2019 VAUXHALL VIVARO spare wheel

Vehicle care195
3.Place lifting pad spigot of the jack
under the jacking hole located
nearest the wheel concerned.
Ensure the jack is positioned
correctly. The jack base must be
on the ground directly below the
jacking hole in a manner that
prevents it from slipping.
4. Install wrench onto the jack and raise the vehicle by turning the
wrench until the wheel is clear of
the ground.
5. Unscrew wheel bolts completely by turning anticlockwise and wipe
clean with a cloth.
Put wheel bolts somewhere
where the threads will not be
soiled.
6. Change the wheel. Spare wheel 3 195.
7. Screw in the wheel bolts.
8. Lower the vehicle and remove jack.
9. Tighten each of the wheel bolts in
a crosswise sequence using the
wheel wrench. Ensure the wrench is securely located. The wrench
should turn clockwise to tighten
the bolts. Invert the wrench if
necessary.
Tightening torque is 160 Nm.
10. Replace the wheel cover, ensuring that the valve hole in thewheel cover is aligned with the
tyre valve before installing.
Notice
If applicable, fit anti-theft bolts
nearest the tyre valve (otherwise it
may not be possible to refit the wheel
cover).11. Stow the replaced wheel 3 195
and the vehicle tools 3 185.
12. Have the new wheel balanced on the vehicle.
Check the tyre pressure of the
installed tyre 3 213.
Check the wheel bolt torque.
Have the defective tyre renewed or
repaired as soon as possible.
Spare wheel
Some vehicles are equipped with a tyre repair kit instead of a spare wheel
3 191.
The spare wheel can be classified as
a temporary spare wheel depending
on the size compared to the other
mounted wheels and country
regulations. In this case a permissible maximum speed applies, even
though no label at the spare wheel
indicates this.

196Vehicle careCaution
The use of a spare wheel that issmaller than the other wheels or in combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
It may be necessary to jack the
vehicle up to gain access to the spare
wheel on a fully loaded vehicle with a
flat rear tyre.
Wheel changing 3 194.
The spare wheel is mounted under
the rear underbody and may be
secured using a security bolt that can
only be removed using the wheel bolt sleeve supplied.
Vehicle tools 3 185.9 Warning
Due to the weight of the tyre
assembly, exercise caution when
releasing the spare wheel carrier.
Do not fully remove bolt 1.
Support the spare wheel with a
suitable object to prevent the
wheel falling suddenly when
loosening the carrier bolts - risk of injury!
To release the spare wheel carrier,fully remove bolt 2 then loosen bolt 1,
ensuring it is not fully removed. Then
move the spare wheel carrier up and
down and from side to side, until it
clears bolt 1, and lower the carrier
assembly.
When installing the wheel ensure that
the spare wheel carrier is correctly
positioned before tightening the bolts.
Summer and winter tyres
If you use winter tyres, the spare
wheel may still be fitted with a
summer tyre.
If you use the spare wheel when it is
fitted with a summer tyre the vehicle's driveability may be affected,
especially on slippery road surfaces.
Directional tyres
Fit directional tyres such that they roll in the direction of travel. The rolling
direction is indicated by a symbol
(e.g. an arrow) on the sidewall.
The following applies to tyres fitted
opposing the rolling direction:
● Driveability may be affected. Have the defective tyre renewed
or repaired as soon as possible
and fit it instead of the spare
wheel.
● Do not drive faster than 50 mph.
● Drive particularly carefully on wet
and snow-covered road
surfaces.

226Recommended fluids andlubricants ........................ 204, 208
Refuelling ................................... 160 Registered trademarks ...............218
Remote control ............................. 20
Restraining lattice .........................79
Reversing light ........................... 178
Reversing lights .........................112
Ride control systems ..................148
Roof load ...................................... 80
Roof rack ..................................... 80
S Safety belts ................................... 53
Safety net .................................... 78
Seat adjustment ....................... 7, 46 Seat belt ........................................ 8
Seat belt reminder .......................96
Seat belts ..................................... 53
Seat folding .................................. 48
Seat heating ................................. 48
Seat position ................................ 45
Seats ............................................ 74
Selective catalytic reduction .......140
Service ............................... 128, 203
Service display ............................ 92
Service information ....................203
Service vehicle soon .................... 97
Side airbag system ......................61
Sidelights .................................... 108Side turn lights ........................... 177
Sliding door .................................. 31
Sliding side door ........................... 31
Spare wheel ............................... 195
Spare wheel security tool ...........185
Speed limiter ................89, 101, 153
Speedometer ............................... 89
Starting and operating ................131
Starting off ................................... 17
Starting the engine ...............17, 133
Steering ...................................... 130
Steering column controls ..............83
Steering wheel adjustment ......9, 83
Steering wheel controls ...............83
Stop engine .................................. 97
Stop-start system.......... 17, 100, 135
Storage ......................................... 71
Storage box .................................. 74
Storage compartment ...................73
Storage compartments .................71
Sun visors .................................... 43
Symbols ......................................... 4
T
Tablet holder................................. 71
Tachograph ........................ 101, 106
Tachometer ................................. 90
Tailgate ......................................... 33
Tailgate emergency release .........33
Tail lights ................................... 176Temporary spare wheel ..............195
Three-point seat belt .................... 54
Toll road stickers .......................... 41
Tools .......................................... 185
Top-Tether .................................... 64
Torx key ...................................... 185
Touchscreen ............................... 102
Tow bar....................................... 162
Towing ................................ 162, 198
Towing another vehicle .............199
Towing a trailer ........................... 162
Towing eye ......................... 185, 198
Towing the vehicle .....................198
Traction Control system ............. 148
Trailer coupling ........................... 162
Trailer stability assist .................163
Trailer towing ............................. 162
Transmission ............................... 16
Tread depth ............................... 189
Trip computer ............................ 104
Trip odometer .............................. 90
Turbo engine warm-up ...............133
Turn lights ............................ 95, 111
Tyre chains ................................ 190
Tyre changing ............................. 194
Tyre designations ......................186
Tyre pressure ............................ 186
Tyre pressure monitoring system ............................... 99, 188
Tyre pressures ........................... 213