2019 FORD FUSION open hood

ENGINE OIL DIPSTICK - 1.5L
ECOBOOST™
Minimum.
A
Maximum.
B
ENGINE OIL DIPSTICK - 2.0L
ECOBOOST™/2.5L/2.7L
ECOBOOST™ Minimum.
A
Nominal.
B
Maximum.
C
ENGINE OIL CHECK
To check the engine oil level consistently
and accurately, do the following: 1.
Make sure the parking brake is on. Make
sure the transmission is in park (P) or
neutral (N).
2. Run the engine until it reaches normal operating temperature.
3. Make sure that your vehicle is on level ground.
4. Switch the engine off and wait 15 minutes for the oil to drain into the oil
pan. Checking the engine oil level too
soon after you switch the engine off
may result in an inaccurate reading.
5. Open the hood. See Opening and
Closing the Hood (page 256).
6. Remove the dipstick and wipe it with a clean, lint-free cloth. See
Under
Hood Overview (page 260).
7. Reinstall the dipstick and remove it again to check the oil level. See Under
Hood Overview
(page 260).
8. Make sure that the oil level is between
the maximum and minimum marks. If
the oil level is at the minimum mark,
add oil immediately. See
Capacities
and Specifications (page 328).
9. If the oil level is correct, replace the dipstick and make sure it is fully seated.
Note: Do not remove the dipstick when the
engine is running.
Note: If the oil level is between the
maximum and minimum marks, the oil level
is acceptable. Do not add oil.
Note: The oil consumption of new engines
reaches its normal level after approximately
3,000 mi (5,000 km)
.
Adding Engine Oil WARNING:
Do not remove the
filler cap when the engine is running.
261
Fusion (CC7) Canada/United States of America, enUSA, Edition date: 201805, Second-Printing MaintenanceE199415
AB E250320

Do not use supplemental engine oil
additives because they are unnecessary
and could lead to engine damage that may
not be covered by the vehicle Warranty.
Only use oils certified for gasoline engines
by the American Petroleum Institute (API).
An oil with this trademark symbol
conforms to the current engine and
emission system protection standards and
fuel economy requirements of the
International Lubricants Specification
Advisory Committee (ILSAC).
To top up the engine oil level do the
following:
1. Clean the area surrounding the engine
oil filler cap before you remove it.
2. Remove the engine oil filler cap. See Under Hood Overview (page 260).
Turn it counterclockwise and remove
it.
3. Add engine oil that meets our specifications. See
Capacities and
Specifications (page 328). You may
have to use a funnel to pour the engine
oil into the opening.
4. Recheck the oil level.
5. If the oil level is correct, replace the dipstick and make sure it is fully seated.
6. Replace the engine oil filler cap. Turn it clockwise until you feel a strong
resistance. Note:
Do not add oil further than the
maximum mark. Oil levels above the
maximum mark may cause engine damage.
Note: Make sure you install the oil filler cap
correctly.
Note: Soak up any spillage with an
absorbent cloth immediately.
OIL CHANGE INDICATOR
RESET
Use the information display controls on
the steering wheel to reset the oil change
indicator.
From the main menu scroll to: Action and description
Message
Press the right arrow button,
then from this menu scroll
to the following message.
Settings
Press the right arrow button,
then from this menu scroll
to the following message.
Vehicle
Press the right arrow button,
then from this menu scroll
to the following message.
Oil Life
Press and hold the
OK
button until the instrument
cluster displays the
following message.
Hold OK to
Reset
Reset Successful
When the oil change indic-
ator resets the instrument
cluster displays 100%.
Remaining Life
{00}%
262
Fusion (CC7) Canada/United States of America, enUSA, Edition date: 201805, Second-Printing MaintenanceE142732

Note:
Make sure that the wiper blade locks
into place. Lower the wiper arm and blade
back to the windshield. The wiper arms will
automatically return to their normal position
when the ignition is turned on.
Replace wiper blades at least once per
year for optimum performance.
Poor wiper quality can be improved by
cleaning the wiper blades and the
windshield.
ADJUSTING THE HEADLAMPS
Vertical Aim Adjustment
The headlamps on your vehicle are
properly aimed at the assembly plant. If
your vehicle has been in an accident, the
alignment of your headlamps should be
checked by your authorized dealer.
Headlamp Aiming Target 8 feet (2.4 meters)
A
Center height of lamp to ground
B
25 feet (7.6 meters)
C
Horizontal reference line
D Vertical Aim Adjustment Procedure
1. Park the vehicle directly in front of a
wall or screen on a level surface,
approximately 25 ft (7.6 m) away.
2. Measure the height of the headlamp bulb center from the ground and mark
an
8 ft (2.4 m) horizontal reference line
on the vertical wall or screen at this
height.
Note: To see a clearer light pattern for
adjusting, you may want to block the light
from one headlamp while adjusting the
other.
3. Turn on the low beam headlamps to illuminate the wall or screen and open
the hood. 4. On the wall or screen you will observe
a flat zone of high intensity light
located at the top of the right hand
portion of the beam pattern. If the top
edge of the high intensity light zone is
not at the horizontal reference line, the
headlamp will need to be adjusted.
273
Fusion (CC7) Canada/United States of America, enUSA, Edition date: 201805, Second-Printing MaintenanceE142592 E142465

5. Locate the vertical adjuster on each
headlamp. Using a Phillips #2
screwdriver, turn the adjuster either
clockwise or counterclockwise in order
to adjust the vertical aim of the
headlamp. The horizontal edge of the
brighter light should touch the
horizontal reference line.
6. Close the hood and turn off the lamps.
Horizontal Aim Adjustment
Horizontal aim is not required for this
vehicle and is not adjustable.
REMOVING A HEADLAMP Note:
To remove push pins, use a
flat-bladed screwdriver to pull up the center
release pin.
1. Make sure the headlamp control is in the off position and open the hood.
2. Remove the six push pins securing the
front fascia to the front trim cover.
3. Remove the three bumper cover upper
screws using a flat-bladed screwdriver. 4. Remove the push pin at the inboard
side of the headlamp you are servicing.
274
Fusion (CC7) Canada/United States of America, enUSA, Edition date: 201805, Second-Printing MaintenanceE145594 E159693

Auxiliary Power Points................................145
110 Volt AC Power Point................................... 145
12 Volt DC Power Point..................................... 145
Locations............................................................... 145
AWD See: All-Wheel Drive........................................... 171
B
Battery See: Changing the 12V Battery..................... 270
Blind Spot Information System................211 Switching the System Off and On................212
System Errors....................................................... 212
Using the Blind Spot Information System................................................................ 211
BLIS See: Blind Spot Information System............211
Body Styling Kits..........................................287
Bonnet Lock See: Opening and Closing the Hood..........256
Booster Seats..................................................30 Types of Booster Seats...................................... 30
Brake Fluid Check........................................269
Brakes................................................................176 General Information........................................... 176
Breaking-In.....................................................230
Bulb Specification Chart..........................344
C
Cabin Air Filter...............................................130
Capacities and Specifications - 1.5L EcoBoost™.................................................328
Alternative Engine Oil for Extremely Cold Climates............................................................ 331
Specifications..................................................... 328
Capacities and Specifications - 2.0L EcoBoost™..................................................331
Alternative Engine Oil for Extremely Cold Climates........................................................... 335
Specifications...................................................... 332
Capacities and Specifications - 2.5L.................................................................335
Alternative Engine Oil for Extremely Cold Climates........................................................... 339
Specifications..................................................... 336Capacities and Specifications - 2.7L
EcoBoost™.................................................339
Alternative Engine Oil for Extremely Cold
Climates........................................................... 343
Specifications..................................................... 340
Capacities and Specifications.................319
Car Wash See: Cleaning the Exterior.............................. 280
Catalytic Converter......................................163 On-Board Diagnostics (OBD-II)................... 164
Readiness for Inspection and Maintenance (I/M) Testing................................................... 164
Center Console
..............................................147
Changing a Bulb...........................................276
Front Halogen Fog Lamp................................. 277
Headlamp............................................................. 276
LED Lamps............................................................ 277
License Plate Lamp........................................... 278
Reversing Lamp.................................................. 278
Changing a Fuse
..........................................254
Fuses...................................................................... 254
Changing a Road Wheel............................310 Changing a Road Wheel Procedure.............312
Dissimilar Spare Wheel and Tire Assembly
Information...................................................... 310
Stowing the Flat Tire Using the Retainer Strap................................................................... 316
Stowing the Flat Tire Without the Retainer Strap................................................................... 315
Changing the 12V Battery
.........................270
Changing the Engine Air Filter.................278 2.5L Engine........................................................... 279
EcoBoost Engines.............................................. 279
Changing the Wiper Blades......................272
Checking MyKey System Status................61 MyKey Distance..................................................... 61
Number of Admin Keys...................................... 62
Number of MyKeys.............................................. 62
Checking the Wiper Blades......................272
Child Restraint and Seatbelt Maintenance.................................................42
Child Restraint Positioning.........................32
Child Safety......................................................20 General Information............................................ 20
Child Safety Locks..........................................33 Left-Hand Side...................................................... 34
Right-Hand Side................................................... 34
Cleaning Leather Seats.............................284
537
Fusion (CC7) Canada/United States of America, enUSA, Edition date: 201805, Second-Printing Index

Head Restraints..............................................131
Adjusting the Head Restraint......................... 132
Tilting Head Restraints .................................... 133
Heated Exterior Mirrors...............................129
Heated Rear Window..................................129
Heated Seats.................................................138
Heated Steering Wheel................................75
Heating See: Climate Control........................................... 121
Hill Start Assist
..............................................178
Switching the System On and Off................179
Using Hill Start Assist........................................ 179
Hints on Controlling the Interior Climate...........................................................127
Defogging the Side Windows in Cold Weather............................................................. 129
General Hints........................................................ 127
Quickly Cooling the Interior............................ 128
Quickly Heating the Interior............................ 128
Recommended Settings for Cooling...........129
Recommended Settings for Heating..........128
Hints on Driving With Anti-Lock Brakes.............................................................176
Home Screen
................................................409
Hood Lock See: Opening and Closing the Hood..........256
I
In California (U.S. Only)
............................239
Information Display Control.......................75
Information Displays.....................................97 General Information............................................ 97
Information Messages...............................106 Active Park............................................................ 106
Adaptive Cruise Control................................... 107
AdvanceTrac®..................................................... 107
Airbag..................................................................... 108
Alarm...................................................................... 108
All-Wheel Drive.................................................... 110
Automatic Engine Shutdown......................... 110
Auto Start-Stop.................................................. 108
Battery and Charging System.......................... 111
Blind Spot Information and Cross Traffic Alert System...................................................... 111
Doors and Locks................................................... 112
Driver Alert.............................................................. 112
Fuel........................................................................\
.... 112Hill Start Assist.....................................................
112
Keys and Intelligent Access............................. 113
Lane Keeping System........................................ 114
Maintenance.......................................................... 114
MyKey....................................................................... 115
Park Aid................................................................... 116
Park Brake.............................................................. 116
Power Steering...................................................... 117
Pre-Collision Assist............................................. 117
Remote Start......................................................... 117
Seats........................................................................\
118
Starting System .................................................. 118
Tire Pressure Monitoring System................... 118
Traction Control................................................... 119
Transmission......................................................... 119
Installing Child Restraints...........................22 Child Seats.............................................................. 22
Using Lap and Shoulder Belts......................... 22
Using Lower Anchors and Tethers for CHildren (LATCH)............................................ 27
Using Tether Straps............................................. 28
Instrument Cluster
........................................90
Instrument Lighting Dimmer......................79 Vehicles With Front Fog Lamps..................... 80
Vehicles Without Front Fog Lamps..............80
Instrument Panel
............................................18
Interior Lamps.................................................82 Front Interior Lamp............................................. 83
Rear Interior Lamps............................................. 83
Interior Luggage Compartment Release...........................................................69
Interior Mirror...................................................88 Auto-Dimming Mirror......................................... 88
Manual Dimming Mirror.................................... 88
Introduction.........................................................7
J
Jump Starting the Vehicle........................234 Connecting the Jumper Cables.................... 234
Jump Starting...................................................... 235
Preparing Your Vehicle..................................... 234
Removing the Jumper Cables....................... 235
541
Fusion (CC7) Canada/United States of America, enUSA, Edition date: 201805, Second-Printing Index

Navigation Menu...............................................
440
SiriusXM Traffic and Travel Link................... 443
SYNC AppLink.................................................... 442
Waypoints............................................................. 441
Normal Scheduled Maintenance..........479 Intelligent Oil-Life Monitor............................. 479
Normal Maintenance Intervals.................... 480
O
Oil Change Indicator Reset......................262
Oil Check See: Engine Oil Check....................................... 261
Opening and Closing the Hood..............256 Closing the Hood................................................ 257
Opening the Hood............................................. 256
Ordering Additional Owner's Literature......................................................243
Obtaining a French Owner ’s Manual..........243
Overhead Console
........................................147
P
Parking Aids....................................................183 Principle of Operation....................................... 183
Passive Anti-Theft System..........................71 SecuriLock®............................................................ 71
PATS See: Passive Anti-Theft System...................... 71
Perchlorate........................................................13
Personal Safety System ™
..........................43
How Does the Personal Safety System
Work?.................................................................. 43
Phone...............................................................429 During a Phone Call.......................................... 433
Making Calls........................................................ 432
Pairing Your Cell Phone for the First Time................................................................... 429
Phone Menu........................................................ 430
Receiving Calls.................................................... 433
Smartphone Connectivity.............................. 434
Text Messaging................................................... 434
Post-Crash Alert System
..........................236
Power Door Locks See: Locking and Unlocking............................. 64
Power Seats....................................................133 10-way power seat............................................. 135
6-way power seat............................................... 134Power Lumbar.....................................................
135
Power Windows.............................................85 Accessory Delay................................................... 86
Bounce-Back......................................................... 85
One-Touch Down................................................. 85
One-Touch Up....................................................... 85
Window Lock......................................................... 86
Pre-Collision Assist......................................216 Adjusting Pre-Collision Assist
Settings.............................................................. 217
Blocked Sensors.................................................. 217
Using the Pre-Collision Assist System............................................................... 216
Protecting the Environment........................17
Puncture See: Changing a Road Wheel........................ 310
R
Rear Parking Aid............................................183 Obstacle Distance Indicator........................... 184
Rear Seat Armrest........................................147
Rear Seats........................................................137
Rear View Camera
.......................................193
Camera Guidelines............................................ 194
Camera System Settings................................. 195
Enhanced Park Aids or Park Pilot.................195
Manual Zoom....................................................... 195
Rear Camera Delay............................................ 196
Using the Rear View Camera System.........194
Rear View Camera See: Rear View Camera.................................... 193
Recommended Towing Weights
............225
Refueling..........................................................158 Refueling System Overview........................... 158
Refueling System Warning............................. 160
Refueling Your Vehicle...................................... 159
Remote Control..............................................53 Car Finder................................................................ 56
Intelligent Access Key......................................... 53
Remote Start.......................................................... 57
Replacing the Battery......................................... 55
Sounding the Panic Alarm................................ 56
Using the Key Blade............................................ 54
Remote Start
.................................................130
Automatic Settings............................................ 130
Heated and Cooled Features......................... 130
Last Settings........................................................ 130
543
Fusion (CC7) Canada/United States of America, enUSA, Edition date: 201805, Second-Printing Index

U
Under Hood Overview - 1.5L
EcoBoost™..................................................257
Under Hood Overview - 2.0L EcoBoost™.................................................258
Under Hood Overview - 2.5L...................259
Under Hood Overview - 2.7L EcoBoost™................................................260
Unique Driving Characteristics................153
Universal Garage Door Opener...............140
HomeLink Wireless Control System...........140
USB Port
.........................................................358
Using Adaptive Cruise Control................198 Automatic Cancellation.................................. 202
Blocked Sensor.................................................. 203
Canceling the Set Speed................................. 201
Changing the Set Speed.................................. 201
Detection Issues................................................. 202
Following a Vehicle.......................................... 200
Following a Vehicle to a Complete Stop................................................................... 200
Hilly Condition Usage....................................... 202
Overriding the Set Speed................................ 201
Park Brake Application.................................... 202
Resuming the Set Speed................................. 201
Setting the Adaptive Cruise Speed.............199
Setting the Adaptive Cruise Speed When Your Vehicle is Stationary........................... 199
Setting the Gap Distance............................... 200
Switching Adaptive Cruise Control Off...................................................................... 202
Switching Adaptive Cruise Control On........................................................................\
199
Switching to Normal Cruise Control..........204
System Not Available...................................... 203
Using All-Wheel Drive..................................171 Driving In Special Conditions With
All-Wheel Drive (AWD)................................. 171
Using Cruise Control
....................................197
Canceling the Set Speed................................. 198
Changing the Set Speed.................................. 197
Resuming the Set Speed................................. 198
Setting the Cruise Speed................................. 197
Switching Cruise Control Off......................... 198
Switching Cruise Control On........................... 197
Using MyKey With Remote Start Systems..........................................................62 Using Snow Chains
.....................................303
Using Stability Control................................182
Using Summer Tires...................................303
Using SYNC™ With Your Media Player
............................................................380
Accessing Your USB Song Library...............384
Bluetooth Devices and System
Settings............................................................ 386
Connecting Your Digital Media Player to the USB Port.......................................................... 380
Media Menu Features...................................... 383
Media Voice Commands................................. 381
USB 2..................................................................... 386
Voice Commands for Audio Sources.........387
Using SYNC™ With Your Phone............363 Accessing Features through the Phone
Menu................................................................. 368
Accessing Your Phone Settings..................... 371
Bluetooth Devices.............................................. 372
Making Calls......................................................... 367
Pairing a Phone for the First Time..............364
Pairing Subsequent Phones.......................... 365
Phone Options during an Active Call.........367
Phone Voice Commands................................ 365
Receiving Calls.................................................... 367
System Settings................................................. 373
Text Messaging.................................................. 369
Using Traction Control...............................180 Switching the System Off............................... 180
System Indicator Lights and Messages......................................................... 180
Using a Switch.................................................... 180
Using the Information Display Controls............................................................ 180
Using Voice Recognition............................361 Audio Voice Commands................................... 411
Climate Voice Commands.............................. 412
Initiating a Voice Session................................. 361
Mobile App Voice Commands....................... 415
Navigation Voice Commands........................ 414
Phone Voice Commands................................. 412
SiriusXM Traffic and Travel Link Voice Commands...................................................... 415
System Interaction and Feedback..............362
Voice Settings Commands............................. 416
Utilizing the Mediation/Arbitration Program (Canada Only)
.........................241
546
Fusion (CC7) Canada/United States of America, enUSA, Edition date: 201805, Second-Printing Index