2019 TOYOTA AYGO air condition

4418-2. Steps to take in an emergency
8
When trouble arises
AYGO_OM_Europe_OM99R19E
WARNING
■Driving to spread the liquid sealant evenly
Observe the following precautions to reduce the risk of accidents.
Failure to do so may result in a loss of vehicle control and cause death or
serious injury.
● Drive the vehicle carefully at a low speed. Be especially careful when turn-
ing and cornering.
● If the vehicle does not drive straight or you feel a pull through the steering
wheel, stop the vehicle and check the following:
• Tire condition. The tire may have separated from the wheel.
• Tire inflation pressure. If tire inflation pressure is 130 kPa (1.3 kgf/cm2
or bar, 19 psi) or less, the tire may be severely damaged.
NOTICE
■ When performing an emergency repair
● A tire should only be repaired with the emergency tire puncture repair kit if
the damage is caused by a sharp object such as nail or screw passing
through the tire tread.
Do not remove the sharp object from the tire. Removing the object may
widen the opening and disenable emergenc y repair with the repair kit.
● The repair kit is not waterproof. Make sure that the repair kit is not
exposed to water, such as when it is being used in the rain.
● Do not put the repair kit directly onto dusty ground such as sand at the
side of the road. If the repair kit vacuums up dust etc., a malfunction may
occur.
● Do not turn the bottle upside down when using it, as doing so may cause
damage to the compressor.
■ Handling the emergency tire puncture repair kit
● The repair kit power source should be 12 V DC suitable for vehicle use. Do
not connect the repair kit to any other source.
● If gasoline splatters on the repair kit, the repair kit may deteriorate. Take
care not to allow gasoline to contact it.
● Place the repair kit in a storage to prevent it from being exposed to dirt or
water.
● Store the repair kit in the luggage compartment out of reach of children.
● Do not disassemble or modify the repair kit. Do not subject parts such as
the air pressure gauge to impacts. This may cause a malfunction.

4658-2. Steps to take in an emergency
8
When trouble arises
AYGO_OM_Europe_OM99R19E
If your vehicle overheats
●The high engine coolant temperature warning light (P. 417) comes
on or flashes, or a loss of engine power is experienced. (For exam-
ple, the vehicle speed does not increase.)
● Steam comes out from under the hood.
Stop the vehicle in a safe place and turn off the air conditioning sys-
tem, and then stop the engine.
If you see steam:
Carefully lift the hood after the steam subsides.
If you do not see steam:
Carefully lift the hood.
After the engine has cooled
down sufficiently, inspect the
hoses and radiator core (radia-
tor) for any leaks.
Radiator
Cooling fan
If a large amount of coolant
leaks, immediately contact any
authorized Toyota retailer or
Toyota authorized repairer, or
any reliable repairer.
The following may indicate that your vehicle is overheating.
Correction procedures
1
2

4668-2. Steps to take in an emergency
AYGO_OM_Europe_OM99R19E
The coolant level is satisfactory if it is between the “FULL” or “F”
and “LOW” lines on the reservoir.
Radiator cap
Reservoir
“FULL” or “F”
“LOW”
Add coolant if necessary.
Water can be used in an emer-
gency if coolant is unavailable.
Start the engine and turn the air conditioning system on to check
that the radiator cooling fan operate and to check for coolant leaks
from the radiator or hoses.
The fan operate when the air conditioning system is turned on immediately
after a cold start. Confirm that the fan is operating by checking the fan
sound and air flow. If it is difficult to check these, turn the air conditioning
system on and off repeatedly. (The fan may not operate in freezing tem-
peratures.)
Ty pe ATy pe B
1
2
3
4

4799-1. Specifications
9
Vehicle specifications
AYGO_OM_Europe_OM99R19E
Manual transmission (including front differential)
Gear oil capacity (Reference)1.7 L (1.8 qt., 1.5 Imp.qt.)
Gear oil type“TOYOTA Genuine Manual Transmission
Gear Oil LV GL-4 75W” or equivalent
NOTICE
■ Manual transmission gear oil
● Please be aware that depending on the particular characteristics of the
gear oil used or the operating conditions, idle sound, shift feeling and/or
fuel efficiency may be different or affected and, in the worst case, damage
to the vehicle’s transmission. Toyota recommends to use “TOYOTA Genu-
ine Manual Transmission Gear Oil LV GL-4 75W” to achieve optimal per-
formance.
● Your Toyota vehicle is filled with “TOYOTA Genuine Manual Transmission
Gear Oil LV GL-4 75W” at the factory. Use Toyota approved “TOYOTA
Genuine Manual Transmission Gear Oil LV GL-4 75W” or an equivalent oil
of matching quality that satisfies the above specifications. Please contact
any authorized Toyota retailer or Toyota authorized repairer, or any reliable
repairer for further details.
Clutch
Clutch pedal wear reserve stroke28  48 mm (1.1  1.9 in.)
Remaining stroke38.1  62.1 mm (1.5  2.4 in.)

488What to do if... (Troubleshooting)
AYGO_OM_Europe_OM99R19E
What to do if... (Troubleshooting)
●If you lose your keys or mechanical keys, new genuine keys or mechanical
keys can be made by any authorized Toyota retailer or Toyota authorized
repairer, or any reliable repairer. ( P. 1 1 2 )
●Vehicles with a smart entry & start system
If you lose your electronic keys, the risk of vehicle theft increases signifi-
cantly. Contact any authorized Toyota retailer or Toyota authorized
repairer, or any reliable repairer immediately. ( P. 117)
●Is the key battery weak or depleted? (P. 383)
●Vehicles with a smart entry & start system
Is the engine switch in IGNITION ON mode?
When locking the doors, turn the engine switch off. ( P. 187)
●Vehicles with a smart entry & start system
Is the electronic key left inside the vehicle?
When locking the doors, make sure that you have the electronic key on
your person.
●The function may not operate properly due to the condition of the radio
wave. ( P. 122, 132)
●Is the child-protector lock set?
The rear door cannot be opened from inside the vehicle when the lock is
set. Open the rear door from outside and then unlock the child-protector
lock. ( P. 121)
If you have a problem, check the following before contacting any
authorized Toyota retailer or Toyota authorized repairer, or any
reliable repairer.
The doors cannot be locked, unlocked, opened or closed
You lose your keys
The doors cannot be locked or unlocked
The rear door cannot be opened (5-door models)

492Alphabetical index
AYGO_OM_Europe_OM99R19E
Alphabetical index
A/C..................................... 320, 326
Air conditioning filter.............. 382
Automatic air conditioning
system ................................ 326
Manual air conditioning
system ................................ 320
ABS (Anti-lock Brake
System) .................................. 247
Function ................................ 247
Warning light ......................... 419
Air conditioning filter .............. 382
Air conditioning
system ............................ 320, 326
Air conditioning filter.............. 382
Automatic air conditioning
system ................................ 326
Manual air conditioning
system ............................... 320
Airbag manual on-off
system ...................................... 47
Airbags ....................................... 34
Airbag manual on-off
system .................................. 47
Airbag operating conditions .... 41
Airbag precautions for
your child .............................. 37
Airbag warning light .............. 419
Correct driving posture............ 28
Curtain shield airbag
operating conditions ............. 42
Curtain shield airbag
precautions ........................... 37
General airbag precautions..... 37
Locations of airbags................ 34
Modification and disposal
of airbags.............................. 40
Side airbag operating
conditions ............................. 41
Side airbag precautions .......... 37
Side and curtain shield
airbags operating
conditions ............................. 41
Side and curtain shield
airbags precautions .............. 37
SRS airbags............................ 34
Anchor brackets ........................ 72
Antennas (smart entry &
start system) .......................... 129
Anti-lock brake system
(ABS) ...................................... 247
Function ................................ 247
Warning light ......................... 419
Audio system*......................... 258
Audio input .................... 261, 288
AUX port ....................... 261, 288
Bluetooth® audio................... 304
iPod....................................... 273
Optimal use........................... 262
Portable music player ........... 261
Radio .................................... 264
Steering wheel audio
switch ................................. 260
USB memory ........................ 281
Automatic air conditioning
system .................................... 326
Air conditioning filter ............. 382
Automatic air conditioning
system ............................... 326
Automatic light control
system .................................... 201
AUX port*......................... 261, 288
A

496Alphabetical index
AYGO_OM_Europe_OM99R19E
Gauges...................................... 101
Gear Shift Indicator ......... 192, 195
Glove box ................................. 336
Grocery bag hooks .................. 339
Hands-free system
(for cellular phone)*.............. 306
Head restraints......................... 156
Headlights ................................ 199
Follow me home system ....... 201
Light switch ........................... 199
Replacing light bulbs ............. 396
Wattage................................. 482
Heaters
Automatic air conditioning
system ................................ 326
Manual air conditioning
system ................................ 320
Seat heaters.......................... 332
Outside rear view
mirrors ........................ 322, 328
High mounted stoplight
Replacing .............................. 402
Wattage................................. 482
Hood.......................................... 358
Hooks
Grocery bag hooks................ 339
Retaining hooks (floor mat) ..... 26
Horn .......................................... 158
Identification ............................ 473
Vehicle .................................. 473
Ignition switch
(engine switch) .............. 182, 185
Immobilizer system ................... 76
Indicators ................................... 96
Initialization
Tire pressure warning
system ................................ 373
Inside rear view mirror ............ 160
Instrument cluster light
control .................................... 106
Interior lights............................ 334
Switch ................................... 334
Wattage ................................ 482
ISOFIX rigid anchors ................. 55
Jack
Positioning a floor jack .......... 360
Vehicle-equipped jack... 429, 443
Keyless entry
Smart entry &
start system ................ 119, 123
Wireless remote
control......................... 119, 123
Keys .......................................... 110
Battery-saving function ......... 132
Electronic key ....................... 110
Engine switch................ 182, 185
If the electronic key does not
operate properly ................. 458
G
H
I
J
K