Insurance company and policy
number
. General description of the
damage to the other vehicle
Choose a reputable repair facility
that uses quality replacement parts.
See “Collision Parts” earlier in this
section.
Page 347 of 356
Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
346 Index
Cigarette Lighter . . . . . . . . . . . . . . . . . 84
Circuit Breakers . . . . . . . . . . . . . . . . 249
CleaningExterior Care . . . . . . . . . . . . . . . . . 294
Interior Care . . . . . . . . . . . . . . . . . . 299
Climate Control Systems . . . . . . . 144 Air Conditioning . . . . . . . . . . . . . . 144
Heating . . . . . . . . . . . . . . . . . . . . . . . 144
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Rear Heating System . . . . . . . . . 146
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Cluster, Instrument . . . . . . . . . . . . . . 86
Collision Damage Repair . . . . . . . 328
Compartments
Storage . . . . . . . . . . . . . . . . . . . . . . . . . 76
Compass . . . . . . . . . . . . . . . . . . . . . . . . 81
Connected Services
Connections . . . . . . . . . . . . . . . . . . 342
Diagnostics . . . . . . . . . . . . . . . . . . . 343
Navigation . . . . . . . . . . . . . . . . . . . . 341
Connections
Connected Services . . . . . . . . . . 342
Control Traction and ElectronicStability . . . . . . . . . . . . . . . . . . . . . 178
Control of a Vehicle . . . . . . . . . . . . . 153
Convex Mirrors . . . . . . . . . . . . . . . . . . 21 Coolant
Engine Temperature Gauge . . . . 89
Cooling . . . . . . . . . . . . . . . . . . . . 144, 146
Cooling System . . . . . . . . . . . . . . . . . 230
Courtesy Transportation Program . . . . . . . . . . . . . . . . . . . . . . . 327
Cruise Control . . . . . . . . . . . . . . . . . . 180
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Customer Assistance . . . . . . . . . . . 324 Offices . . . . . . . . . . . . . . . . . . . . . . . . 323
Text Telephone (TTY)Users . . . . . . . . . . . . . . . . . . . . . . . 324
Customer Information Publications OrderingInformation . . . . . . . . . . . . . . . . . . 330
Customer Satisfaction
Procedure . . . . . . . . . . . . . . . . . . . . . 321
Cybersecurity . . . . . . . . . . . . . . . . . . . 333
D
Damage Repair, Collision . . . . . . . 328
Danger, Warning, and Caution . . . . 2
Data Collection Infotainment System . . . . . . . . . . 334
OnStar . . . . . . . . . . . . . . . . . . . . . . . 334
Data Recorders, Event . . . . . . . . . 333
Daytime Running
Lamps (DRL) . . . . . . . . . . . . . . . . . . 112 Defensive Driving . . . . . . . . . . . . . . . 152
Delayed Locking . . . . . . . . . . . . . . . . . 14
Devices
Auxiliary . . . . . . . . . . . . . . . . . . . . . . 131
Diagnostics Connected Services . . . . . . . . . . 343
Distracted Driving . . . . . . . . . . . . . . . 151
Dome Lamps . . . . . . . . . . . . . . . . . . . 114
Door
Cargo Door Relocking . . . . . . . . . . 14
Delayed Locking . . . . . . . . . . . . . . . . 14
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Power Locks . . . . . . . . . . . . . . . . . . . . 14
Rear Doors . . . . . . . . . . . . . . . . . . . . . 18
Side . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Sliding . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Drive Belt Routing, Engine . . . . . . 320
Driver Assistance Systems . . . . . 182
Driver Information Center (DIC) . . . . . . . . . . . . . . . . . . . 99
Driving
Better Fuel Economy . . . . . . . . . 151
Characteristics andTowing Tips . . . . . . . . . . . . . . . . . 196
Defensive . . . . . . . . . . . . . . . . . . . . . 152
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 152
Hill and Mountain Roads . . . . . . 156
If the Vehicle is Stuck . . . . . . . . . 158
Page 348 of 356
Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Index 347
Driving (cont'd)Loss of Control . . . . . . . . . . . . . . . 154
Off-Road Recovery . . . . . . . . . . . 154
Vehicle Load Limits . . . . . . . . . . . 158
Wet Roads . . . . . . . . . . . . . . . . . . . 155
Winter . . . . . . . . . . . . . . . . . . . . . . . . 156
Dual Tire
Rotation . . . . . . . . . . . . . . . . . . . . . . 270
E
E85 or FlexFuel . . . . . . . . . . . . . . . . 193
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 213
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 249
Floor Console Fuse Block . . . . 253
Fuses and Circuit Breakers . . . 249
Overload . . . . . . . . . . . . . . . . . . . . . 248
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 336
Engine
Air Cleaner/Filter . . . . . . . . . . . . . 229
Check Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . . 93
Compartment Overview . . . . . . . 218
Coolant Heater . . . . . . . . . . . . . . . 167
Coolant Temperature Gauge . . . . 89 Engine (cont'd)
Cooling System . . . . . . . . . . . . . . . 230
Drive Belt Routing . . . . . . . . . . . . 320
Exhaust . . . . . . . . . . . . . . . . . . . . . . 170
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 236
Oil Life System . . . . . . . . . . . . . . . 224
Oil Pressure Gauge . . . . . . . . . . . . 88
Oil Pressure Light . . . . . . . . . . . . . . 97
Overheating . . . . . . . . . . . . . . . . . . 235
Power Messages . . . . . . . . . . . . . 104
Running While Parked . . . . . . . . 171
Starting . . . . . . . . . . . . . . . . . . . . . . . 165
Enhanced Technology Glass . . . . 24
Entry Lighting . . . . . . . . . . . . . . . . . . . 115
Entry/Exit Lighting . . . . . . . . . . . . . . 115
Equipment, Towing . . . . . . . . . . . . . 208
Event Data Recorders . . . . . . . . . . 333
Exit Lighting . . . . . . . . . . . . . . . . . . . . 115
Extender, Seat Belt . . . . . . . . . . . . . . 42
Exterior Lamp Controls . . . . . . . . . 110
Exterior Lamps Off Reminder . . . 111
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 116
F
FanEngine . . . . . . . . . . . . . . . . . . . . . . . . 236
Fast Idle System . . . . . . . . . . . . . . . . 166 Filter,
Engine Air Cleaner . . . . . . . . . . . 229
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 111
Flashers, Hazard Warning . . . . . . 113
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 276 Changing . . . . . . . . . . . . . . . . . . . . . 278
FlexFuel
E85 . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 302
Fluid Automatic
Transmission . . . . . . . . . . . 225, 228
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 239
Power Steering . . . . . . . . . . . . . . . 237
Washer . . . . . . . . . . . . . . . . . . . . . . . 237
Folding Mirrors . . . . . . . . . . . . . . . . . . 22
Forward Collision Alert
(FCA) System . . . . . . . . . . . . . . . . . 186
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 331
Front Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . 27
Front Storage . . . . . . . . . . . . . . . . . . . . 76
Front Turn Signal Bulb Replacement . . . . . . . . . . . . 245
Fuel Additives . . . . . . . . . . . . . . . . . . . . . 192
Economy, Driving for Better . . . 151
Page 349 of 356
Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
348 Index
Fuel (cont'd)Filling a Portable Fuel
Container . . . . . . . . . . . . . . . . . . . 195
Filling the Tank . . . . . . . . . . . . . . . 194
Foreign Countries . . . . . . . . . . . . 192
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Low Fuel Warning Light . . . . . . . . . 98
Prohibited Fuels . . . . . . . . . . . . . . 192
Recommended . . . . . . . . . . . . . . . 192
Top Tier . . . . . . . . . . . . . . . . . . . . . . 191
Full-Size Spare Tire . . . . . . . . . . . . 287
Fuses Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 249
Floor Console Fuse Block . . . . 253
Fuses and Circuit Breakers . . . 249
G
Gauges Engine Coolant Temperature . . . 89
Engine Oil Pressure . . . . . . . . . . . . 88
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Odometer . . . . . . . . . . . . . . . . . . . . . . . 87
Speedometer . . . . . . . . . . . . . . . . . . . 87
Trip Odometer . . . . . . . . . . . . . . . . . . 87
Voltmeter . . . . . . . . . . . . . . . . . . . . . . . 90
Warning Lights andIndicators . . . . . . . . . . . . . . . . . . . . . 85 General Information
Service and Maintenance . . . . . 303
Towing . . . . . . . . . . . . . . . . . . . . . . . . 196
Vehicle Care . . . . . . . . . . . . . . . . . . 215
Glass, Enhanced Technology . . . . 24
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 325
H
Halogen Bulbs . . . . . . . . . . . . . . . . . . 245
Hazard Warning Flashers . . . . . . . 113
Head Restraints . . . . . . . . . . . . . . . . . 27
Headlamps
Aiming . . . . . . . . . . . . . . . . . . . . . . . . 245
Automatic . . . . . . . . . . . . . . . . . . . . . .112
Bulb Replacement . . . . . . . . . . . . 245
Daytime RunningLamps (DRL) . . . . . . . . . . . . . . . . .112
Flash-to-Pass . . . . . . . . . . . . . . . . . . 111
High-Beam On Light . . . . . . . . . . . . 98
High/Low Beam Changer . . . . . . 111
Heated Mirrors . . . . . . . . . . . . . . . . . . . 22
Heater Engine Coolant . . . . . . . . . . . . . . . 167
Heating . . . . . . . . . . . . . . . . . . . . 144, 146
High-Beam On Light . . . . . . . . . . . . . 98
Hill and Mountain Roads . . . . . . . . 156
Hill Start Assist (HSA) . . . . . . . . . . 177 Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . 217
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
How to Wear Seat Belts
Properly . . . . . . . . . . . . . . . . . . . . . . . . 34
HVAC . . . . . . . . . . . . . . . . . . . . . . 144, 146
I
Idle System Fast . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Ignition Positions . . . . . . . . . . . . . . . 163
Ignition Transmission Lock Check . . . . . . . . . . . . . . . . . . . . . . . . . 243
Immobilizer . . . . . . . . . . . . . . . . . . . . . . 20
Indicator Vehicle Ahead . . . . . . . . . . . . . . . . . . 96
Infants and Young Children, Restraints . . . . . . . . . . . . . . . . . . . . . . 57
Information Publication Ordering . . . . . . . . . . 330
Infotainment . . . . . . . . . . . . . . . . . . . . 117
Infotainment System . . . . . . . . . . . . 334
Instrument Cluster . . . . . . . . . . . . . . . 86
Instrument Panel Overview . . . . . . . 5
Interior Rearview Mirrors . . . . . . . . . 22
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 288
Page 352 of 356
Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Index 351
ProgramCourtesy Transportation . . . . . . 327
Prohibited Fuels . . . . . . . . . . . . . . . . 192
Proposition 65 Warning,
California . . . . . . . . . . . .215, 240, 288, Back Cover
Publication Ordering Information . . . . . . . . . . . . . . . . . . . . 330
R
Radio Frequency Statement . . . . 331
Radio Reception . . . . . . . . . . . . . . . . 125
RadiosAM-FM Radio . . . . . . . . . . . . . . . . . 123
Satellite . . . . . . . . . . . . . . . . . . . . . . . 124
Reading Lamps . . . . . . . . . . . . . . . . . 115
Rear Axle . . . . . . . . . . . . . . . . . . . . . . . 241
Locking . . . . . . . . . . . . . . . . . . . . . . . 180
Rear Climate Control System . . . 146
Rear Doors . . . . . . . . . . . . . . . . . . . . . . 18
Rear Heating System . . . . . . . . . . . 146
Rear Seats . . . . . . . . . . . . . . . . . . . . . . 29
Rear Vision Camera (RVC) . . . . . 184
Rear Windows . . . . . . . . . . . . . . . . . . . 25
Rearview Mirrors . . . . . . . . . . . . . . . . 22
Reclining Seatbacks . . . . . . . . . . . . . 28 Recommended
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 192
Recommended Fluids and Lubricants . . . . . . . . . . . . . . . . . . . . . 313
Records Maintenance . . . . . . . . . . . . . . . . . . 316
Recreational Vehicle Towing . . . . 292
Reimbursement Program,
GM Mobility . . . . . . . . . . . . . . . . . . . 325
Remote Keyless Entry (RKE) System . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Remote Vehicle Start . . . . . . . . . . . . 12
Replacement Parts Airbags . . . . . . . . . . . . . . . . . . . . . . . . . 55
Maintenance . . . . . . . . . . . . . . . . . . 314
Replacing Airbag System . . . . . . . . 55
Replacing LATCH System
Parts after a Crash . . . . . . . . . . . . . 70
Replacing Seat Belt System Parts after a Crash . . . . . . . . . . . . . 43
Reporting Safety Defects
Canadian Government . . . . . . . . 332
General Motors . . . . . . . . . . . . . . . 332
U.S. Government . . . . . . . . . . . . . 331
Restraints
Where to Put . . . . . . . . . . . . . . . . . . . 61
Retained Accessory Power (RAP) . . . . . . . . . . . . . . . . . . 167 Roads
Driving, Wet . . . . . . . . . . . . . . . . . . 155
Roadside Assistance Program . . . . . . . . . . . . . . . . . . . . . . . 325
Rotation, Tires . . . . . . . . . . . . . . . . . . 268
Routing, Engine Drive Belt . . . . . . 320
Running the Vehicle While Parked . . . . . . . . . . . . . . . . . . . . . . . . 171
S
Safety Defects ReportingCanadian Government . . . . . . . . 332
General Motors . . . . . . . . . . . . . . . 332
U.S. Government . . . . . . . . . . . . . 331
Safety Locks . . . . . . . . . . . . . . . . . 14, 15
Safety System Check . . . . . . . . . . . . 42
Satellite Radio . . . . . . . . . . . . . . . . . . 124
Scheduling Appointments . . . . . . . 327
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . 33 Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Extender . . . . . . . . . . . . . . . . . . . . . . . . 42
How to Wear Seat BeltsProperly . . . . . . . . . . . . . . . . . . . . . . . 34
Lap-Shoulder Belt . . . . . . . . . . . . . . 36
Reminders . . . . . . . . . . . . . . . . . . . . . . 90
Replacing after a Crash . . . . . . . . 43
Use During Pregnancy . . . . . . . . . . 41