2019 KIA OPTIMA PHEV battery

871
Maintenance
Fuse NameFuse ratingCircuit Protected
FUSE
SENSOR 115AOxygen Sensor (Up/Down), E/R Junction Block (Cooling Fan Relay)
IGN COIL20AIgnition Coil #1/#2/#3/#4
ECU 210APCM
TCU 110APCM
HEV ECU 210AHPCU, E/R Junction Block (Battery C/Fan Relay)
ECU 310APCM
POWER OUT-LET220AFront Power Outlet #1
HORN20AHorn Relay, ICM Relay Box (Burglar Alarm Horn Relay)
WIPER 130AWiper Power Relay
BATTERYC/FAN15AE/R Junction Block (Battery C/Fan Relay)

Maintenance
72
8
Relay NameType
COOLING FAN RelayMINI
BLOWER RelayMICRO
BATTERY C/FAN RelayMICRO
H/LAMP HI RelayMICRO
POWER OUTLET RelayMICRO
H/LAMP WASHER RelaMICRO
DEICER RelayMICRO
REAR HEATED RelayMINI
PTC HEATER 1MINI
PTC HEATER 2MINI
IG3 3MICRO
Relay

873
Maintenance
Battery terminal cover
✽ ✽NOTICE
Not all fuse panel descriptions in
this manual may be applicable to
your vehicle. It is accurate at the
time of printing. When you inspect
the fuse panel in your vehicle, refer
to the fuse panel label on the inside
of the fuse cover. This diagram will
provide you with the specific infor-
mation for your vehicles.
OJFH075172
OJFH075171

Maintenance
74
8
LIGHT BULBS
Bulb replacement precaution
Please keep extra bulbs on hand
with appropriate wattage ratings in
case of emergencies.
Refer to “Bulb Wattage” in chapter 9.
When changing lamps, first turn off
the engine at a safe place, firmly
apply the parking brake and detach
the battery’s negative (-) terminal.
Use only bulbs of the specified
wattage.✽ ✽ NOTICE
• If the light bulb or lamp connector
is removed while the lamp is still
on, the fuse box's electronic sys-
tem may log it as a malfunction.
Therefore, a lamp malfunction
incident may be recorded as a
Diagnostic Trouble Code (DTC) in
the fuse box.
• It is normal for an operating lamp to flicker momentarily. This is due
to a stabilization function of the
vehicle’s electronic control device.
If the lamp lights up normally
after momentarily blinking, then
it is functioning as normal.
However, if the lamp continues to
flicker several times or turns off
completely, there may be an error
in the vehicle’s electronic control
device. Please have the vehicle
checked by an authorized Kia
dealer immediately.
WARNING- Working on
the lights
Prior to working on the lights,
firmly apply the parking brake,
ensure that the engine
start/stop button is in OFF posi-
tion and turn off the lights to
avoid sudden movement of the
vehicle that may cause burning
your fingers or receiving an
electric shock.
CAUTION -Light replace-
ment
Be sure to replace the burned- out bulb with one of the samewattage rating. Otherwise, itmay cause damage to the fuseor electric wiring system.
CAUTION -Headlamp
Lens
To prevent damage, do notclean the headlamp lens withchemical solvents or strongdetergents.

897
Maintenance
Canister
Fuel vapors generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in
the canister are drawn into the surge
tank through the purge control sole-
noid valve.
Purge Control Solenoid Valve(PCSV)
The purge control solenoid valve is
controlled by the Engine Control
Module (ECM); when the engine
coolant temperature is low during
idling, the PCSV closes so that evap-
orated fuel is not taken into the
engine. After the engine warms up
during ordinary driving, the PCSV
opens to introduce evaporated fuel to
the engine.
3. Exhaust emission control system
The Exhaust Emission Control
System is a highly effective system
which controls exhaust emissions
while maintaining good vehicle per-
formance.
Vehicle modifications
This vehicle should not be modified.
Modification of your vehicle could
affect its performance, safety or
durability and may even violate gov-
ernmental safety and emissions reg-
ulations.
In addition, damage or performance
problems resulting from any modifi-
cation may not be covered under
warranty.
If you use unauthorized electronic
devices, it may cause the vehicle to
operate abnormally, wire damage,
battery discharge and fire. For your
safety, do not use unauthorized
electronic devices.
Engine exhaust gas precautions
(carbon monoxide)
Carbon monoxide can be present with other exhaust fumes.
Therefore, if you smell exhaust
fumes of any kind inside your vehi-
cle, have it inspected and repaired
immediately. If you ever suspect
exhaust fumes are coming into
your vehicle, drive it only with all
the windows fully open. Have your
vehicle checked and repaired
immediately.
WARNING - Exhaust
Engine exhaust gases contain
carbon monoxide (CO). Though
colorless and odorless, it is
dangerous and could be lethal if
inhaled. Follow the instructions
on this page to avoid CO poi-
soning.

911
Specifications, Consumer information, Reporting safety defects
Roadside Assistance is provided on all new current
model year Kia Vehicles from the date the vehicle is deliv-
ered to the first retail buyer or otherwise put into use (in-
service date), whichever is earlier, for a period of 60
months or 60,000 miles, whichever is earlier, subject to
the terms, conditions and exclusions set forth in the Kia
Warranty and Consumer Information Manual applicable
to your model year vehicle.
KMA reserves the right to limit or deny services or other
benefits to any owner or driver when, in KMA's judgment,
the claims and/or service requests are excessive in fre-
quency or type of occurrence.
Toll free consumer assistance
Kia's toll-free Consumer Assistance hot line is staffed
from 5:00 AM to 6:00 PM PST, Monday through Friday
and is accessible by dialing 1-800-333-4Kia (4542).
For more information regarding assistance available,
please refer to your Kia Warranty & Consumer
Information Manual.
Emergency roadside assistance
Kia's toll free Roadside Assistance hot line is staffed 24
hours a day, 365 days a year and is accessible by dialing
1-800-333-4Kia (4542).
Please note that you must provide your Vehicle
Identification Number (VIN) to verify coverage at the time
of your call. The VIN can be found on the dash of your
vehicle on the driver’s side, on the door jamb of the dri-
ver’s door, your vehicle’s registration or proof of insur-
ance card.
Kia utilizes a network of over 30,000 roadside assistance
providers. Should you accidentally run out of fuel, require
a battery jump, or need help changing a tire, a Kia
Roadside Assistance Representative will dispatch some-
one to deliver a small quantity of gas, change a flat tire
with your inflated spare, or arrange a battery jump to
allow you to proceed to your destination. We have access
to a network of over 10,000 locksmiths to help you should
you become locked out of your Kia.
In the event that mechanical difficulty renders your vehi-
cle undriveable due to a warranty-related concern, Kia’s
Roadside Assistance Representative will arrange to
transport your vehicle to the nearest Kia dealer or to an
authorized Kia alternative service location.
CONSUMER ASSISTANCE (U.S. ONLY)

Index
2I
Active ECO system. . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-84Limitation of Active ECO operation . . . . . . . . . . . . 6-85
Plug-in hybrid vehicle . . . . . . . . . . . . . . . . . . . . . . . 6-84
When Active ECO is activated . . . . . . . . . . . . . . . . . 6-85
Air bag - advanced supplemental restraint system . . . . 3-43 Adding equipment to or modifying your air bag-equipped vehicle . . . . . . . . . . . . . . . . . . . . 3-70
Air bag warning label. . . . . . . . . . . . . . . . . . . . . . . . 3-70
Air bag warning light . . . . . . . . . . . . . . . . . . . . . . . . 3-46
Curtain air bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-63
Driver's and passenger's front air bag . . . . . . . . . . . 3-58
How does the air bag system operate? . . . . . . . . . . . 3-44
Inflation and non-inflation conditions of the air bag . 3-64
Occupant Detection System (ODS) . . . . . . . . . . . . . 3-50
Side air bag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-61
SRS Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-69
SRS components and functions . . . . . . . . . . . . . . . . 3-47
Air cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-28\
Filter replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . 8-28
Air conditioner compressor label . . . . . . . . . . . . . . . . . . 9-9
Air conditioning system . . . . . . . . . . . . . . . . . . . . . . . . . 9-5
Air ventilation seat . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-141
Antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . 5-2
Appearance care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-88 Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-88
Interior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-93 Audio System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2
Antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-\
2
How vehicle audio works . . . . . . . . . . . . . . . . . . . . . . 5-3
Automatic climate control system . . . . . . . . . . . . . . . 4-118 Air Conditioning refrigerant label . . . . . . . . . . . . . 4-132
Automatic heating and air conditioning. . . . . . . . . 4-119
Checking the amount of air conditioner refrigerant and compressor lubricant . . . . . . . . . . . . . . . . . . . . . . 4-131
Climate control air filter. . . . . . . . . . . . . . . . . . . . . 4-130
Manual heating and air conditioning . . . . . . . . . . . 4-120
System operation . . . . . . . . . . . . . . . . . . . . . . . . . . 4-128
Automatic transaxle . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-12 Automatic transaxle operation . . . . . . . . . . . . . . . . . 6-12
Good driving practices . . . . . . . . . . . . . . . . . . . . . . . 6-18
Battery. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . 8-36 For best battery service . . . . . . . . . . . . . . . . . . . . . . 8-36
Recharging the battery . . . . . . . . . . . . . . . . . . . . . . . 8-37
Reset items . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-38
Before driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5 Before entering vehicle . . . . . . . . . . . . . . . . . . . . . . . 6-5
Before starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
Necessary inspections . . . . . . . . . . . . . . . . . . . . . . . . 6-5
Blind-spot Collision Warning (BCW) . . . . . . . . . . . . . 6-86 BCW (Blind-Spot Collision Warning)/LCA (Lane Change Assist) . . . . . . . . . . . . . . . . . . 6-87
A
B

I7
Index
Light bulb position (front) . . . . . . . . . . . . . . . . . . . . 8-75
Light bulb position (rear) . . . . . . . . . . . . . . . . . . . . . 8-75
Light bulb position (side) . . . . . . . . . . . . . . . . . . . . . 8-76
Map lamp bulb replacement. . . . . . . . . . . . . . . . . . . 8-85
Personal lamp bulb replacement . . . . . . . . . . . . . . . 8-86
Position lamp + DRL (LED type) bulb replacement . 8-80
Rear turn signal lamp bulb replacement . . . . . . . . . 8-81
Room lamp bulb replacement . . . . . . . . . . . . . . . . . 8-86
Side repeater lamp bulb replacement . . . . . . . . . . . . 8-81
Stop and tail lamp (LED type) bulb replacement . . 8-82
Trunk lamp bulb replacement . . . . . . . . . . . . . . . . . 8-87
Vanity mirror lamp bulb replacement . . . . . . . . . . . 8-85
Lighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
4-102 AFLS (Adaptive Front Lighting System) . . . . . . . 4-110
Battery saver function . . . . . . . . . . . . . . . . . . . . . . 4-102
Check headlight . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-109
Daytime running light . . . . . . . . . . . . . . . . . . . . . . 4-102
Headlight leveling device . . . . . . . . . . . . . . . . . . . . 4-109
High Beam Assist . . . . . . . . . . . . . . . . . . . . . . . . . . 4-105
High beam operation . . . . . . . . . . . . . . . . . . . . . . . 4-104
Lighting control . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-102
Turn signals and lane change signals . . . . . . . . . . . 4-108
Luggage volume . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-5 Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
Owner maintenance precautions . . . . . . . . . . . . . . . . 8-5
Owner’s responsibility . . . . . . . . . . . . . . . . . . . . . . . . 8-4
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 4-47 Inside rearview mirror . . . . . . . . . . . . . . . . . . . . . . . 4-47
Outside rearview mirror . . . . . . . . . . . . . . . . . . . . . . 4-49
Online factory authorized manuals (U.S. only) . . . . . . 9-15 Electrical troubleshooting manual . . . . . . . . . . . . . . 9-15
Owner's manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-15
Service manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-15
Owner maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6 Owner maintenance schedule. . . . . . . . . . . . . . . . . . . 8-6
Panoramic sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-37 Closing the sunroof . . . . . . . . . . . . . . . . . . . . . . . . . 4-42
Resetting the sunroof . . . . . . . . . . . . . . . . . . . . . . . . 4-42
Sliding the sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . 4-40
Sunroof open warning . . . . . . . . . . . . . . . . . . . . . . . 4-38
Sunshade. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-39\
Tilting the sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . 4-41M
O
P