2019 KIA OPTIMA brake

773
Maintenance
Fuse NameFuse ratingCircuit Protected
FUSE
B+440ASmart Junction Block (Leak Current Autocut Device Fuse - INTERIOR LAMP, MEMORY1, MULTI
MEDIA, Fuse - DOOR LOCK, MODULE1, SMART KEY, BRAKE SWITCH)
E-CVVT 140AE-CVVT Relay
VACUUMPUMP 120AVacuum Pump
DEICER20ADeicer Relay
AMS10ABattery Sensor
E-CVVT 220APCM
A/CON10AA/C Control Module
E-CVVT 320APCM
HEATED
MIRROR10AA/C Control Module, Driver/Passenger Power Outside Mirror, ECM
WIPER 210ABCM, PCM/ECM
H/LAMP HI20AHead Lamp HI Relay
JFa PE USA 7.qxp 5/17/2018 6:36 PM Page 73

Maintenance
76
7
LIGHT BULBS
Bulb replacement precaution
Please keep extra bulbs on hand
with appropriate wattage ratings in
case of emergencies.
Refer to “Bulb Wattage” in chapter 8.
When changing lamps, first turn off
the engine at a safe place, firmly
apply the parking brake and detach
the battery’s negative (-) terminal.
net-work failure
The headlamp, taillight, and fog light
may light up when the head lamp
switch is turned ON, and not light up
when the taillight or for light switch is
turned ON. This may be cause by
network failure or vehicle electrical
control system malfunction. If there is
a problem, we recommend the sys-
tem be serviced by an authorized Kia
dealer.
trical control system stabilization
A normally functioning lamp may
flicker momentarily. This momentary
occurrence is due to the stabilization
function of the vehicle's electrical
control system. If the lamp stops
flickering after a few moments, the
vehicle does not require service.
However, if the lamp goes out after
the momentary flickering, or the flick-
ering continues, we recommend the
system be serviced by an authorized
Kia dealer.
WARNING- Working on the lights
Prior to working on the light,
firmly apply the parking brake,
ensure that the ignition switch
is turned to the LOCK position
and turn off the lights to avoid
sudden movement of the vehi-
cle , burns to your skin for fin-
gers, or an electric shock.
CAUTION -Light replace-
ment
Be sure to replace the burned- out bulb with one of the samewattage rating. Otherwise, itmay cause damage to the fuseor electric wiring system.
CAUTION -Headlamp
Lens
To prevent damage, do notclean the headlamp lens withchemical solvents or strongdetergents.
JFa PE USA 7.qxp 5/17/2018 6:36 PM Page 76

795
Maintenance
Waxing
Wax the vehicle when water will no
longer bead on the paint.
Always wash and dry the vehicle
before waxing. Use a good quality
liquid or paste wax, and follow the
manufacturer’s instructions. Wax all
metal trim to protect it and to main-
tain its luster.
Removing oil, tar, and similar materi-
als with a spot remover will usually
strip the wax from the finish. Be sure
to re-wax these areas even if the rest
of the vehicle does not yet need wax-
ing.
Do not apply wax on embossed
unpainted unit, as it may tarnish the
unit.
OJB037800
CAUTION - Wet engine
Water washing in the enginecompartment including highpressure water washing maycause the failure of electricalcircuits located in the enginecompartment.
Never allow water or other liq- uids to come in contact withelectrical/electronic compo-nents inside the vehicle asthis may damage them.
WARNING
After washing the vehicle, test
the brakes while driving slowly
to see if they have been affected
by water. If braking performance
is impaired, dry the brakes by
applying them lightly while
maintaining a slow forward
speed.
JFa PE USA 7.qxp 5/17/2018 6:38 PM Page 95

797
Maintenance
Do a thorough washing of theundercarriage at the end of the
winter.
Use professional service techni- cians or governmental inspection
stations to annually inspect for cor-
rosion.
Immediately seek an inspection of your vehicle if you become visually
aware of corrosion flaking or scal-
ing or if you become aware of a
change in vehicle performance,
such as soft or spongey brakes,
fluids leaking, impairment of direc-
tional control, suspension noises
or rattling metal straps.Aluminum wheel maintenance
The aluminum wheels are coated
with a clear protective finish.
Do not use any abrasive cleaner,polishing compound, solvent, or
wire brushes on aluminum wheels.
They may scratch the finish.
Clean the wheel when it has cooled.
Use only a mild soap or neutral detergent, and rinse thoroughly
with water. Also, be sure to clean
the wheels after driving on salted
roads. This helps prevent corro-
sion.
Avoid washing the wheels with highspeed vehicle wash brushes.
Do not use any alkaline or acid detergents It may damage and cor-
rode the aluminum wheels coated
with a clear protective finish.
Corrosion protection
Protecting your vehicle from corrosion
By using the most advanced design
and construction practices to combat
corrosion, we produce vehicles of
the highest quality. However, this is
only part of the job. To achieve the
long-term corrosion resistance your
vehicle can deliver, the owner's
cooperation and assistance is also
required.
Common causes of corrosion
The most common causes of corro-
sion on your vehicle are:
Road salt, dirt and moisture that isallowed to accumulate underneath
the vehicle.
Removal of paint or protective coatings by stones, gravel, abra-
sion or minor scrapes and dents
which leave unprotected metal
exposed to corrosion.
JFa PE USA 7.qxp 5/17/2018 6:38 PM Page 97

Specifications, Consumer information, Reporting safety defects
88
LubricantVolumeClassification
Coolant 1.6 T-GDI
7.50 US qt. (7.1
l)
Mixture of antifreeze and water
(Ethylene-glycol with phosphate based coolant for
cooling device)
2.0 T-GDI
7.92 US qt. (7.5
l)
2.4 GDI
7.60 US qt. (7.2 l)
Brake fluid
0.47 US qt.(0.45 l) FMVSS116 DOT-3 or DOT-4
Fuel18.5 US gal. (70l)Unleaded gasoline
JFa PE USA 8.qxp 5/17/2018 6:42 PM Page 8

Index
2I
Adding equipment to or modifying your air bag-equippedvehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-\
72
Adjusting outside rearview mirror . . . . . . . . . . . . . . . . 4-56
Air bag inflation conditions . . . . . . . . . . . . . . . . . . . . . 3-67
Air bag non-inflation conditions . . . . . . . . . . . . . . . . . 3-69
Air bag warning label . . . . . . . . . . . . . . . . . . . . . . . . . . 3-72
Air bag warning light . . . . . . . . . . . . . . . . . . . . . . . . . . 3-48
Air bags. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 3-45 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-46
Air bag warning light . . . . . . . . . . . . . . . . . . . . . . . . 3-48
SRS components and functions . . . . . . . . . . . . . . . . 3-49
Occupant detection system. . . . . . . . . . . . . . . . . . . . 3-52
Driver's and passenger's front air bag . . . . . . . . . . . 3-60
Side air bag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-63
Curtain air bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-65
Air bag inflation conditions . . . . . . . . . . . . . . . . . . . 3-67
Air bag non-inflation conditions . . . . . . . . . . . . . . . 3-69
SRS Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-71
Adding equipment to or modifying your air bag-equipped vehicle . . . . . . . . . . . . . . . . . . . . 3-72
Air bag warning label. . . . . . . . . . . . . . . . . . . . . . . . 3-72
Air cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-34\
Filter replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . 7-34
Air conditioning system lubricants. . . . . . . . . . . . . . . . . 8-6
Air ventilation seat . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-152
Antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
4-157 Anti-lock Brake System (ABS) . . . . . . . . . . . . . . . . . . 5-50
Appearance care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-94
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-94
Interior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-99
Armrest . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. 3-18
Assist mode. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-66\
Audio system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-157 Antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-157
Auto defogging system . . . . . . . . . . . . . . . . . . . . . . . . 4-146
Auto hold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-\
46
Auto light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-10\
4
Automatic climate control system . . . . . . . . . . . . . . . 4-131 Automatic heating and air conditioning. . . . . . . . . 4-132
Manual heating and air conditioning . . . . . . . . . . . 4-133
System operation . . . . . . . . . . . . . . . . . . . . . . . . . . 4-139
Climate control air filter. . . . . . . . . . . . . . . . . . . . . 4-141
Air Conditioning refrigerant label . . . . . . . . . . . . . 4-142
Checking the amount of air conditioner refrigerant and compressor lubricant . . . . . . . . . . . . . . . . . . . . . . 4-141
Automatic heating and air conditioning . . . . . . . . . . . 4-132
Automatic transaxle . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-14 Automatic transaxle operation . . . . . . . . . . . . . . . . . 5-14
Good driving practices . . . . . . . . . . . . . . . . . . . . . . . 5-21
A
JFa PE USA Index.qxp 5/17/2018 6:44 PM Page 2

I3
Index
Back-up lamp bulb replacement . . . . . . . . . . . . . . . . . . 7-87
Battery. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . 7-42For best battery service . . . . . . . . . . . . . . . . . . . . . . 7-42
Recharging the battery . . . . . . . . . . . . . . . . . . . . . . . 7-43
Reset items . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-44
Battery replacement (Folding key) . . . . . . . . . . . . . . . . . 4-8
Battery replacement (Smart key) . . . . . . . . . . . . . . . . . 4-15
Battery saver function. . . . . . . . . . . . . . . . . . . . . . . . . 4-103
Before driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
Blind-spot Collision Warning (BCW) system . . . . . . 5-115 BCW (Blind-spot Collision Warning) . . . . . . . . . . 5-116
RCCW (Rear Cross-traffic Collision Warning) . . . 5-119
Bonnet see the hood . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-36
Brake system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-36 Power brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-36
Parking brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-38
Electronic Parking Brake (EPB) . . . . . . . . . . . . . . . 5-39
Auto hold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-46
Anti-lock Brake System (ABS) . . . . . . . . . . . . . . . . 5-50
Electronic Stability Control (ESC) . . . . . . . . . . . . . 5-52
Vehicle Stability Management (VSM) . . . . . . . . . . . 5-56
Hill-start Assist Control (HAC) . . . . . . . . . . . . . . . . 5-58
Brakes fluid. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-31\
Checking the brake fluid level . . . . . . . . . . . . . . . . . 7-31
Bulb replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-76
Bulb replacement precaution . . . . . . . . . . . . . . . . . . . . 7-76 Bulb wattage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-3
Button start/stop, see engine start/stop button . . . . . . . 5-10
California Perchlorate notice . . . . . . . . . . . . . . . . . . . 7-105
Camera (Rear view) . . . . . . . . . . . . . . . . . . . . . . . . . . 4-101
Capacities (Lubricants) . . . . . . . . . . . . . . . . . . . . . . . . . . 8-7
Care
Care of seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-33
Tire care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-45\
Exterior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-94
Interior care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-99
Center console storage . . . . . . . . . . . . . . . . . . . . . . . . 4-148
Central door lock switch. . . . . . . . . . . . . . . . . . . . . . . . 4-22
Chains - Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-146
Checking fluid levels . . . . . . . . . . . . . . . . . . . . . . . . . . 7-25
Checking tire inflation pressure . . . . . . . . . . . . . . . . . . 7-46
Child restraint system . . . . . . . . . . . . . . . . . . . . . . . . . . 3-34 Selecting a Child Restraint System (CRS) . . . . . . . 3-35
Installing a Child Restraint System (CRS) . . . . . . . 3-38
Securing a child restraint with the LATCH anchors system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-\
40
Securing a child restraint seat with "Tether Anchor" system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-\
41
Child-protector rear door lock . . . . . . . . . . . . . . . . . . . 4-24
Climate control air filter . . . . . . . . . . . . . . . . . . . . . . . . 7-36 Filter inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-36
C
B
JFa PE USA Index.qxp 5/17/2018 6:44 PM Page 3

I5
Index
Dual clutch transmission . . . . . . . . . . . . . . . . . . . . . . . 5-22Dual clutch transmission operation . . . . . . . . . . . . . 5-22
Good driving practices . . . . . . . . . . . . . . . . . . . . . . . 5-33
Dynamic Bending Light (DBL) . . . . . . . . . . . . . . . . . 4-111
Economical operation . . . . . . . . . . . . . . . . . . . . . . . . . 5-139
Electric power steering . . . . . . . . . . . . . . . . . . . . . . . . . 4-49
Electrical equipment (U.S. ONLY) . . . . . . . . . . . . . . . 8-15
Electro Chromic Mirror (ECM) . . . . . . . . . . . . . . . . . . 4-54
Electronic Parking Brake (EPB). . . . . . . . . . . . . . . . . . 5-39
Electronic Stability Control (ESC) . . . . . . . . . . . . . . . . 5-52
Emergency starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5 Jump starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
Emergency while driving . . . . . . . . . . . . . . . . . . . . . . . . 6-3
Emission control system . . . . . . . . . . . . . . . . . . . . . . . 7-102 Crankcase emission control system . . . . . . . . . . . . 7-102
Evaporative emission control (including ORVR: Onboard Refueling Vapor Recovery) system . . . 7-102
Exhaust emission control system . . . . . . . . . . . . . . 7-103
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . 8-2
Engine compartment . . . . . . . . . . . . . . . . . . . . . . . . 2-6, 7-4
Engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-28 Checking the coolant level . . . . . . . . . . . . . . . . . . . . 7-28
Changing the coolant . . . . . . . . . . . . . . . . . . . . . . . . 7-30
Engine coolant temperature gauge . . . . . . . . . . . . . . . . 4-62
Engine number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-11 Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-\
26
Checking the engine oil level. . . . . . . . . . . . . . . . . . 7-26
Changing the engine oil and filter . . . . . . . . . . . . . . 7-27
Engine overheats. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7
Engine start/stop button . . . . . . . . . . . . . . . . . . . . . . . . 5-10 Illuminated engine start/stop button. . . . . . . . . . . . . 5-10
Engine start/stop button position . . . . . . . . . . . . . . . 5-10
Starting the engine . . . . . . . . . . . . . . . . . . . . . . . . . . 5-12
Engine start/stop button illumination . . . . . . . . . . . . . . 5-10
Engine start/stop button position . . . . . . . . . . . . . . . . . 5-10
Engine will not start . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
Evaporative emission control (including ORVR: Onboard Refueling Vapor Recovery) system . . . . . . . . . . . . 7-102
Exhaust emission control system . . . . . . . . . . . . . . . . 7-103
Explanation of scheduled maintenance items . . . . . . . 7-22 Engine oil and filter . . . . . . . . . . . . . . . . . . . . . . . . . 7-22
Drive belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-22
Fuel filter (for gasoline) . . . . . . . . . . . . . . . . . . . . . . 7-22
Fuel lines, fuel hoses and connections . . . . . . . . . . . 7-22
Vapor hose and fuel filler cap . . . . . . . . . . . . . . . . . 7-22
Vacuum crankcase ventilation hoses . . . . . . . . . . . . 7-23
Air cleaner filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-23
Spark plugs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-23
Valve clearance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-23
Cooling system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-23
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-\
23
Automatic transmission fluid . . . . . . . . . . . . . . . . . . 7-23
Dual clutch transmission fluid . . . . . . . . . . . . . . . . . 7-24
E
JFa PE USA Index.qxp 5/17/2018 6:44 PM Page 5