2019 Ram 4500 Chassis Cab check engine

442 SERVICING AND MAINTENANCE
Fluid And Filter Changes — Eight-Speed Transmission
Under normal operating conditions, the fluid installed at the
factory will provide satisfactory lubrication for the life of the
vehicle.
Routine fluid and filter changes are not required. However,
change the fluid and filter if the fluid becomes contaminated
(with water, etc.), or if the transmission is disassembled for
any reason.
Fluid And Filter Changes — Six Speed Transmission
Refer to the “Maintenance Plan” for the proper maintenance
intervals.
In addition, change the fluid and filters if the fluid becomes
contaminated (with water, etc.), or if the transmission is
disassembled for any reason.
Rear Axle And 4x4 Front Driving Axle Fluid Level
For models with 9.25 in Front Axles and 11.5 in Rear Axles,
refer to “Fluids And Lubricants” in “Servicing And Mainte-
nance” for further information. For normal service, periodic
fluid level checks are not required. When the vehicle is
serviced for other reasons, the exterior surfaces of the axle
assembly should be inspected.
When checking the fluid level, the vehicle should be in a
level position. The fluid level at room temperature should be
as follows:
3500 Front Axle: ¼ in ± ¼ in (6.4 mm ± 6.4 mm) below the
bottom of the fill hole.
3500 Rear Axle: ¼ in ± ¼ in (6.4 mm ± 6.4 mm) below the
bottom of the fill hole.
4500/5500 Front Axle: ¼ in +/- ¼ in (6.4 mm ± 6.4 mm)
below the bottom of the fill hole.
4500/5500 Rear Axle: 1/8 in +/- 1/8 in (3.2 mm +/- 3.2 mm)
below the bottom of the fill hole.
CAUTION!
If the fluid temperature is below 50°F (10°C) it may not
register on the dipstick. Do not add fluid until the
temperature is elevated enough to produce an accurate
reading. Run the engine at idle, in PARK, to warm the
fluid.

MULTIMEDIA 509
Uconnect 4/4C/4C NAV Settings
Uconnect 4/4C/4C NAV With 8.4–inch Display Buttons On The Touchscreen And Buttons On The Faceplate
Press the “Apps” button on the touchscreen then press the
“Settings” button on the touchscreen to display the settings
menu screen. In this mode the Uconnect system allows you
to access programmable features that may be equipped such
as Language, Display, Units, Voice, Clock, Safety & Driving
Assistance, Mirrors & Wipers, Lights, Doors & Locks, Power
Side Steps (if equipped), Auto-On Comfort (if equipped), Engine Off Options, Suspension, Trailer, Audio, Phone/
Bluetooth, SiriusXM Setup (if equipped), Restore Settings
and System Information.
NOTE:
Only one category may be selected at a time.
When making a selection, press the button on the touch
-
screen to enter the desired mode. Once in the desired mode,
press and release the preferred setting until a check-mark
appears next to the setting, showing that setting has been
selected. Once the setting is complete, press the back arrow
button on the touchscreen to return to the previous menu or
press the “X” button on the touchscreen to close out of the
settings screen. Pressing the Up or Down Arrow buttons on
the touchscreen on the right side of the screen will allow you
to toggle up or down through the list of available settings.
NOTE:
All settings should be changed with the ignition in the RUN
position.
1 — Uconnect Buttons On The Touchscreen
2 — Uconnect Buttons On The Faceplate
9

MULTIMEDIA 529
Uconnect 4C NAV With 12–inch Display Settings
Uconnect 4C NAV With 12–inch Display Buttons On The Touchscreen And Buttons On The Faceplate
Press the “Settings” button on the touchscreen to display the
settings menu screen. In this mode the Uconnect system
allows you to access programmable features that may be
equipped such as Language, Display, Units, Voice, Clock &
Date, Camera, Safety & Driving Assistance, Mirrors and Wipers, Lights, Doors & Locks, Auto-On Comfort (if
equipped), Engine Off Options, Suspension, Trailer, Audio
Settings, Bluetooth, SiriusXM Setup (if equipped), Reset and
System Information.
NOTE:
Only one category may be selected at a time.
When making a selection, press the button on the touch
-
screen to enter the desired mode. Once in the desired mode,
press and release the preferred setting until a check-mark
appears next to the setting, showing that setting has been
selected. Once the setting is complete, press the back arrow
button on the touchscreen to return to the previous menu or
press the “X” button on the touchscreen to close out of the
settings screen. Pressing the Up or Down Arrow buttons on
the touchscreen on the right side of the screen will allow you
to toggle up or down through the list of available settings.
NOTE:
All settings should be changed with the ignition in the RUN
position.
1 — Uconnect Buttons On The Touchscreen
2 — Uconnect Buttons On The Faceplate
9

591
Auto Unlock, Doors ................................................................ 269
Automatic Door Locks ............................................................. 37
Automatic Headlights .............................................................. 68
Automatic Temperature Control (ATC) ................................ 89
Automatic Transmission ................................................ 265, 442 Adding Fluid ....................................................................... 442Fluid And Filter Change .................................................... 442
Fluid Change........................................................................ 442
Fluid Level Check ....................................................... 439, 440
Fluid Type .................................................................... 439, 486
Shifting.................................................................................. 256
Special Additives................................................................. 439
Automatic Transmission Limp Home Mode ...................... 269
Auxiliary Driving Systems .................................................... 174
Axle Fluid................................................................. 442, 443, 486
Axle Lubrication.............................................................. 442, 443 B
Back-Up .................................................................................... 326
Back-Up Camera ..................................................................... 326
Battery............................................................................... 148, 417 Charging System Light....................................................... 148
Keyless Key Fob Replacement ............................................ 19
Battery Saver Feature ............................................................... 71 Belts, Seat ................................................................................. 241
Body Builders Guide ................................................................ 14
Body Mechanism Lubrication ............................................... 428 B-Pillar Location ......................................................................450
Brake Assist System ................................................................163
Brake Control System .............................................................162
Brake Fluid .......................................................................438, 486
Brake System....................................................................438, 476 Fluid Check ..........................................................................438
Master Cylinder ...................................................................438Parking ..................................................................................252
Warning Light......................................................................146
Brake/Transmission Interlock ..............................................256
Bulb Replacement ...................................................................371
Bulbs, Light ......................................................................243, 371 C
Cab Top Clearance Lights ......................................................379
Camera...................................................................................... 326
Camera, Rear....................................................................326, 330
Capacities, Antifreeze (Engine Coolant) ..............................483
Capacities, Fluid ......................................................................483
Caps, Filler Oil (Engine) ..................................................................415, 419
Power Steering .....................................................................284
Radiator (Coolant Pressure)...............................................436
Car Washes ..............................................................................471
Carbon Monoxide Warning ...........................................240, 482
Cargo Light ................................................................................71 Cellular Phone .........................................................................555
11

592
Center High Mounted Stop Light......................................... 377
Center Seat Storage Compartment ....................................... 106
Changing A Flat Tire .............................................................. 390
Chart, Tire Sizing .................................................................... 446
Check Engine Light (Malfunction Indicator Light) ........... 159
Checking Your Vehicle For Safety ........................................ 240
Checks, Safety .......................................................................... 240
Child Restraint ........................................................................ 214
Child Restraints Booster Seats ........................................................................ 218
Child Seat Installation ................................................ 229, 231
How To Stow An unused ALR Seat Belt ......................... 227Infant And Child Restraints .............................................. 216Locating The LATCH Anchorages ................................... 224
Lower Anchors And Tethers For Children ..................... 220Older Children And Child Restraints .............................. 217
Seating Positions ................................................................. 219
Clean Air Gasoline .................................................................. 479
Cleaning Wheels................................................................................... 464
Climate Control ......................................................................... 77 Automatic ............................................................................... 81
Manual .................................................................................... 77
Cold Weather Operation........................................................ 250
Compact Disc (CD) Maintenance ......................................... 584
Compact Spare Tire ................................................................ 462 Contract, Service......................................................................587
Cooling Pressure Cap (Radiator Cap) ..................................436
Cooling System ........................................................................433
Adding Coolant (Antifreeze) .............................................435
Coolant Level ...............................................................434, 437Cooling Capacity .................................................................483
Disposal Of Used Coolant..................................................436Drain, Flush, And Refill .....................................................434
Inspection ............................................................................. 437
Points To Remember ........................................................... 437Pressure Cap ........................................................................436Radiator Cap ........................................................................436Selection Of Coolant (Antifreeze) .............................434, 484
Corrosion Protection ...............................................................470
Cruise Control (Speed Control) ....................................285, 288
Cruise Light ............................................................................. 157
Cupholders...............................................................................115
Customer Assistance ..............................................................585
Cybersecurity ...........................................................................488 D
Daytime Running Lights ..........................................................67
Dealer Service ..........................................................................417
Defroster, Rear Window ..........................................................77
Defroster, Windshield ......................................................77, 241
Delay (Intermittent) Wipers ....................................................75
Diagnostic System, Onboard .................................................158

594
Enhanced Accident Response Feature ......................... 212, 409
Entry System, Illuminated ....................................................... 74
Ethanol...................................................................................... 480
Exhaust Gas Cautions .................................................... 240, 482
Exhaust System ............................................................... 240, 431
Exterior Lighting ....................................................................... 66 Exterior Lights ................................................................... 66, 243 F
Filters Air Cleaner ........................................................................... 420Air Conditioning ........................................................... 91, 423
Engine Fuel .......................................................................... 484
Engine Oil..................................................................... 419, 484
Engine Oil Disposal ............................................................ 419
Flashers Turn Signals ........................................................... 70, 157, 243
Flash-To-Pass ............................................................................. 68
Flat Tire Changing .................................................. 390, 444, 461
Flat Tire Stowage .................................................... 396, 444, 461
Fluid Capacities ....................................................................... 483
Fluid Leaks ............................................................................... 243
Fluid Level Checks Brake ..................................................................................... 438
Power Steering..................................................................... 284
Fluids And Lubricants ........................................................... 484
Fog Lights........................................................................... 70, 377 Fold Flat Load Floor ...............................................................112
Fold-Flat Seats ...........................................................................39
Forward Collision Warning................................................... 174
Four Wheel Drive .................................................................... 272
Four-Way Hazard Flasher .....................................................366
Freeing A Stuck Vehicle .........................................................405
Front Axle (Differential) .........................................................442
Fuel ............................................................................................479 Adding ..................................................................................336
Additives ..............................................................................480
Clean Air...............................................................................479
Ethanol ..................................................................................480
Filler Cap (Gas Cap)............................................................337
Filter ...................................................................................... 484
Gasoline ................................................................................479Light ...................................................................................... 152
Materials Added ..................................................................480
Methanol...............................................................................480
Octane Rating.......................................................................479Requirements .......................................................................479Tank Capacity ......................................................................483
Fuses..........................................................................................380 G
Garage Door Opener (HomeLink) ..........................................97 Gas Cap (Fuel Filler Cap) .......................................................337
Gasoline, Clean Air .................................................................479

597
Low Fuel ............................................................................... 152Malfunction Indicator (Check Engine)............................. 150Park ....................................................................................... 157Passing .................................................................................... 68
Seat Belt Reminder .............................................................. 146Security Alarm..................................................................... 148
Service ................................................................................... 371Traction Control .................................................................. 169
Transfer Case ....................................................................... 280Turn Signals ................................................... 70, 157, 243, 373
Warning Instrument Cluster Descriptions .............. 148, 157
Limited-Slip Differential ................................................ 281, 443
Load Shed Battery Saver Mode............................................. 144
Load Shed Battery Saver On ................................................. 144
Load Shed Electrical Load Reduction .................................. 144
Load Shed Intelligent Battery Sensor ................................... 144
Loading Vehicle ...................................................................... 337 Tires....................................................................................... 450
Locks Automatic Door..................................................................... 37
Child Protection .................................................................... 38
Power Door ............................................................................ 33
Low Tire Pressure System ..................................................... 177
Lubrication, Body ................................................................... 428
Lug Nuts/Bolts ....................................................... 396, 476, 477 M
Maintenance Free Battery ......................................................417
Maintenance Schedule............................................................ 410
Malfunction Indicator Light (Check Engine) ..............150, 159
Manual Park Release .........................................................................403
Service ...................................................................................589
Media Hub ...............................................................................551
Memory Seat ..............................................................................44
Methanol...................................................................................480
Mirrors ........................................................................................56 Electric Powered ....................................................................59
Heated .....................................................................................62
Memory...................................................................................44
Outside....................................................................................58
Rearview .............................................................56, 57, 58, 366 Trailer Towing .......................................................................61
Modifications/Alterations Vehicle.....................................................................................14
Monitor, Tire Pressure System ..............................................177
Mopar Parts..............................................................................588
MP3 Control ............................................................................. 551
Multi-Function Control Lever .................................................66 N
Navigation System (Uconnect GPS) .....................................326
New Vehicle Break-In Period ................................................251
11

INSTALLATION OF RADIO TRANSMITTING
EQUIPMENT
Special design considerations are incorporated into this
vehicle’s electronic system to provide immunity to radio
frequency signals. Mobile two-way radios and telephone
equipment must be installed properly by trained person-
nel. The following must be observed during installation.
The positive power connection should be made directly
to the battery and fused as close to the battery as possible.
The negative power connection should be made to body
sheet metal adjacent to the negative battery connection.
This connection should not be fused.
Antennas for two-way radios should be mounted on the
roof or the rear area of the vehicle. Care should be used
in mounting antennas with magnet bases. Magnets may
affect the accuracy or operation of the compass on
vehicles so equipped.
The antenna cable should be as short as practical and
routed away from the vehicle wiring when possible. Use
only fully shielded coaxial cable.
Carefully match the antenna and cable to the radio to
ensure a low Standing Wave Ratio (SWR).Mobile radio equipment with output power greater than
normal may require special precautions.
All installations should be checked for possible interfer-
ence between the communications equipment and the
vehicle’s electronic systems.
WARNING:
Operating, servicing and maintaining a
passenger vehicle or off-road highway
motor vehicle can expose you to chemicals
including engine exhaust, carbon monoxide,
phthalates, and lead, which are known to
the State of California to cause cancer and
birth defects or other reproductive harm.
To minimize exposure, avoid breathing
exhaust, do not idle the engine except as
necessary, service your vehicle in a
well-ventilated area and wear gloves or
wash your hands frequently when servicing
your vehicle. For more information go to
www.P65Warnings.ca.gov/passenger-vehicle.
VEHICLES SOLD IN CANADA
With respect to any Vehicles Sold in Canada, the name
FCA US LLC shall be deemed to be deleted and the name
FCA Canada Inc. used in substitution therefore.
DRIVING AND ALCOHOL
Drunken driving is one of the most frequent causes of
accidents.
Your driving ability can be seriously impaired with blood
alcohol levels far below the legal minimum. If you are
drinking, don’t drive. Ride with a designated non-
drinking driver, call a cab, a friend, or use public trans-
portation.
WARNING!
Driving after drinking can lead to an accident.
Your perceptions are less sharp, your reflexes are
slower, and your judgment is impaired when you
have been drinking. Never drink and then drive.
This manual illustrates and describes the operation of
features and equipment that are either standard or op-
tional on this vehicle. This manual may also include a
description of features and equipment that are no longer
available or were not ordered on this vehicle. Please
disregard any features and equipment described in this
manual that are not on this vehicle.
FCA US LLC reserves the right to make changes in design
and specifications, and/or make additions to or improve-
ments to its products without imposing any obligation
upon itself to install them on products previously manu-
factured.
Copyright © 2018 FCA US LLC
Copyright © 2019 FCA US LLC