2019 TOYOTA GT86 transmission

13Your Warranties in Detail
WARRANTY
NEW VEHICLE LIMITED WARRANTY
WHAT IS COVERED
AND HOW LONG
Basic Warranty
This warranty covers repairs and
adjustments needed to correct defects
in materials or workmanship of any
part supplied by Toyota, subject to the
exceptions indicated under “What
Is Not Covered” on pages 14–15.
Coverage is for 36 months or 36,000 miles,
whichever occurs rst, with the exception of
wheel alignment and wheel balancing, which
are covered for 12 months or 12,000 miles,
whichever occurs rst.
Powertrain Warranty
This warranty covers repairs needed to
correct defects in materials or workmanship
of any component listed below and in the
next column and supplied by Toyota, subject
to the exceptions indicated under “What Is
Not Covered” on pages 14–15.
Coverage is for 60 months or 60,000 miles,
whichever occurs rst.
Engine
Cylinder block and head and all internal
parts, timing gears and gaskets, timing
chain/belt and cover, ywheel, valve
covers, oil pan, oil pump, engine mounts,
turbocharger housing and all internal parts,
supercharger housing and all internal
parts, engine control computer, water
pump, fuel pump, seals and gaskets.
Transmission and Transaxle
Case and all internal parts, torque

converter, clutch cover, transmission
mounts, transfer case and all internal
parts, engine control computer, seals
and gaskets.
Front-Wheel-Drive System
Final drive housing and all internal parts,
axle shafts, drive shafts, constant velocity
joints, front hub and bearings, seals
and gaskets.
Rear-Wheel-Drive System
A xle housing and all internal parts,
propeller shafts, U-joints, axle shafts,
drive shafts, bearings, supports, seals
and gaskets.
Restraint Systems Warranty
This warranty covers repairs needed to
correct defects in materials or workmanship
of any seatbelt or air bag system supplied by
Toyota, subject to the exceptions indicated
under “What Is Not Covered” on pages 14–15.
Coverage is for 60 months or 60,000 miles,
whichever occurs rst.
For vehicles sold and registered in the
state of Kansas, the warranty for seatbelts
and related components is 10 years,
regardless of mileage.

25Your Warranties in Detail
WARRANTY
CALIFORNIA EMISSION CONTROL WARRANTY
WHAT IS NOT COVERED
These warranty obligations do not apply
to failures or noncompliance caused by:
• The use of replacement parts not
certified in accordance with aftermarket
parts certification regulations.
• The use of replacement parts not
equivalent in quality or design to
original equipment parts.
Provisions under the “What Is Not Covered”
section of the New Vehicle Limited Warranty
also apply to this warranty.
PARTS LIST:
LONG-TERM EMISSION
DEFECT WARRANTY
The parts listed here are covered for seven
years or 70,000 miles from the vehicle’s
in-service date, whichever occurs rst.
Air/Fuel Metering System
• Engine control computer (engine
control module)
• Fuel pump (high pressure and
low pressure)
• Injector
• Neutral start switch
• Throttle body
• Transmission control computer
(transmission control module)
Air Induction System
• Intake manifold
Catalyst System
• Exhaust front pipe (including
catalytic converter)
• Exhaust manifold (including
manifold converter)
Evaporative Control System
• Charcoal canister
• Check valve
• Fuel tank
† Covered under the Hybrid System Warranty for eight years or 100,000 miles, whichever occurs first.

37Maintenance Log
MAINTENANCE
SCHEDULED MAINTENANCE
Driving on dirt
or dusty roads
Driving on dirt
or dusty roads
Automatic transmission uid
Brake uid
Brake lines and hoses
Brake pads and discs
Cabin air lter Bolts and nuts
on chassis
Normal Normal Normal
Normal Severe
Severe SevereMiles (000)
Month
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
When operating in high humidity areas or in mountainous areas, replace e\
very 15,000 miles or
15 month, whichever occurs rst.
When operating in areas where road salts or other corrosive materials ar\
e used; if living in coastal areas,
inspect every 7,500 miles or 7.5 months, whichever occurs rst.
Note: Driving in heavy trafc, on dirt roads or in urban, dusty or de\
sert areas may shorten the life of the cabin air lter.
Replacement may be needed if you notice reduced airow from the air c\
onditioner and heater or if the windows fog
easily when you use the “fresh” mode. Consult your dealer if any o\
f these conditions occur.After the described period, continue to follow the described maintenance\
at the recommended intervals. I = Inspect; R = Replace, Change, Rotate Tires or Lubricate; T = Tighten\
to Specied Torque
Maintenance Item
I IIRII
I I
I II
I
I
I
I II I
R R
R R
R
R
R R
R
Repeated short driving distance; driving on rough and/or muddy roads; dr\
iving in areas where
road salts or other corrosive materials are used; if living in coastal a\
reas, inspect every
7,500 miles or 7.5 months, whichever occurs rst.
T T T T T T T T T T T T
Maintenance Interval (Miles or Number of Months, Whichever Occurs First\
)

39Maintenance Log
MAINTENANCE
SCHEDULED MAINTENANCE
Exhaust pipes and mountings
Fuel lines and
connections,
fuel tank
vapor vent system hoses
and fuel tank
band
Fuel lter
Fuel tank cap gasket
Manual transmission oil
Parking brake lining
and drums
Rear differential oil
Spark plugs Driver’s oor mat proper installation
Normal Normal
Severe Normal
SevereMiles (000)
Month
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90
Maintenance Item
IIIIII
I II
I
II
I II
R
R
I
I I
When operating in areas where road salts or other corrosive materials ar\
e used; if living in coastal areas,
inspect every 7,500 miles or 7.5 months, whichever occurs rst.
When operating in areas where road salts or other corrosive materials ar\
e used; if living in coastal areas,
inspect every 7,500 miles or 7.5 months, whichever occurs rst.
Note: When operating the vehicle in extremely cold or hot weather condit\
ions, contamination of the lter may occur andlter replacement should be performed more often.
I
I
I
I
I
I I
I I
IIIIIIIII
After the described period, continue to follow the described maintenance\
at the recommended intervals.
I = Inspect; R = Replace, Change, Rotate Tires or Lubricate; T = Tighten\
to Specied Torque
Maintenance Interval (Miles or Number of Months, Whichever Occurs First\
)

41Maintenance Log
MAINTENANCE
EXPLANATION OF MAINTENANCE ITEMS
T
he following descriptions are
provided to give you a better
understanding of the maintenance
items that should be performed on your
vehicle. The scheduled maintenance log
indicates at which mileage/time intervals
each item should be performed. Please
note that many maintenance items should
be performed only by a qualied technician.
For further information on maintenance
items you can perform yourself, see
the “Maintenance and Care” and
“Do-It-Yourself Maintenance” sections
of the Owner’s Manual .
Automatic Transmission Fluid or
Manual Transmission Oil
Inspect or replace at specied intervals.
When performing inspections, check each
component for signs of leakage. If you
discover any leakage, have it repaired by
a qualied technician immediately.
Ball Joints and Dust Covers
Check the suspension and steering
linkage ball joints for looseness and
damage. Check all dust covers for
deterioration and damage. Replace
any deteriorated or damaged parts.
A qualied technician should perform
these operations.
Brake Lines and Hoses
Visually inspect for proper installation.
Check for chang, cracks, deterioration
and signs of leakage. Replace any
deteriorated or damaged parts. A qualied
technician should perform these operations.
Brake Linings/Drums and
Brake Pads/Discs
Check the brake linings (shoes) and
drums for scoring, burning, uid leakage,
broken parts and excessive wear. Check
the pads for excessive wear and the discs
for runout, excessive wear and uid
leakage. Replace any deteriorated or
damaged parts. A qualied technician
should perform these operations.
Cabin Air Filter
Replace at specied intervals. Driving in
heavy trafc, on dirt roads or in urban,
desert or dusty areas may shorten lter’s
life. More frequent replacement may
be necessary.
Differential Oil
Inspect at specied intervals. When
performing inspections, check each
component for signs of leakage. If you
discover any leakage, have it repaired
by a qualied technician immediately.
Drive Belts
Inspect for cracks, excessive wear and
oiliness. Check the belt tension and adjust
if necessary. Replace the belts if they
are damaged.