2019 VOLVO V60 fuel pump

7
SERVICE AND MAINTENANCE
Demanding driving
In demanding driving conditions, such as operating
the vehicle in hot weather, towing a trailer, or
driving for extended periods at higher altitudes
than normal, it may be advisable to switch to
higher octane fuel (91 or higher) or to change
gasoline brands to fully utilize your engine’s
capacity, and for the smoothest possible operation.
NOTE
When switching to higher octane fuel or
changing gasoline brands, it may be necessary
to fill the tank more than once before a
difference in engine operation is noticeable.Fuel FormulationsDo not use gasoline that contains lead as a knock
inhibitor, and do not use lead additives. Besides
damaging the exhaust emission control systems
on your vehicle, lead has been strongly linked to
certain forms of cancer.
Many fuels contain benzene as a solvent.
Unburned benzene has been strongly linked to
certain forms of cancer. If you live in an area where
you must fill your own gas tank, take precautions.
These may include:• standing upwind away from the filler nozzle
while refueling
• refueling only at gas stations with vapor
recovery systems that fully seal the mouth of
the filler neck during refueling
• wearing neoprene gloves while handling a fuel
filler nozzle.
Use of AdditivesWith the exception of gas line antifreeze during
winter months, do not add solvents, thickeners,
or other store-bought additives to your vehicle’s
fuel, cooling, or lubricating systems. Overuse may
damage your engine, and some of these additives
contain organically volatile chemicals. Do not
needlessly expose yourself to these chemicals.
WARNING
Never carry a cell phone that is switched
on while refueling your vehicle. If the phone
rings, this may cause a spark that could ignite
gasoline fumes, resulting in fire and injury.
WARNING
Carbon monoxide is a poisonous, colorless, and
odorless gas. It is present in all exhaust gases.
If you ever smell exhaust fumes inside the
vehicle, make sure the passenger compartment
is ventilated, and immediately return the
vehicle to a trained and qualified Volvo service
technician for correction.
Deposit control gasoline (detergent
additives)Volvo recommends the use of detergent gasoline
to control engine deposits. Detergent gasoline
is effective in keeping injectors and intake valves
clean. Consistent use of deposit control gasolines
will help ensure good drivability and fuel economy.
If you are not sure whether the gasoline contains
deposit control additives, check with the service
station operator.
NOTE
Volvo does not recommend the use of external
fuel injector cleaning systems.Unleaded fuelEach Volvo has a three-way catalytic converter
and must use only unleaded gasoline. U.S. and
Canadian regulations require that pumps delivering
unleaded gasoline be labeled “UNLEADED”. Only
these pumps have nozzles which fit your vehicle’s
filler inlet. It is unlawful to dispense leaded fuel
into a vehicle labeled “unleaded gasoline only”.
Leaded gasoline damages the threeway catalytic
converter and the heated oxygen sensor system.
Repeated use of leaded gasoline will lessen the
effectiveness of the emission control system and
could result in loss of emission warranty coverage.
State and local vehicle inspection programs will
make detection of misfueling easier, possibly
resulting in emission test failure for misfueled
vehicles.


8
SERVICE AND MAINTENANCE
NOTE
Some U.S. and Canadian gasolines contain
an octane enhancing additive called
methylcyclopentadienyl manganese tricarbonyl
(MMT). If such fuels are used, your Emission
Control System performance may be affected,
and the Check Engine Light (malfunction
indicator lamp) located on your instrument
panel may light. If this occurs, please return
your vehicle to an authorized Volvo retailer for
service.Gasoline containing alcohol and ethers
(oxygenated fuels)Some fuel suppliers sell gasoline containing
“oxygenates” which are usually alcohols or ethers.
In some areas, state or local laws require that the
service pump be marked indicating use of alcohols
or ethers. However, there are areas in which the
pumps are unmarked. If you are not sure whether
there is alcohol or ethers in the gasoline you buy,
check with the service station operator. To meet
seasonal air quality standards, some areas require
the use of “oxygenated” fuel.
Methanol
Do not use gasolines containing methanol (methyl
alcohol, wood alcohol). This practice can result in
vehicle performance deterioration and can damage critical parts in the fuel system. Such damage may
not be covered under the New Vehicle Limited
Warranty.
Volvo allows the use of the following “oxygenated”
fuels; however, the octane ratings listed in your
owner’s manual must still be met.
Alcohol – Ethanol
Fuels containing up to 10% ethanol by volume
may be used. Ethanol may also be referred to as
Ethyl alcohol, or “Gasohol.”
Ethers – MTBE
Fuels containing up to 15% MTBE may be used.
Engine oilThis vehicle comes from the factory with synthetic
oil.Oil specificationsFull synthetic engine oil meeting the minimum
ACEA A5/B5 must be used. Lower quality oils
may not offer the same fuel economy, engine
performance, or engine protection.
Volvo recommends:Oil additives must not be used. 

43
WARRANTY
bringing vehicle to any authorized Volvo retailer.
To the extent required by any federal, state, or
provincial law, whether statutory or common law, a
vehicle manufacturer shall be required to provide
a means for non-franchised repair facilities to
perform Emission Performance Warranty repairs.
However, to avoid delay and ensure proper
service, it is recommended that service under this
warranty be performed by an authorized Volvo
retailer.
When determining whether an owner has
complied with the written instructions for proper
maintenance and use, Volvo may require an
owner to submit evidence of compliance if it has
an objective reason for believing:
1. maintenance was not performed and,
2. that if not performed, it could be the cause
of the vehicle exceeding applicable emission
standards.
Failure to notify the owner of a decision to honor
or deny an Emission Performance Warranty claim
within thirty (30) days from the time the vehicle
is presented for repair shall result in the vehicle
manufacturer being responsible for repairing
the vehicle without charge to the vehicle owner,
unless such failure is attributable to the vehicle
owner or to events which are beyond the control
of the vehicle manufacturer or repair facility.
2019 Emission Warranty Parts List –
Federal – U.S. and CanadaThe following are some items covered by the
Emission Warranty for two (2) years or 24,000
miles/40,000 km, whichever occurs first. Volvo
has continued coverage on these items under
new car warranty to four (4) years or 50,000
miles/80,000 kilometers, whichever occurs first.
Components marked with one
“*” are covered
by the Long Term Warranty for eight (8) years
or 80,000 miles/130,000 km, whichever
occurs first. Hybrid components marked with
“**” are covered for eight (8) years or 100,000
miles/160,000 kilometers, whichever occurs first.
• Ambient Air Temperature Sensor
• Camshaft Position Sensor
• Capless Fuel Filler Pipe
• Catalytic Converter
“*”
• Charge Air Cooler
• Coolant Thermostat
• Crankshaft Position Sensor
• CVVT Solenoid Valve
• CVVT Timing Device
• Electronic Throttle Module (ETM)
• Engine Control Module Hardware
“*”
• Engine Control Module Software
• Engine Coolant Temperature Sensor
• EVAP Canister Purge Valve• EVAP Carbon Canister
• EVAP Hydrocarbon Scrubber
• EVAP Leakage Control Module (ELCM)
• EVAP Leakage Diagnostic Pump
• Filler Pipe
• Fuel High Pressure Sensor
• Fuel Injector
• Fuel Low Pressure Sensor
• Fuel Pump including Pressure Regulator
• Fuel Pump Electronic Module (PEM)
• Fuel Rail (including fuel pressure sensor)
• Fuel Tank
• Fuel Tank Isolation Valve (FTIV)
• Heated Oxygen Sensors
• High Pressure Fuel Pump
• Hybrid Powertrain Cooling (Radiator)
“**”
• Hybrid Cooling Battery-Radiator
“**”
• Hybrid Cooling Condenser including high
pressure sensor
“**”
• Hybrid Cooling Fan (engine cooling)
“**”
• Hybrid Cooling Fan (hybrid cooling circuit)
“**”
• Hybrid Cooling Pump
“**”
• Hybrid Cooling Temperature Sensor
“**”
• Hybrid Cooling Thermostat
“**”
• Hybrid Cooling Valve
“**”

* Covered by the Long Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.
** Hybrid components are covered for eight (8) years or 100,000 miles/160,000 kilometers, whichever occurs first.

52
WARRANTY2019 Model Year Emission Parts ListNon-hybrid models only
California, Connecticut, Delaware, Maine,
Massachusetts, Maryland, New Jersey, New York,
Oregon, Pennsylvania, Rhode Island, Vermont and
Washington The components listed in the chart below apply to
non-hybrid models and are covered by the Long
Term Defect and Performance Warranty for seven (7) years or 70,000 miles/113,000 kilometers,
whichever occurs first.
ENGINE VIN CODE NUMBER
A2 10 16 AC
Catalytic Converter
A
XXXX
Charge Air Cooler XXXX
CVVT Timing Device (Exhaust)XXXX
CVVT Timing Device (Inlet)XXXX
Electronic Throttle Module (ETM)XXXX
Engine Control Module
A
XXXX
Fuel Pump XXXX
Fuel Tank AssemblyXXXX
Transmission Control Module XXXX
Turbocharger XXXX
Supercharger X
Supercharger Bypass ValveX
A The Engine Control Module and Catalytic Converter are also covered by the 8-year or 80,000-mile Long Term Emissions Warranty. Please see the list in the article “2019 Emission Warranty Parts List –
Federal – U.S. and Canada” in this booklet.