2020.25 OPEL VIVARO C engine coolant

Vehicle care213● Open the bonnet, close all doorsand lock the vehicle.
● Disconnect the clamp from the negative terminal of the vehicle
battery. Note that all systems are
not functional, e.g. anti-theft
alarm system.
Putting back into operation
When the vehicle is to be put back into
operation:
● Connect the clamp to the negative terminal of the vehicle
battery. Initialize the power
windows 3 42.
● Check tyre pressure.
● Fill up the washer fluid reservoir.
● Check the engine oil level.
● Check the coolant level.
● Fit the number plates if necessary.End-of-life vehicle recovery
Information on end-of-life vehicle
recovery centres and the recycling of
end-of-life vehicles is available on our website, where legally required. Only
entrust this work to an authorised
recycling centre.Vehicle checks
Performing work9 Warning
Only perform engine compartment
checks when the ignition is off.
The cooling fan may start
operating even if the ignition is off.

Vehicle care215
Different dipsticks are used
depending on engine variant.
Pull out the dipstick, wipe it clean,
reinsert it fully, pull out and read the
engine oil level.
When the engine oil level has
dropped to the MIN mark, top up the
engine oil.
We recommend the use of the same
grade of engine oil that was used at
last change.
The engine oil level must not exceed the MAX mark on the dipstick.
Caution
Overfilled engine oil must be
drained or suctioned out. If the oil exceeds the maximum level, do
not start the vehicle and contact a
workshop.
Capacities 3 270.
Fit the cap on straight and tighten it.
Engine coolant The factory filled coolant provides
freeze protection down to approx.
-37 °C.
Caution
Only use approved antifreeze.
Coolant and antifreeze 3 262.
Coolant level
Caution
Too low a coolant level can cause engine damage.

216Vehicle care
If the cooling system is cold, the
coolant level should be above the
MIN mark. Top up if the level is low.
9Warning
Allow the engine to cool before
opening the cap. Carefully open
the cap, relieving the pressure
slowly.
To top up, use a 1:1 mixture of
released coolant concentrate mixed
with clean tap water. If no coolant
concentrate is available, use clean
tap water. Install the cap tightly. Have
the coolant concentration checked
and have the cause of the coolant
loss remedied by a workshop.
Washer fluid
Fill with clean water mixed with a
suitable quantity of approved
windscreen washer fluid which
contains antifreeze.
Caution
Only washer fluid with a sufficient
antifreeze concentration provides
protection at low temperatures or
a sudden drop in temperature.
Washer fluid 3 262.
Brakes In the event of minimum thickness of
the brake lining, a squealing noise
sounds during braking.
Continued driving is possible but
have the brake lining replaced as
soon as possible.
Once new brake linings are installed,
do not brake unnecessarily hard for
the first few journeys.
Brake fluid9 Warning
Brake fluid is poisonous and
corrosive. Avoid contact with eyes, skin, fabrics and painted surfaces.

262Service and maintenanceRecommended fluids,lubricants and parts
Recommended fluids and lubricants
Only use products that meet the
recommended specifications.9 Warning
Operating materials are
hazardous and could be
poisonous. Handle with care. Pay
attention to information given on
the containers.
Engine oil
Engine oil is identified by its quality
and its viscosity. Quality is more
important than viscosity when
selecting which engine oil to use. The oil quality ensures e.g. engine
cleanliness, wear protection and oil
aging control, whereas viscosity
grade gives information on the oil's
thickness over a temperature range.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 266.
Topping up engine oilCaution
In case of any spilled oil, wipe it up and dispose it properly.
Engine oils of different manufacturersand brands can be mixed as long as
they comply with the required engine
oil quality and viscosity.
Use of engine oils for all petrol
engines with only ACEA quality is
prohibited, since it can cause engine
damage under certain operating
conditions.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 266.
Additional engine oil additives
The use of additional engine oil
additives could cause damage and
invalidate the warranty.
Engine oil viscosity grades
The SAE viscosity grade gives
information of the thickness of the oil.
Multigrade oil is indicated by two
figures, e.g. SAE 5W-30. The first
figure, followed by a W, indicates the
low temperature viscosity and the
second figure the high temperature viscosity.
Select the appropriate viscosity grade depending on the minimum ambient
temperature 3 266.
All of the recommended viscosity
grades are suitable for high ambient
temperatures.
Coolant and antifreeze
Use only organic acid type-long life
coolant (LLC) antifreeze approved for
the vehicle. Consult a workshop.
The system is factory filled with
coolant designed for excellent
corrosion protection and frost
protection down to approx. -37 °C.
This concentration should be
maintained all year round. The use of additional coolant additives that
intend to give additional corrosion

281Climate control systems.............139
Clock............................................. 98
Control indicators........................ 110
Control of the vehicle .................153
Controls ........................................ 94
Convex shape .............................. 39
Coolant and antifreeze ...............262
Cornering lights .......................... 133
Cruise control ....................115, 174
Cupholders .................................. 78
Curtain airbag system .................. 65
D Danger, Warnings and Cautions ...4
Daytime running lights ...............133
Declaration of conformity ............273
DEF ............................................ 162
Deflation detection system .........114
Diesel exhaust fluid ....................162
Diesel fuel system bleeding .......219
Door open .................................. 116
Doors ...................................... 31, 33
Driver alert .................................. 201
Driver assistance systems ..........174
Driver Information Centre ...........116
Driving characteristics and towing tips .............................. 205
Driving hints ................................ 153E
Electric adjustment ......................39
Electrical system......................... 231
Electronic climate control system 143
Electronic driving programmes ..168
Electronic key system ...................24
Electronic Stability Control and Traction Control system ..113, 171
Emergency call ........................... 128
End-of-life vehicle recovery .......213
Engine compartment fuse box ...232
Engine coolant ........................... 215
Engine coolant temperature ......113
Engine coolant temperature gauge ..................................... 108
Engine data ............................... 268
Engine exhaust .......................... 161
Engine identification ...................265
Engine oil ................... 214, 262, 266
Engine oil level monitor ..............109
Engine oil pressure ....................114
Entry lighting .............................. 137
Event data recorders ..................275
Exhaust filter ....................... 113, 161
Exit lighting ................................ 137
Exterior care .............................. 253
Exterior light ............................... 115
Exterior lighting ....................13, 130
Exterior mirrors ............................. 39F
Fault ........................................... 168
Fixed air vents ........................... 150
Floor mats................................... 256
Folding front seat ..........................51
Folding mirrors ............................. 40
Folding tray .................................. 86
Forward collision alert................. 187
Front airbag system .....................64
Front fog lights ...........115, 134, 224
Front pedestrian protection ........191
Front seats.................................... 48
Front storage ................................ 79
Front turn lights .......................... 225
Fuel for diesel engines ..............203
Fuel gauge ................................. 107 Fuses ......................................... 231
G
Gauges ....................................... 105
Gear selection ........................... 166
Gear shifting ............................... 113
General information ...................205
Glass panel .................................. 46
Glovebox ..................................... 78
Glovebox cooler ......................... 150
H
Halogen headlights ....................220
Hand brake ................................. 170
Hazard warning flashers ............133