2019 Ram 3500 check oil

SERVICING AND MAINTENANCE 501
Mileage or time passed
(whichever comes first)
20,000
30,000
40,00050,000
60,000
70,000
80,00090,000
100,000
110,000120,000130,000140,000150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000 48,000
64,00080,000
96,000
112,000
128,000144,000160,000
176,000192,000208,000224,000240,000
Additional Inspections
Inspect the CV/Universal joints. X X X XX XX
Inspect front suspension, tie rod
ends, and replace if necessary. X X X
XX XX

Inspect the front and rear axle
surfaces. If gear oil leakage is
suspected, check the fluid
level. If using your vehicle for
police, taxi, fleet, off-road or
frequent trailer towing, change
axle fluid.
X X X
XX XX
Inspect the brake linings,
replace as necessary. X X X
XX XX
Adjust parking brake as
necessary. X X X
XX XX
Inspect transfer case fluid. XX X
7

SERVICING AND MAINTENANCE 505
Checking Oil Level — Gas Engine
To assure proper lubrication of your vehicle's engine, the
engine oil must be maintained at the correct level. Check the
oil level at regular intervals, such as every fuel stop. The best
time to check the engine oil level is about five minutes after
a fully warmed up engine is shut off.
Checking the oil while the vehicle is on level ground will
improve the accuracy of the oil level readings. Always main-
tain the oil level within the SAFE zone on the dipstick.
Adding one quart of oil when the reading is at the bottom of
the SAFE zone will result in a reading at the top of the safe
zone on these engines.
Adding Washer Fluid
The fluid reservoir is located under the hood and should be
checked for fluid level at regular intervals. Fill the reservoir
with windshield washer solvent only (not radiator anti -
freeze). When refilling the washer fluid reservoir, take some washer fluid and apply it to a cloth or towel and wipe the
wiper blades clean. This will help blade performance.
To prevent freeze-up of your windshield washer system in
cold weather, select a solution or mixture that meets or
exceeds the temperature range of your climate. This rating
information can be found on most washer fluid containers.
After the engine has warmed up, operate the defroster for a
few minutes to reduce the possibility of smearing or freezing
the fluid on the cold windshield. Windshield washer solu-
tion used with water as directed on the container, aids
cleaning action, reduces the freezing point to avoid line clog
-
ging, and is not harmful to paint or trim.
CAUTION!
Overfilling or underfilling will cause oil aeration or loss
of oil pressure. This could damage your engine.
WARNING!
Commercially available windshield washer solvents are
flammable. They could ignite and burn you. Care must
be exercised when filling or working around the washer
solution.
7

SERVICING AND MAINTENANCE 527
(Continued)
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically. Refer
to the “Maintenance Plan” in this section for the proper
maintenance intervals.
Fluid Level Check — Brake Master Cylinder
The fluid level of the master cylinder should be checked
when performing under the hood service or immediately if
the brake system warning lamp indicates system failure.
If necessary, add fluid to bring level within the designated
marks on the side of the reservoir of the brake master
cylinder. Be sure to clean the top of the master cylinder area
before removing cap.With disc brakes the fluid level can be expected to fall as the
brake linings wear. However, an unexpected drop in fluid
level may be caused by a leak and a system check should be
conducted.
Refer to “Fluids And Lubricants” in “Technical Specifica
-
tions” for further information.
WARNING!
Riding the brakes can lead to brake failure and possibly
a collision. Driving with your foot resting or riding on
the brake pedal can result in abnormally high brake
temperatures, excessive lining wear, and possible brake
damage. You would not have your full braking capacity
in an emergency.
WARNING!
• Use only manufacturer's recommended brake fluid. Refer to “Fluids And Lubricants” in “Technical Speci -
fications” for further information. Using the wrong
type of brake fluid can severely damage your brake
system and/or impair its performance. The proper type
of brake fluid for your vehicle is also identified on the
original factory installed hydraulic master cylinder
reservoir.
• To avoid contamination from foreign matter or mois -
ture, use only new brake fluid or fluid that has been in
a tightly closed container. Keep the master cylinder
reservoir cap secured at all times. Brake fluid in a open
container absorbs moisture from the air resulting in a
lower boiling point. This may cause it to boil unexpect -
edly during hard or prolonged braking, resulting in
sudden brake failure. This could result in a collision.
7

SERVICING AND MAINTENANCE 529
Fluid Level Check — Eight-Speed Transmission
The fluid level is preset at the factory and does not require
adjustment under normal operating conditions. Routine
fluid level checks are not required, therefore the transmis-
sion has no dipstick. An authorized dealer can check your
transmission fluid level using special service tools.
If you notice fluid leakage or transmission malfunction, visit
an authorized dealer immediately to have the transmission
fluid level checked. Operating the vehicle with an improper
fluid level can cause severe transmission damage. Fluid And Filter Changes — Eight-Speed Transmission
Under normal operating conditions, the fluid installed at the
factory will provide satisfactory lubrication for the life of the
vehicle.
Routine fluid and filter changes are not required. However,
change the fluid and filter if the fluid becomes contaminated
(with water, etc.), or if the transmission is disassembled for
any reason.
Rear Axle And 4x4 Front Driving Axle Fluid Level
For normal service, periodic fluid level checks are not
required. When the vehicle is serviced for other reasons the
exterior surfaces of the axle assembly should be inspected. If
gear oil leakage is suspected inspect the fluid level. Refer to
“Fluids And Lubricants” in “Technical Specifications” for
further information. This inspection should be made with
the vehicle in a level position.
For all 2500/3500 Model axles, the fluid level should be 1/
4 in ± 1/4 in (6.4 mm ± 6.4 mm) below the fill hole on the
9.25 in front, 11.5 in rear axle, and 12.0 in rear axle.
CAUTION!
If a transmission fluid leak occurs, visit an authorized
dealer immediately. Severe transmission damage may
occur. An authorized dealer has the proper tools to adjust
the fluid level accurately.
7

530 SERVICING AND MAINTENANCE
Lubricant Selection
Refer to “Fluids And Lubricants” in “Technical Specifica-
tion” for further information.
NOTE:
The presence of water in the gear lubricant will result in
corrosion and possible failure of differential components.
Operation of the vehicle in water, as may be encountered in
some off-highway types of service, will require draining and
refilling the axle to avoid damage.
Limited-Slip Differentials DO REQUIRE limited slip oil
additive (friction modifiers).
NOTE:
Slight noise and mild shuddering may be evident while
turning a vehicle with limited slip differential on concrete or
dry pavement. These conditions should be considered
normal operation of the limited slip differential.
Drain And Refill
Refer to the “Maintenance Plan” for the proper maintenance
intervals.Transfer Case
Selection Of Lubricant
Use only the manufacturer's recommended fluid. Refer to
“Fluids And Lubricants” in “Technical Specifications” for
further information.
Fluid Level Check
This fluid level can be checked by removing the filler plug.
The fluid level should be to the bottom edge of the filler plug
hole with the vehicle in a level position.
Drain And Refill
Refer to the “Maintenance Plan” in this section for the proper
maintenance intervals.

562 SERVICING AND MAINTENANCE
Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical solvents
or abrasive cleaners. This will weaken the fabric. Sun
damage can also weaken the fabric.
If the belts need cleaning, use a mild soap solution or luke-
warm water. Do not remove the belts from the vehicle to
wash them. Dry with a soft cloth.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
NOTE:
If the belts retract slowly, inspect the upper turning loop for
soiling. If soiling is present, clean with a wet soft cloth until
all residue is removed.Plastic And Coated Parts
Use Mopar Total Clean to clean vinyl upholstery.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care must
be taken to avoid scratching the plastic.
1. Clean with a wet soft cloth. A mild soap solution may be used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
cloth.
2. Dry with a soft cloth.
WARNING!
A frayed or torn belt could rip apart in a collision and
leave you with no protection. Inspect the belt system
periodically, checking for cuts, frays, or loose parts.
Damaged parts must be replaced immediately. Do not
disassemble or modify the system. Seat belt assemblies
must be replaced after a collision if they have been
damaged (i.e., bent retractor, torn webbing, etc.).
CAUTION!
• Direct contact of air fresheners, insect repellents, suntan lotions, or hand sanitizers to the plastic,
painted, or decorated surfaces of the interior may cause
permanent damage. Wipe away immediately.
• Damage caused by these type of products may not be covered by your New Vehicle Limited Warranty.

679
Automatic Door Locks ............................................................. 39
Automatic Headlights .............................................................. 69
Automatic Tailgate Release ................................................... 102
Automatic Temperature Control (ATC) ................................ 91
Automatic Transmission ................................................ 301, 529 Adding Fluid ....................................................................... 529Fluid And Filter Change .................................................... 529
Fluid Change........................................................................ 529
Fluid Level Check ....................................................... 528, 529
Fluid Type .................................................................... 528, 574
Special Additives................................................................. 528
Automatic Transmission Limp Home Mode ...................... 306
Auxiliary Driving Systems .................................................... 208
Axle Fluid......................................................................... 529, 574
Axle Lubrication...................................................................... 529 B
Back-Up .................................................................................... 397
Back-Up Camera ..................................................................... 397
Bar, Stabilizer/Sway System ................................................. 322
Battery............................................................................... 182, 506 Charging System Light....................................................... 182
Keyless Key Fob Replacement ............................................ 21
Battery Saver Feature ............................................................... 73 Belts, Seat ................................................................................. 287
Blind Spot Monitoring............................................................ 208
Body Builders Guide ................................................................ 15 Body Mechanism Lubrication ...............................................517
B-Pillar Location ......................................................................537
Brake Assist System ................................................................197
Brake Control System .............................................................196
Brake Fluid .......................................................................527, 574
Brake System....................................................................527, 565 Fluid Check ..........................................................................527
Master Cylinder ...................................................................527Parking ..................................................................................298
Warning Light......................................................................180
Brake/Transmission Interlock ..............................................301
Bulb Replacement ...................................................................446
Bulbs, Light ......................................................................289, 446 C
Cab Top Clearance Lights ......................................................455
Camera...................................................................................... 397
Camera, Rear....................................................................397, 401
Camper .....................................................................................144
Capacities, Fluid ......................................................................571
Caps, Filler Oil (Engine) ..................................................................504, 508
Radiator (Coolant Pressure)...............................................525
Car Washes ..............................................................................558
Carbon Monoxide Warning ...........................................286, 570
Cargo Light ................................................................................72 Cellular Phone .........................................................................647
11

682
Enhanced Accident Response Feature ......................... 255, 498
Entry System, Illuminated ....................................................... 76
Ethanol...................................................................................... 568
Exhaust Gas Cautions .................................................... 286, 570
Exhaust System ............................................................... 286, 520
Exterior Lighting ....................................................................... 67 Exterior Lights ................................................................... 67, 289 F
Filters Air Cleaner ........................................................................... 509Air Conditioning ........................................................... 93, 512
Engine Oil..................................................................... 509, 572
Engine Oil Disposal ............................................................ 508
Flashers Turn Signals ........................................................... 71, 191, 289
Flash-To-Pass ............................................................................. 69
Flat Tire Changing .................................................. 469, 531, 548
Flat Tire Stowage .................................................... 483, 531, 548
Fluid Capacities ....................................................................... 571
Fluid Leaks ............................................................................... 289
Fluid Level Checks Brake ..................................................................................... 527
Fluid, Brake .............................................................................. 574
Fluids And Lubricants ........................................................... 572
Fog Lights........................................................................... 71, 451
Fold Flat Load Floor ............................................................... 119 Fold-Flat Seats ...........................................................................40
Forward Collision Warning................................................... 216
Four Wheel Drive .................................................................... 309
Four-Way Hazard Flasher .....................................................440
Freeing A Stuck Vehicle .........................................................494
Front Axle (Differential) .........................................................529
Fuel ............................................................................................567 Adding ..................................................................................408
Additives ..............................................................................568
Clean Air...............................................................................568
Ethanol ..................................................................................568
Filler Cap (Gas Cap)............................................................ 410
Gasoline ................................................................................567Light ...................................................................................... 186
Materials Added ..................................................................568
Methanol...............................................................................568
Octane Rating...............................................................567, 572Requirements ...............................................................567, 571Tank Capacity ......................................................................571
Fuses..........................................................................................457 G
Garage Door Opener (HomeLink) ........................................104
Gas Cap (Fuel Filler Cap) .......................................................410
Gasoline, Clean Air .................................................................568
Gasoline, Reformulated..........................................................568
General Information ...............................................................230