2019 Ram 3500 Chassis Cab air filter

SERVICING AND MAINTENANCE 421
2. Lift the air cleaner cover to access the air cleaner filter.
3. Remove the air cleaner filter element from the housingassembly.
Open Air Cleaner Filter Assembly Engine Air Cleaner Filter Installation
NOTE:
Inspect and clean the housing if dirt or debris is present
before replacing the air filter element.
1. Install the air cleaner filter element into the housing
assembly with the air cleaner filter inspection surface
facing downward.
2. Install the air cleaner cover onto the housing assembly.
3. Tighten the fasteners (six) on the air cleaner filter assembly
Air Conditioner Maintenance
For best possible performance, your air conditioner should
be checked and serviced by an authorized dealer at the start
of each warm season. This service should include cleaning of
the condenser fins and a performance test. Drive belt tension
should also be checked at this time.
1 — Air Cleaner Cover
2 — Air Cleaner Filter7

SERVICING AND MAINTENANCE 423
Cabin Filter Replacement (A/C Air Filter)
Refer to the “Maintenance Plan” for the proper maintenance
intervals.
The cabin air filter is located in the fresh air inlet behind the
glove compartment. Perform the following procedure to
replace the filter:
1. Open the glove compartment and remove all contents.2. With the glove compartment door open, remove the
glove compartment tension tether and tether clip by
sliding the clip toward the face of the glove compartment
door. Lift the clip out of glove compartment door and
release into dash panel.
Right Side Of Glove Compartment
WARNING!
Do not remove the cabin air filter while the vehicle is
running, or while the ignition is in the ACC or ON/RUN
mode. With the cabin air filter removed and the blower
operating, the blower can contact hands and may propel
dirt and debris into your eyes, resulting in personal
injury.
1 — Glove Compartment Door
2 — Glove Compartment Tension Tether
7

SERVICING AND MAINTENANCE 425
Filter Cover Removal
5. Remove the cabin air filter by pulling it straight out of the housing. Cabin Air Filter
6. Install the cabin air filter with the arrow on the filter pointing toward the floor. When installing the filter
cover, press on each end until you hear an audible click.
7. Reinstall the glove compartment on the hinges.
1 — Finger Tabs
CAUTION!
The cabin air filter is identified with an arrow to indicate
airflow direction through the filter. Failure to properly
install the filter will result in the need to replace it more
often. 7

SERVICING AND MAINTENANCE 439
Automatic Transmission
Selection Of Lubricant
It is important to use the proper transmission fluid to ensure
optimum transmission performance and life. Use only the
manufacturer’s specified transmission fluid. Refer to “Fluids
And Lubricants” in “Technical Specifications”. It is
important to maintain the transmission fluid at the correct
level using the recommended fluid. No chemical flushes
should be used in any transmission; only the approved lubri-
cant should be used. Special Additives
The manufacturer strongly recommends against using any
special additives in the transmission. Automatic Transmis
-
sion Fluid (ATF) is an engineered product and its perfor -
mance may be impaired by supplemental additives.
Therefore, do not add any fluid additives to the transmis -
sion. The only exception to this policy is the use of special
dyes for diagnosing fluid leaks in six-speed transmissions.
Avoid using transmission sealers as they may adversely
affect seals.
• Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing the
brake fluid to catch fire. Brake fluid can also damage
painted and vinyl surfaces, care should be taken to
avoid its contact with these surfaces.
• Do not allow petroleum based fluid to contaminate the brake fluid. Brake seal components could be damaged,
causing partial or complete brake failure. This could
result in a collision.
WARNING! (Continued)CAUTION!
Using a transmission fluid other than the manufacturer’s
recommended fluid may cause deterioration in
transmission shift quality and/or torque converter
shudder, and (for six-speed transmissions) will require
more frequent fluid and filter changes. Refer to “Fluids
And Lubricants” in “Technical Specifications” for fluid
specifications.
7

INDEX
A
Adaptive Cruise Control (ACC) (Cruise Control) ............. 288
Adding Engine Coolant (Antifreeze) ................................... 435
Adding Fuel ............................................................................. 336
Additives, Fuel ........................................................................ 480
Adjust Down....................................................................................... 42
Forward .................................................................................. 42
Rearward ................................................................................ 42
Up ............................................................................................ 42
Adjustable Pedals...................................................................... 55
Air Bag Air Bag Operation ............................................................... 205Air Bag Warning Light ....................................................... 203
Enhanced Accident Response ................................... 212, 409
Event Data Recorder (EDR) ............................................... 409
If Deployment Occurs ........................................................ 211
Knee Impact Bolsters .......................................................... 206Maintaining Your Air Bag System.................................... 213
Maintenance......................................................................... 213
Transporting Pets ................................................................ 240
Air Bag Light ........................................................... 146, 203, 241
Air Cleaner, Engine (Engine Air Cleaner Filter) ................ 420
Air Conditioner Maintenance ............................................... 421 Air Conditioner Refrigerant ..........................................421, 422
Air Conditioner System..........................................................421
Air Conditioning ................................................................. 77, 88
Air Conditioning Filter .....................................................91, 423
Air Conditioning System .........................................................89
Air Conditioning, Operating Tips ..........................................89
Air Filter ...................................................................................420
Air Pressure Tires .......................................................................................455
Alarm Panic ........................................................................................18
Security Alarm ...............................................................30, 148
Alterations/Modifications Vehicle.....................................................................................14
Android Auto ..........................................................................579
Antifreeze (Engine Coolant) ..................................................434 Capacites...............................................................................483
Disposal ................................................................................436
Anti-Lock Brake System (ABS) .............................................161
Anti-Lock Warning Light.......................................................154
Apple CarPlay .........................................................................581
Assist, Hill Start .......................................................................164
Audio Systems (Radio)........................................................... 487
Auto Down Power Windows ..................................................92

593
Differential, Limited Slip ....................................................... 281
Dipsticks Power Steering..................................................................... 284
Disabled Vehicle Towing ....................................................... 406
Disposal Antifreeze (Engine Coolant) .............................................. 436
Do Not Disturb ........................................................................ 579
Door Ajar.................................................................................. 150
Door Ajar Light ....................................................................... 150
Door Locks Automatic ............................................................................... 37
Doors........................................................................................... 32
Drag And Drop Menu ............................................................ 487
Driver’s Seat Back Tilt .............................................................. 39
Driving
Through Flowing, Rising, Or Shallow Standing Water ....364

Dual Rear Wheels ................................................... 396, 467, 477 E
Electric Brake Control System ............................................... 162 Anti-Lock Brake System ..................................................... 161
Electronic Roll Mitigation .......................................... 166, 170
Electrical Power Outlets......................................................... 117
Electronic Range Select (ERS)........................................ 262, 270
Electronic Stability Control (ESC) ........................................ 166
Electronic Throttle Control Warning Light ......................... 149
Electronically Shifted Transfer Case .................................... 272 Emergency Braking.................................................................252
Emergency, In Case Of Freeing Vehicle When Stuck ..............................................405Hazard Warning Flasher ....................................................366
Jacking...................................................................................390
Jump Starting .......................................................................398
Emission Control System Maintenance ...............................159
Engine .......................................................................................415 Air Cleaner ...........................................................................420
Break-In Recommendations...............................................251Compartment Identification ..............................................415Coolant (Antifreeze)............................................................ 484
Exhaust Gas Caution................................................... 240, 482Fails To Start.........................................................................249
Flooded, Starting .................................................................249
Fuel Requirements ..............................................................479
Jump Starting .......................................................................398Oil ..................................................................................418, 484
Oil Filler Cap ................................................................415, 419
Oil Filter ................................................................................419Oil Reset ................................................................................130Oil Selection .........................................................................418
Oil Synthetic .........................................................................419
Overheating..........................................................................401
Starting..................................................................................246
Engine Oil Viscosity................................................................419
11

594
Enhanced Accident Response Feature ......................... 212, 409
Entry System, Illuminated ....................................................... 74
Ethanol...................................................................................... 480
Exhaust Gas Cautions .................................................... 240, 482
Exhaust System ............................................................... 240, 431
Exterior Lighting ....................................................................... 66 Exterior Lights ................................................................... 66, 243 F
Filters Air Cleaner ........................................................................... 420Air Conditioning ........................................................... 91, 423
Engine Fuel .......................................................................... 484
Engine Oil..................................................................... 419, 484
Engine Oil Disposal ............................................................ 419
Flashers Turn Signals ........................................................... 70, 157, 243
Flash-To-Pass ............................................................................. 68
Flat Tire Changing .................................................. 390, 444, 461
Flat Tire Stowage .................................................... 396, 444, 461
Fluid Capacities ....................................................................... 483
Fluid Leaks ............................................................................... 243
Fluid Level Checks Brake ..................................................................................... 438
Power Steering..................................................................... 284
Fluids And Lubricants ........................................................... 484
Fog Lights........................................................................... 70, 377 Fold Flat Load Floor ...............................................................112
Fold-Flat Seats ...........................................................................39
Forward Collision Warning................................................... 174
Four Wheel Drive .................................................................... 272
Four-Way Hazard Flasher .....................................................366
Freeing A Stuck Vehicle .........................................................405
Front Axle (Differential) .........................................................442
Fuel ............................................................................................479 Adding ..................................................................................336
Additives ..............................................................................480
Clean Air...............................................................................479
Ethanol ..................................................................................480
Filler Cap (Gas Cap)............................................................337
Filter ...................................................................................... 484
Gasoline ................................................................................479Light ...................................................................................... 152
Materials Added ..................................................................480
Methanol...............................................................................480
Octane Rating.......................................................................479Requirements .......................................................................479Tank Capacity ......................................................................483
Fuses..........................................................................................380 G
Garage Door Opener (HomeLink) ..........................................97 Gas Cap (Fuel Filler Cap) .......................................................337
Gasoline, Clean Air .................................................................479