For a list of the high-priced emission-related parts that are covered for 7
years or 70,000 miles, go to www.owner.ford.com / Owner Manuals.
Select the list that corresponds to the model and the model year of your
vehicle. NOTE: This list is vehicle specific and may not be the same for
all vehicles. It is based on the replacement cost of each specific part,
which can vary between vehicle lines.
If Gross Vehicle Weight rating is over 14,000 lbs.:
For 5 years or 50,000 miles (gasoline powered engines and vehicles) or
5 years or 100,000 miles (diesel powered engines and vehicles)
(whichever first occurs):
If an emissions-related part on your vehicle is defective, the part will be
repaired or replaced by Ford. This is your emission control system
DEFECTS WARRANTY.25
WHAT IS COVERED?
If the parts on the following list contains a defect that affects emissions,
they are covered by the Defects Warranties.
•Air Flow Sensor
• Air/Fuel Feedback Control
System and Sensors
• Air Induction System
• Catalytic Converters (including
Selective Catalytic Reduction
and Diesel Oxidation Catalysts)
• Cold Start Enrichment System
(diesel only)
• Controls for Deceleration
(diesel only)
• Diesel Exhaust Fluid System
• Diesel Particulate Filter
• Electronic Ignition System
(diesel only)
• Electronic Engine Control
Sensors and Switches
• Powertrain Control Module
(PCM)/Engine Control Module
(ECM)*
• Evaporative Emission Control
System
• Exhaust Gas Recirculation
(EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to
Catalyst)
• Fuel Filler Tube and Seal
(non-diesel only) •
Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank (non-diesel only)
• Fuel Tank Pressure Control
Valve
• Heating Elements of Side
Mirrors and Back Windows
(3.0L diesel F-150 only)
• Ignition Coil and/or Control
Module
• Intake Manifold
• Intercooler Assembly - Engine
Charger
• Malfunction Indicator Lamp
(MIL)/On-Board Diagnostic
(OBD) System
• PCV System and Oil Filler Cap
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Control Module
(TCM) and Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only 27
Important Information about List of Parts
There may be additional coverage for these parts through the Bumper to
Bumper, Powertrain, or Diesel Engine limited warranties. In any case, the
warranty with the broadest coverage applies.
Also covered by this warranty are all emissions-related bulbs, hoses,
clamps, brackets, tubes, gaskets, seals, belts, connectors, non diesel fuel
lines, and wiring harnesses that are used with components on the list of
parts above.
Concerning parts that should be replaced on a certain maintenance
schedule: these parts remain under warranty until the first required
replacement time that is specified in yourOwner’s Manual.
NOTE: If the diagnosis does not reveal a defect, the Defects Warranty
does not apply.
Your Ford Motor Company dealer maintains a complete list of covered
parts. For more details about the specific parts that are covered by the
Defects Warranty, contact your dealer.
WHAT IS NOT COVERED?
Ford Motor Company may deny you emissions warranty coverage if your
vehicle or a part does not contain a defect that affects emissions or has
failed because of abuse, neglect, improper maintenance, unapproved
modifications, or any items included in What Is Not Covered?,
pages 12-15.
28
