2019 VAUXHALL MOVANO_B suspension

212Vehicle carenot be driven. Seek the
assistance of a workshop.
21. Stow tyre repair kit under the front
seat.
Notice
The driving characteristics of the repaired tyre are severely affected,
therefore have this tyre replaced.
If unusual noise is heard or the
compressor becomes hot, turn
compressor off for at least
30 minutes.
The built-in safety valve opens at a
pressure of 7 bar (102 psi).
Note the expiry date of the kit. After
this date its sealing capability is no
longer guaranteed. Pay attention to
storage information on sealant
bottle.
Replace the used sealant bottle. Dispose of the bottle as prescribed
by applicable laws.
The compressor and sealant can be
used from approx. -30 °C.Wheel changing
Make the following preparations and
observe the following information:
● Park the vehicle on a level, firm and non-slippery surface. The
front wheels must be in the
straight-ahead position.
● Apply the parking brake and engage first gear or reverse gear
(manual transmission) or N
(manual transmission
automated).
● Switch off the air suspension system 3 142.
● Remove the spare wheel 3 214.
● Never change more than one wheel at a time.
● Use the jack only to change wheels in case of puncture, not
for seasonal winter or summer
tyre change.
● The jack is maintenance-free.
● If the ground on which the vehicle
is standing is soft, a solid board
(max. 1 cm thick) should be
placed under the jack.● No people or animals may be in the vehicle when it is jacked-up.
● Never crawl under a jacked-up vehicle.
● Do not start the engine when the vehicle is raised on the jack.
● Clean wheel bolts / nuts and their
threads before mounting the wheel.9 Warning
Do not grease wheel bolt, wheel
nut and wheel nut cone.
1. Remove the wheel cover using the hook supplied.
Vehicle tools 3 203.
Depending on vehicle, first
remove the bolt / nut covers by
hand then remove the wheel
cover, or press wheel cover at the points indicated by the arrows and
turn to release.
Rear-wheel drive, with twin rear
wheels: Remove the tyre valve
extender from the inner rear
wheel.

Vehicle care217Jump starting
The jump start terminal is located in
the engine compartment.
A vehicle with a discharged vehicle
battery can be started using jump
leads and the vehicle battery of
another vehicle.
Do not start with a quick charger.9 Warning
Be extremely careful when starting
with jump leads. Any deviation
from the following instructions can
lead to injuries or damage caused
by battery explosion or damage to the electrical systems of both
vehicles.
9 Warning
Avoid contact of the battery with
eyes, skin, fabrics and painted
surfaces. The fluid contains
sulphuric acid which can cause
injuries and damage in the event
of direct contact.
Caution
The air suspension system must
be switched off prior to jump
starting.
Air suspension 3 142.
● Never expose the vehicle battery
to naked flames or sparks.
● A discharged vehicle battery can already freeze at a temperature
of 0 °C. Defrost the frozen vehicle
battery before connecting jump leads.
● Wear eye protection and protective clothing when
handling a vehicle battery.
● Use a booster battery with the same voltage (12 V). Its capacity(Ah) must not be much less than
that of the discharged vehicle
battery.
● Use jump leads with insulated terminals and a cross section of
at least 25 mm 2
.
● Do not disconnect the discharged
battery from the vehicle.
● Switch off all unnecessary electrical consumers.
● Switch off the air suspension system 3 142.
● Do not lean over the vehicle battery during jump starting.
● Do not allow the terminals of one
lead to touch those of the other
lead.
● The vehicles must not come into contact with each other during
the jump starting process.
● Apply the parking brake and engage neutral (manual
transmission) or N (manual
transmission automated).

Vehicle care219far away from the discharged
vehicle battery as possible,
however at least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump start.
2. After 5 minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of
1 minute.
3. Allow both engines to idle for approx. 3 minutes with the leads
connected.
4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle The towing eye and wheel wrench are
stowed with the vehicle tools 3 203.
Disengage the cover using a suitable
tool and remove.
Screw the towing eye clockwise into
the front towing point and tighten fully using the wheel wrench.
Attach a tow rope – or better still a tow
rod – to the towing eye, never to the
bumper or front suspension units.
Caution
Do not tow the vehicle from the
rear. The front towing eye must
only be used for towing and not
recovering a vehicle.
Switch on ignition to permit operation
of brake lights, horn and windscreen
wipers, and move the steering wheel
slightly to release the steering wheel
lock.
Switch off the air suspension system 3 142.
Caution
Deactivate the driver assistance
systems like active emergency
braking 3 165, otherwise the
vehicle may automatically brake during towing.
Move the selector lever to neutral.
Release the parking brake.

220Vehicle careCaution
Vehicles with manual
transmission automated: If neutral cannot be selected, the vehiclemust only be towed with the drive
wheels raised off the ground.
The vehicle should always be
towed with the ignition switched
off.
Manual transmission automated
3 152.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust fumes
from the towing vehicle, switch on the air recirculation system 3 119 and
close the windows.
Seek the assistance of a workshop.
After towing, unscrew the towing eye
and refit the cover.
Towing another vehicle
Attach a tow rope – or better still a tow
rod – to the rear towing eye, never to
the rear axle and suspension units.
Caution
The rear towing eye must only be
used for towing and not recovering a vehicle.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.

240IndexAAbsorptive Glass Mat battery .....185
Accessories and vehicle modifications .......................... 179
Active emergency braking ..103, 165
AdBlue ........................ 101, 145, 225
AdBlue gauge ............................... 93
AdBlue tank ................................ 229
Adjustable air vents ...................131
Airbag and belt tensioners ...........98
Airbag deactivation ................63, 98
Airbag label................................... 59 Airbag system .............................. 59
Air conditioning regular operation ................................ 132
Air conditioning system .............. 119
Air intake .................................... 132
Air suspension ........................... 142
Air suspension system................ 219
Air vents...................................... 131
Antifreeze ................................... 183
Antilock brake system ................ 156
Antilock brake system (ABS) .....100
Anti-theft alarm system ................36
Anti-theft bolts............................. 212
Anti-theft locking system .............. 35
Anti-theft security lock ..................23
Appearance care ........................221
Armrest ........................................ 51
Ashtrays ....................................... 91Automatic light control ...............110
Automatic locking ...................24, 29
Autostop ....................... 17, 137, 138
Auxiliary heater ........................... 125
B Battery .................... 21, 22, 125, 185
Battery discharge protection ......117
Battery, jump starting.................. 217
Belts.............................................. 55
Bonnet ....................................... 180
Bottle holders................................ 75
Brake assist ............................... 158
Brake fluid .......................... 185, 225
Brakes ............................... 156, 185
Brake system ............................. 100
Breakdown.................................. 219
Bulb replacement ....................... 189
Bus Rear seats ................................. 52
C
Cabin bulkhead grille ....................81
Capacities .................................. 229
Cargo management system ........78
Car Pass ...................................... 21
Catalytic converter .....................144
Central locking system ................24
Centre high-mounted brake light 195
Changing tyre and wheel size ...208
Charging system .......................... 99

244Reversing lights .........................114
Ride control systems ..........158, 161
Ride height ................................. 142
Roof .............................................. 44
Glass panel ............................... 44
Roof load ...................................... 83
Roof rack ..................................... 83
S Safety belts ................................... 55
Safety net .................................... 81
Seat adjustment ....................... 7, 47
Seat belt ........................................ 8
Seat belt reminder .......................98
Seat belts ..................................... 55 Seat heating ................................. 52
Seat position ................................ 46
Selective catalytic reduction .......145
Selector lever ............................. 153
Service ............................... 132, 224
Service display ......................94, 99
Service information ....................224
Service vehicle soon .................... 99
Side airbag system ......................63
Sidelights .................................... 110
Side turn lights ........................... 195
Side windows................................ 42
Sliding door .................................. 30
Sliding side door ........................... 30
Spare wheel ............................... 214Speed limiter ................91, 104, 163
Speedometer ............................... 91
Starting and operating ................136
Starting off ................................... 17
Starting the engine .......17, 137, 153
Steering ...................................... 135
Steering column controls ..............86
Steering wheel adjustment ....10, 86
Steering wheel controls ...............86
Stop engine ................................ 100
Stop-start system.......... 17, 103, 138
Storage ......................................... 74
Storage compartments .................74
Storage net ............................. 75, 76
Sun visors .................................... 44
Suspension height ......................142
Suspension seat ........................... 47
Swivelling shelf ............................. 75
Symbols ......................................... 4
T Tachograph ........................ 104, 109
Tachometer ................................. 92
Tail lights ................................... 193
Three-point seat belt .................... 56
Tools .......................................... 203
Top-Tether .................................... 65
Touchscreen ............................... 105
Tow bar....................................... 175
Towing ........................................ 175Towing another vehicle .............220
Towing a trailer ........................... 175
Towing equipment .....................176
Towing eye ................................. 219
Towing the vehicle .....................219
Traction Control system ............. 158
Trailer coupling ........................... 175
Trailer stability assist .................176
Trailer towing ............................. 175
Transmission ............................... 17
Transmission display ...........95, 152
Tread depth ............................... 207
Trip computer ............................ 107
Trip odometer .............................. 92
Turbo engine warm-up ...............137
Turn lights ............................ 98, 113
Tyre chains ................................ 208
Tyre changing ............................. 212
Tyre designations ......................204
Tyre pressure ............................ 204
Tyre pressure monitoring system ............................. 102, 205
Tyre pressures ........................... 230
Tyre repair kit ............................. 209
Tyres .......................................... 204
Tyres and wheel size, changing. 208
U
Ultrasonic parking assist............. 167
Underseat storage .......................76