2019 VOLVO S60 TWIN ENGINE open hood

MAINTENANCE AND SERVICE
568
Engine compartment overview
This overview shows some service-related com-ponents.
Some of the components included in the vehi-cle's electric drive system are located in theengine compartment. Exercise caution whenaccessing the engine compartment and onlytouch what is required for normal maintenance.

WARNING
Orange wiring may only be handled by quali-fied personnel.

WARNING
A number of electrical components in TwinEngine Plug-in Hybrid vehicles use high-volt-age current and can be extremely dangerousif handled incorrectly.
Do not touch anything that is not clearlydescribed in this Owner's Manual.
Be careful when checking/filling fluids inthe engine compartment.
The layout of the engine compartment may vary depend-ing on model and engine variant.
Coolant expansion tank
Brake fluid reservoir (located on the driver'sside)
Washer fluid filler pipe12
Fusebox
Air filter
Engine oil filler pipe
WARNING
Bear in mind that the cooling fan (located atthe front of the engine compartment behindthe radiator) may start or continue runningautomatically up to about 6 minutes after theengine is turned off.
Always entrust engine washing to a workshop– an authorized Volvo workshop is recom-mended. If the engine is hot, there is a risk offire.

WARNING
The ignition system works with extremely highand dangerous voltages. The vehicle electricalsystem should always be in ignition mode 0when work in being performed in the enginecompartment.
Do not touch any spark plugs or ignition coilswhen the vehicle electrical system is in igni-tion mode II or when the engine is warm.

Related information
Opening and closing the hood (p. 566)
Filling washer fluid (p. 609)
Refilling coolant (p. 571)
Fuses in the engine compartment (p. 582)
Checking and filling engine oil (p. 570)
Ignition modes (p. 395)
12Fill the washer fluid at regular intervals, e.g. when refueling.

SPECIFICATIONS
}}
613
Vehicle Emission Control Information. USmodels. Your Volvo is designed to meet all appli-cable emission standards, as evidenced by thecertification label on the underside of the hood.For further information regarding these regula-tions, please consult your Volvo retailer.
Vehicle Emission Control Information.Canadian models. Your Volvo is designed tomeet all applicable emission standards, as evi-denced by the certification label on the undersideof the hood. For further information regardingthese regulations, please consult your Volvoretailer.
Vehicle Identification Number (VIN). TheVIN plate is located on the top left surface of thedashboard. The Vehicle Identification Number(VIN) should always be quoted in all correspond-ence concerning your vehicle with the retailer andwhen ordering parts.
Tire inflation pressures. This label indicatesthe correct inflation pressures for the tires thatwere on the vehicle when it left the factory.
Federal Motor Vehicle Safety Standards(FMVSS) specifications (USA) and Ministry ofTransport (CMVSS) standards (Canada). YourVolvo is designed to meet all applicable safetystandards, as evidenced by the certification labelon the driver's side B-pillar (the structural mem-ber at the side of the vehicle, at the rear of thedriver's door opening). This label also includescodes for paint color, etc. For further informationregarding these regulations, please consult yourVolvo retailer. U.S. models have the upper decal;Canadian models have the lower one.

INDEX
630
Fuel 428
Travel Link service 468
Fuel filling 426
Fuel gauge 85
Fuel requirements 428, 429
Fuel tank
volume 622
Fuse box 580
Fuses 580
below the glove compartment 586
in engine compartment 582
in trunk 589
replacing 580
G
Gasoline grade428
Gauge
fuel gauge85
hybrid battery86
Gear selector positions
automatic transmission406
Glass, laminated/reinforced164
Glove compartment549
Gracenote®473
Grocery bag holders 553
Gross vehicle weight617
H
Handbrake400
Hand wash599
Hard disk
space500
Hazard warning flashers159
HD radio457
Headlamp beam
adjustment152
Headlight pattern, adjustment152
Head restraint191
Head-up display140
activating/deactivating141
cleaning594
Distance Alert270
replacing windshield566
settings142
store position142, 182, 183
Heated wiper blades174
Heater224
auxiliary heater224
parking heater224
Heating
Seats208, 209
steering wheel210
windows213
high beams154, 155
High engine temperature431
Hill Start Assist405
Hill Start Assist (HSA)405
Hoisting the vehicle564
Hold
vehicle function423
HomeLink®440
programming 441
type approval 443
use 442
HomeLink® remote control
programmable 440
Home safe lighting160
Honk192
Hood, opening566
Horn192
Hybrid battery578
Charging375
Hybrid battery gauge86
Hybrid gauge85
Hybrid mode412, 417