2019 Ram ProMaster City power steering fluid

STARTING AND OPERATING
CONTENTS
STARTING THE ENGINE ..................149
▫ Automatic Transmission ..................149
▫ Normal Starting ....................... .149
▫ Cold Weather Operation .................149
▫ Extended Park Starting ...................150
▫ If Engine Fails To Start ..................150
▫ After Starting ......................... .151
 ENGINE BLOCK HEATER — IF EQUIPPED . . . .151
 ENGINE BREAK-IN RECOMMENDATIONS . . . .152
 PARKING BRAKE ...................... .152
 AUTOMATIC TRANSMISSION ..............154
▫ Key Ignition Park Interlock ................155
▫ Brake/Transmission Shift Interlock System . . . .155
▫ Nine-Speed Automatic Transmission .........156
POWER STEERING ..................... .162
▫ Power Steering Fluid Check ...............163
 SPEED CONTROL — IF EQUIPPED ..........164
▫ To Activate .......................... .164
▫ To Set A Desired Speed ...................164
▫ To Vary The Speed Setting ................165
▫ To Accelerate For Passing .................166
▫ To Resume Speed ...................... .166
▫ To Deactivate ........................ .166
 PARKSENSE REAR PARK ASSIST —
IF EQUIPPED ......................... .166
▫ ParkSense Rear Park Assist Sensors ..........167
▫ ParkSense Rear Park Assist Alerts ...........168
▫ ParkSense

Rear Park Assist Failure Indications . .169
6

NOTE:
•Increased noise levels at the end of the steering wheel
travel are considered normal and do not indicate that
there is a problem with the power steering system.
• Upon initial start-up in cold weather, the power steering
pump may make noise for a short amount of time. This
is due to the cold, thick fluid in the steering system. This
noise should be considered normal, and it does not in
any way damage the steering system.
CAUTION!
Prolonged operation of the steering system at the end of
the steering wheel travel will increase the steering fluid
temperature and it should be avoided when possible.
Damage to the power steering pump may occur.
Power Steering Fluid Check
Checking the power steering fluid level at a defined service
interval is not required. The fluid should only be checked
if a leak is suspected, abnormal noises are apparent,
and/or the system is not functioning as anticipated. Coor-
dinate inspection efforts through your authorized dealer.
WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to ensure accurate fluid level reading. Do not
overfill. Use only manufacturer’s recommended power
steering fluid.
CAUTION!
Do not use chemical flushes in your power steering
system as the chemicals can damage your power steer-
ing components. Such damage is not covered by the
New Vehicle Limited Warranty.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to “Fluids And Lubricants” in “Technical
Specifications” for further information.
6
STARTING AND OPERATING 163

SERVICING AND MAINTENANCE
CONTENTS
SCHEDULED SERVICING .................233
▫ Maintenance Plan ...................... .234
 ENGINE COMPARTMENT .................237
▫ Engine Compartment — 2.4L ..............237
▫ Checking Oil Level .....................238
▫ Adding Washer Fluid ...................238
▫ Maintenance-Free Battery .................239
 DEALER SERVICE ...................... .240
▫ Engine Oil .......................... .240
▫ Engine Oil Filter ...................... .241
▫ Engine Air Cleaner Filter .................242
▫ Air Conditioner Maintenance ..............242
▫ Body Lubrication ..................... .243
▫ Windshield Wiper Blades .................244 ▫
Exhaust System ....................... .244
▫ Cooling System ....................... .246
▫ Brake System ........................ .250
▫ Power Steering Fluid ....................252
▫ Automatic Transmission ..................252
▫ Upfitter Connectors — If Equipped ..........254
 RAISING THE VEHICLE ..................256
 TIRES ............................... .256
▫ Tire Safety Information ..................256
▫ Tires — General Information ..............266
▫ Tire Types ........................... .272
▫ Spare Tires — If Equipped ................273
▫ Wheel

And Wheel Trim Care ..............276
▫ Tire Chains (Traction Devices) .............277
8

ENGINE COMPARTMENT
Engine Compartment — 2.4L
1 — Air Cleaner Filter5 — Power Distribution Center (Fuses)
2 — Power Steering Fluid Reservoir 6 — Washer Fluid Reservoir
3 — Oil Fill Cap 7 — Engine Coolant Pressure Cap
4 — Brake Fluid Reservoir 8 — Engine Oil Dipstick
8
SERVICING AND MAINTENANCE 237

WARNING!(Continued)
•Do not allow petroleum based fluid to contaminate
the brake fluid. Brake seal components could be
damaged, causing partial or complete brake failure.
This could result in a collision.
Power Steering Fluid
Check the fluid level with the vehicle on flat ground and
engine cold. Fluid should be between MIN and MAX
references on the reservoir body.
The level may go over the MAX line when oil is hot.
If topping off is required, make sure the oil you use is
approved. Refer to “Fluids And Lubricants” in “Technical
Specifications” for further information.
WARNING!
Because it is flammable, do not allow the power
steering fluid to come into contact with hot engine
parts
NOTE: Power steering fluid consumption is very low. If
you need to top off your fluid often and multiple times
have your system inspected by your authorized dealer.
Automatic Transmission
Selection Of Lubricant
It is important to use the proper transmission fluid to
ensure optimum transmission performance and life. Use
only the manufacturer’s specified transmission fluid. Refer
to “Fluids And Lubricants” in “Technical Specifications”
for fluid specifications. It is important to maintain the
transmission fluid at the correct level using the recom-
mended fluid.
NOTE: No chemical flushes should be used in any trans-
mission; only the approved lubricant should be used.
CAUTION!
Using a transmission fluid other than the manufactur-
er ’s recommended fluid may cause deterioration in
transmission shift quality and/or torque converter
shudder. Refer to “Fluids And Lubricants” in “Techni-
cal Specifications” for fluid specifications.
252 SERVICING AND MAINTENANCE

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission Use only Mopar ZF 8&9 Speed ATF Automatic Transmission Fluid, or equivalent.
Failure to use the correct fluid may affect the function or performance of your
transmission.
Brake Master Cylinder We recommend you use Mopar DOT 4.
The fluid must be changed every 24 months. This interval is time based only,
mileage intervals do not apply.
Power Steering Reservoir Use Pentosin CHF 11S power steering fluid meeting FCA Material Standard
MS-11655.
294 TECHNICAL SPECIFICATIONS

Body Mechanism Lubrication..................243
B-Pillar Location .......................... .262
Brake Assist System .........................89
Brake Fluid .............................. .294
Brake, Parking ............................ .152
Brake System ......................... .250, 286
Anti-Lock (ABS) ..........................88
Fluid Check ........................ .251, 294
Master Cylinder ........................ .251
Parking .............................. .152
Warning Light ...........................74
Brake/Transmission Interlock ..................155
Bulb Replacement ......................... .191
Bulbs, Light .......................... .145, 191
Camera, Rear ............................ .171
Capacities, Fluid .......................... .292
Caps, Filler Fuel ................................. .172
Oil (Engine) ........................ .237, 241
Power Steering ......................... .163
Radiator (Coolant Pressure) .................249
Carbon Monoxide Warning ................143, 291
Cargo Area Cover ...........................60
Cargo Compartment .........................60 Cargo Tie-Downs
...........................60
Car Washes .............................. .280
Cellular Phone ........................... .310
Certification Label ......................... .174
Chains, Tire ............................. .277
Changing A Flat Tire .....................204, 256
Chart, Tire Sizing .......................... .258
Check Engine Light (Malfunction Indicator Light) ....84
Checking Your Vehicle For Safety ...............142
Checks, Safety ............................ .142
Child Restraint ........................... .122
Child Restraints Booster Seats ........................... .126
Child Seat Installation ..................136,
140
How To Stow An unused ALR Seat Belt ........133
Infant And Child Restraints .................124
Locating The LATCH Anchorages .............131
Lower Anchors And Tethers For Children .......128
Older Children And Child Restraints ...........125
Seating Positions ........................ .127
Clean Air Gasoline ........................ .289
Cleaning Wheels ............................... .276
Climate Control ............................48
Cold Weather Operation ..................... .149
12
INDEX 327

Towing............................... .228
Emission Control System Maintenance ............84
Engine ................................. .237
Air Cleaner ............................ .242
Block Heater ........................... .151
Break-In Recommendations .................152
Checking Oil Level ...................... .238
Coolant (Antifreeze) ..................... .292
Cooling .............................. .246
Exhaust Gas Caution ...................143, 291
Fails To Start ........................... .150
Flooded, Starting ........................ .150
Jump Starting .......................... .220
Oil .............................. .240, 292
Oil Filler Cap ....................... .237, 241
Oil Filter .............................. .241
Oil Selection ........................ .240, 292
Oil Synthetic ........................... .241
Overheating ........................... .223
Starting .............................. .149
Engine Oil Viscosity ........................ .241
Engine Oil Viscosity Chart ....................241
Enhanced Accident Response Feature .........120, 229
Ethanol ................................. .289
Exhaust Gas Cautions ....................143, 291 Exhaust System
....................... .143, 244
Exterior Lights ......................... .41, 145
Filters Air Cleaner ............................ .242
Air Conditioning ..........................53
Engine Oil ......................... .241, 292
Engine Oil Disposal ...................... .241
Flashers Hazard Warning ........................ .191
Turn Signals ......................... .82, 145
Flooded Engine Starting ..................... .150
Fluid, Brake ............................. .294
Fluid
Capacities ........................... .292
Fluid Leaks .............................. .146
Fluid Level Checks Brake ................................ .251
Engine Oil ............................ .238
Power Steering ......................... .163
Fluids And Lubricants ...................... .292
Fog Lights ................................42
Fold-Flat Seats .............................29
Four-Way Hazard Flasher .....................191
Freeing A Stuck Vehicle ..................... .226
Fuel ................................... .288
12
INDEX 329